Ford F-150 Service Bulletins (2021)
634 manufacturer communications on file.
- June 5, 2025•Document ID: 11019494Service Bulletin/Repair InstructionsPOWER TRAIN
- Mfr Comm. #:
- SSM 53878
- Date Added:
- June 11, 2025
- Manufacturer:
- LINCOLN
SummarySome 2021-2025 Expedition/Navigator and 2021-2025 F-150 non-Lightning/non-PowerBoost vehicles may exhibit a rattle/scraping noise from the bellhousing area on start-up. This may be due to the torque converter studs contacting the engine to transmission spacer plate (separator plate). To correct this condition, inspect the engine to transmission spacer plate and torque converter studs for wear/damage. If wear/damage is found, replacement of the torque converter is not necessary. Replace only the engine to transmission spacer plate. Refer to Workshop Manual (WSM) Section 303-01 > Engine to Transmission Spacer Plate for full spacer plate removal and installation. When reinstalling the starter motor, make sure the starter is flush with the engine to transmission spacer plate prior to tightening the studbolts. Failure to do so may result in damaging the newly installed engine to transmission spacer plate.
Associated Products (15)Associated Documents - June 2, 2025•Document ID: 11019418Service Bulletin/Repair InstructionsPOWER TRAIN
- Mfr Comm. #:
- TSB 25-2236
- Date Added:
- June 10, 2025
- Manufacturer:
- FORD
SummaryThis article supersedes TSB 25-2155 to add labor time for F-150 Lightning. Some of the vehicles listed in the Model statement above may exhibit at least one of the following conditions: * "Active Air Dam System Fault See Manual" warning message in the instrument panel cluster (IPC) * Diagnostic trouble code (DTC) C0604:00 stored in the PCM This may be due to the software level in the powertrain control module (PCM).
Associated Products (3)Associated Documents - June 2, 2025•Document ID: 11018782Service Bulletin/Repair InstructionsPOWER TRAIN
- Mfr Comm. #:
- TSB 25-2229
- Date Added:
- June 2, 2025
- Manufacturer:
- FORD
SummaryThis article supersedes TSB 23-2429 to change the labor operation from actual time to fixed time. Some vehicles listed in the Model statement above may exhibit an illuminated powertrain malfunction (wrench) indicator with diagnostic trouble code (DTC) P084B stored in the powertrain control module (PCM). This may be due to the software level of the PCM. To correct this condition, perform the Service Procedure below to reprogram the PCM to the latest software level via the Ford Diagnosis and Repair System (FDRS).
Associated Products (3)Associated Documents - May 15, 2025•Document ID: 11018526Service Bulletin/Repair InstructionsVISIBILITY/WIPER
- Mfr Comm. #:
- TSB 25-2201
- Date Added:
- May 21, 2025
- Manufacturer:
- FORD
SummarySome of the vehicles listed in the Model statement above equipped with one-touch up/down front windows may exhibit a window not responding to one-touch controls, not opening all the way and/or bouncing back when using the one-touch close function. This may be due to a calibration parameter in the driver door module (DDM) and/or passenger door module (PDM).
Associated Products (5)Associated Documents - May 13, 2025•Document ID: 11018521Service Bulletin/Repair InstructionsENGINE; POWER TRAIN
- Mfr Comm. #:
- SSM 53764
- Date Added:
- May 21, 2025
- Manufacturer:
- FORD
SummarySome 2020 Continental, 2020-2024 Edge/Nautilus, 2020-2025 Explorer/Aviator/Escape/Corsair/F-150/F-Super Duty/Ranger/Transit/E-Series, 2021-2025 Bronco, and 2022-2025 Maverick vehicles may require an engine cooling system flush to be performed for various concerns. Workshop Manual (WSM), Section 303-03 has been updated to eliminate the need to remove and install the radiator assembly to perform a radiator flush.
Associated Products (65)2025 Ford Bronco2025 Ford E-3502025 Ford E-4502025 Ford Escape2025 Ford Expedition2025 Ford Explorer2025 Ford F-1502025 Ford Maverick2025 Ford Mustang2025 Ford Ranger2025 Ford Transit2025 Lincoln Aviator2025 Lincoln Corsair2024 Ford Bronco2024 Ford E-3502024 Ford E-4502024 Ford Edge2024 Ford Escape2024 Ford Expedition2024 Ford Explorer+ 45 moreAssociated Documents - May 6, 2025•Document ID: 11018318Service Bulletin/Repair InstructionsPOWER TRAIN
- Mfr Comm. #:
- TSB 25-2165
- Date Added:
- May 14, 2025
- Manufacturer:
- FORD
SummarySome of the vehicles listed in the Model statement above may exhibit an illuminated malfunction indicator lamp (MIL) with diagnostic trouble code (DTC) P2450 stored in the powertrain control module (PCM). This may be due to the software level of the PCM.
