Ford Maverick Service Bulletins

230 manufacturer communications on file.

January 17, 2024•Document ID: 10249790
Service Bulletin/Repair Instructions
POWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE (TCM/PCM/TECM); ELECTRICAL SYSTEM; POWER TRAIN
Mfr Comm. #:
SANVol 2 Issue 1
Date Added:
February 6, 2024
Manufacturer:
FORD
Summary
The Service Awareness Newsletter is an informal communication that contains information that may not be presently available in a TSB, SSM, GSB, or other electronic communication. This artile includes ifnormation on warranty, technical service tips and other service information.
Associated Products (15)
2025 Ford E-350 2024 Ford Bronco 2024 Ford Bronco Sport 2024 Ford E-350 2024 Ford E-450 2024 Ford Edge 2024 Ford Escape 2024 Ford Expedition 2024 Ford Explorer 2024 Ford F-150 2024 Ford Maverick 2024 Ford Mustang 2024 Ford Ranger 2024 Ford Transit 2024 Ford Transit Connect
Associated Documents
- Download MC-10249790-0001.pdf↗
November 14, 2023•Document ID: 10245385
Service Bulletin/Repair Instructions
EQUIPMENT
Mfr Comm. #:
SSM 52065
Date Added:
November 21, 2023
Manufacturer:
FORD
Summary
Some 2022-2023 Maverick vehicles equipped with hard, soft or roll-up bed covers accessories may exhibit a water intrusion into the pickup box floor. These accesories are not designed to be waterproof. Do not perform any repairs or submit a warranty claim for this condition
Associated Products (2)
2023 Ford Maverick 2022 Ford Maverick
Associated Documents
- Download MC-10245385-0001.pdf↗
November 9, 2023•Document ID: 10245258
Service Bulletin/Repair Instructions
POWER TRAIN
Mfr Comm. #:
SSM 52051
Date Added:
November 15, 2023
Manufacturer:
LINCOLN
Summary
Some 2019-2023 Edge/Nautilus and 2022-2023 Maverick vehicles equipped with all wheel drive (AWD) may exhibit chatter/shudder during low speed turning events. This may be due to fluid contamination in the rear drive unit (RDU). Drain and refill the RDU, refer to Workshop Manual Section (WSM) 205-02. Drive for 5 miles (8 km) in stop and go conditions with right and left turns and re-evaluate. If the issue is still present, continue with normal WSM diagnostics. For claiming, use causal part 4000.
Associated Products (8)
2023 Ford Edge 2023 Ford Maverick 2023 Lincoln Nautilus 2022 Ford Edge 2022 Ford Maverick 2022 Lincoln Nautilus 2021 Ford Edge 2021 Lincoln Nautilus
Associated Documents
- Download MC-10245258-0001.pdf↗
November 3, 2023•Document ID: 10246067
Service Bulletin/Repair Instructions
ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL
Mfr Comm. #:
23L04
Date Added:
December 5, 2023
Manufacturer:
FORD
Summary
Certain 2022 Maverick Vehicles Equipped With a 2.5L I4 Gas/Electric Engine - Vehicle Emissions Control Information (VECI) Label Update First part submitted 10/3/23
Associated Products (1)
2022 Ford Maverick
Associated Documents
- Download MC-10246067-0001.pdf↗
October 27, 2023•Document ID: 10244876
Service Bulletin/Repair Instructions
ENGINE AND ENGINE COOLING; HYBRID PROPULSION SYSTEM
Mfr Comm. #:
SSM 52024
Date Added:
November 4, 2023
Manufacturer:
LINCOLN
Summary
Some 2020-2023 Escape/2021-2023 Corsair equipped with 2.5L engine full hybrid electric vehicle (FHEV) and plug-in hybrid electric vehicle (PHEV) powertrain and 2022-2023 Maverick vehicles equipped with 2.5L engine FHEV powertrain may exhibit a condition where the 12V battery voltage is low or discharged with diagnostic trouble code (DTC) U3003:62 stored in the direct current/direct current converter control module (DC/DC). The vehicle may also exhibit DTC U3003:16 and/or U3000:04 stored in the DC/DC module. This may be due to an open in the 300 amp high-current fuse F4 located in the high-current battery junction box (BJB).
