Ford F-150 Complaints

39,812 consumer complaints on file.

#11766840September 25, 2026
ELECTRICAL SYSTEM, POWER TRAIN
While driving my 2015 F-150 in live traffic, the vehicle suffered an abrupt, catastrophic powertrain and electronic control module failure, resulting in an immediate engine stall and severe traffic hazard. Multiple cluster warnings (Check Engine, Cross Traffic, Hill Assist) illuminated, followed by a total mechanical shutdown into a permanent "No Start" condition. The truck was towed to a Ford dealership.The diagnosis by the certified Ford technician (Repair Order #5804) confirms the root cause mirrors the exact hardware defect covered under Ford Recall 26S / NHTSA Campaign 26V237000. The transmission internal molded lead frame and Transmission Range (TR) Sensor suffered a severe electrical short circuit due to thermal degradation in the fluid.Crucially, this failure triggered a sudden, uncommanded downshift that forced the transmission into 2nd gear at driving speed. This created a violent rotational speed shock that physically shattered the internal planetary gears and clutches. This severe mechanical explosion left the "EXCESSIVE METAL" found in the oil pan, completely destroying the transmission internals.Simultaneously, the internal short circuit back-fed destructive voltage directly into the PCM reference circuit, immediately blowing the 10-amp main power supply circuit (Fuse F93). Because the shorted PCM completely killed module communication ("NO COMMUNICATION WITH PCM"), the computer was physically incapable of saving diagnostic trouble codes (DTCs) prior to replacement. The "TRANS TR SENSOR CODES" only surfaced once a new PCM was installed to restore communication. Ford is wrongfully denying my $8,581.23 recall reimbursement of my transmission and pcm solely because the defect itself completely destroyed the computer’s ability to log data before repairs began.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11766871September 25, 2026
POWER TRAIN
2017 F-150 is dropping into limp mode due to code P0722 (OSS sensor), but Ford's safety recall 26S28 framework fails to replace the broken hardware for this specific code. Dealership performed PCM Update recall campaign 26S28/26V237. Charged me for a diagnostic fee because P0722 is not covered in the customer satisfaction program campaign 26N04, Even though P0722 points to the same transmission molded leadframe failure. After the PCM update my truck will still drop into limp mode and can be dangerous if pulling onto highway and stuck in 3rd gear causing no power during taking off. It also will sometimes stay in 1st gear and I have to pull over and shut the truck off to get it to shift again.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11766888September 25, 2026
POWER TRAIN
Driving on interstate when my truck suddenly flashed a wrench light and downshifted to 5th gear. Truck went into limp mode limiting my gears to 3rd through 5th gear. Had vehicle towed to Ford Dealership. They wanted $399 just to do a diagnostic and scan for codes. My truck was showing code P0720 (Output Shaft Speed Sensor) at my house before being towed. This output shaft speed sensor is integrated into the internal molded lead frame, which is the part that was recalled for replacement on Safety Recall Notice 26S28/NHTSA Recall 26V237. However, Ford will not cover this under the lead frame recall. My guess would be because they know it’s a loophole and they can still make money off of repairs for the same part.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11766891September 25, 2026
ENGINE
Brought my 2020 Ford F150 2.7L EcoBoost in for mandatory emissions recall 24E12. Vehicle had zero dashboard lights or performance issues prior. Immediately upon completion of the PCM flash, the check engine light activated. When the truck was scanned I am now receiving a P0420 and P0430 catalytic converter efficiency codes. The dealership is now requiring $6000 for replacement of qty 2 catalytic converters caused by the recall parameters. This is a predatory compliance software update designed to shift manufacturing component failures onto the consumer after the 80k mile warranty window (truck has 105k). I have filed a complaint with Ford and asked for a P01 Financial Review for After-Warranty Assistance and have been told there is nothing Ford can or will do to assist and I must pay them $6000 if i want them to fix this. Because of this the vehicle is now not emissions compliant.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11766898September 25, 2026
POWER TRAIN
The contact owns a 2015 Ford F-150. The contact stated that while driving 45 MPH, the transmission unexpectedly downshifted with an abnormal sound. The transmission seized in fifth gear and failed to shift as needed, with the check engine warning light illuminated. The contact stated that the failure was a persistent failure. The dealer was contacted by phone and made aware of the failure. The vehicle was taken to the dealer where it was diagnosed with a failed turbine speed sensor and internal lead frame failure. The contact was informed that the lead frame needed to be replaced. The vehicle was being repaired. The contact referenced an unknown recall; however, the VIN was not associated with a recall associated with the failure. The manufacturer was contacted by phone and a case was filed. The contact was informed that the repair was not covered under recall. The failure mileage was 163,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11766921September 25, 2026
POWER TRAIN
