Ram 3500 Complaints

2,367 consumer complaints on file.

#11519597April 29, 2023
SERVICE BRAKES, VEHICLE SPEED CONTROL, ELECTRICAL SYSTEM
While driving at any speed the abs and traction control lights start flashing and a chime goes constantly. also when this happens it causes the cruise control to disengage without any warning. Also leaving you without abs brakes. I am on my 3rd abs module and 2nd hydraulic control unit and needing a 3rd hydraulic control unit for this vehicle with less than 62,000 miles the first one went out around 16,000 miles and the second at 37,000 miles. This is also my second truck from this manufacturer to do the exact same thing that happened at 30,000 miles and had another one in the family that did it at 7,000 miles. As i research online I find that this a common occurrence and nothing has been done to resolve the issue other than just replacing the parts with new and wait for it to happen again. I am in need of a new hydraulic control unit and am being told that they are on some kind of hold until the earliest date of August and just to drive the truck with non-working safety equipment.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11519595April 29, 2023
POWER TRAIN
I PURCHASED THIS 2022 RAM 3500 MENTIONED ABOVE WITH 10 MILES ON IT. I DROVE IT 159 MILES AND THE TRANSMISSION WENT COMPLETELY OUT AND WOULD NOT MOVE. THE DEALERSHIP I TOOK IT TO MENTIONED THEY HAD TWO OTHER TRUCKS THERE WITH THE SAME PROBLEM THAT'S BEEN THERE FOR OVER A MONTH... AND DIDN'T HAVE ANY TIMEFRAME ON WHEN IT COULD BE FIXED OR A RESOLUTION FOR THIS PROBLEM. I'M HOPING THERE'S A LEMON LAW I CAN ADDRESS AND WILL HAVE TO BE ON THE HUNT FOR A NEW TRUCK ONCE AGAIN, AS IT'S PART OF MY LIVELIHOOD! IS THERE ANYWAY THIS SHOULD BE A RECALL ITEM OR REPAIRED BY THE DEALER. PLEASE ADVISE ON THE BEST COURSE OF ACTION I SHOULD TAKE. THANK YOU
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11519492April 28, 2023
SERVICE BRAKES
ABS and Traction control lights have been on/off for 60,000kms approximately, have had it to the dealer approx 8 times for this issue, still unresolved. Traction control acts extremely odd at times and break pedal feels "soft" at times. Lights on dash come and go intermittently and so does the "soft" break pedal feeling. Warranty is now up and dealer continues to want to replace random parts @ my expense.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11519493April 28, 2023
FORWARD COLLISION AVOIDANCE: ADAPTIVE CRUISE CONTROL, FORWARD COLLISION AVOIDANCE: AUTOMATIC EMERGENCY BRAKING
The ABS/HCU module failed. I had to replace on 05/14/2021. At the time of replacement, I was unaware the NHTSA launched an investigation October of 2022. At this present moment, I am faced with replacing the ABS/HCU module again. The cruise control does not work and the traction and ABS lights are on again.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11519525April 28, 2023
SERVICE BRAKES
The HCU and ABS module for 2018 and 2017 model years of the ram 3500 and 2500 are a known issue that should be recalled. There's some type of issue where the ABS and the traction control lights will turn on affecting the safety of the vehicle. Many people have the issue if you do a quick search on any RAM forum. From my understanding there was a design change on the replacement part. The easiest and probably most common fix is to remove the fuse for the ABS.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11519336April 27, 2023
SERVICE BRAKES
The ABS and hydraulic brake failure comes on multiple time while driving. I’m told this disables 4x4,anti lock brakes and cruise control. Part is on back order and could take up to 4 months to arrive and cost up to 800.00 to replace
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11519199April 27, 2023
SERVICE BRAKES, ELECTRICAL SYSTEM
September-October 2022 --The Anti-Braking System module has quit working. (ABS). Requested replacement part from Dealership in October 2022. Dealership advises Mopar cancelled parts request to them. I have no anti braking working on vehicle. Dealership advises me to contact Mopar directly for help. I advised them that wasn't my job it was theirs' .
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11519071April 26, 2023
POWER TRAIN
frequently when shifting from D to R or any combination, all selections light up followed a loud bang from rearend. sometimes it correctes itself, other times engine must be shut down. dealer has diagnosed problem. Its a short in transmision wiring harness as they performed a rigorous, multipoint "wiggle test". its been in shop 4+ times to no avail.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11519072April 26, 2023
SERVICE BRAKES
The service electronic brake light freq comes on. Dealer said it brake "module" needed changing and did. they also charged me $800 for it. Vehicle is still making the claim that the elctronic braking system still needs servicing almost imediately after repair.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11518719April 24, 2023
SERVICE BRAKES
ABS and HCU Warning lights come on and off. Looking around the internet this is a huge Problem. Took it to a local Ram dealer today and was told its a $1600.00 out of pocket cost seeing the truck is just out of warranty (of course) with 37,000 miles on it. Driving with the cruise control on it throws the warning lights on and off and cruise stops working. It seems the brakes are weak too. The dealer also informed us today they could not even get the parts to fix the problem until at least August! We also had to pile another $1500.00 in it a few months ago because the 4wd did not work either.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11518489April 23, 2023
AIR BAGS
Frontal collision at 45 mph, totaled truck but airbags did not deploy. The insurance company sent the truck to the auction. My safety was at risk. Not that I am aware of, the insurance company has photos. Inspected by police and insurance adjuster. No symptoms of anything wrong with the vehicle.