Associated Products (3)
2023 Ford Maverick 2023 Lincoln Corsair 2022 Ford Maverick
Associated Documents
- Download MC-10244876-0001.pdf↗
October 19, 2023•Document ID: 10244854
Service Bulletin/Repair Instructions
AIR BAGS: AIR BAG/RESTRAINT CONTROL MODULE; ELECTRICAL SYSTEM; AIR BAGS: AIR BAG/RESTRAINT CONTROL MODULE:SOFTWARE
Mfr Comm. #:
SSM 51998
Date Added:
November 3, 2023
Manufacturer:
FORD
Summary
Some 2023 Escape/Corsair vehicles built on 6-Apr-2023 and through 11-May-2023 and 2023 Bronco Sport/Maverick vehicles built on 30-Jan-2023 and through 6-Jun-2023 may exhibit an illuminated air bag warning indicator with DTC B0082:1A stored in the restraints control module (RCM). This may be due to an issue with the passenger seatbelt retractor at connector C303B. If a connection issue is found, replace the passenger front seatbelt retractor and pretensioner assembly before attempting a wiring repair. This issue does not affect the proper operation of the air bags, retractor and pretensioner. Refer to the Workshop Manual (WSM), Section 501-20A Seatbelt Systems > Removal and Installation. For claiming, use causal part 78611B08 and applicable labor times in Section 12 of the Service Labor Time Standards (SLTS) Manual.
Associated Products (4)
2023 Ford Bronco Sport 2023 Ford Escape 2023 Ford Maverick 2023 Lincoln Corsair
Associated Documents
- Download MC-10244854-0001.pdf↗
October 5, 2023•Document ID: 10244707
Service Bulletin/Repair Instructions
ELECTRICAL SYSTEM:SOFTWARE; UNKNOWN OR OTHER; EQUIPMENT:ELECTRICAL:INFOTAINMENT:SOFTWARE; EQUIPMENT:ELECTRICAL:NAVIGATIONAL SYSTEM(GLOBAL POSITIONING SYSTEM)
Mfr Comm. #:
TSB 23-2307
Date Added:
November 2, 2023
Manufacturer:
LINCOLN
Summary
Some 2019-2020 Edge/F-150/Fusion/Continental/MKZ/Nautilus, 2019-2021 Mustang/Ranger/Transit Connect, 2020-2021 EcoSport/Escape/Expedition/Explorer/F-Super Duty/Aviator/Corsair/Navigator, 2021 Bronco Sport and 2020-2022 Explorer/Aviator vehicles with SYNC 3 may experience various SYNC performance related concerns. This may be due to the SYNC Software. To correct the condition, follow the Service Procedure to update the SYNC module (APIM) software.
Associated Products (25)
2023 Ford Bronco Sport 2023 Ford Explorer 2023 Ford Maverick 2023 Ford Mustang 2023 Ford Ranger 2023 Lincoln Aviator 2022 Ford Bronco Sport 2022 Ford Escape 2022 Ford Explorer 2022 Ford Maverick 2022 Ford Mustang 2022 Ford Ranger 2022 Lincoln Aviator 2022 Lincoln Corsair 2021 Ford Bronco Sport 2021 Ford Ecosport 2021 Ford Escape 2021 Ford Expedition 2021 Ford Explorer 2021 Ford Mustang+ 5 more
Associated Documents
- Download MC-10244707-0001.pdf↗
October 4, 2023•Document ID: 10244716
Service Bulletin/Repair Instructions
POWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE (TCM/PCM/TECM); ELECTRICAL SYSTEM:SOFTWARE
Mfr Comm. #:
TSB 23-2315
Date Added:
November 2, 2023
Manufacturer:
FORD
Summary
Some 2023 Maverick vehicles built on or before 11-Apr-2023 and equipped with a 2.5L full hybrid electric vehicle (FHEV) powertrain may exhibit an illuminated malfunction indicator lamp (MIL) with diagnostic trouble code (DTC) P2282. This may be due to the software in the powertrain control module (PCM). To correct this condition, follow the Service Procedure to reprogram various modules starting with the PCM.
