Hyundai Santa Fe Complaints

8,019 consumer complaints on file.

#11627410November 26, 2024
ENGINE
My 2013 Hyundai Santa Fe Sport is consuming a quart of oil and more within a 7-10 day time period. I took it to my local Hyundai dealership but it's not covered by a recall for this and there are No open recalls.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11627525November 26, 2024
ENGINE, UNKNOWN OR OTHER, VEHICLE SPEED CONTROL
The engine seized due to an issue with the oil plug and another part, leading to a lack of oil in the system. The vehicle is currently with Hyundai and available for inspection upon request. How Safety Was Put at Risk: While driving on the highway, I suddenly lost acceleration (below 40mphs). I was forced to pull over to the left side of the highway where it was shallow, where I risked being hit by passing vehicles until there was a safe break in traffic, allowing me to maneuver to an exit. This created a hazardous situation for both myself and other drivers. Reproduction or Confirmation of the Problem: The issue has been confirmed by an independent automotive technician, who diagnosed the problem as a blown engine caused by a lack of oil. The vehicle is now with Hyundai for further inspection. Inspection by Others: The vehicle has been inspected by an independent service center and is currently being inspected by Hyundai. No other parties, such as the police or insurance representatives, have been involved. Warning Lamps or Messages Prior to Failure: The only warning sign prior to the incident was the check engine light blinking at the time of the failure. There were no other warning lamps, messages, or symptoms before the engine seized. The vehicle was within the oil range limit of 7,500 miles at the time of the incident. Additional Notes: The incident occurred suddenly, without prior warning or indication of an issue. Based on the diagnosis and known issues with the oil plug, I believe this failure was caused by a defect.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11627598November 26, 2024
FORWARD COLLISION AVOIDANCE: WARNINGS, VEHICLE SPEED CONTROL
The contact owns a 2025 Hyundai Santa Fe. The contact stated that while driving 55 MPH, the Forward Collision Avoidance Warning Alert System Failed to operate as needed. The contact stated that the vehicle independently accelerated, and the contact depressed the brake pedal and the vehicle responded as needed. The vehicle was not taken to an independent mechanic or dealer to be diagnosed or repaired. The manufacturer was not notified of the failure. The approximate failure mileage was 133,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11627161November 25, 2024
ENGINE, FUEL/PROPULSION SYSTEM
I have Hyudai Santafe 2017 Sport, bought it from dealership in 2020 with 46,000 Miles and in around past 4/5 years added 30,000 miles. Which is not much, in the past one year i have noticed that engine oil is burning faster than usual. On every oil change after driving between 1200 and 1500 miles the oil engine sign blinks and upon checking needed 2 Quarts of oil. I spoke the dealership and they are not very helpfull. Also they did the oil combustion test which i was charged. Later i was advised to do. ("Good morning, Just got off the phone with you sir warranty won't cover it due to the vehicle being out of manufacture warranty and mileage. My technician recommended starting with combustion chamber cleaning which would be around 1200 before taxes and shop supplies. Combustion chamber cleaning is the process of removing carbon buildup from the combustion chamber and intake valves of a fuel-injection engine. to see if that fixes the problem that you are having with the car burning oil. If that step doesn't work we we would submit a warranty pa again, to see if they would cover a new engine." Please advise what should be my next step, as per my mechanic the only solultion right now i have is keep adding oil carefully.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11627278November 25, 2024
ENGINE
While driving down the highway my car started slowing down and would not accelerate. All the lights came up on the dash board and would not let me accelerate. I had to merge 2 lanes to the shoulder on a busy highway where my car ended up dying and would not turn over. I was concerned for my safety and the speed limit was 70MPH and my car rapidly went down. After 5 minutes my car came back on and then immediately stopped working again. I had my car towed to the local Hyundai dealer where they said I would need a new engine on a 4 year old car. My make and model are in the recall for engine issues but my VIN # was not included. I spoke to Hyundai a few times and they stated there was nothing they can do and we needed to pay for the new engine.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11627127November 24, 2024
ENGINE
