Ford F-150 Service Bulletins (2024)
282 manufacturer communications on file.
- May 30, 2026•Document ID: 11033575Service Bulletin/Repair InstructionsPOWER TRAIN
- Mfr Comm. #:
- TSB 26-2263
- Date Added:
- June 5, 2026
- Manufacturer:
- LINCOLN
SummaryThis bulletin supersedes 26-2112. Reason For Update: add 2026 model year vehicles, update LV fluid XT-10-QLVC and CXT-10-LV6 description to add "Transfer Case Fluid 4WD Only", and update Step 4 to inspect/replace 7H351 and 7B177 outside of this article. Some of the vehicles listed in the Model statement above may exhibit at least one of the following conditions: - No upshift past second gear - Unable to achieve third gear ratio - Illuminated MIL with DTCs P0757 and P2701 This may be due to a damaged one-way clutch (OWC).
Associated Products (18)2026 Ford Expedition2026 Ford Explorer2026 Ford F-1502026 Ford Mustang2026 Ford Transit2026 Lincoln Navigator2025 Ford Expedition2025 Ford Explorer2025 Ford F-1502025 Ford Mustang2025 Ford Transit2025 Lincoln Navigator2024 Ford Expedition2024 Ford Explorer2024 Ford F-1502024 Ford Mustang2024 Ford Transit2024 Lincoln NavigatorAssociated Documents - May 27, 2026•Document ID: 11033253Service Bulletin/Repair InstructionsUNKNOWN OR OTHER; ELECTRICAL SYSTEM
- Mfr Comm. #:
- SSM 54877
- Date Added:
- June 3, 2026
- Manufacturer:
- FORD
SummarySome 2024-2026 F-150 vehicles may experience a no crank/no start condition and/or display various warning indicators/messages in the instrument panel cluster (IPC), including but not limited to, "Pre-Collision Assist Not Available", "Hill Start Assist Not Available", "Pre-Collision Assist Fault", and/or "Service AdvanceTrac". The vehicle may also have multiple communication fault diagnostic trouble codes (DTC) related to the high-speed control area network 2 (HS-CAN2) and the flexible data rate control area network (FD-CAN) modules and/or the entire network may be unresponsive. This may be due to improperly seated connector and/or a pin fit condition in connector C210. <br /><br /> If the vehicle exhibits the above conditions, access and inspect connector C210 for proper attachment, pin fit, and/or damage and repair as necessary. This connector can be accessed by removing the glovebox from its hinge. Refer to Workshop Manual (WSM), Section 412-00 Climate Control System - General Information > Removal and Installation > Cabin Air Filter and perform Steps 1 and 2. If the fault persists, refer to WSM, Sec
Associated Products (3)Associated Documents - May 27, 2026•Document ID: 11033252Service Bulletin/Repair InstructionsFUEL/PROPULSION SYSTEM; EXTERIOR LIGHTING
- Mfr Comm. #:
- SSM 54874
- Date Added:
- June 3, 2026
- Manufacturer:
- FORD
SummarySome 2024-2026 F-150 vehicles may exhibit an incorrect fuel gauge indication when distance to empty (DTE) is below 50 miles. Workshop Manual (WSM), Sections 413-01 > Description and Operation > Instrument Panel Cluster (IPC) - System Operation and Component Description along with 413-01 > Diagnosis and Testing > Pinpoint Test D have been updated for this concern.
Associated Products (3)Associated Documents - May 18, 2026•Document ID: 11032914Service Bulletin/Repair InstructionsELECTRICAL SYSTEM; FUEL/PROPULSION SYSTEM
- Mfr Comm. #:
- SSM 54838
- Date Added:
- May 26, 2026
- Manufacturer:
- FORD
SummarySome 2024 F-150 vehicles may exhibit a condition where the volume is limited to 14 with a "MyKey volume limited" message in the center display screen. To resolve this concern, disconnect the vehicle's 12-volt battery cables for 10 minutes and reconnect. For hybrid vehicles, disconnect the vehicle's primary 12-volt battery and the auxiliary battery located under the rear seat. Refer to Workshop Manual (WSM), Section 414-01. If a battery reset does not resolve this solution inform customers that engineering is currently working on a solution. Monitor Professional Technician System (PTS) for additional information and schedule service appointments for customers once the repair becomes available. If a customer's vehicle exhibits this concern, submit a Vehicle Concern Report. To submit a report, click on the "Submit Global Concern Report (GCR)" link at the upper right of the PTS Vehicle ID screen (vehicle identification number ÝVIN¨ required) and fill out the form. Include the article number of this message in the text of the form. Do not use the "Report A Problem" link to submit a report for this condition.