The contact owns a 2015 Ford F-150. The contact stated that while driving 60 MPH, the transmission unexpectedly downshifted from sixth gear into first gear. The powertrain warning light and Malfunction Indicator Light (MIL) illuminated after the failure. The contact pulled over to the side of the road. The vehicle was towed to the residence. The contact received notification of NHTSA Campaign Number: 26V237000 (Power Train), and the vehicle was towed to the dealer, where a PCM software update and leadframe wiring harness replacement were performed; however, the failure persisted, and the dealer confirmed that the vehicle could not be test-driven due to a safety hazard. The contact stated that the recall remedy failed to address the safety hazard. The manufacturer was notified of the failure and referred the contact back to the dealer for assistance. The failure mileage was 186,214.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11766959September 25, 2026
POWER TRAIN
I own a 2018 Ford F-150 equipped with the 10R80 automatic transmission. The vehicle currently has approximately 70,000 miles. The transmission has developed intermittent harsh shifting and, more concerningly, has repeatedly appeared to slip or disengage from gear while the vehicle is moving. On multiple occasions while driving at highway speeds, pressing the accelerator did not result in acceleration because the transmission was no longer effectively transferring power to the wheels. This caused a temporary loss of motive power while traveling in traffic. The transmission subsequently re-engaged. The vehicle has also stored diagnostic trouble code P0734, indicating an incorrect 4th-gear ratio. The transmission fluid has been serviced, the vehicle software is current, and an adaptive transmission relearn has been performed by a mechanic. The P0734 code and transmission symptoms returned after these measures. Ford has issued Technical Service Bulletin 25-2475 for 2017-2020 F-150 vehicles equipped with the 10R80 transmission. The bulletin includes P0734 and harsh or delayed transmission operation and identifies axial movement of the CDF clutch-cylinder sleeve causing hydraulic circuit leakage as a possible cause. I am reporting this because the unexpected loss of propulsion at highway speeds creates a safety concern, particularly when merging, changing lanes, or traveling in surrounding traffic.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11766994September 25, 2026
POWER TRAIN
While driving on a residential road, my 2019 Ford F-150 (10R80 10-speed automatic with 88k miles) lost power to the wheels – the engine revved but the truck would not move. It did not recover after I shifted to reverse, then park, then shut the engine off and restarted. The vehicle had to be towed. This followed an earlier event on or around July 7, 2026 (at ~86,500 miles) where the transmission failed to downshift from 4th gear at a stop and stalled the engine, recovering only after cycling the shifter. The truck has a history of hard shifting into and past 4th gear for over a year now. No warning lights appeared during these events. The safety risk is that the transmission intermittently loses drive engagement and can stall the vehicle in traffic. When the engine stalls, power brake assist is lost after one or two pedal applications. Had the loss of drive occurred in an intersection or on the highway rather than a low-speed residential road, it could have caused a collision. An authorized Ford dealer has twice been unable to duplicate the fault on test drives, consistent with the intermittent 10R80 CDF clutch cylinder hydraulic leak described in Ford TSB 25-2126. The dealer’s technician suspects an F-clutch concern.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11767002September 25, 2026
UNKNOWN OR OTHER
My Ford F-150 had recall 26S28 performed by J Allen Ford through mobile service at my home. Before the recall, my truck was operating normally with NO transmission issues—no skipped shifts, hard shifts, unexpected downshifting, warning lights, or other symptoms. I arrived home 10–30 minutes before the technician and the recall was completed at my home. Approximately 1–2 hours later, I drove to the store and the truck immediately began skipping shifts, downshifting unexpectedly, and having hard/harsh shifts. None of these problems existed before the recall. The truck was then towed to J Allen Ford. They checked for codes, inspected the engine, and tested the transmission. They stated there were no lead-frame codes and said they believed the problem was internal to the transmission. The truck has now been at J Allen Ford for over a month. Both J Allen Ford and I contacted Ford Motor Company. I reached a Ford department that could potentially assist, and they also contacted J Allen Ford. I was told the recall department would not assist because there were no lead-frame codes. J Allen Ford also stated Ford would not provide financial assistance because of the truck's age. I understand that I cannot personally determine what caused the transmission failure. However, the timing is extremely concerning: my truck had no transmission symptoms before the recall and developed serious transmission problems within 1–2 hours afterward. **I am asking Ford Motor Company to help resolve this issue and repair my vehicle. I should not be left responsible for the cost of repairing a major transmission problem that did not exist before Ford's recall service was performed. I need Ford to investigate what happened and provide assistance in getting my truck repaired and safely back on the road.**
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11767015September 25, 2026
EXTERIOR LIGHTING
Should be able to simply repair my daytime running lamps at a reasonable cost. One of them is now dim, causing lower visibility for other drivers. Ford's cost for me to repair was quoted today at over $2,100. Simply put, unreasonable! This is an issue that has effected several vehicles.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11767050September 25, 2026
POWER TRAIN
10R80 transmission failure - the truck jerks in and out of gear and transitions between gear levels can be delayed by seconds causing lack of control
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11767051September 25, 2026
VEHICLE SPEED CONTROL
While parking, the truck accelerated on it own. The vehicle jumped over the parking cement stop.
