Ford F-150 Service Bulletins (2022)
475 manufacturer communications on file.
- September 22, 2026•Document ID: 11037559Service Bulletin/Repair InstructionsPOWER TRAIN
- Mfr Comm. #:
- TSB 26-2408
- Date Added:
- September 30, 2026
- Manufacturer:
- FORD
SummaryThis bulletin supersedes 26-2309. Reason For Update: update the Model section to remove Aviator 10R80, update the Parts list to add 3.3L to W520514-S440, and add L1MZ-7Z490-G valve body separator plate for Aviator. Some of the vehicles listed in the Model statement above may exhibit at least one of the following conditions: * Harsh 3-4, 4-5 upshifts * Harsh 5-3, 4-3 downshifts * Harsh reverse engagements These symptoms may be worse when cold. This may be due to the F clutch friction plates brinelling into the clutch and planetary container cylinder (7B177).
Associated Products (22)2024 Ford Expedition2024 Ford Explorer2024 Ford F-1502024 Ford Mustang2024 Ford Transit2024 Lincoln Navigator2023 Ford Expedition2023 Ford Explorer2023 Ford F-1502023 Ford Mustang2023 Ford Ranger2023 Ford Transit2023 Lincoln Aviator2023 Lincoln Navigator2022 Ford Expedition2022 Ford Explorer2022 Ford F-1502022 Ford Mustang2022 Ford Ranger2022 Ford Transit+ 2 moreAssociated Documents - September 3, 2026•Document ID: 11037297Service Bulletin/Repair InstructionsELECTRICAL SYSTEM; UNKNOWN OR OTHER
- Mfr Comm. #:
- TSB 26-2391
- Date Added:
- September 12, 2026
- Manufacturer:
- FORD
SummaryThis bulletin updates 26-2206. Reason for update: update the Service Procedure to revise Steps 19-21, adding Step 22, and adding Figure 15-16 to clarify connector C316 location. Some of the vehicles listed in the Model statement above may exhibit diagnostic trouble codes (DTCs) C1001:31, U3000:89, and/or U3000:49 stored in the image processing module A (IPMA) and at least one of the following conditions: "Front Camera Fault Service Required" message Pre-collision assist inoperative Adaptive cruise control inoperative Front windshield camera alignment routine fails to complete This may be due to the coaxial cable between the IPMA camera and the IPMA.
Associated Products (3)Associated Documents - August 26, 2026•Document ID: 11036595Service Bulletin/Repair InstructionsPOWER TRAIN; UNKNOWN OR OTHER; ELECTRICAL SYSTEM
- Mfr Comm. #:
- TSB 26-2395
- Date Added:
- September 1, 2026
- Manufacturer:
- FORD
SummaryThis article supersedes 26-2287. Reason for update: update the labor operation numbers to add MT to operations C, F, G, H, J, K, L and M, and correct the part number LIMZ-4A015-B to L1MZ-4A015-B. Some of the vehicles listed in the Model statement above may exhibit at least one of the following conditions: Harsh engagement Delayed engagement Harsh shift Delayed shift Illuminated malfunction indicator lamp (MIL) with diagnostic trouble codes (DTC)s P0751, P0752, P0756, P0757, P0761, P0762, P0766, P0767, P0771, P0772, P2700, P2701, P2702, P2703, P2704, P2705, P2707, P2708, P0729, P0731, P0732, P0733, P0734, P0735, P0736, P076F, P07D9, P07F6 and/or P07F7 stored in the powertrain control module (PCM) or transmission control module (TCM). This may be due to axial movement of the CDF clutch cylinder sleeve causing hydraulic circuit leaks. NOTE: If internal transmission service is required to address a concern detected with the CDF clutch cylinder following this article, technicians should carefully inspect and replace other transmission components and flush transmission fluid cooler only as ne
Associated Products (9)Associated Documents - August 22, 2026•Document ID: 11036530Service Bulletin/Repair InstructionsSEATS; UNKNOWN OR OTHER
- Mfr Comm. #:
- SSM 55100
- Date Added:
- September 1, 2026
- Manufacturer:
- FORD
SummaryFor Various Ford and Lincoln vehicles, if diagnostics lead to the replacement of the front seat cushion cover J-clips, lower-level service parts are now available. Use service part W709919-S901 if the J-clip is completely detached from the seat cover and W715386-S424 if the clip is still partially attached. It is not necessary to replace the seat cover if only the J-clip is separating from the cover. Refer to PTS Home > Technical Assistance > Technical Support Videos > Section 501- Body and Paint > Seat J-Clips. For claiming, use causal parts from list below and labor operations 63100A and 63100A5. Causal Parts for claiming: Bronco/Bronco Sport/Escape/Explorer/Expedition/Navigator: 7862900 or 7862901 F-150/F-Super Duty: 1562900 or 1562901 Ranger/Maverick: 6062900 or 6062901