Associated Products (1)
2023 Ford Maverick
Associated Documents
- Download MC-10244716-0001.pdf↗
September 30, 2023•Document ID: 10243427
Service Bulletin/Repair Instructions
POWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE (TCM/PCM/TECM); POWER TRAIN
Mfr Comm. #:
23P18
Date Added:
October 3, 2023
Manufacturer:
FORD
Summary
Certain 2023 Model Year Maverick Vehicles Equipped with a 2.5L Duratec â Hybrid Engine - Powertrain Control Module (PCM) Reprogramming
Associated Products (1)
2023 Ford Maverick
Associated Documents
- Download MC-10243427-0001.pdf↗
September 30, 2023•Document ID: 10243425
Service Bulletin/Repair Instructions
ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL
Mfr Comm. #:
23L04
Date Added:
October 4, 2023
Manufacturer:
FORD
Summary
Certain 2022 Maverick Vehicles Equipped With a 2.5L I4 Gas/Electric Engine - Vehicle Emissions Control Information (VECI) Label Update In the affected vehicles, the VECI label lists an incorrect EPA test group.
Associated Products (1)
2022 Ford Maverick
Associated Documents
- Download MC-10243425-0001.pdf↗
September 28, 2023•Document ID: 10243653
Service Bulletin/Repair Instructions
SERVICE BRAKES, AIR:ANTILOCK:WHEEL SPEED SENSOR; EQUIPMENT
Mfr Comm. #:
SSM 51948
Date Added:
October 6, 2023
Manufacturer:
FORD
Summary
Some 2023 Escape, Corsair, Bronco Sport and Maverick vehicles built on 01-May-2023 and through 22-Sep-2023 may exhibit a squeal and/or grinding noise and/or vibration from the front brakes while braking. This may be due to excessive wheel hub lateral runout. To correct this condition, remove the front brake disc(s) of the affected wheel(s). Refer to the Workshop Manual (WSM), Section, 206-03. Clean the raised ring-like surface of the front wheel hub near the wheel studs. Using a dial indicator, slowly rotate the wheel hub and measure the runout on the ring-like surface. If the total runout exceeds 0.001 inch (0.03mm), replace the wheel hub. Refer to the WSM, Section 204-01. Document the measured run out in the warranty claim. For claiming use the causal part number 1104 and applicable labor operations in Section 01 of the Service Labor Time Standards (SLTS)
Associated Products (4)
2023 Ford Bronco Sport 2023 Ford Escape 2023 Ford Maverick 2023 Lincoln Corsair
Associated Documents
- Download MC-10243653-0001.pdf↗
September 14, 2023•Document ID: 10243534
Service Bulletin/Repair Instructions
POWER TRAIN; POWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE (TCM/PCM/TECM); UNKNOWN OR OTHER
Mfr Comm. #:
SSM 51921
Date Added:
October 4, 2023
Manufacturer:
FORD
Summary
Some 2022-2023 Maverick vehicles equipped with 2.5L full hybrid electric vehicle (FHEV) powertrain may exhibit an illuminated malfunction indicator lamp (MIL) with diagnostic trouble codes (DTCs) P2C22, P237C and/or P237D stored in the powertrain control module (PCM). This may be due to water intrusion in the exhaust heat exchanger.