I was driving my 2017 Hyundai Santa Fe and suddenly I heard the knock sound from the engine and when I pulled over, I saw the oil came down from the engine. I towed my vehicle to Hyundai dealership and they diagnosed the issue is vertical square and potential rod bearing failure. My vehicle has only 91k miles. I want to find out if there is any recall on this issue that happened to my car. Please let me know.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11626940November 22, 2024
ELECTRICAL SYSTEM, ENGINE
The E .C. M. PART# 39110-3C561 started faulting out, causing stalling abruptly while stop at an intersection an merging into traffic.This events were randomly happening causing higher risks of accidents. I took the vehicle for service an was informed that the "ECM" was causing this faults. The vehicle had the check engine light on during this time. The service shop advised me to bring the vehicle in to the Hyundai dealer, because the problem is likely to increase. The Hyundai dealer verify that the "ECM " is faulty an extremely difficult if not impossible to find. This faulting "ECM " part has literally but my vehicle totally useless.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11626890November 22, 2024
VISIBILITY:SUN/MOON ROOF ASSEMBLY
As my wife and I were traveling down the interstate at 45 mph, we heard a loud POP, but we were unable to figure out where it came from. Just a few seconds later, the sunroof exploded into a million tiny pieces of glass that partially rained down on our heads and shoulders. It was quite a startling sound. There was a hole about 8 inches across in the moveable sunroof and more pieces were continuing to fall out. To protect our heads, I closed the shade. There was no evidence of an object striking. Windows were all closed when the incident occurred.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11626601November 21, 2024
ENGINE
Excessive oil consumption greater that 1 quart per 1000 miles.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11626687November 21, 2024
VEHICLE SPEED CONTROL
I was driving on the highway when, out of nowhere, my car started shaking whenever I went over 40 miles per hour. It was quite alarming and honestly a bit scary. So, I would like to request a recall on it. A week after I took it to Hyundai, they informed me that they sent it to you to see if it would be approved to cover the motor. I’ve had this car for just 2 years, and it's frustrating to deal with issues like this. I truly appreciate your attention to this matter, as I hope we can resolve it soon. Thank you for your understanding!
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11626427November 20, 2024
ELECTRICAL SYSTEM, ENGINE
Hi Hyundai- my 2025 Santa Fe calligraphy HEV, with around 900 miles wasn’t turning on and only able to start with a jump. After parking, it was unable to maintain a charge to start up again even after driving 1-2 hours. The dealer wasn’t sure why, replaced the 12v battery first and recharged it overnight. Unfortunately it also drained. Finally diagnosed that the hybrid starter generator needed replacing. More bad news, after replacing they discovered what the service manager said was a defective relay pack of some sort had fused. And the kicker is the part is unavailable until January. I am not sure how widespread or rampant this issue is, but I am concerned there might be more or further issues identified.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11626081November 19, 2024
ELECTRICAL SYSTEM, POWER TRAIN, ENGINE
Vehicle has gone into limp mode 2 times in the past week. Power when accelerating would not exceed 30 mph when pushing the gas pedal to the floor. Had to pull over as I was getting onto the highway and stop/ power down the car and restart.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11626158November 19, 2024
ENGINE
The contact owns a 2018 Hyundai Santa Fe. The contact stated that upon checking the engine oil dipstick, the dipstick was abnormally dry. No warning lights were illuminated. The vehicle was taken to the dealer, who performed an oil consumption test over 1,000 miles, and found that the engine was consuming 2 quarts of oil. The contact was informed that the excessive oil consumption could cause damage to the engine. The vehicle was not repaired. The manufacturer was notified of the failure but provided no assistance. The failure mileage was unknown. The VIN was not available.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11626147November 19, 2024
ELECTRICAL SYSTEM
The back doors should unlock when the SUV is put in park or the motor is turned off. However, it does not unlock over 25% of the time. This means the back doors can not be opened from the outside or inside. People in the back cannot get out unless the doors are manually unlocked from the control panel in the front. This is a real safety issue if there was an accident and the people are trapped in the car. This issue has been reported to the dealer for almost two years. They have not been able to fix the issue. I have reported this problem to Hyundai National Consumer Affairs (case # [XXX]) asking for their help. I ask if this falls under the lemon law since it can not be fixed and is safety issue. I was informed they could not help me. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11625743November 17, 2024