Associated Products (5)Associated Documents - May 1, 2025•Document ID: 11019035Over The AirFORWARD COLLISION AVOIDANCE: ADAPTIVE CRUISE CONTROL
- Mfr Comm. #:
- 25-BC-CS-25.02.02 F-150
- Date Added:
- June 3, 2025
- Manufacturer:
- FORD
Summary"Quality improvements include: -Module configuration settings update to ensure BlueCruise functilonality"
Associated Products (1)Associated Documents - May 1, 2025•Document ID: 11018197Service Bulletin/Repair InstructionsUNKNOWN OR OTHER
- Mfr Comm. #:
- TSB 25-2142
- Date Added:
- May 8, 2025
- Manufacturer:
- FORD
SummaryThis article supersedes TSB 24-2442 to update the service procedure Some 2021-2024 F-150 vehicels equipped with a 3.5L PowerBoost engine, may exhibit at least one of the following conditions: * "12V Battery State of Charge Low" message displayed in the instrument panel cluster (IPC) * "Charging System Service Soon" message displayed in the IPC * "Remote Features Disabled To Preserve Battery" in FordPass * DTC B11D9:09 stored in the body control module (BCM) * Center display screen message of "System Off To Save Battery" * No crank/no start condition and or a discharged 12v battery This may be due to an erroneous calculation of battery state of charge (SOC) by the battery monitoring system (BMS), the software in the air conditioning control module (ACCM) and/or the software in the transfer case control module (TCCM).
Associated Products (4)Associated Documents - April 26, 2025•Document ID: 11017335Service Bulletin/Repair InstructionsUNKNOWN OR OTHER
- Mfr Comm. #:
- TSB 25-2155
- Date Added:
- April 30, 2025
- Manufacturer:
- FORD
SummaryThis article supersedes TSB 24-2404 and TSB 23-2126 to change the labor operation from actual time to fixed time. Some of the vehicles listed in the Model statement above may exhibit at least one of the following conditions: * "Active Air Dam System Fault See Manual" warning message in the instrument panel cluster (IPC) * Diagnostic trouble code (DTC) C0604:00 stored in the PCM This may be due to the software level in the powertrain control module (PCM).
Associated Products (3)Associated Documents - April 17, 2025•Document ID: 11017121Service Bulletin/Repair InstructionsUNKNOWN OR OTHER
- Mfr Comm. #:
- TSB 25-2131
- Date Added:
- April 22, 2025
- Manufacturer:
- FORD
SummaryThis bulletin supersedes TSB 24-2436. Reason for update: update the Part List and Service Procedure Some of the vehicles listed in the Model statement above may exhibit at least one of the following conditions: * Harsh engagement * Delayed engagement * Harsh shift * Delayed shift * Illuminated malfunction indicator lamp (MIL) with diagnostic trouble codes (DTC) P0751, P0752, P0756, P0757, P0761, P0762, P0766, P0767, P0771, P0772, P2700, P2701, P2702, P2703, P2704, P2705, P2707, P2708, P0729, P0731, P0732, P0733, P0734, P0735, P0736, P076F, P07D9, P07F6 and/or P07F7 stored in the powertrain control module (PCM) or transmission control module (TCM). This may be due to axial movement of the CDF clutch cylinder (7H351) sleeve causing hydraulic circuit leaks. NOTE: If internal transmission service is required to address a concern detected with the CDF clutch cylinder following this article, technicians should carefully inspect and replace other transmission components and flush transmission fluid cooler only as necessary to confirm proper function. Add a new line to the repair order to document any additional
Associated Products (11)Associated Documents - April 4, 2025•Document ID: 11016915Service Bulletin/Repair InstructionsUNKNOWN OR OTHER
- Mfr Comm. #:
- SSM 53569
- Date Added:
- April 9, 2025
- Manufacturer:
- FORD
SummarySome 2021-2025 Ford and Lincoln vehicles may exhibit diagnostic trouble code (DTCs) U2100 and/or U3002 stored in the cruise control module (CCM), side obstacle detection control module LH (SODL), side obstacle detection control module RH (SODR), side obstacle detection control module C (SODCMC) and/or side obstacle detection control module D (SODCMD) after a module replacement.
Associated Products (25)2025 Ford Bronco Sport2025 Ford Escape2025 Ford Explorer2025 Ford F-1502025 Ford Maverick2025 Ford Mustang2025 Ford Ranger2025 Lincoln Aviator2025 Lincoln Corsair2024 Ford Escape2024 Ford Expedition2024 Ford F-1502024 Ford Mustang2024 Ford Ranger2024 Lincoln Corsair2024 Lincoln Navigator2023 Ford Escape2023 Ford Expedition2023 Ford F-1502023 Lincoln Corsair+ 5 moreAssociated Documents - April 3, 2025•Document ID: 11016924Service Bulletin/Repair InstructionsUNKNOWN OR OTHER
- Mfr Comm. #:
- TSB 25-2089
- Date Added:
- April 9, 2025
- Manufacturer:
- FORD
SummarySome of the vehicles listed in the Model statement above may exhibit tailgate applique poor adhesion. This may be due to poor tape adhesion between the applique.