Associated Products (50)2026 Ford Bronco2026 Ford Bronco Sport2026 Ford Escape2026 Ford Expedition2026 Ford Explorer2026 Ford F-1502026 Ford Maverick2026 Ford Ranger2026 Lincoln Navigator2025 Ford Bronco2025 Ford Bronco Sport2025 Ford Escape2025 Ford Expedition2025 Ford Explorer2025 Ford F-1502025 Ford Maverick2025 Ford Ranger2025 Lincoln Navigator2024 Ford Bronco2024 Ford Bronco Sport+ 30 moreAssociated Documents - August 21, 2026•Document ID: 11036522Service Bulletin/Repair InstructionsELECTRICAL SYSTEM; FUEL/PROPULSION SYSTEM
- Mfr Comm. #:
- SSM 55111
- Date Added:
- September 1, 2026
- Manufacturer:
- FORD
SummarySome 2022-2026 F-150 Lightning vehicles may exhibit a reduced distance to empty (DTE) projection, a high voltage battery pack state of charge (SOC) that drops from 100% to less than 90% within 60 seconds of being driven, and an inability to reach a target SOC using the scheduled charging feature without any diagnostic trouble codes (DTCs) in the battery energy control module (BECM). This may be due to an issue in one or more cells within the high voltage battery pack. To correct the condition, run the "BECM Battery Health" application using the latest software version of the Ford Diagnosis and Repair System (FDRS). If any cells are identified as exceeding state of charge and/or capacity thresholds, refer to the Workshop Manual (WSM), Section 414-03A High Voltage Battery, Mounting and Cables > Diagnosis and Testing > High Voltage Battery, Mounting and Cables Electric. Perform Pinpoint Test High Voltage Battery Pack Cell Balancing Faults, Step 4 (PPT Step AO4 for 2022-2024 vehicles/PPT Step AQ4 for 2024-2026 vehicles) and proceed with Pinpoint Test directions following the results of Step 4.
Associated Products (5)Associated Documents - August 14, 2026•Document ID: 11036301Service Bulletin/Repair InstructionsSTRUCTURE:BODY; VISIBILITY/WIPER
- Mfr Comm. #:
- SSM 55093
- Date Added:
- August 20, 2026
- Manufacturer:
- FORD
SummarySome 2021-2026 F-150 vehicles may exhibit a concern of the windshield wipers not parking in the correct position on the windshield and/or over-traveling. This may be due to incorrect alignment of the wiper pivot arm on the wiper linkage assembly. Wiper pivot arms may or may not be equipped with an alignment key. Alignment keys are a manufacturing aid and are not needed for proper alignment and operation. In some instances, it may be necessary to remove this alignment key to achieve proper alignment. Replacement of the wiper pivot arm, due to a missing alignment key is a not warrantable. Refer to Workshop Manual (WSM), Section 501-16.
Associated Products (6)Associated Documents - August 3, 2026•Document ID: 11035556Service Bulletin/Repair InstructionsUNKNOWN OR OTHER; FUEL/PROPULSION SYSTEM; POWER TRAIN; ELECTRICAL SYSTEM
- Mfr Comm. #:
- SSM55059
- Date Added:
- August 3, 2026
- Manufacturer:
- LINCOLN
SummarySome 2021-2023 F-150 vehicles equipped with a 3.5L PowerBoost engine, 2020-2026 Explorer vehicles equipped with a 3.3L hybrid engine, and 2020-2023 Lincoln Aviator vehicles equipped with a 3.0L EcoBoost hybrid engine may exhibit an illuminated powertrain malfunction (wrench) indicator with diagnostic trouble code (DTC) P0A1E stored in the powertrain control module (PCM). The vehicle may be unable to enter electric-only drive modes as expected during normal drive cycles. This may be due to the belt integrated starter generator (BISG). For vehicles with this condition, follow the necessary Pinpoint Test in Workshop Manual (WSM), Section 303-06 for DTC P0A1E and repair the vehicle as directed. Note that previous replacement of the BISG does not negate the need for subsequent BISG replacements if directed to do so by the appropriate Pinpoint Test diagnostics. Engineering is investigating this BISG quality concern. Monitor PTS for updates regarding this investigation.
