Hyundai Santa Fe Complaints

8,019 consumer complaints on file.

#11631370December 18, 2024
ENGINE
Crack was found in oil pan during regular maintenance. The engine was replaced by Hyundai and now has around 60,000 miles on it. At my expense, the oil plan was replaced.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11631403December 18, 2024
POWER TRAIN
Transmission: yes, available upon inspection I own a 2019 Hyundai Santa Fe. I have brought it in for repairs on the transmission a couple of times. The check engine light has come on but the computer was not displaying the problem. I am aware that this is not uncommon for the year, make, and model. Recently, I was driving my car on a high-speed highway when the transmission went out. While suppressing the gas, the transmission slipped and would not accelerate. As cars were passing me on either side, my car decelerated and cars behind me came close to rear-ending me. Again, this was at high speeds and put my safety in jeopardy. I was finally able to find a gap in the cars and able to get to the shoulder but not after several minutes of unsafe conditions. After this incident, I brought it back to the service center and the computer analysis did display that it is an internal transmission problem. The service center has inspected the transmission. Yes, the warning lamps were displaying, first about 8 months prior. As stated previously, the actual problem was not displaying. Attached document is previous work done for transmission due to incorrect computer diagnostics.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11631477December 18, 2024
POWER TRAIN
See attached document for complaint.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11631455December 18, 2024
BACK OVER PREVENTION
The contact owns a 2021 Hyundai Santa Fe. The contact received notification of NHTSA Campaign Number: 24V879000 (BACK OVER PREVENTION); however, the part to do the recall repair was unavailable. The local dealer was contacted, and it was confirmed that the part was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11631028December 16, 2024
TIRES:TREAD/BELT
All 4 tires had the belts Seperate within a year. Less than 15k miles on each. The car started riding rough and pulling hard. Size: 235 /65 R16 103T SL BSW
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11630860December 16, 2024
ENGINE, POWER TRAIN
Catastrophic engine failure without warning. Rod bearings blew car unable to produce power.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11630858December 16, 2024
FUEL/PROPULSION SYSTEM
When I first start my car for the day, I get an error message, which says transmission error get transmission checked immediately. I’m unable to put my car into gear and when I try to go forward the transmission acts as if insufficient transmission fluid and does not accelerate properly and go into gear. I went to a Hyundai dealer in October 2024!to get the car serviced. The Hyundai dealer flushed the transmission system For a while I no longer got the transmission error message on the dash. A few weeks later I had the transmission error again and the car would not go into gear. I took the car in for a second time to be serviced by Hyundai dealer They said that they reset the software. About a week later I got the transmission error message again, along with the difficulty of engage in the transmission. The workaround I had for this was to turn the car off and turn it back on again and that would get rid of the transmission error message until the next day. I plan to take my car in to a Hyundai dealer this week and report to them that I’ve been having this transmission error message almost daily for the last week. This problem makes the car feel unreliable, and it is a potential safety risk to not be able to accelerate and change gear when operating the vehicle. The car also lurches foreard slightly after parking and turning off thr ignition.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11630778December 15, 2024
UNKNOWN OR OTHER
rear camera malfunction just like other models
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11630804December 15, 2024
SERVICE BRAKES, WHEELS
I purchased my 2023 Santa Fe brand new off the show room floor in Jan 2024. After about 6k miles when braking on the highway the entire vehicle would shudder and shake including the steering wheel. I took it into the dealership where I was informed this is a KNOWN ISSUE with this year/make/model with the rotors. They claimed they would turn the rotors but if the issue persists they would replace them. About 2k miles later (apx 2 months) the shuddering happened AGAIN. So I made an apt to get them replaced where the new service tech tried to tell me again this is a KNOWN ISSUE but now I would be responsible for a $250 replacement of the rotors. I refused to pay as they are within the 12k or 1 year warranty and they refused to replace them. That service tech also said the day prior he had to deliver that news to 4 OTHER patrons about the replacement of their rotors. I feel extremely unsafe in this vehicle and the issue is still not fixed as I have a claim in process with the manufacture directly. The claim was put in on 12/7/24 where I was told I would be contacted within 2-3 BUSINESS DAYS by a manager due to my claim being escalated. It is now 12/15/24 and still NO CONTACT from Hyundai. The vehicle shuddering is increasingly worse and worse and I feel very unsafe in this suv.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11630749December 14, 2024
POWER TRAIN, ELECTRICAL SYSTEM:HORN
I have had to have a problem with my power teain worked on at two different Hundia dealership I am having an issue where the horn just stops blowing and that isvery dangerous. After switching off and restarting the horn will work again.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11630741December 14, 2024
POWER TRAIN, BACK OVER PREVENTION: WARNINGS
On December4th 2024 my car rolled forward into a barrier post. I stopped to get air in my tires and the Parking Allert went off as I got near the barrier post. I then parked my car. I left my car running and driver door partially opened. I dropped the valve cap between the spokes of the last tire being filled. So, I got into the car and backed up about three feet to get the cap. Parked the car got out and it rolled forward into the barrier post. I was completely out of the car but just by my driver door. I tried to get back in but it was too quick. Subsequently, I drove to work to let my supervisor know i would need time to go to the dealership. I was concerned air bags would deploy since that didnt happen. Also because the car didnt stop on its own felt the integrity of systems were questionable. So, I repeated the steps at work like the incident. Except, I stayed in the car. The car beeped and the dash said Shift to P when my door was open and placing in drive and reverse. I NEVER got any indications of such when the car hit the barrier. I found the two DTC's that showed on my Hyundai App were related to DTC U110387 and U110382. I had 99 miles on the car having purchased it with 15 miles on it. The original date of these DTCs is Aug 27th, 2024, with a last reported Aug 30, 2024. I see recalls 24V529000 and 24V246000. I don't know if they are related. but this has to be addressed. My car is at the dealership being repaired and my insurance rate will no doubt go up and the value of my car down. This isnt right.