Associated Products (1)Associated Documents - May 18, 2026•Document ID: 11032750Service Bulletin/Repair InstructionsPOWER TRAIN
- Mfr Comm. #:
- TSB 26-2241
- Date Added:
- May 18, 2026
- Manufacturer:
- FORD
SummaryThis bulletin supersedes 25-2587. Reason For Update: update the Parts list to add the F-clutch friction plates HL3Z-7B164-D and the F-clutch steel plates PR3Z-7B164-A for the proper vehicle lines, replace the transfer case mounting bolt part number from W714288-S438 to W714288-S437, update the part number W720688-S439 quantity from 2 to 1, update the part number ML3Z-7869-C claim quantity from 2 to 1 (only if necessary), update the description of CXT-10-LV6 and XT-10-QLVC by adding "transfer case fluid, 4WD only", move HL3Z-7A191-B and L1MZ-7F396-A fluid pan gaskets to the parts to inspect and replace list, and remove TL1Z-6775-A self adhesive heat shield from the F-150/Expedition/Navigator parts list as it is not a discard item. Some of the vehicles listed in the Model statement above may exhibit at least one of the following conditions: * Harsh 3-4, 4-5 upshifts * Harsh 5-3, 4-3 downshifts * Harsh reverse engagements These symptoms may be worse when cold. This may be due to the F clutch friction plates brinelling into the clutch and planetary container cylinder (7B177).
Associated Products (22)2024 Ford Expedition2024 Ford Explorer2024 Ford F-1502024 Ford Mustang2024 Ford Transit2024 Lincoln Navigator2023 Ford Expedition2023 Ford Explorer2023 Ford F-1502023 Ford Mustang2023 Ford Ranger2023 Ford Transit2023 Lincoln Aviator2023 Lincoln Navigator2022 Ford Expedition2022 Ford Explorer2022 Ford F-1502022 Ford Mustang2022 Ford Ranger2022 Ford Transit+ 2 moreAssociated Documents - May 15, 2026•Document ID: 11032757Service Bulletin/Repair InstructionsPOWER TRAIN
- Mfr Comm. #:
- SSM 54824
- Date Added:
- May 19, 2026
- Manufacturer:
- FORD
SummarySome 2023-2026 F-150 Raptor R vehicles may experience an intermittent extended crank condition when starting the vehicle with no powertrain related diagnostics trouble codes (DTC) stored in the powertrain control module (PCM). This condition will not prevent the vehicle from starting. This may be due to the software in the PCM. This condition does not affect vehicle durability, and no additional diagnosis or service is required for this condition at this time. Inform customers that they can continue to drive the vehicle and engineering is currently working on a solution for this condition that is expected by the end of Q3 2026. Replacement or reprogramming of the PCM will not resolve this condition. Monitor Professional Technician System (PTS) for additional information and schedule service appointments for customers once the repair becomes available. <br /><br /> If a vehicle exhibits this concern, click on the "Submit Global Concern Report (GCR)" link at the upper right of the PTS Vehicle ID screen (vehicle identification number ÝVIN¨ required) and fill out the form. Do not use the "Report A Problem"
Associated Products (4)Associated Documents - May 14, 2026•Document ID: 11032749Service Bulletin/Repair InstructionsPOWER TRAIN
- Mfr Comm. #:
- TSB 26-2238
- Date Added:
- May 18, 2026
- Manufacturer:
- FORD
SummaryThis article supersedes TSB 26-2130 to update labor operation to reprogram the PCM and check EVAP system from actual time to fixed time, and add extra time to reprogram coordinated modules (if required). Some of the vehicles listed in the Model statement above may exhibit an illuminated malfunction indicator lamp (MIL) with diagnostic trouble code (DTC) P2450 stored in the powertrain control module (PCM). This may be due to the software in the PCM.