Associated Products (12)Associated Documents - July 23, 2026•Document ID: 11035261Over The AirENGINE; FUEL/PROPULSION SYSTEM
- Mfr Comm. #:
- PT-26.11.3 F-150
- Date Added:
- July 28, 2026
- Manufacturer:
- FORD
Summary25S75 Recall remedy -Powertrain Control Module update to introduce logic to prevent low pressure fuel pump binding and maintain fuel flow to the engine.
Associated Products (1)Associated Documents - July 23, 2026•Document ID: 11035269Service Bulletin/Repair InstructionsUNKNOWN OR OTHER; ELECTRICAL SYSTEM; FUEL/PROPULSION SYSTEM
- Mfr Comm. #:
- SSM 55031
- Date Added:
- July 28, 2026
- Manufacturer:
- FORD
SummarySome 2021-2026 Ford/Lincoln vehicles may exhibit various symptoms including but not limited to the auto start/stop system not operating as intended with a "Check Charging System" message in the instrument panel cluster (IPC) while the charging system is operating properly with no charging related diagnostic trouble codes (DTC) stored. This may be due to someone using an aftermarket programmer to change the body control module (BCM) configuration to disable the auto start/stop system or perform other unsupported programming modifications. To correct this condition on F-150 and Bronco vehicles, download and run the Ford Diagnosis and Repair System (FDRS) application titled "BCM-Charging System Configuration Correction". Running this application will determine if the BCM configuration was modified by the customer and if so, provide the option to return the configuration back to factory settings. For other vehicle models exhibiting concerns related to unsupported aftermarket BCM programming, submit a Technical Support Request (TSR) requesting support to revert the BCM configuration
Associated Products (61)2026 Ford Bronco2026 Ford Bronco Sport2026 Ford Escape2026 Ford Expedition2026 Ford Explorer2026 Ford F-1502026 Ford Maverick2026 Ford Mustang2026 Ford Ranger2026 Ford Transit2026 Lincoln Aviator2026 Lincoln Corsair2026 Lincoln Nautilus2026 Lincoln Navigator2025 Ford Bronco2025 Ford Bronco Sport2025 Ford Escape2025 Ford Expedition2025 Ford Explorer2025 Ford F-150+ 41 moreAssociated Documents - July 21, 2026•Document ID: 11035267Service Bulletin/Repair InstructionsUNKNOWN OR OTHER; ELECTRICAL SYSTEM
- Mfr Comm. #:
- SSM 55028
- Date Added:
- July 28, 2026
- Manufacturer:
- FORD
SummarySome 2021-2024 Ford and Lincoln vehicles may exhibit an "Updating SYNC" message on the vehicle center display screen after an over the air (OTA) update. The message can be cleared from the center display screen and SYNC can be used normally, but it will re-appear at every subsequent ignition cycle. Inform customers that engineering is currently working on a software update solution for this condition to be delivered OTA expected in late Q3 2026. Software will update automatically if vehicle connectivity is enabled in the vehicles settings. Monitor Professional Technician System (PTS) for additional information.
Associated Products (20)2024 Ford Bronco2024 Ford Edge2024 Ford Expedition2024 Ford F-1502024 Lincoln Navigator2023 Ford Bronco2023 Ford Edge2023 Ford Expedition2023 Ford F-1502023 Lincoln Navigator2022 Ford Bronco2022 Ford Edge2022 Ford Expedition2022 Ford F-1502022 Lincoln Navigator2021 Ford Bronco2021 Ford Edge2021 Ford Expedition2021 Ford F-1502021 Lincoln NavigatorAssociated Documents - July 14, 2026•Document ID: 11035100Service Bulletin/Repair InstructionsSEATS; ELECTRICAL SYSTEM; UNKNOWN OR OTHER; VISIBILITY/WIPER
- Mfr Comm. #:
- SSM 55008
- Date Added:
- July 20, 2026
- Manufacturer:
- FORD
SummarySome 2021-2026 Ford vehicles may exhibit inoperative heated/cooled seats, heated steering wheel and/or front/rear defrost features after a remote start is performed through the Ford mobile application or with the key fob. Customers may also experience heated/cooled seats, heated steering wheel and/or front/rear defrost features turning on in unexpected conditions such as during warmer weather. These features will operate normally when commanded in the center display screen. This may be due to the customer not setting up their "Climate Settings" through the Ford mobile application. To correct this condition, inform the customer they should perform a remote start from the Ford mobile application and then adjust the "Climate Settings" in the Ford mobile application as desired. These settings only need to be set once and will persist through subsequent remote starts. Heated and cooled seats will be set to Level 2 when turned ON via "Climate Settings" in the Ford mobile application during a remote start event. This is normal operating characteristic. This condition does not affect vehicle durability and no a
