Ford · Model Report
Showing safety data for the 1990 model year only.
THIS IS NOT A SAFETY RECALL IN ACCORDANCE WITH THE SAFETY ACT. HOWEVER, IT IS DEEMED A SAFETY IMPROVEMENT CAMPAIGN BY THE AGENCY. VEHICLE DESCRIPTION: 1990-1993 FORD F-SERIES VEHICLES EQUIPPED WITH DUAL FUEL TANKS AND 4.9, 5.0,5.8, OR 7.5 LITER GASOLINE FUELED ENGINES. SOME VEHICLES CAN EXPERIENCE A CROSS TANK FUEL FLOW CONDITION DUE TO A DAMAGED CHECK VALVE IN THE FUEL PUMP/SENDER ASSEMBLY. FUEL MAY BE SUPPLIED FROM ONE TANK AND SOME OR ALL OF THE UNUSED FUEL MAY BE RETURNED TO THE OTHER TANK.
THE IGNITION SWITCH COULD EXPERIENCE AN INTERNAL SHORT CIRCUIT.
A MALFUNCTIONING CHECK VALVE WITHIN THE FUEL PUMP ASSEMBLY CAUSES A PORTION OF THE UNUSED FUEL FROM ONE TANK TO BE RETURNED TO THE SECOND TANK. WHEN THIS OCCURS, THE CAPACITY OF THE SECOND TANK CAN BE EXCEEDED, CAUSING FUEL SPILLAGE.
UNDER CERTAIN CONDITIONS, THE SNAP RING THAT LOCATES THE PARK GEAR ON THE OUTPUT SHAFT OF THE TRANSMISSION MAY FRACTURE.
INCORRECTLY INSTALLED FUEL LINE CONNECTORS HAVE FUEL SUPPLY AND RETURN LINES CROSSED.
Unknown component(s) failure causes vehicle to stall at speed that vary, fuel supply is sufficient and battery good, no indication that stall is imminent. Varying time lapses allow restart and normal driving. Ammeter and temp gauges normal. Re-start may occur immediately or several hours. Online search reveal this to be common with F150 1990-1995. I drive Colorado state highways that often have no shoulder to stop on and 60 mph limit is rarely observed by speeding motorists along with following too closely or too fast for conditions which has caused great concern for safety with stalled vehicle in traffic lane. Nighttime hazards with deer, elk and no street or road lighting does not slow traffic in general. Slept in vehicle after incident last Saturday night barely off the road, tried re-starts often twice started then stalled and manually pushed truck back to shoulder that had space. Nearest populated area approx 40 miles.
No injuries · No fire · No crash
REPLACE FRONT FUEL PUMP, AND HAVE BEEN USING THAT TANK EXCLUSIVELY AS IT STARTS AND RUNS BETTER THAN THE REAR. THIS MORNING I NOTICED FUEL LEAKING FROM THE REAR TANK, WHICH WAS HALF FULL WHEN I STARTED USING THE FRONT TANK. I OPENED THE FILLER NECK AND GAS WAS SPILLING OUT. I TURNED THE KEY TO START POSITION AND THE REAR TANK SHOWED COMPLETELY FULL. THE RETURN LINE FROM THE FRONT TANK HAS BEEN RETURN UNUSED FUEL TO THE REAR TANK, CAUSING IT TO OVERFLOW.
No injuries · No fire · No crash
TL* THE CONTACT OWNS A 1990 FORD F-150. THE CONTACT STATED FUEL LEAKED FROM ONE TANK INTO THE OTHER TANK AND CAUSED THE VEHICLE TO JERK WITHOUT WARNING. THE CONTACT PULLED OVER TO THE SIDE OF THE ROADWAY AND SWITCHED THE FUEL BUTTON TO THE OTHER TANK. THE VEHICLE WAS TOWED TO THE RESIDENCE. THE VEHICLE WAS NOT TAKEN TO BE DIAGNOSED NOR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE HOWEVER, NO ASSISTANCE WAS OFFERED. THE FAILURE MILEAGE WAS 162,000.
No injuries · No fire · No crash
TL* THE CONTACT OWNS A 1990 FORD F-150. THE CONTACT NOTICED A STRONG FUEL ODOR OUTSIDE THE VEHICLE AND INSIDE WHILE DRIVING VARIOUS SPEEDS. ALSO, WHILE EXAMINING THE VEHICLE AND OPENING THE FUEL TANK, THE FUEL POURED OUT. QUIRK FORD OF AUGUSTA (7 WATER ST, HALLOWELL, ME 04347, (207) 430-1600) WAS CONTACTED AND STATED THAT THERE WAS NO REMEDY FOR THE FAILURE. THE VEHICLE WAS NOT TAKEN TO A DEALER OR INDEPENDENT MECHANIC FOR DIAGNOSTIC TESTING OR REPAIRS. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND INFORMED THE CONTACT THAT THE VEHICLE WAS NOT INCLUDED IN A RECALL. THE FAILURE MILEAGE WAS 172,000.
No injuries · No fire · No crash
TL* THE CONTACT OWNS A 1990 FORD F-150. THE CONTACT STATED THAT THE GEAR SHIFTED OUT OF THE PARK POSITION INTERMITTENTLY WHILE PARKED ON AN INCLINE. WHENEVER THE VEHICLE SHIFTED OUT OF GEAR, IT ROLLED FORWARD UNTIL THE EMERGENCY BRAKE WAS ENGAGED. THE VEHICLE STOPPED MOVING WHEN IT ROLLED INTO A CURB. THE FAILURE OCCURRED TWICE SINCE THE VEHICLE WAS PURCHASED ON JANUARY 16, 2018. AN UNKNOWN DEALER WAS CONTACTED AND STATED THAT THERE WAS AN OPEN MANUFACTURER'S RECALL (90S10) FOR THE TRANSMISSION; HOWEVER, THE VIN TOOL INDICATED THERE WERE NO OPEN RECALLS. THE MANUFACTURER WAS NOTIFIED BY THE DEALER AND STATED THAT THE PARTS WERE NO LONGER AVAILABLE TO COMPLETE THE OPEN TRANSMISSION RECALL. THE FAILURE MILEAGE WAS APPROXIMATELY 70,627.
No injuries · No fire · No crash