Associated Products (5)Associated Documents - May 14, 2026•Document ID: 11032747Service Bulletin/Repair InstructionsENGINE
- Mfr Comm. #:
- TSB 26-2233
- Date Added:
- May 18, 2026
- Manufacturer:
- FORD
SummaryThis article supersedes TSB 26-2116 to clarify the prior approval statement. Some of the vehicles listed in the model statement above may exhibit an oil leak from the oil filter adapter to engine block mounting area. This may be due to block porosity or a block crack just below the oil filter adapter near the main bearing cap outer bolt.
Associated Products (4)Associated Documents - May 7, 2026•Document ID: 11032693Service Bulletin/Repair InstructionsELECTRICAL SYSTEM; UNKNOWN OR OTHER
- Mfr Comm. #:
- TSB 26-2185
- Date Added:
- May 14, 2026
- Manufacturer:
- FORD
SummaryThis bulletin supersedes 25-2621. Reason for update: add 2026 model year vehicles and Transit, update the causal part number (15604), update the Service Procedure, update the service labor operations for 2023 F-Super Duty, and add service labor operations for Transit. Some vehicles listed in the Model statement above may exhibit a no crank/no start condition where the customer cannot start their vehicle. The vehicle may also exhibit a "No Key Detected" message displayed on the instrument panel cluster (IPC), and no key fob works in the back up slot. The remote keyless entry (RKE) functionality will work to lock/unlock the vehicle.
Associated Products (23)2026 Ford Bronco2026 Ford Expedition2026 Ford Explorer2026 Ford F-1502026 Ford Mustang2026 Ford Ranger2026 Lincoln Aviator2026 Lincoln Nautilus2026 Lincoln Navigator2025 Ford Bronco2025 Ford Expedition2025 Ford Explorer2025 Ford F-1502025 Ford Mustang2025 Ford Ranger2025 Lincoln Aviator2025 Lincoln Nautilus2025 Lincoln Navigator2024 Ford Bronco2024 Ford F-150+ 3 moreAssociated Documents - May 6, 2026•Document ID: 11032695Service Bulletin/Repair InstructionsEXTERIOR LIGHTING; POWER TRAIN; ENGINE
- Mfr Comm. #:
- TSB 26-2217
- Date Added:
- May 14, 2026
- Manufacturer:
- FORD
SummaryThis bulletin supersedes 24-2441. Reason for update: consolidation of prior bulletins and an update the Service Procedure to diagnose and replace the cylinder head temperature (CHT) sensor with an updated version. Some of the vehicles listed in the Model Statement above may exhibit all of the following conditions: * Illuminated power train malfunction (wrench) indicator/malfunction indicator lamp (MIL) with diagnostic trouble codes (DTCs) P1299, P1285 and/or P2C39 stored in the powertrain control module (PCM). * "Engine Over-Temperature" and/or Service Vehicle Soon warning message(s) displayed in the instrument panel cluster (IPC) This may be due to the software in the PCM and/or the CHT sensor. Note: The vehicle's cooling fan will operate normally with no loss of engine coolant.
Associated Products (2)Associated Documents - April 30, 2026•Document ID: 11032251Service Bulletin/Repair InstructionsELECTRICAL SYSTEM; UNKNOWN OR OTHER
- Mfr Comm. #:
- SSM 54729
- Date Added:
- May 5, 2026
- Manufacturer:
- FORD
SummarySome 2024 F-150 vehicles may exhibit a condition where the volume is limited to 14 with a "MyKey volume limited" message in the SYNC screen. To resolve this concern, disconnect the vehicle's 12-volt battery cables for 10 minutes and reconnect. If a battery reset does not resolve this solution inform customers that engineering is currently working on a solution. Monitor Professional Technician System (PTS) for additional information and schedule service appointments for customers once the repair becomes available. If a customer's vehicle exhibits this concern, submit a Vehicle Concern Report. To submit a report, click on the "Submit Global Concern Report (GCR)" link at the upper right of the PTS Vehicle ID screen (vehicle identification number ÝVIN¨ required) and fill out the form. Include the article number of this message in the text of the form. Do not use the "Report A Problem" link to submit a report for this condition. For claiming, use causal part 18C869 and labor operation 10654C.