Associated Products (13)Associated Documents - July 9, 2026•Document ID: 11035465EmissionsELECTRICAL SYSTEM; UNKNOWN OR OTHER
- Mfr Comm. #:
- 26E04
- Date Added:
- August 3, 2026
- Manufacturer:
- FORD
SummaryNEW VEHICLE DELIVERY HOLD - Emissions Recall 26E04 Certain 2021-2025 Model Year F-150, Maverick, Mustang, Ranger, Expedition, Bronco Sport, Explorer, Bronco, Navigator, and Aviator Vehicles Powertrain Control Module Software Update
Associated Products (49)2025 Ford Bronco2025 Ford Bronco Sport2025 Ford Expedition2025 Ford Explorer2025 Ford F-1502025 Ford Maverick2025 Ford Mustang2025 Ford Ranger2025 Lincoln Aviator2025 Lincoln Navigator2024 Ford Bronco2024 Ford Bronco Sport2024 Ford Expedition2024 Ford Explorer2024 Ford F-1502024 Ford Maverick2024 Ford Mustang2024 Ford Ranger2024 Lincoln Aviator2024 Lincoln Navigator+ 29 moreAssociated Documents - July 9, 2026•Document ID: 11034970Service Bulletin/Repair InstructionsPOWER TRAIN
- Mfr Comm. #:
- TSB 26-2294
- Date Added:
- July 13, 2026
- Manufacturer:
- FORD
SummaryThis bulletin supersedes 26-2066. Reason for update: To remove "(2024 only)" from the Issue statement to include 2021-2025 vehicles that may exhibit a clicking sound coming from the gear shift lever. Some of the vehicles listed in the Model statement above equipped with a console GSM may exhibit at least one of the following conditions: * Clicking sound coming from the gear shift lever after it is placed and kept in reverse, neutral or drive position. * Gear shift lever stuck in park * Gear shift lever will not shift into park * Gear shift lever will not shift out of gear * Gear shift lever will not stow/unstow * Gear shift lever will move past the park position * Loose gear shift lever arm at pivot * Illuminated powertrain malfunction (wrench) indicator with DTCs P0929:77, P0929:00, P0929:07 and/or P0929:9A stored in the GSM This may be due to the GSM. Note: If the gear shifter lever will not shift into park, the transmission will automatically shift into park when the return to park function is triggered.
Associated Products (5)Associated Documents - July 2, 2026•Document ID: 11034224Service Bulletin/Repair InstructionsPOWER TRAIN
- Mfr Comm. #:
- TSB 26-2309
- Date Added:
- July 1, 2026
- Manufacturer:
- FORD
SummaryThis bulletin supersedes 26-2241. Reason For Update: update the parts list to correct the claim quantity of the part number JB3Z-4B496-B from 3 to 6. Some of the vehicles listed in the Model statement above may exhibit at least one of the following conditions: * Harsh 3-4, 4-5 upshifts * Harsh 5-3, 4-3 downshifts * Harsh reverse engagements These symptoms may be worse when cold. This may be due to the F clutch friction plates brinelling into the clutch and planetary container cylinder (7B177).
Associated Products (22)2024 Ford Expedition2024 Ford Explorer2024 Ford F-1502024 Ford Mustang2024 Ford Transit2024 Lincoln Navigator2023 Ford Expedition2023 Ford Explorer2023 Ford F-1502023 Ford Mustang2023 Ford Ranger2023 Ford Transit2023 Lincoln Aviator2023 Lincoln Navigator2022 Ford Expedition2022 Ford Explorer2022 Ford F-1502022 Ford Mustang2022 Ford Ranger2022 Ford Transit+ 2 moreAssociated Documents - July 1, 2026•Document ID: 11034540Service Bulletin/Repair InstructionsPOWER TRAIN; ELECTRICAL SYSTEM
- Mfr Comm. #:
- TSB 26-2304
- Date Added:
- July 6, 2026
- Manufacturer:
- FORD
SummaryThis bulletin supersedes 25-2383. Reason for update: to add 2023-2026 F-150 2.7L vehicles. Some of the vehicles listed in the Model Statement may exhibit a vibration/shudder felt during light throttle tip in at highway speeds (8,9,10 gear) with no diagnostic trouble codes (DTC) present. This may be due to various software parameters in the powertrain control module (PCM).
