Ford F-150 Complaints

39,812 consumer complaints on file.

#11652204April 2, 2025
POWER TRAIN
The transmission is a safety issue and is available for inspection. The six speed automatic has a 5th to 4th downshift that is regularly rough and can be jarring at times. A few weeks ago on my way home from work while driving 30 mph around a small bend the truck shifted from 4th to 2nd on its own and bucked so hard that it scared me and brought my hands off the steering wheel and made my back sore for the next day. This is a blind bend because of the shrubbery in the front yard at the bend and it is also at the beginning of a school zone. This could've been a worse situation if there would've been a car or school bus going in the opposite direction. This was certainly the worst one yet but there have been similar situations where the truck jarringly shifted from 4th to 3rd on its own. The problem has not been reproduced, confirmed or inspected as mentioned above. I have read multiple stories stating very similar or even the same occurrences on the forums. The lead frame in the transmission seems to be the leading cause for this issue. Others have been to the dealer, had the computer reflashed and were told it just needs to relearn their driving, only to have the issue return. After seeing these stories and now reading about the investigation into the issue I've been holding off to see what happens as I do not want to waste time and money to not have the issue fixed. There were not any warning lamps, etc before or after this issue. I have noticed that when the jarring shifts occur the small area of the cluster that shows gears one through six goes black and remains that way until manually pressing the button on the shifter to make the image reappear. To this point these shifting issues almost always occur at low speeds while gently resting my foot on the gas to keep a steady speed. It feels as though the transmission shifts into fifth too early, the rpms slowly lower and then it downshifts to fourth in a jarring manner.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11652243April 2, 2025
POWER TRAIN
The contact owns a 2018 Ford F-150. The contact stated while driving at various speeds, the vehicle shifted to neutral(N) unintendedly and the vehicle jerked. Additionally, the contact continued driving at a slower speed; however, the failure recurred while driving. No warning light was illuminated. An unknown local dealer was contacted and advised the contact that the failure might be related to Technical Service Bulletin: 252126; however, the VIN was not included. The vehicle was not diagnosed or repaired. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 32,700.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11652266April 2, 2025
ENGINE
Vehicle has just 70,000 on it. Engine light came on after the vehicle was rattling at the engine start and running rough at idle and had power issues when driven. The vehicle was taken to the dealership where it was diagnosed that the timing chain needed to be replaced and probably the cam phasers. Over $5,200 + in repair costs. Vehicle was taken to an independent service location for repair where the issues were confirmed.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11652271April 2, 2025
POWER TRAIN
The contact owns a 2013 Ford F-150. The contact stated that while driving at various speeds, the vehicle lost power. The infotainment system went blank, and the power train and check engine warning lights illuminated intermittently. The vehicle was steered to the side of the road and turned off. The contact stated that on the last occasion when the vehicle experienced the failure, the rear wheels locked up, causing the contact to lose control of the vehicle briefly. The vehicle was taken to a dealer where it was diagnosed that the molded lead frame needed to be replaced. The vehicle was not repaired. The contact believed that the failure was associated with Manufacturer Recall Number: 19N01. The manufacturer was notified of the failure. The failure was approximately 78,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11652279April 2, 2025
ENGINE, POWER TRAIN
The contact owns a 2018 Ford F-150. The contact stated that upon starting the vehicle, there was an abnormal rattling sound coming from the vehicle for four minutes. The contact stated that the vehicle stalled. The check engine warning light was illuminated. While driving approximately 35-40 MPH, the transmission was shifting hard. The RPM was fluctuating. While parking or driving, the vehicle thrusted forward and backward. The failure persisted over time. The contact called the local dealer, but the vehicle was not diagnosed or repaired. The vehicle was taken to an independent mechanic, who retrieved DTC: P0019, indicating a camshaft position correlation Bank 2 Sensor B; and DTC: P0025, indicating an exhaust (B) camshaft position timing over-retarded (Bank 2). The manufacturer was contacted and referred the contact to the NHTSA Hotline. The failure mileage was approximately 52,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11652304April 2, 2025
POWER TRAIN
failure of driver side left turbo leaking. Dealership suggests a rebuild of the unit for $3,000 but an independent mechanic suggests the replace the turbo because it has an internal issue that will just cause it to leak again. After researching online this is a common problem with this particular turbo with even a service bulletin. chrome-extension://efaidnbmnnnibpcajpcglclefindmkaj/https://static.nhtsa.gov/odi/tsbs/2020/MC-10176843-0001.pdf
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11652321April 2, 2025
POWER TRAIN
Vehicle would downshift to 3rd or 1st gear and will not shift out of that gear at any speeds. Would happen at randomly at highway speeds or just from accelerating from a stop, causing dangerous speed changes while on highway. Turning engine/keys completely off and back on will reset the error. Service wrench light would also come on occasionally when this happens. This issue has been prevalent for the last few years since after hitting 60k miles mark. Inspection is available upon request. Issue cannot be reproduced on demand, only randomly. Issue has not been evaluated by any service technicians or dealerships or any other persons except myself using a diagnostics code scanner. Using a diagnostic scanner shows error code "P0722-00 Output Shaft Speed Sensor Circuit No Signal - Not Current DTC."