Crash:
Yes
Fire:
No
Injuries:
0
Deaths:
0
#11630492December 13, 2024
ELECTRICAL SYSTEM, UNKNOWN OR OTHER
I have a 2022 santa fe xrt within the 1st yr of owing in 2022 the horn stopped working in the winter. Went to dealership told it was known issue they replaced it. A few months later into following year still winter went out again they fixed again stating my car has 2 horns and both failed. So far 2022 and 2023 2 times. Fast forward to earlier in 2024 beginning of year horn failed again took to dealer expressed my concern of this is a safety and inconvenience issue they apologized but no recall yet. Now it's almost 2025 and I will be taking my car back to the dealership this weekend for yet another time due to the horn not working at all. I've found out my horn has not worked due to driving and a vehicle almost colliding into my lane and went to honk horn and nothing. A separate time a person has cut out in front of me almost causing an accident and all I could do is to lock up my breaks and swerve hope they see me and don't get hit could not beep to warn them. I bought the car brand new in 2022 feb and I have had the horn replaced 4 to 5 times and they still are staying no recall this is ridiculous.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11630016December 11, 2024
ENGINE, UNKNOWN OR OTHER
The engine on my car was consuming oil at a rapid rate. The dealer service department gave me the run around for many month. Stating they could never duplicate the issue. when clearly the whitish blue smoke pouring out of tailpipe and horrible combustion fumes inside cabin of car. At some point bluish smoke turned to black smoke and that when the $800 combustion test was suggested. Which they say will tell me if the engine is bad. how do they not know the signs of a bad engine. my car sat in service department for 2 months for them to say it's not covered under warranty. I tried everything to hold the manufacture responsible and they was unwilling to budge and help. The car has the extended warranty and my car was under the mileage and years. My car been sitting in my driveway since May 2024 needing a engine replacement. The fumes in cabin of vehicle was unbearable which cause me to have to drive with window down. Vehicle never show any warning lights when engine oil was low or empty. another incident was with the radio not turning off even after the battery went died. The radio continue to work and connect to phone when battery was died. After charging battery radio would again kill battery and not shut off. The only way it would shut off is to disconnect radio. How dealer explained the issue was that of a modem. That the car probably need to be reset when radio was disconnected it worked. But after that it happen 3 more times. these cars need to be recalled and all customer should get there money back. To own a 2005 Santa Fe with over 216,000 miles with no oil burning / leaking or smoke out tailpipe say a lot on the manufacturing of this vehicle. I have no mechanical issues with this car and that was the reason i wanted to upgrade to 2017. Now I wish I had never brought the 2017. Beware before buying this brand because they are no good.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11630088December 11, 2024
ENGINE
Check engine light came on and acceleration failed. Hyundai dealership indicated there are no valves in the intake and exhaust ports.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11630171December 11, 2024
ENGINE
The engine went out while driving on the freeway. All maintenance has always been done and it was burning oil.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11630004December 10, 2024
ENGINE
Over the past year, the engine light continues to come on. The first time this happened, there was no oil in the reservoir even though it had recently had an oil change. They did another oil change and sent us on our way. The next time.[XXX], the check engine light came there was a loud clanking sound and low oil again. This was the code the dealership said it was: Code P0021 [XXX] . He suggested a tune-up at this time. He says the engine light should stay off. We just need to continue to check the oil. [XXX]. Check engine light came on again as my son was driving. He lost pressure is the gas pedal. When he pushed it, the vehicle would not accelerate. We has it towed to the same dealership On 10/2/24, they were finally able to tell us what Hyundai felt was wrong: Timing components will need to be replaced- the timing tensioner or chain has failed $4363.20. We pushed back because our personal mechanic said the following: We were told by our mechanic and some of the research that we did that the breaking of the timing chain is connected to the loss of oil pressure that has been happening because of the default in the engine which is part of the recall for that vehicle. What can they tell us about that? Those