Associated Products (6)Associated Documents - June 24, 2026•Document ID: 11034134Service Bulletin/Repair InstructionsELECTRICAL SYSTEM; UNKNOWN OR OTHER
- Mfr Comm. #:
- TSB 26-2297
- Date Added:
- June 29, 2026
- Manufacturer:
- FORD
SummarySome of the vehicles listed in the model statement above equipped with SYNC4 may experience a blank center display screen or black center display after welcome animation. The rear-view camera will still function when shifting the vehicle to reverse under these conditions.
Associated Products (38)2026 Ford Escape2026 Ford Mustang GTD2026 Lincoln Corsair2025 Ford Bronco2025 Ford Bronco Sport2025 Ford Escape2025 Ford F-1502025 Ford Maverick2025 Ford Mustang2025 Ford Ranger2025 Lincoln Corsair2024 Ford Bronco2024 Ford Edge2024 Ford Escape2024 Ford Expedition2024 Ford F-1502024 Ford Mustang2024 Ford Ranger2024 Lincoln Corsair2024 Lincoln Navigator+ 18 moreAssociated Documents - June 18, 2026•Document ID: 11034009Over The AirELECTRICAL SYSTEM
- Mfr Comm. #:
- BCMC-26.DG F-150
- Date Added:
- June 19, 2026
- Manufacturer:
- FORD
SummaryQuality improvements include: -Addresses a false trailer brake fault message when starting the vehicle in cold weather
Associated Products (3)Associated Documents - June 18, 2026•Document ID: 11034011Service Bulletin/Repair InstructionsPOWER TRAIN
- Mfr Comm. #:
- TSB 26-2287
- Date Added:
- June 22, 2026
- Manufacturer:
- FORD
SummaryThis article supersedes 25-2302. Reason for update: update the labor time allowance for F-150 vehicles, update the Parts list to replace the part number W716979-S439 with W721084-S439, and add a note for LV fluids XT-10-QLVC and CXT-10-LV6 "Transfer Case Fluid". Some of the vehicles listed in the Model statement above may exhibit at least one of the following conditions: Harsh engagement Delayed engagement Harsh shift Delayed shift Illuminated malfunction indicator lamp (MIL) with diagnostic trouble codes (DTC)s P0751, P0752, P0756, P0757, P0761, P0762, P0766, P0767, P0771, P0772, P2700, P2701, P2702, P2703, P2704, P2705, P2707, P2708, P0729, P0731, P0732, P0733, P0734, P0735, P0736, P076F, P07D9, P07F6 and/or P07F7 stored in the powertrain control module (PCM) or transmission control module (TCM). This may be due to axial movement of the CDF clutch cylinder sleeve causing hydraulic circuit leaks. NOTE: If internal transmission service is required to address a concern detected with the CDF clutch cylinder following this article, technicians should carefully inspect and replace other tra
Associated Products (9)Associated Documents - June 16, 2026•Document ID: 11034032Service Bulletin/Repair InstructionsUNKNOWN OR OTHER; ELECTRICAL SYSTEM
- Mfr Comm. #:
- SSM 54941
- Date Added:
- June 23, 2026
- Manufacturer:
- FORD
SummarySome 2022-2024 F-150 vehicles equipped with a perimeter alarm may exhibit a false alarm activation intermittently. This may be due to the software in the body control module (BCM). Monitor the BCM alarm event parameter identifications (PID). If ALARM_EVT_1/2/3/4 show a value of Intrusion Sensor, reprogram the BCM using the latest software level of the Ford Diagnosis and Repair System (FDRS) diagnostic scan tool. For claiming, use causal part 15604 and labor operations 12651D and BCM.
Associated Products (3)Associated Documents - June 16, 2026•Document ID: 11034019Service Bulletin/Repair InstructionsUNKNOWN OR OTHER; SERVICE BRAKES
- Mfr Comm. #:
- SSM 54940
- Date Added:
- June 22, 2026
- Manufacturer:
- FORD
SummarySome 2021-2026 F-150 vehicles may exhibit a U2100:00 diagnostic trouble code (DTC) for initial configuration incomplete stored in the trailer control module (TRM). This may be due to the vehicle having a Ford accessory trailer brake kit installed without being programmed following the included instructions. If the vehicle was built with minor feature code FDDAA and a trailer brake gain switch is present in the stock location in the instrument panel, a Ford Accessory trailer brake kit has been installed on the vehicle. If a Ford Accessory trailer brake kit is present, download and run the "TRM - Towbar Configuration" application using the latest software level of the Ford Diagnosis and Repair System (FDRS) scan tool. To confirm a vehicle is built with a certain minor feature code, review the build information by double-clicking the vehicle identification number (VIN) in the upper left corner in the Professional Technician System (PTS).
Associated Products (6)Associated Documents