Ram 3500 Complaints

2,367 consumer complaints on file.

#11506986February 13, 2023
WHEELS
The contact owns a 2018 Ram 3500. The contact stated while her brother was driving approximately 40 MPH, the rear passenger’s side wheel started to wobble. The contact stated that the driver was able to coast to the side of the road and removed the hub cap. The contact became aware that there were only two-wheel studs holding the wheel to the wheel hub. The vehicle was towed to the dealer who diagnosed the vehicle and related the failure to NHTSA Campaign Number: 21V398000 (Wheels) however, the VIN was not included. The wheel hub and studs were replaced. The manufacturer was made aware of the failure and confirmed that the VIN was not included. The failure mileage was unknown.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11506988February 13, 2023
WHEELS
The contact owns a 2017 Ram 3500. The contact stated that while the vehicle was being driven at approximately 75 MPH, there was a sudden drop on the passenger’s side of the vehicle. The driver waited until the vehicle decelerated before being able to coast to the side of the road. The vehicle was towed to an independent mechanic. The contact stated that the rear passenger’s side wheel had detached. The wheel hub assembly, brake pads, rotors, and studs on all four wheels were replaced. The manufacturer was made aware of the failure. The manufacturer confirmed that the VIN was not included in NHTSA Campaign Number: 21V398000 (Wheels). The approximate failure mileage was 75,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11507016February 13, 2023
SERVICE BRAKES
Constant ABS issues, most recently HCU has been diagnosed.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11506613February 10, 2023
SERVICE BRAKES
The hydraulic control unit is repeatedly having problems. 09-01-2020- Inspect Brake System. Serviced at Carlock Chrysler Dodge Jeep Ram in Tupelo, MS at 19,056 miles. No parts replaced that I can recall, but the warning light and dinging stopped. The warning that was emailed to me included this information- Your vehicle's ABS Warning Light recently indicated the Antilock portion of the braking system is not functioning. If the ABS Warning Light remains on or turns on while driving, the conventional brake system will continue to operate normally unless the Brake Warning Light is on. Have your vehicle serviced at your dealership immediately. This was at 18,302 miles. 1/13/23- It sent a report with the same issue again. The mileage at this time was 45,260. The light and warning had been going on and off since at least October every time I hit a bump in the road. I tried obtaining a replacement hydraulic control unit, but it was backordered. I have another vehicle to use so I only used this one when I absolutely have to. I have read on forums that this problem is widespread and I truly believe something needs done about it. Replacing a hydraulic control unit every 30,000 miles or so at the expense of $1200 plus dollars each time is not economically feasible. The first time it was checked, the truck was under warranty. I do believe mine is extremely low miles for it's age and should not be having this issue repeatedly. 2019-2022 Have a recall, however my 2018 is having the exact same problems.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11505853February 6, 2023
POWER TRAIN
I was driving on the interstate and new truck with 170 miles on it just made 2 loud noises and then would not go over 10 miles an hour, Which I think is very dangerous. Now its been at the service station for Ram for a month and the mechanic said this was his 6th truck with under 600 miles with the same problem. And Ram is not doig much to assist me.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11505493February 4, 2023
SERVICE BRAKES, STEERING
I have the ABS light and traction control light coming on intermittently and the warning "Service ABS system" and "Service Electronic Braking System. Code is C0020-01 - ABS Pump Motor Control-General Electrical Failure. ABS module and HCU are replaced under warranty once.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11505571February 4, 2023
SERVICE BRAKES
ABS and traction control lights activate and error message states to service electronic braking system. No ABS functions as a result. Dealership diagnosed problem as the ABS HCU(hydraulic control unit). Issue can not be corrected due to unavailability of parts. This is a safety issue that should be recalled as it is a known problem by the manufacturer.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11505363February 3, 2023
SERVICE BRAKES, HYDRAULIC
The contact owns a 2018 Ram 3500. The contact stated that while driving at an undisclosed speed, the brakes inadvertently engaged. The traction control warning light was illuminated, and the Service Electronic Braking System message was displayed. The vehicle was taken to the dealer, where it was diagnosed that the HCU needed to be replaced; however, the replacement part would be on backorder until March 2023. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was 37,353.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11505097February 2, 2023
POWER TRAIN
While traveling approximately 15 miles per hour transmission locked-up in the middle of the road and would not move. Dash lit-up with check engine lights. Truck was towed to dealership where it was determined that a new transmission was needed and ordered. As of today, the truck has been at the dealership for repair for just under 40 days.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11504948February 1, 2023
ENGINE AND ENGINE COOLING:ENGINE:GASOLINE:TURBO/SUPERCHARGER
The contact owns a 2016 Ram 3500. The contact stated while driving at an undisclosed speed, the vehicle became difficult to drive. The check engine and MIL warning lights were illuminated. The contact stated that the vehicle was taken to the local dealer where it was diagnosed and determined that the turbo actuator needed to be replaced. The vehicle was repaired, but the failure persisted. The manufacturer was contacted but no additional assistance was provided. The approximate failure mileage was 55,600.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11504990February 1, 2023
SERVICE BRAKES, HYDRAULIC