timing chains are supposed to last a long time and not go out at 130,000 miles or whatever the odometer reading is now. Can this be considered in the recall information for replacing the engine? It does not seem that they're really working with us or helping us on this. Our contact person went back to his shop foreman who went back to Hyundai to ask about this. He then said his shop foreman said it doesn't seem to be directly related to that warranty extension TXX8 - but we will submit all information to Hyundai prior approval and see what they say. It then took him until October 14 to say the following: Hyundai is asking my master technician to remove the valve valve cover and inspect timing parts closer. We took it to another INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11630007December 10, 2024
STRUCTURE:BODY
Locked the doors normally with the remote. Went into the doctor's office. Returned to the car the driver's door would not unlock. All other doors worked normally. Could not unlock the door with either handle, the switch or the remote. The Dealer says that the door latch mechanism failed in the locked position with the door closed. This would make it very difficult to exit the car in an accident, fire or submersion. The only exit is to crawl over the high mid console and exit through the right front passenger door, this is a very difficult maneuver.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11630009December 10, 2024
ENGINE
All of a sudden, while driving the car it started to shake. When I slowed down to stop it was shaking more and idling so low I thought it was going to shut off. Went to the mechanic we use, mis firing on multiple cylinders. After replacing the plugs it was still doing the same thing. The oil was checked, only 2000 miles from my last oil change, I was nearly out of oil. I was told that these cars run a lot of oil, and run hot. Basically getting that low on oil the engine burned up. I never got a low oil light. Its only been 2000 miles into my recent oil change. The mechanic said this is a common problem with these cars, people shouldn't go more than 2000 without at least checking oil level and probably will need oil added. I was told not to drive it anymore, it could potentially over heat or stall out.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11629882December 10, 2024
ENGINE, ENGINE AND ENGINE COOLING
The contact's husband owns a 2016 Hyundai Santa Fe. The contact stated that while driving at various speeds, the vehicle failed to accelerate upon depression of the accelerator pedal. The check engine warning light appeared on the instrument panel during the failure. Despite the vehicle operating in LIMP Mode, the vehicle was taken to an independent mechanic where an oil change was performed. The mechanic warned after the service was performed that there may be an ongoing failure with the engine. Several days later, the contact stated that while in stop and go traffic, the vehicle stalled with the check engine warning light illuminated. Due to the failure, the vehicle was towed to an independent mechanic where a diagnostic test was performed; and the contact was informed that the failure might be related to the cam shaft. The contact had the vehicle towed to a dealer and informed that the failure was probably related to the high-pressure fuel pump. The high-pressure fuel pump was replaced; however, the failure persisted. The contact was then informed by the dealer that the engine needed to be replaced. The manufacturer was not notified of the failure. The vehicle remained with the dealer unrepaired. The failure mileage was approximately 200,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11629667December 9, 2024
ELECTRICAL SYSTEM, UNKNOWN OR OTHER
The vehicle seat caught fire overnight, Sept 26th, and was discovered the morning of Sept 27th 2024. The fire was contained to inside the vehicle and melted parts of the driver seat and lower part of steering wheel. The vehicle interior was covered in orange dust and had extremely toxic smell inside. Insurance 3rd party inspected and declared it a total loss. A few weeks later, a neighbor and fellow Hyundai SantaFe owner mentioned that he had heard of an issue with the Santa Fe catching fire. With this new information, I called Hyundai to alert them. Hyundai opened an investigation, but closed the claim since the 3rd party that declared it a total loss had already sold it as salvage. They also denied any recalls pertaining to my specific vehicle or knowledge that electrical fire was a potential issue for this model and year. There was a recall for a tow hitch that lead to fires....but mine did not have a tow hitch. Obvious concern is that this could be a wider issue than just 1 vehicle and lives and property of those owners and others could be at significant risk.
Crash:
No
Fire:
Yes
Injuries:
0
Deaths:
0

← Back to Hyundai Santa Fe