Associated Products (1)Associated Documents - April 29, 2026•Document ID: 11032246Service Bulletin/Repair InstructionsELECTRICAL SYSTEM; UNKNOWN OR OTHER
- Mfr Comm. #:
- SSM 54786
- Date Added:
- May 5, 2026
- Manufacturer:
- FORD
SummarySome 2022-2024 F-150 vehicles may exhibit a condition where the intrusion alarm will activate without an external source. This may be due to the software in the body control module (BCM). Reprogramming or replacing the BCM may not resolve this condition. Inform customers that engineering is currently working on a solution for this condition expected by the end of Q2 2026. Inform the customer that the alarm can be disabled every time the ignition is cycled OFF. Refer to the Owner's Manual, "SETTING THE ALARM SECURITY LEVEL" (page 133). Monitor Professional Technician System (PTS) for additional information and schedule service appointments for customers once the repair becomes available.
Associated Products (3)Associated Documents - April 14, 2026•Document ID: 11031644Over The AirFORWARD COLLISION AVOIDANCE: ADAPTIVE CRUISE CONTROL; UNKNOWN OR OTHER; ELECTRICAL SYSTEM; LANE DEPARTURE: ASSIST
- Mfr Comm. #:
- IPMA-25.22.7.3.10B F-150
- Date Added:
- April 28, 2026
- Manufacturer:
- FORD
SummaryQuality improvements include: -Enhanced BlueCruise performance
Associated Products (1)Associated Documents - April 9, 2026•Document ID: 11031371Over The AirVISIBILITY/WIPER
- Mfr Comm. #:
- DDM-26.21.5 F-150
- Date Added:
- April 17, 2026
- Manufacturer:
- FORD
SummaryQuality improvements include: -Prevents window bounce backs after using the one touch up feature
Associated Products (3)Associated Documents - April 9, 2026•Document ID: 11031308Service Bulletin/Repair InstructionsENGINE
- Mfr Comm. #:
- TSB 26-2116
- Date Added:
- April 14, 2026
- Manufacturer:
- FORD
SummaryThis article supersedes TSB 25-2323 to update the Service procedure, Parts list, and add a clarification note about Cost Cap and Prior approval process requirement for vehicles under NVLW. Some of the vehicles listed in the model statement above may exhibit an oil leak from the oil filter adapter to engine block mounting area. This may be due to block porosity or a block crack just below the oil filter adapter near the main bearing cap outer bolt.
Associated Products (4)Associated Documents - April 9, 2026•Document ID: 11031299Service Bulletin/Repair InstructionsELECTRICAL SYSTEM; UNKNOWN OR OTHER
- Mfr Comm. #:
- SSM 54734
- Date Added:
- April 14, 2026
- Manufacturer:
- FORD
SummarySome 2024 F-150 vehicles may exhibit a condition where the volume is limited to 14 with a "MyKey volume limited" message in the SYNC screen. To resolve this concern, disconnect the vehicle's 12-volt battery cables for 10 minutes and reconnect. If a battery reset does not resolve this solution inform customers that engineering is currently working on a solution. Monitor Professional Technician System (PTS) for additional information and schedule service appointments for customers once the repair becomes available. If a customer's vehicle exhibits this concern, submit a Vehicle Concern Report. To submit a report, click on the "Submit Global Concern Report (GCR)" link at the upper right of the PTS Vehicle ID screen (vehicle identification number ÝVIN¨ required) and fill out the form. Include the article number of this message in the text of the form. Do not use the "Report A Problem" link to submit a report for this condition. For claiming, use causal part 10849 and labor operation 10654C.
Associated Products (1)Associated Documents - April 8, 2026•Document ID: 11031295Service Bulletin/Repair InstructionsUNKNOWN OR OTHER; ELECTRICAL SYSTEM
- Mfr Comm. #:
- SSM 54727
- Date Added:
- April 14, 2026
- Manufacturer:
- FORD
SummarySome 2024 F-150/Escape/Corsair vehicles may exhibit no audio/no volume with diagnostic trouble code (DTC) U1A00:87 stored in the accessory protocol interface module (APIM). This may be due to the software in the front audio control module (ACM). To correct the condition, reprogram the ACM using the latest software level of the Ford Diagnosis and Repair System (FDRS). For claiming, use causal part 18C869 and labor operations 12651D and 12651D4.
