Ford · Model Report
Showing safety data for the 2022 model year only.
Ford Motor Company (Ford) is recalling certain 2020-2026 Explorer and Lincoln Aviator vehicles. The seat belt anchor bolts at the second-row outer seating positions may be improperly secured.
Ford Motor Company (Ford) is recalling certain 2020-2022 Escape, Lincoln Corsair, 2020-2024 Lincoln Aviator, and Explorer vehicles. The image on the center display may flip or invert, resulting in an incorrectly displayed rearview image when the vehicle is placed in reverse. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 111, "Rear Visibility."
Ford Motor Company (Ford) is recalling certain 2020-2022 Explorer, Escape, Lincoln Aviator, and Lincoln Corsair vehicles. The windshield wiper motor may fail and prevent the windshield wipers from operating properly.
Ford Motor Company (Ford) is recalling certain 2016-2019 Lincoln MKC, 2016-2023 Explorer, 2019-2020 Fusion, 2019-2024 Ranger, 2020-2022 Lincoln Corsair, Escape, 2021-2024 Bronco, Bronco Sport, and 2022-2024 Maverick vehicles. The engine block heater may crack and develop a coolant leak, causing it to short circuit when the block heater is plugged in.
Ford Motor Company (Ford) is recalling certain 2021-2023 Bronco, Explorer, Lincoln Aviator, F-250 SD, F-350 SD, F-450 SD, F-550 SD, 2021-2022 Lincoln Navigator, Mustang, F-150, and 2022 Expedition vehicles. The low-pressure fuel pump may fail, which can result in an engine stall while driving.
While operating the vehicle, a loud clunk occurred, followed by a grinding noise. I stopped the vehicle immediately. Upon exiting, I observed the rear driver‑side tire positioned at an abnormal angle. Inspection underneath the vehicle revealed a fractured rear control arm. This failure is consistent with recall 23S55, which applies to Ford Explorers manufactured between 6/25/21 and 7/6/22. My vehicle’s build date is July 2022, which falls within the affected production window. The damage is clearly consequential to the control arm failure.
No injuries · No fire · No crash
Rear wiper was working intermittently now it does not work at all. I notice campaign 26S14 (NHTSA Campaign 26V117) but my vin is not included. Even though I have the same problem
No injuries · No fire · No crash
RECALL COMPLIANCE & SAFETY DEFECT DESCRIPTION: The vehicle was transported via roadside assistance to a licensed manufacturer dealership due to severe engine overheating under an active manufacturer safety recall. Service personnel systematically modified intake paperwork to alter the true mechanical state upon arrival, removing safety recall and towing documentation. Intake files were falsified with the notation stating that the customer reported a bad battery, executed solely to evade mandatory factory safety recall tracking protocols and obscure dealer liability for subsequent failures. UNAUTHORIZED SHOP-FLOOR HAZARDS & MECHANICAL DAMAGE: Following custody transfer, shop technicians induced severe physical damage to the vehicle's twin-turbocharger assembly, resulting in a snapped turbo stud and a torn engine air filter. The vehicle was subsequently operated on public roads by shop personnel for 75 to 80 unauthorized miles under active engine overheating conditions without correcting thermal or safety recall failures, creating an immediate risk of catastrophic engine block structural cracking. The safety failures triggered 13 critical system fault codes across powertrain, electrical, and battery systems, which went entirely unaddressed while the shop attempted to compel payment under an altered repair estimate. CYBER SABOTAGE OF OUTBOUND SAFETY TELEMATICS: To actively obstruct diagnostic tracking and safety verification, shop staff executed a forced remote network reset of the vehicle's cellular modem. This reset deliberately severed user profile access and entirely deactivated the outbound telematics pipeline to systematically block the outbound transmission of the 13 powertrain and thermal fault messages to the user and manufacturer databases.
No injuries · No fire · No crash
I purchased a 2022 Ford Explorer XLT in March 2026 with approximately 19,500 miles on the vehicle. While driving, I suddenly heard a loud noise above me. I looked up and discovered that a clip from the panoramic sunroof shade had broken. I took the vehicle to the dealership for inspection and was informed the repair would cost approximately $500. While waiting at the dealership, another customer arrived with the same problem on their Ford Explorer. This is a safety concern because the unexpected noise distracted me while I was driving and caused me to look away from the road to determine what had happened. A component of the panoramic sunroof shade should not fail under normal use, especially at such low mileage.
No injuries · No fire · No crash
Exhaust manifold turbo charged cracked while driving. Exposing everyone in the vehicle to raw exhaust inside the vehicle every time it is driven. The replacement part is back ordered until September 16th from the dealership. I was told this is an extremely common issue with ford explorers. I don’t understand how this part is not recalled. It has slowly gotten worse and worse. No warning lamps came on. You can hear the engine or manifold rattling/ticking while the vehicle is running. The vehicle is available for inspection. I brought the vehicle to a repair shop called MIDAS. Where I was told exactly what was wrong with it. The problem is reproduced every single time the vehicle is on. The replacement part is also not covered under fords “emissions warranty”. Even though it is part of the emissions.
No injuries · No fire · No crash