ENGINE
After a perfect dealership maintenance history and being babied since bought new, the 3.3L V6 engine in our 2017 Hyundai Santa Fe seized at 101,800 miles without any warning other than a slight knock on startup the day this occurred. The engine seized while being driven on a side road without any warning lights, causing loss of steering and braking power. Hyundai has extended the warranty on the 4 cyl engines for this model year vehicle, but based on online forums there is clearly a manufacturing defect with the V6 engines as well. We were forced to pay ($1,541) for 20% of the cost to repair the engine with rebuilt components after Hyundai kept the car for nearly four months. I feel this payment should be reimbursed given the warranty on the V6 engines also needs to be extended.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11625690November 16, 2024
ELECTRICAL SYSTEM, FUEL/PROPULSION SYSTEM, POWER TRAIN
Twice, the car refused to switch from EV mode back to gas mode. This resulted in the hybrid battery dying and the car losing power. The first time, I was merging onto the freeway and the gas pedal was all the way at the floor, but I was only maintaining speed (not accelerating). Both times, the car was driveable for approximately one mile on the hybrid battery alone. However, a warning came on the dash, “Check hybrid system. Stop safely.” The second time, I was able to pull into a parking lot before the hybrid battery died. The next day, I was able to drive the car normally. The dealership is unable to pull any codes or replicate the issue. Unfortunately, it only happens intermittently and we have not identified a common theme for the failure.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11625702November 16, 2024
VEHICLE SPEED CONTROL, FORWARD COLLISION AVOIDANCE: ADAPTIVE CRUISE CONTROL
THE CRUISE CONTROL USES A CAMERA , THE IS SUPPOSED TO WATCH YOUR EYES , TO MAKE SURE YOU ARE WATCHING THE ROAD . UNFORTUNATELY , IF YOU ARE WEARING GLASSES ( WHICH I MUST WHEN I AM DRIVING ) THE LIGHT REFLECTING OFF THEM MAKES THE UNIT THINK I AM NOT WATCHING THE ROAD . FOR BACKROUND, I WAS A HIGHWAY PATROL OFFIGER FOR 30 YEARS . I AM VERY ATTENTIVE TO THE ROAD AHEAD OF ME . IT SEEMS HYUNDAI KNOWS OF THIS PROBLEM , WHICH SUDDENLY DISENGAGES THE CRUISE CONTROL , CAUSING RAPID DECELERATION OF THE VEHICLE . AT HIGHWAY SPEED , THIS IS VERY DANGEROUS . IT HAS BEEN NOTED ON MANY FORUMS , AND MY DEALER KNOWS ABOUT THE PROBLEM , BUT THERE IS NO WAY TO DISCONNECT THE CAMERA FROM THE SYSTEM . THIS IS REALLY AN ACCIDENT WAITING TO HAPPEN .
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11625631November 15, 2024
UNKNOWN OR OTHER
The rear section of panoramic sunroof exploded. We were traveling approximately 60 MPH on HWY 395 crossing the bridge on the Columbia River between WA and OR. Suddenly we heard a very loud explosion. When we stopped to investigate we found a hole in the sunroof. It exploded up and outward. There were very few glass shards inside the vehicle and no debris or evidence of anything that could have caused the breakage. The Hyundai dealer was unwilling to repair it as a warranty item. We paid a glass company through our insurance company to replace the glass. I’m aware that there were problems a few years ago with the Hyundai sunroofs and was advised to file this incident report. It was extremely scary to experience the noise.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11625615November 15, 2024
POWER TRAIN
The contact owns a 2024 Hyundai Santa Fe. The contact received a notification of NHTSA Campaign Number: 24V529000 (Power Train) however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11625178November 14, 2024
UNKNOWN OR OTHER
While driving down the road at around 50 mph with no one in front of us, we heard a loud bang above us, and our Panoramic Sunroof exploded. I continued driving to reach a safe area to pull off and look at the damage, and saw glass flying away behind me into oncoming traffic. When surveying the vehicle, there was a large whole in the middle of the panoramic sunroof. It seems to have simply exploded, as there were no cars in front of us and nothing could have hit the vehicle at the time. We were able to pull off safely and cover the hole with cardboard and duct tape to get home safely. However this is a huge safety risk. Had we been on the interstate, we would have had to drive for miles with a blown out sunroof creating unsafe conditions for ourselves and other drivers. Hyundai (so far) will not warranty this as part of their extended warranty even though there are numerous class action lawsuits against them for this part being defective. I believe that Hyundai should be held responsible for exploding panoramic sunroofs. This is not the first incident they have had as it seems to be a regular occurrence.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Hyundai Santa Fe