Associated Products (3)Associated Documents - April 2, 2026•Document ID: 11031263Service Bulletin/Repair InstructionsLANE DEPARTURE: BLIND SPOT DETECTION; ELECTRICAL SYSTEM
- Mfr Comm. #:
- SSM 54720
- Date Added:
- April 10, 2026
- Manufacturer:
- FORD
SummaryVarious 2020-2026 Ford and Lincoln vehicles equipped with blind spot information system (BLIS) may experience an inoperative blind spot monitoring with a "Blind Spot System Fault" message displayed in the instrument panel cluster (IPC). This may also be accompanied by diagnostic trouble codes (DTCs) B118C:11 and/or B118C:15 stored in the driver door module (DDM), and/or B118D:11 and/or B118D:15 stored in the passenger door module (PDM). This may be due to the wiring connector from the mirror to the BLIS module. If diagnostics lead to an internal mirror wiring harness fault, a new lower level BLIS light pigtail is now released for service. It is not necessary to replace the exterior mirror assembly. Use part number SC3Z-14A411-B to resolve the concern.
Associated Products (64)2026 Ford Expedition2026 Ford Explorer2026 Ford F-1502026 Ford Mustang2026 Ford Ranger2026 Lincoln Aviator2025 Ford Bronco2025 Ford Bronco Sport2025 Ford Escape2025 Ford Expedition2025 Ford Explorer2025 Ford F-1502025 Ford Mustang2025 Ford Ranger2025 Ford Transit2025 Lincoln Aviator2025 Lincoln Corsair2024 Ford Bronco2024 Ford Bronco Sport2024 Ford Edge+ 44 moreAssociated Documents - April 2, 2026•Document ID: 11031262Service Bulletin/Repair InstructionsPOWER TRAIN
- Mfr Comm. #:
- SSM 54719
- Date Added:
- April 10, 2026
- Manufacturer:
- FORD
SummaryFor 20212026 vehicles equipped with the 10R80 transmission, a new Transmission Clutch Circuit Leak Test has been introduced in the Ford Diagnosis and Repair System (FDRS). This test utilizes the pressure and vacuum transducer (PVT) when available. When referred to a specific clutch (A-F) test by a pinpoint test in Workshop Manual (WSM), Section 307-01 > Diagnosis and Testing, the Clutch Assembly tests have been updated with a hyperlink to the new Transmission Line Pressure Test - Pressure Vacuum Transducer (PVT) Is Available procedure in WSM, Section 307-01 > General Procedures. This procedure provides instructions to perform the FDRS Transmission Clutch Circuit Leak Test when applicable. The new test improves the accuracy of detecting leaks within transmission fluid circuits and replaces the previous air check method. The previous air check procedure has been shown to produce a high rate of false positives, which may lead to unnecessary repairs when no actual leak is present. Accordingly, the air check procedure is not to be used for diagnosing internal transmission hydraulic leaks or as justification
Associated Products (38)2026 Ford Expedition2026 Ford Explorer2026 Ford F-1502026 Ford Mustang2026 Lincoln Navigator2025 Ford Expedition2025 Ford Explorer2025 Ford F-1502025 Ford Mustang2025 Ford Transit2025 Lincoln Navigator2024 Ford Expedition2024 Ford Explorer2024 Ford F-1502024 Ford Mustang2024 Ford Transit2024 Lincoln Navigator2023 Ford Expedition2023 Ford Explorer2023 Ford F-150+ 18 moreAssociated Documents - April 1, 2026•Document ID: 11031261Service Bulletin/Repair InstructionsPOWER TRAIN
- Mfr Comm. #:
- SSM 54714
- Date Added:
- April 10, 2026
- Manufacturer:
- FORD
SummarySome 2021-2026 F-150 PowerBoost vehicles may exhibit an illuminated powertrain malfunction (wrench) indicator with diagnostic trouble codes (DTC) P2884, P2885 and/or P2886 stored in the powertrain control module (PCM). Workshop Manual (WSM), Section 307-01 > Automatic Transmission - 10 Speed Automatic Transmission - 10R80 MHT > Diagnosis and Testing > DTC Chart and Pinpoint Tests - 3.5L V6 PowerBoost (CN) > Pinpoint Test J: Engine Disconnect Clutch has been updated to address this condition.
Associated Products (6)Associated Documents