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11652324April 2, 2025
POWER TRAIN
The contact owns a 2012 Ford F-150. The contact stated while driving at an undisclosed speed, the transmission independently downshifted into first gear. No warning light was illuminated. The vehicle was taken to the dealer; however, the failure was not duplicated. The contact was advised not to drive the vehicle for safety reasons. The contact stated that the vehicle had been repaired under NHTSA Campaign Number: 19V075000 (Power Train); two days prior to the failure; however, the failure occurred. The contact stated that the failure reoccurred three days after the recall repair was performed. The manufacturer was made aware of the failure and a case was filed. The contact was advised to contact the NHTSA Hotline to report the failure. The failure mileage was approximately 175,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11652326April 2, 2025
EXTERIOR LIGHTING
The rear lightbar was replaced under a safety recall with a defective part. The replacement started flickering after 4 months and the reverse lights would strobe due to moisture. The dealership inspected and determined it was defective,not damaged and Ford has agreed to pay 60 percent only. Safety recall 23s30
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11652342April 2, 2025
POWER TRAIN
The contact owns a 2013 Ford F-150. The contact stated that when the vehicle was started and the accelerator pedal was depressed, the vehicle failed to respond as intended. The contact stated that the RPM was at 4,000, but the vehicle failed to move. The contact turned off and restarted the vehicle, shifted to drive, and depressed the accelerator pedal and the vehicle operated normally. The contact stated that the "WRENCH" symbol and check engine warning lights were illuminated. Additionally, the contact stated that the speedometer failed to operate while driving. The contact stated that after stopping and turning off and restarting the vehicle, the speedometer gauge functionality returned. The contact stated that the failure was almost constant. The contact had taken the vehicle to a local dealer, where it was diagnosed and determined that the transmission had a speed signal fault and the transmission needed to be serviced. The vehicle was not repaired. The contact stated that prior to the failures, the vehicle had been repaired under NHTSA Campaign Number: 19V433000 (Power Train). The contact stated that the vehicle had been operating normally prior to the recall repair. The manufacturer was not informed of the failure. The failure mileage was approximately 200,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11652366April 2, 2025
ENGINE, FUEL SYSTEM, GASOLINE
The contact owns a 2020 Ford F-150. The contact stated that the check engine warning light was illuminated, and the contact became aware of a significant loss in fuel economy. The vehicle was taken to a certified mechanic who diagnosed that the catalytic converter had failed. The vehicle was not repaired. The vehicle was taken to the dealer, who diagnosed that the catalytic converters had failed. The contact was informed that the catalytic converters needed to be replaced. The vehicle was not repaired. The manufacturer was informed of the failure and opened a case. The manufacturer referred the contact to the NHTSA Hotline to report the failure. The failure mileage was approximately 100,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11652372April 2, 2025
ENGINE AND ENGINE COOLING
The contact owns a 2018 Ford F-150. The contact stated that when the vehicle was started, the vehicle was idling rough and there was an abnormal knocking sound coming from the vehicle. The contact stated there was no warning light illuminated. The contact had taken the vehicle to a local dealer, where an oil consumption test was performed. The contact returned the vehicle to the dealer, and it was determined that the engine had consumed over 3 quarts of oil during the test period. The dealer diagnosed the vehicle and determined that the engine needed to be replaced. The contact stated that the dealer advised that it was a known failure of the 2nd generation 5.0-liter engines. The vehicle was not repaired. The manufacturer was informed of the failure and referred the contact to the NHTSA Hotline. The failure mileage was approximately 64,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11652376April 2, 2025
ENGINE