Associated Products (2)
2023 Ford Maverick 2022 Ford Maverick
Associated Documents
- Download MC-10243534-0001.pdf↗
August 4, 2023•Document ID: 10240574
Service Bulletin/Repair Instructions
POWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE (TCM/PCM/TECM); UNKNOWN OR OTHER; POWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE:SOFTWARE
Mfr Comm. #:
TSB 23-2248
Date Added:
August 10, 2023
Manufacturer:
FORD
Summary
Some 2022-2023 Maverick vehicles built on or before 11-Apr-2023 and equipped with a 2.5L full hybrid electric vehicle (FHEV) powertrain may exhibit a shudder or vibration when the vehicle is braking at 15 mph (24 km/h) or below, when the gas engine shuts down and the vehicle is operating in electric mode only. This may be due to the software in the powertrain control module (PCM). To correct this condition, follow the Service Procedure to reprogram various modules starting with the PCM.
Associated Products (2)
2023 Ford Maverick 2022 Ford Maverick
Associated Documents
- Download MC-10240574-0001.pdf↗
August 2, 2023•Document ID: 10241627
Service Bulletin/Repair Instructions
ELECTRICAL SYSTEM
Mfr Comm. #:
SSM 51838
Date Added:
September 4, 2023
Manufacturer:
LINCOLN
Summary
In various 2017-2023 Ford and Lincoln vehicles, customers may receive a message in the FordPass or LincolnWay App stating Feature Unavailable. Since this is a fleet vehicle, it cannot access the (SYNC Connect) FordPass or LincolnWay app through the TCU Embedded Modem. If this message appears, the vehicle may be equipped with a fleet telematics module. Replacement of the TCU or TCU related repairs will not prevent this message from appearing. Refer the customer to in app FordPass Guides or LincolnWay Concierge Teams to aid with fleet telematics removal. Open app, select Account > Help > CHAT or CALL option.
Associated Products (44)
2023 Ford Bronco 2023 Ford Bronco Sport 2023 Ford Edge 2023 Ford Escape 2023 Ford Expedition 2023 Ford Explorer 2023 Ford F-150 2023 Ford Maverick 2023 Ford Mustang 2023 Ford Ranger 2023 Ford Transit 2023 Lincoln Aviator 2023 Lincoln Corsair 2023 Lincoln Nautilus 2023 Lincoln Navigator 2022 Ford Bronco 2022 Ford Bronco Sport 2022 Ford Edge 2022 Ford Escape 2022 Ford Expedition+ 24 more
Associated Documents
- Download MC-10241627-0001.pdf↗
August 1, 2023•Document ID: 10240577
Service Bulletin/Repair Instructions
POWER TRAIN; UNKNOWN OR OTHER; EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL
Mfr Comm. #:
SSM 51823
Date Added:
August 11, 2023
Manufacturer:
LINCOLN
Summary
Some 2019-2023 Edge/Nautilus, 2020-2023 Escape/Corsair, 2021-2023 Bronco Sport, 2022-2023 Maverick vehicles equipped with all wheel drive (AWD) may exhibit chatter/shudder during low speed turning events. This may be due to fluid contamination in the rear drive unit (RDU). Drain and refill the RDU, refer to Workshop Manual Section (WSM) 205-02. Drive for 5 miles (8 km) in stop and go conditions with right and left turns and re-evaluate. If the issue is still present, continue with normal WSM diagnostics. For claiming, use base (4000) causal part.