The contact owns a 2018 Ram 3500. The contact stated that while driving at various speeds, the "Service ABS" warning message and ABS warning light were illuminated. The vehicle was taken to a local dealer, where it was diagnosed that the ABS hydraulic unit needed to be replaced; however, the part for the repair was not available. The vehicle was not repaired. The manufacturer was made aware of the failure. The approximate failure mileage was 25,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11505050February 1, 2023
ELECTRICAL SYSTEM, SERVICE BRAKES
ABS Brake Module and Electronic Braking Module are issues warnings. Unknown
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11505032February 1, 2023
POWER TRAIN
On 4 different occasions when accelerating from a stop when we proceed forward slowly vehicle will rev up to 4500 RPM without any forward movement. After coasting to side of road we put vehicle in park and after a few minutes we put it in drive and it will run fine. We have not had any code lights appear or warning signs appear.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11504875February 1, 2023
POWER TRAIN
Backed out of a parking spot onto a busy road, put the truck in drive and nothing. Transmission failure. ME and my daughter were stuck in the middle of the road and truck would only go in reverse. Had to reverse a u-turn in middle of road and back into parking spot. Dealer confirmed a failure in the transmission and is repairing/ replacing. Upon fruther investigation into this issue online there is a list of truck that this is happening to. Check engine light also came on when vehical would not move.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11504593January 31, 2023
UNKNOWN OR OTHER
2 of the safety recalls have not been made and the Dealer Mak Haik Dodge Chrysler Jeep in Temple TX has not been able to make these 2 repairs: 22V835000 Dip Stick and 21V398000 Lug nuts. The vehicle has been in several times in the last 12 months and the Dealer Service Dept has not provided any estimates to get parts or repair except to say "they dont get but 1 dipstick per week and there are 50+ vehicles in front of me", thus over 1 year.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11504766January 31, 2023
SERVICE BRAKES
ABS and Traction Control lights stay on due to the HCU (Hydraulic Control Module) failure, a known problem reported from the garage. I've been waiting for a replacement part for 6 months. I was told to check back in the middle of March 2023.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11504661January 31, 2023
POWER TRAIN
We were traveling westbound on the interstate I-10 towards Los Angeles California on Nov 13/22 near Cabazon CA in my 2022 Ram 3500, SRW, 6.7 HO with the Aisin transmission. It was rush hour stop-and-go traffic. I was traveling at a speed of approximately 35mph when a large bang came from under the vehicle. There was an immediate and complete power loss and we had to coast to the shoulder of the road and try to avoid being struck by traffic. Once on the shoulder, I had got out and checked under the vehicle. There was nothing that I could see that was wrong. There was a check engine light that went on. Using a jobber OB2 scanner, codes P0731 (Gear 1 incorrect ratio) and P0732 (Gear 2 incorrect ratio) were present. The truck was towed to the Redlands CDJR dealer for service with only 6700 miles on the odometer. It turned out to require a complete new Aisin transmission. The repair took a month to complete and looks to have been caused by a defective snap ring as per service bulletin 21-002-23 (K1 clutch drum snap ring and K1 input shaft drum sub assembly) although the Redlands CDJR dealer or FCA will not confirm. The bulletin states the affected vehicles are the 2022-23 Ram 3500 pickup, 3500 cab and chassis, and 4500/5500 Cab Chassis trucks. Due to the immediate power loss, with zero warning, we were just able to get to the shoulder of the road and could have easily caused a massive pile up and possible deaths due to the failure. FCA refuses to inspect or confirm that the new transmission (68498560AB) installed in my truck addresses the 21-002-23 service bulletin and said I would need to pay out of pocket for the inspection to occur at a dealer. There are numerous documented cases of newly installed transmissions failing shortly after being "repaired". I believe it would be in the publics best interest that FCA/RAM issue a recall on the effected vehicles as these vehicles are typically used for emergency, commercial and towing application's.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11504451January 30, 2023
SERVICE BRAKES
IVE HAD THE ABS PUMP CONTROL MODULE GO OUT THREE TIMES WITHIN THE LAST 2 YEARS
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11504264January 29, 2023
SERVICE BRAKES
While driving on a paved 4-lane road near Mount Rushmore National Memorial in dry conditions, the dash warning system began intermittently flashing "Service Electronic Braking System". The orange ABS and traction control lights also began flashing. The foregoing visual warnings were accompanied by an intermittently ringing audio warning. Retrieval of error codes from the ABS control system with a INNOVA 5610 scan tool showed: DTC CODE C-0020-01 - ABS PUMP MOTOR CONTROL - GENERAL ELECTRICAL FAILURE. This code relates to failure of the ABS Hydraulic Control Unit (HCU) and indicates that repair requires replacing the failed HCU with part 68143491AB (replaces part 68143491AA HCU). (SEE Fiat-Chrysler Automobiles STAR Online Publication case number S2005000004. This STAR Online publication (released on 4/28/22020) further states that if replacing the HCU does not solve the failure, the ABS control module may require replacing as well.)
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11504007January 27, 2023
SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP:ABS WARNING LIGHT
The contact owns a 2017 Ram 3500. The contact stated while starting the vehicle, the "Service ABS system" warning light intermittently illuminated; however, the warning light disappeared while driving. The contact stated that the failure recurred, and the local dealer was made aware of the failure. The vehicle was not diagnosed nor repaired. The manufacturer was not made aware of the failure. The approximate failure mileage was 14,200. The contact stated that plenty of other FCA vehicles have the same exact issues. When the contact mentioned their experience with their local dealer, they were told that this happens all the time but the vehicle should still be safe to drive. The dealer was unwilling to open a case with the manufacturer and told the contact that it would take several months to receive parts and get it repaired.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Ram 3500