Associated Products (3)Associated Documents - April 1, 2025•Document ID: 11016853Service Bulletin/Repair InstructionsUNKNOWN OR OTHER
- Mfr Comm. #:
- SSM 53559
- Date Added:
- April 8, 2025
- Manufacturer:
- FORD
SummarySome 2021-2025 F-150 vehicles equipped with the rear parking aid feature may exhibit all of the following conditions:<br /> * A rear parking aid alarm activation when in reverse and no rear obstacles are present<br /> * No diagnostic trouble codes (DTCs) stored in the image processing module A (IPMA)<br /> The Workshop Manual (WSM) has recently been updated to address this condition. Refer to the WSM, Section 413-13A Parking Aid - Vehicles With: Front Parking Aid/Rear Parking Aid > Diagnosis and Testing > Parking Aid > Pinpoint Test R: Continuous Or Intermittent Tone When No Obstacles Or Fault Codes Are Present.
Associated Products (5)Associated Documents - March 19, 2025•Document ID: 11016077Service Bulletin/Repair InstructionsUNKNOWN OR OTHER
- Mfr Comm. #:
- TSB 25-2105
- Date Added:
- March 31, 2025
- Manufacturer:
- FORD
SummaryThis article supersedes TSB 25-2048 to update the labor time description.
Associated Products (4)Associated Documents - March 19, 2025•Document ID: 11016076Service Bulletin/Repair InstructionsUNKNOWN OR OTHER
- Mfr Comm. #:
- TSB 25-2104
- Date Added:
- March 31, 2025
- Manufacturer:
- FORD
SummaryThis article supersedes TSB 24-2251 to update the labor times associated with the Service Procedure from M-time to AP-time.
Associated Products (12)Associated Documents - March 19, 2025•Document ID: 11016071Service Bulletin/Repair InstructionsUNKNOWN OR OTHER
- Mfr Comm. #:
- TSB 25-2103
- Date Added:
- March 28, 2025
- Manufacturer:
- FORD
SummaryThis article supercedes TSB 23-2341 to update the production fix date.
Associated Products (3)Associated Documents - March 6, 2025•Document ID: 11016252OtherUNKNOWN OR OTHER
- Mfr Comm. #:
- 24N04- S1
- Date Added:
- April 2, 2025
- Manufacturer:
- FORD
SummaryCustomer Satisfaction Program 24N04 – Supplement #1 Certain 2021-2023 Model Year F-150 HEV and 2022-2023 Model Year Maverick HEV Vehicles Replacement of Exhaust Gas Heat Recovery System If Failed
Associated Products (5)Associated Documents - March 6, 2025•Document ID: 11015558Service Bulletin/Repair InstructionsUNKNOWN OR OTHER
- Mfr Comm. #:
- TSB 25-2069
- Date Added:
- March 11, 2025
- Manufacturer:
- FORD
SummarySome of the vehicles listed in the Model statement above may exhibit may exhibit the trailer brake gain amount not displaying in the IPC when depressing the trailer brake control switch, but the trailer brakes still perform correctly and are adjusted when using the switch.
Associated Products (3)Associated Documents - March 1, 2025•Document ID: 11015266Service Bulletin/Repair InstructionsUNKNOWN OR OTHER
- Mfr Comm. #:
- SSM 53454
- Date Added:
- March 7, 2025
- Manufacturer:
- FORD
SummarySome 2021-2025 F-150 Built on or before 01-Feb-2025 and 2024 F-Super Duty vehicles equipped with one-touch up/down front windows may exhibit a window not responding to one-touch controls, does not open all the way and/or bounces back when using the one-touch close function.
Associated Products (5)Associated Documents - February 25, 2025•Document ID: 11014834Service Bulletin/Repair InstructionsUNKNOWN OR OTHER
- Mfr Comm. #:
- TSB 25-2048
- Date Added:
- March 4, 2025
- Manufacturer:
- FORD
SummarySome of the vehicles listed in the Model statement above may exhibit at least one of the following conditions: * General system performance/stability/intermittent system reboot * Intermittent wireless Apple CarPlay or Android Auto function * Phone related concerns with intermittent no audio or static * Navigation/global positioning system (GPS) related concerns through Apple CarPlay and Android Auto * Alexa function consistency and stability
Associated Products (4)Associated Documents