Associated Products (17)
2023 Ford Bronco Sport 2023 Ford Edge 2023 Ford Escape 2023 Ford Maverick 2023 Lincoln Corsair 2023 Lincoln Nautilus 2022 Ford Bronco Sport 2022 Ford Edge 2022 Ford Escape 2022 Ford Maverick 2022 Lincoln Corsair 2022 Lincoln Nautilus 2021 Ford Bronco Sport 2021 Ford Edge 2021 Ford Escape 2021 Lincoln Corsair 2021 Lincoln Nautilus
Associated Documents
- Download MC-10240577-0001.pdf↗
July 24, 2023•Document ID: 10239630
Service Bulletin/Repair Instructions
STEERING
Mfr Comm. #:
SSM 51812
Date Added:
July 25, 2023
Manufacturer:
FORD
Summary
Some 2020-2022 Escape/Corsair, 2021-2022 Bronco Sport, and 2022 Maverick vehicles built on or before 23-Mar-2022 may exhibit a hard, stiff, and/or difficult to turn condition due to a lack of power steering assist during engine start-up with U3000 diagnostic trouble codes (DTCs) stored in the PSCM. Using the latest version of Ford Diagnosis and Repair System (FDRS) tool, select and run the PSCM - Reset the Power Steering Control Module (PSCM) application. After PSCM reset, perform an ignition cycle. Update the PSCM to the latest software level using FDRS tool. If the U3000 DTC returns, continue with diagnostics and repair direction using Workshop Manual (WSM), Section 211-02 > Power Steering > Diagnosis and Testing. For claiming, use causal part 3C529 and applicable labor operations in Section 10 of the Service Labor Time Standards (SLTS) Manual.
Associated Products (7)
2022 Ford Bronco Sport 2022 Ford Escape 2022 Ford Maverick 2022 Lincoln Corsair 2021 Ford Bronco Sport 2021 Ford Escape 2021 Lincoln Corsair
Associated Documents
- Download MC-10239630-0001.pdf↗
June 30, 2023•Document ID: 10238445
Service Bulletin/Repair Instructions
POWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE (TCM/PCM/TECM); POWER TRAIN
Mfr Comm. #:
TSB 23-2209
Date Added:
July 3, 2023
Manufacturer:
FORD
Summary
Some 2023 Maverick vehicles built on or before 11-Apr-2023 and equipped with a 2.5L full hybrid electric vehicle (FHEV) powertrain may exhibit a shudder or vibration when the vehicle is braking at 15 mph (24 km/h) or below, when the gas engine shuts down and the vehicle is operating in electric mode only. This may be due to the software in the powertrain control module (PCM). To correct this condition, follow the Service Procedure to reprogram the PCM.
Associated Products (1)
2023 Ford Maverick
Associated Documents
- Download MC-10238445-0001.pdf↗
June 23, 2023•Document ID: 10238867
Service Bulletin/Repair Instructions
ELECTRICAL SYSTEM
Mfr Comm. #:
22B39 S1
Date Added:
July 7, 2023
Manufacturer:
FORD
Summary
Certain 2022 Maverick HEVs Maverick No-start Condition Reason for supplement- labor operation updates
Associated Products (1)
2022 Ford Maverick
Associated Documents
- Download MC-10238867-0001.pdf↗
June 22, 2023•Document ID: 10238889
Service Bulletin/Repair Instructions
SERVICE BRAKES; EQUIPMENT
Mfr Comm. #:
23P02
Date Added:
July 7, 2023
Manufacturer:
FORD
Summary
Certain 2023 Model Year Maverick Vehicles with an Electronic Brake Booster Electronic Brake Booster Replacement In the affected vehicles, the Electronic Brake Booster (EBB) may have an internal leak in the normally closed valve due to a flat spot on the ball of the armature assembly
Associated Products (1)
2023 Ford Maverick
Associated Documents
- Download MC-10238889-0001.pdf↗
June 22, 2023•Document ID: 10238882
Service Bulletin/Repair Instructions
EQUIPMENT; ELECTRICAL SYSTEM
Mfr Comm. #:
23B34
Date Added:
July 7, 2023
Manufacturer:
FORD
Summary
Certain 2022 Model Year Maverick Vehicles Install Missing USB Wire Harness In all of the affected vehicles, a parts shortage led to assembly of the vehicle without the USB cable connection from the radio. This will cause the USB ports to be inoperable.
Associated Products (1)
2022 Ford Maverick
Associated Documents
- Download MC-10238882-0001.pdf↗

← Back to Ford Maverick