Truck decelerates while on incline. Engine light did come on. Took Car to Bill Brown Ford dealership. has been at dealer since 2/12/25. Code P0305 due to low compression on cylinder #5 110 PSI, #4 121psi all others at 145-150 psi. was informed necessary to replace long block. The truck was purchased with extended service warranty thru Ford ESP. warranty lists engine replacement is covered. however, ESP not covering it. Research on internet states frequent issues with 2.7 liter ecoboost 2019 Ford F150 has common issues with the cylinders requiring engine replacement
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11652386April 2, 2025
ENGINE AND ENGINE COOLING:ENGINE:CRANK/CAMSHAFT POSITION SENSOR
The contact owns a 2018 Ford F-150. The contact stated that the check engine warning light had illuminated. The vehicle was taken to the local dealer to be diagnosed, and the contact was informed that the cam phasers were faulty and needed to be replaced. The vehicle was not repaired. The contact stated that the vehicle had previously been serviced for the same failure with the cam phasers under Customer Satisfaction Program: 21B10. The manufacturer was notified of the failure. The approximate failure mileage was 160,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11652419April 2, 2025
UNKNOWN OR OTHER
My [XXX] daughter and friend were driving our F150 lariat super crew cab 3.0 deisel which to our knowledge was in excellent condition. The driver behind her frantically pulled them over as the rear underneath of the truck was on fire. They immediately pulled over and within several minutes the entire truck burned to the ground. Luckily the girls were safe, although very shaken. There were no warning lights on the dash and the smoke was behind the truck. Had their not been a car behind them on the country highway, who knows what could have happened to the girls. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Crash:
No
Fire:
Yes
Injuries:
0
Deaths:
0
#11652245April 2, 2025
ELECTRICAL SYSTEM
Twice while driving my vehicle, the on board display screen will start to flicker and then show multiple lines going through it to where you can’t see anything on the screen. You have to turn the vehicle off and then turn it back on to reset it. It looks almost as if it were a flatscreen TV that had been punched.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11652223April 2, 2025
ENGINE AND ENGINE COOLING
The contact owns a 2021 Ford F-150. The contact received notification of NHTSA Campaign Number: 24V635000 (Engine and Engine Cooling); however, the part to do the recall repair was not yet available. An unknown local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11651949April 1, 2025
POWER TRAIN
Transmission would not engage after stopping at stop sign. Initially accelerated to go thru intersection and truck would not engage any gears and was stuck in the middle of the intersection. Switched gear shift to several gears and drive modes and finally engaged in manual shift. Transmission continued to slip and switch to several gears and skip several gears until arriving at destinations regular drive gear selection. Did not see any issues under the vehicle after parking and fluids appear to be clean and filled up to normal levels. Made appointment immediately for service.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11651950April 1, 2025
POWER TRAIN
On or about March 26 2025 while operating this truck at about 35 MPH the 6 speed transmission shifted to first gear causing the tires to chirp the vehicle to a near stop and red line the engine. This is a known defect that Ford supposedly fixed years ago but apparently was not a proper fix. The vehicle was taken to Medford Ford, Medford NJ on 3/31/2025 where the dealer said transmission should be replaced my expense for $8500 plus tax and the cost of estimate of approximately $202.63. They did not offer an option to repair an otherwise perfectly functioning transmission. This makes me feel like a very unsafe approach. My experience caused such an abrupt stop that under different circumstances there could have been a serious accident.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11651959April 1, 2025
POWER TRAIN
Transmission was changing gears with a very noticeable jerk. Transmission would downshift without warning at various speeds. Transmission would not shift into gear when lever moved from forward to reverse - would stay in neutral Fortunately, the vehicle warranty had been extended, and repairs were accomplished under that. But your recent investigation of F-150 years 2015 - 2017 should be extended because similar problems are existing in later years. The repairs to the vehicle cost over $4,700 - all covered by the warranty. And it appears that the problem with the transmission is well known among the mechanics who work at Ford Dealerships
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Ford F-150