Ford · Model Report
Showing safety data for the 2024 model year only.
Ford Motor Company (Ford) is recalling certain 2021-2026 Bronco and Bronco Raptor vehicles. The engine compartment wiring harness may become damaged and short circuit.
Ford Motor Company (Ford) is recalling certain 2022-2026 Bronco vehicles. The fender flares may not be properly secured and detach from the vehicle.
Ford Motor Company (Ford) is recalling certain 2024-2026 Ranger and Bronco vehicles. The front seats may have a loose or dislodged seat frame height-adjust pivot bolt.
Ford Motor Company (Ford) is recalling certain 2021-2025 Bronco vehicles. The transmission to transfer case joint may be misaligned due to an incorrectly performed previous repair, which could lead to wear of the transmission output shaft splines and transfer case input splines.
Ford Motor Company (Ford) is recalling certain 2021-2026 Ford Bronco and 2021-2024 Ford Edge vehicles. The Accessory Protocol Interface Module (APIM) may overheat and shutdown, which can prevent the rearview camera image from displaying as intended.
I have a 2024 ford bronco 2.3 with a manual transmission 13256 miles .This Saturday we left early in the morning to go to flagstaff. We got on the freeway about to 60 and go in to 6th gear pushed clutch in and it stuck to the floor tryed pull it up and did come back up had a horrible smell and than stop moving could not put in gear and coated off the freeway shut car off let it sit for 5 minutes and started back up put in first gear did not move called road side and was told I could get it towed to the dealership and if it covered under warranty they reimburse me for the tow . I said so your leaving us stranded on the freeway with a car thet should be towed in under worenty this is not safe . 1.5 hours later the tow guy came and was towed to the [XXX] ford which I had [XXX] as my service writer she asked if maby we left the emergency brake on because of the smell than said there is an open recall that need repaired well I like to get the [XXX] to move forward or revers told her the clutch pedal went to the floor and did not come back up and in my experience the hydraulic system in the clutch went out and may have wiped out the clutch I let her know we have 3 cars at home thet are all manual transmission all v8 fro 5000 miles to 105 and never have I had a clutch problem but she had to get the well this is a were and tair idem and you may have to pay for the repair this is the problem shit product and you say it’s bumpers to bumper but they want to charg you any way they can my advice stop bying fords I know this will be are last one ever what a horrible experance and not a peace of mind at all also like all their adversaries say built solid like a rock them should say if you hit a rock your worinty is void INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
No injuries · No fire · No crash
I am the homeowner and the mother of the vehicle owner, [XXX]. I am submitting this statement about a fire involving her parked Ford Bronco in my garage. I was the only person home when I discovered the fire. At approximately 8:30 p.m. on XXX, I had just gotten out of my backyard pool when I heard a loud thump that seemed to come from around the garage. After entering the house, I heard another loud sound. When I opened the door between the house and garage, smoke came into the house. I called [XXX]. [XXX] texted me at 8:34 pm as she received a text notification that her tire pressure was low and asked me to check. I went outside through the front door to the driveway and opened the garage door. Black smoke came out. While speaking with [XXX], I obtained a garden hose and returned to the garage, where I saw active flames coming from the rear-left area of the Bronco. I used the hose on the visible flames. Firefighters arrived approximately five minutes later and took over. By then, I had extinguished most of the flames I could see. There were no injuries. The Bronco had last been driven on Saturday night, XXX. [XXX] flew to [XXX] on Sunday, XXX, and returned home Thursday morning, XXX No one used the Bronco during those days. It remained parked in the garage and was not running when I discovered the fire. Smoke entered the house, and there was damage affecting the garage and its electrical system. The full extent of the property damage is still being assessed. The vehicle was moved out of the garage after the fire. Mercury subsequently arranged towing to [XXX] for investigation. The investigator’s last verbal comment to us was that he thought it was the rear taillight. I understand this to be a preliminary opinion, not a final determination. As of XXX, I have not received a written investigative report and do not know what cause the investigator or insurers will ultimately report. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
My 2024 Ford Bronco repeatedly loses power without warning while driving, including on highways, suddenly slowing to approximately 32 mph. It also fails to accelerate from traffic lights, leaving me stranded in traffic. Dashboard warnings include Powertrain Malfunction, Service AdvanceTrac, Check 4x4, and Pre-Collision Assist Unavailable. On September 30, 2026, at 9:43 PM, the vehicle lost power on the road, nearly causing a rear-end collision. I have videos documenting six incidents between September 30 and October 15, 2026. This dangerous problem has continued since May 2025. Briarwood Ford has attempted repairs seven times, including replacing the accelerator pedal twice and replacing or repairing the engine wiring harness. The vehicle has been out of service for over 60 days, yet the problem continues. Ford diagnostic data from October 15–16 identified codes P2138, U0401, U0403, and U0418. I no longer trust this vehicle to transport my family to chemotherapy appointments or allow my children to drive it. Sudden power loss in traffic creates a serious risk of injury or death. I request an immediate NHTSA safety investigation into this recurring, unresolved defect.
No injuries · No fire · No crash
Front Differential Mount Frame Bracket Cracked Or Broken. See Ford TSB 25-2613 for detail. The Frame Bracket on my vehicle was making a loud clink/clunk sound. The broken bracket was verified by the Ford Dealer on my vehicle and is awaiting a repair. If this failure had occurred during highway speed the left front drive axel would have been placed in a bind and steering could have been lost. A roll over accident could have occurred as a result. Note: I did own a 2022 model of the same type that developed the same sound, Ford dealer verified the sound but did not find the source. The TSB 25-2613 had not been released at that time 9/2025. The 2022 was traded in and has now been resold to an unknown person who possibly has the same Frame Bracket issue.
No injuries · No fire · No crash
The component in question is the MIC Hardtop roof of my 2024 Bronco Raptor. It would seem that there is a current delamination on the roof, similarly to what was recalled on the 21-22 models, for the process and equipment parameter showing clear issues to the current bubbling, cracks and separation from the underlaying layer of the roof. It can be shown through cracks, "snake skinning" and clear integrity of the roof with the material dissolving that the roof is degradation. In regards to safety, you can hear the popping and cracking from the inside of the cabin in the vehicle while going any excess of 20mph. The issue in the past with these MIC hardtop roofs that in a worst case scenario, parts of the roof could detach while the vehicle is moving and potentially create a road hazard and increasing crash risk. Upon bringing this issue to Stamford Ford of Connecticut and All American Ford of Paramus of New Jersey, they both notified me that Ford has rejected my claim, even under the current vehicles bumper to bumper factor warranty. Rationale of the rejection being it is to be believed on their end this is contributed to elemental, environmental or chemical causes. In turn, I explained to them if they were to do a simple Google search on official Bronco forums, you will see hundreds if not thousands of people with the same issue where the integrity of the roofs , like Ford MIC roofs in the past, are mysteriously deteriorating where the inside layer is separating to the top. Ford Motor Company claims that they have been provided photographs which I have never been provided to nor have any evidence that they were provided photographic evidence of my roof.
No injuries · No fire · No crash