Ford · Model Report
Showing safety data for the 2025 model year only.
Ford Motor Company (Ford) is recalling certain 2025 Transit, F-150, and Explorer vehicles. The connecting rod and rod bearing components may have manufacturing defects that can lead to engine damage and engine failure.
Ford Motor Company (Ford) is recalling certain 2025 Explorer vehicles. The bolts securing the front brake caliper may not be tightened properly, which can result in a loss of front brake function and possible wheel damage.
Ford Motor Company (Ford) is recalling certain 2025 Explorer and Aviator vehicles. A mounting bolt for the front subframe may have been tightened improperly.
Ford Motor Company (Ford) is recalling certain 2025 Explorer vehicles. The powertrain control module (PCM) may reset while driving, which can damage the park system or cause an engine stall.
Ford Motor Company (Ford) is recalling certain 2024-2025 F-150, Bronco, 2024 Ranger, 2025 Mustang, Explorer, and Aviator vehicles. The transmission valve body may have been machined incorrectly, which can cause reverse gear failure, or unexpected forward movement in reverse or neutral gear.
I am reporting recurring engine misfires involving my 2025 Ford Explorer Platinum equipped with the 2.3L EcoBoost engine. The vehicle currently has approximately 15,700 miles. The first incident occurred approximately five months ago. The check-engine warning appeared and the vehicle was diagnosed by an authorized Ford dealership with DTC P0303, indicating a cylinder 3 misfire. The cylinder 3 spark plug was replaced. A second misfire subsequently occurred at approximately 15,700 miles. The vehicle again exhibited an engine misfire/check-engine warning and was transported through Ford Roadside Assistance for service. An authorized Ford dealership diagnosed DTC P0301, indicating a cylinder 1 misfire. I was advised that the cylinder 1 spark plug was physically damaged and that a portion/cap of the plug had broken off and was not present. I am concerned because this represents two spark-plug-related misfires involving two different cylinders of the same engine within approximately five months and at relatively low mileage. Ford has issued technical service information addressing P0301-P0304 misfires on certain 2025 Explorer vehicles equipped with the 2.3L EcoBoost engine. I am not claiming that this establishes the cause of my vehicle's failures; I am reporting the recurring condition so NHTSA can document it and evaluate it alongside any similar reports. Both incidents were diagnosed by authorized Ford dealerships. Repair documentation and manufacturer/dealership correspondence concerning the incidents have been retained and can be provided if requested. The vehicle/component may be available for further inspection if requested, subject to its current repair status.
No injuries · No fire · No crash
On XXX, my 2025 Ford Explorer Platinum experienced a complete unexplained no-start failure while approximately six hours from home. The vehicle had less than 1/4 tank of fuel but was not empty and was parked on a slight decline. It remote-started normally and ran for approximately 10 minutes before automatically shutting off. Afterward, it would not restart, repeatedly displayed "Accessory Power Only," and later displayed and audibly announced "System Failure, Contact Dealer." Multiple jump-start attempts failed and the vehicle required towing to Lugoff Ford in [XXX]. Lugoff Ford documented fuel and transmission-related codes and initially advised that the vehicle appeared to need a transmission replacement. That explanation later changed, and the vehicle was returned without an identified cause or repair. I subsequently took the vehicle to Cleveland Ford in [XXX] for a second evaluation. Their repair order specifically states that Ford connected data showed a fuel-pressure code on the day of the failure, but they found no active DTCs and could not duplicate the condition. The vehicle was again returned without diagnosis or repair. I am concerned that an intermittent defect involving the fuel system, transmission controls, electrical system, software, or related components could cause another sudden disabling event. Two Ford dealers have evaluated the vehicle, evidence of the original failure exists, and the underlying cause remains unidentified and unrepaired. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
No injuries · No fire · No crash
The contact owns a 2025 Ford Explorer. The contact stated that while the vehicle was parked, the vehicle was started and the doors were unlocked and the contact walked over to the front passenger’s side door to put her purse inside the vehicle; however, after the contact walked over to the rear driver’s side door to place a child into the car seat, the doors inadvertently locked and the child was trapped and locked inside the vehicle. The key fob failed to operate as designed, and the contact was unable to unlock the doors. The contact broke the rear driver’s side window to remove the child from the vehicle. No warning lights were illuminated. The vehicle was taken to a dealer, and the dealer stated that the failure might be related to a software malfunction; however, the cause of the failure was not yet determined. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 4,000.
No injuries · No fire · No crash
The contact owns a 2025 Ford Explorer. The contact stated that while driving 50 MPH, the brake pedal was depressed; however, the vehicle failed to stop as intended. The vehicle crashed into the driver's side of another vehicle. The air bags failed to deploy. The vehicle was towed to a local tow yard. The contact was transported to the local medical center for medical attention. The contact sustained bruises and contusions during the crash. The contact sustained a continuous headache after the crash. The contact was receiving continuous medical treatment. A Police report was filed. The vehicle was scheduled for an inspection by the insurance company within days. The manufacturer was made aware of the failure, and a case was filed. The failure mileage was approximately 20,000.
Steering fails to self-center after slight bear-left such as lane change manuver or steering to track a gentle left bend in road, typically holding ~10 degree left position of the steering wheel. Center feel is "notchy." Behavior is almost completely a bear-left problem and only a slight similar behavior in bear-right condition. Self-centering from hard left seems to be correct in fully returning wheel to center. This behavior has been confirmed by many owners' complaints posted online, and is a problem unique to the Explorer model and 2020+ generation. Video demonstrating problem while driving: [XXX] Explorer ST Owner Forum post confirms similar behavior by others: [XXX] My dealer is treating this as "not a problem, they all do this." No other vehicle in my life (dozens) has ever exhibited this behaviour of steering not returning to center while moving. After delivery I returned the car almost immediately to the dealer on noticing the steering just felt "weird." They found nothing. I narrowed the behavior down to the specific circumstance of bear-left and notchy on-center feel, returned it again, and again they found nothing. With ~3000mi, no change in behavior --"break-in" is long past. I know how to correct for the issue, but if I loan out the car? While it can be called a fit and finish flaw, on the outside it could be a safety issue for unfamiliar drivers. Answers to General Guidelines questions >>> Dealer has identified no failed components or need for repair after two attempts and multiple discussions of the problem. >>> Safety? Issue results in fatigue after long use of the vehicle. Drivers unfamiliar with non-return-to-center behavior may not give the neccesary corrective input to return steering to center. >>> Two dealer repair visits, both inconclusive. >>>No warning lamps etc. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
No injuries · No fire · No crash