Crash:
Yes
Fire:
No
Injuries:
1
Deaths:
1
#11518052April 20, 2023
SERVICE BRAKES, HYDRAULIC
The contact owns a 2018 Ram 3500. The contact stated while driving approximately 25 MPH, the "Check Brake System" and ABS warning lights were illuminated. The contact stated that the failure reoccurred intermittently while driving at various speeds. The vehicle was taken to a local dealer, where it was diagnosed that the Hydraulic Control Unit (HCU) needed to be replaced; however, the parts were on back order. The vehicle was not repaired. The manufacturer was not made aware of the failure. The approximate failure mileage was 57,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11517837April 19, 2023
ELECTRICAL SYSTEM: INTEGRATED TRAILER BRAKE CONTROL
The contact owns a 2019 Ram 3500. The contact stated that on various occasions and while driving at various speeds with a trailer attached, the brake pedal was depressed; however, the trailer brakes failed to respond. No warning lights were illuminated. The vehicle was taken to two independent mechanics, where the failures could not be duplicated. The failure recurred. The vehicle was taken to a local dealer, where it was diagnosed that the electronic trailer brake controller needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure and a case was opened. The approximate failure mileage was 20,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11517928April 19, 2023
POWER TRAIN
The vehicle does not always go in park. If you attempt to shut the engine off it will notify, If you left the engine running and get out of the vehicle it could roll away. This failure has happened more than 30 times. 3 times today.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11517569April 18, 2023
SERVICE BRAKES
abs trac control going crazy dealer repaired under warranty about 15k drove approx 2k and same issue no longer under warranty tried to buy parts none available. truck doesn't start correctly when the lights are on and when driving there is a dinging as lights flash on and off.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11517380April 17, 2023
STEERING, SUSPENSION, VEHICLE SPEED CONTROL
Truck was repaired June 2019. They welded the jam nut which made it impossible to get an alaignment.Been having a open claim with Chrysler Jeep and Dodge going on 2 years per claim #78469040 Front Suspension Track Bar Frame Bracket ( vehicle recently started to do the death wobble again)
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11517425April 17, 2023
SERVICE BRAKES
Related to investigation PE 22-012, abs hyd control module failed truck only has 18,000 miles.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11516786April 12, 2023
STRUCTURE:BODY, SUSPENSION, UNKNOWN OR OTHER
I purchased this vehicle new in 2016. It currently has approximately 49,000 miles. It has never been involved in any collision. In Feb. 2023 I took it to a Les Schwab Tire Center to have the drag link replaced & alignment done. When the repairs were completed the technician informed me that I may have a rear axle misalignment as he noticed the rear axle appeared to have shifted to the right of the vehicle & recommended taking it to a collision repair shop for further inspection. My next move was taking it to an independent shop & have the rear leaf springs inspected for correct alignment which found nothing abnormal but they also measured from the center of the front wheel to the center of the rear wheel on both sides of the vehicle and found a difference in measurement of approximately 3/4". They had me drive the vehicle down the road as they followed & verified the rear of the truck was tracking to the right. I then proceeded to take it to a Ram Dealer repair shop for inspection & concluded that the rear of the truck was tracking to the right but that they were not equipped to make corrections & recommended taking it to a collision repair shop. I then proceeded with a collision repair shop where they put it on a rack & took measurements of the frame & only found a slight abnormal condition in the frame on the right side in front of the rear axle but concluded that they did not believe it would be was causing the issue. So the issue I have is rear of the truck is tracking to the right. I never knew there was an issue with the truck before I took it to Les Schwab for its first alignment.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11516794April 12, 2023
SERVICE BRAKES
The ABS pump motor was replaced on 10/22/20 at 28,095 covered by warranty. The ABS/ ANTI SKID warning lights came back on at around 58,000 miles. The vehicle was taken to Firkins CDJR in Bradenton, FL for diagnoses confirmation and repair on 04/11/23. I was advised the ABS hydrolic control unit, part # 68143491-AA, needed to be replaced but was unavailable anywhere and it was not going to be available in the foreseeable future. Advised to call customer care who advised me to try a different dealership. I discovered that a replacement control unit, part # 68143491AB, is apparently available at Mopar parts for approximately $350. At this time I don't understand why a CDJR dealership says a part is unavailable that appears to be available on the internet. I pull a 5th wheel and at this time I apparently can't get the ABS system repaired in my 2018 RAM drw diesel with 59,000 miles on it. There was no incident or accident due to ABS system failure. Although the vehicle runs normal I consider this to be a potential safety risk.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11516570April 11, 2023
SERVICE BRAKES
The EVIC display showed Service Antilock Braking System and alternated to Service Electronic Brake System. It would constantly bing and display the ABS light and the Traction Control light. Unit failure of antilock braking system and traction control while driving. Problem is intermittent. Ram is aware of issue, but will not honor as warranty. Parts are BQ for months. Problem apprears to be wide spread.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Ram 3500