BMW · Model Report
Showing safety data for the 2002 model year only.
BMW of North America, LLC (BMW) is recalling certain model year 2000-2003 525i Sedan, 530i Sedan, 540i Sedan, 2001-2003 525i Sports Wagon and 540i Sports Wagon vehicles, and 2000-2004 X5 SAV 3.0i, X5 SAV 4.4i, and X5 SAV 4.6is vehicles. This recall affects certain vehicles where the original steering wheel has been replaced with the optional sports steering wheel. The sports steering wheel has a frontal air bag inflator that may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, temperature and temperature cycling.
BMW of North America, LLC (BMW) is recalling certain 2000-2002 BMW 320i, 323i, 325i, 325xi, 330i, 330xi, 323Ci, 325Ci, 330Ci, M3, 323iT, 325iT and 325xiT vehicles, 2001-2002 525i, 530i, 540i, M5, 525iT and 540iT vehicles, and 2001-2003 X5 3.0i, X5 4.4i, and X5 4.6is vehicles. These vehicles may have had a driver-side air bag module installed as replacement equipment such as after a vehicle crash necessitating replacement of the original air bag, or as a remedy part for a prior recall. These replacement modules contain an air bag inflator that may rupture due to propellant degradation occurring after long-term exposure to lower absolute humidity, temperature and temperature cycling.
ON CERTAIN PASSENGER VEHICLES, THE CONNECTION OF THE SAFETY BELT BUCKLE TO THE STEEL ROPE OF THE TENSIONER DOES NOT MEET BMW SPECIFICATIONS. IN SEVERE FRONTAL CRASHES, THIS CONNECTION CAN DETACH.
ON CERTAIN SPORT UTILITY VEHICLES, IT MAY BE POSSIBLE FOR THE FRONT BRAKE LINE TO SLIP OUT OF THE RETAINING BRACKET LOCATED AT THE FRONT STRUT. THE BRAKE HOSE THAT IS ATTACHED TO THE BRAKE LINE COULD COME IN CONTACT WITH THE TIRE AND BE SUBJECTED TO WEAR AND ABRASION.
Bmw has failed on several occasions to address this issue or service vehicle. I have made them aware of the situation but continue to receive letters that indicate I could die of the airbag.
No injuries · No fire · No crash
Several components or systems have failed or malfunctioned, including the ABS module, power steering, rear left turn signal connection, speedometer, and there are various error codes (P0313, P0500, P1093, P2098, OBDII FAIL, OBD bulb check FAIL). It is not clear if these components are available for inspection upon request based on the information provided. The safety of the driver and others on the road was put at risk due to the failure of the ABS module, the absence of power steering, and the non-functioning rear left turn signal. The malfunctioning ABS system can lead to reduced braking efficiency and increased stopping distances, while the lack of power steering can make the vehicle harder to control. Additionally, the non-functioning rear left turn signal can cause confusion for other drivers on the road, increasing the risk of accidents. It is not clear from the information provided if the problem has been reproduced or confirmed by a dealer or independent service center. There is no information provided about whether the vehicle or its components have been inspected by the manufacturer, police, insurance representatives, or others. The warning lamps and messages, such as the DSC BRAKE and ABS lights, including the check engine light in the dash terminal, have appeared prior to the failure of the mentioned components. The error codes (P0313, P0500, P1093, P2098, OBDII FAIL, OBD bulb check FAIL) also indicate issues with the vehicle. It is not clear when these warning lamps, messages, and error codes first appeared.
No injuries · No fire · No crash
TL* THE CONTACT OWNS A 2002 BMW X5. THE CONTACT STATED WHILE DRIVING 35 MPH, THE HOOD INADVERTENTLY UNLATCHED CAUSING DAMAGE TO THE HOOD. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED WITH NEEDING THE HOOD SHOCKS AND HOOD HINGES TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS INFORMED OF THE FAILURE. THE CONTACT WAS STILL AWAITING A RESPONSE FROM THE MANUFACTURER. THE FAILURE MILEAGE WAS APPROXIMATELY 117,000.
No injuries · No fire · No crash
TL* THE CONTACT OWNS A 2002 BMW X5. THE CONTACT STATED THAT HE DID NOT SECURE THE VEHICLE'S HOOD LATCH WHEN HE PUT THE HOOD DOWN. THE CONTACT THEN DROVE THE VEHICLE AT 35 MPH, WHEN THE HOOD FLUNG UP. NO WARNING LIGHTS ILLUMINATED. BMW OF NORTH LIBERTY (525 MADISON AVE, NORTH LIBERTY, IA 52317) WAS CONTACTED AND MADE AWARE OF THE ISSUE. THE DEALER INFORMED THAT THEY COULD NOT COME TO A CONCLUSIVE DECISION AS TO DETERMINE IF THE VEHICLE WAS EQUIPPED WITH THE HOOD WARNING SYSTEM. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT THE SHOCKS INSIDE THE HOOD HAD RIPPED LOOSE AND THE HOOD NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE BUT INFORMED THAT THE REARVIEW MIRROR WOULD ALERT, IF THE HOOD WAS OPEN AND THE COMPLAINT WOULD BE FORWARDED TO THEIR SAFETY ENGINEER, HOWEVER SINCE THE VEHICLE WAS NOT TAKEN TO A CERTIFIED BMW MECHANIC FOR ROUTINE MAINTENANCE, NO FURTHER ASSISTANCE WAS PROVIDED. THE FAILURE MILEAGE WAS 117,000.
No injuries · No fire · No crash
CAR WAS PARKED. I TRIED TO UNLOCK MY CAR WITH THE KEY FOB AND NOTHING HAPPENED. I UNLOCKED THE DOOR WITH THE KEY AND AFTER GETTING IN THE CENTRAL LOCKING SYSTEM WOULD NOT WORK. AFTER RESEARCHING THE PROBLEM I FOUND THAT THE GMIII CONTROLS THE CENTRAL LOCKING AS WELL AS OTHER ITEMS LIKE THE WINDSHIELD WIPERS, INTERIOR LIGHTS, SUN ROOF, AND REAR UPPER AND LOWER HATCH. I ORDERS A NEW ONE AND WHEN I TOOK THE OLD ONE OUT TO REPLACE IT I FOUND THAT IT HAD CAUGHT ON FIRE AND BLEW FUSE 14. IT APPEARS A THYRISTOR OR TIAC GOT TO HOT AND SET THE BOARD AND CASE ON FIRE. I HAD SMELT A PLASTIC SMELL EARLIER WHILE DRIVING SO IT MAY HAVE BEEN BURNING BEFORE I PARKED. I AM ATTACHING PHOTOS.