Crash:
No
Fire:
No
Injuries:
1
Deaths:
0
#11767061September 25, 2026
ELECTRICAL SYSTEM
I was parking the vehicle and turned off the engine when the speakers gave out a loud noise. I turned the truck on to see if it would continue but there was no music and smoke began coming out around the radio. I moved the truck away from building and retrieved the fire extinguisher from the back seat. I noticed the "door ajar" warning was on even when the doors were closed. The smoke subsided and I did some quick research online. I was able to find a lot of information about the wire harness between the driver's side rear door and door frame being damaged, producing these symptoms. I disconnected the battery and removed the sheath from the wiring harness. Three wires were severed and several were frayed. (see attached photos) I contacted the local Ford dealership and they explained how it could be replaced at the wire connector in the door frame. Most trucks have a connector in the door frame, this truck does not so the Ford tech offered to solder the wires together. I am experienced in wiring and auto mechanics so I completed the repairs myself as he described.
Crash:
No
Fire:
Yes
Injuries:
0
Deaths:
0
#11766591September 24, 2026
POWER TRAIN, ENGINE
2018 Ford F-150 Limited with the 3.5L EcoBoost engine. At approximately 60,000 miles the engine began making a rattling noise from the front of the engine on cold start, lasting several seconds. Over the last three months the noise has become progressively worse and now occurs at every cold start and lasts longer. The check engine light is currently illuminated. The vehicle has not stalled or lost power. A Ford dealer (Wynne Ford, Hampton, VA) diagnosed the condition on September 24, 2026 at 104,661 miles as cam phaser failure, requiring replacement of the variable camshaft timing (VCT) units and associated timing components. This matches Ford's Technical Service Bulletin 23-2143, which covers 2017-2020 F-150 vehicles with the 3.5L EcoBoost engine built on or before November 30, 2019. Ford previously issued Customer Satisfaction Program 21B10 and warranty extension 21N03 for this same defect on March 2, 2021, but 21N03 expressly excluded the F-150 Limited trim, and both programs have since expired. The dealer additionally reported that it has submitted multiple other cam phaser repairs on 2017-2020 3.5L EcoBoost vehicles for manufacturer assistance in the past two months, including vehicles newer and with lower mileage than mine, and that all were denied. The quoted repair is $5,414.11 at my expense. I am filing this report because cam phaser failure in these engines can progress to timing chain damage and engine failure, and because Ford has documented this defect since at least 2021 without issuing a recall. I contacted Ford (case CXH-09424982) and was denied any financial assistance.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11766658September 24, 2026
POWER TRAIN
The contact owns a 2015 Ford F-150. The contact received notification of NHTSA Campaign Number: 26V237000 (Power Train). The contact stated that prior to receiving the recall notification, the vehicle experienced unexpected transmission downshifts into first gear while driving, and the vehicle failed to shift into first gear intermittently. The wrench warning light was intermittently illuminated. The vehicle was towed to the dealer, where it was confirmed that the vehicle failed to shift into first gear, and it was diagnosed that internal transmission failure had caused metal contamination into the transmission fluid. The dealer determined that the transmission needed to be replaced. The contact stated that the recall remedy failed to address the failure. The failure mileage was approximately 69,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11766696September 24, 2026
UNKNOWN OR OTHER
As I was driving down the highway I hear loud sound like gun, I pull over on shoulder to see if my tire blow up. After I look around the car I see my sunroof was shattered thank god the cover was on in the inside. It was a terrifying experience
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11766709September 24, 2026
POWER TRAIN
The contact owns a 2020 Ford F-150. The contact stated that while driving 30 MPH, the transmission jerked while shifting gear. The failure was a recurring failure. The dealer was contacted and the vehicle was diagnosed with CDF drum failure. The contact was informed that the transmission needed to be replaced. The manufacturer was contacted by phone and made aware of the failure. The failure mileage was approximately 40,500.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11766717September 24, 2026
POWER TRAIN, ENGINE
The vehicle is stalling/jerking and long idling. I was told that the transmission needs to be replaced. Less than 80,000 miles. 2018 Ford 150
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11766726September 24, 2026
ELECTRICAL SYSTEM, FUEL/PROPULSION SYSTEM, ENGINE
the issues associated with this recall still dont seem to be remedied. I believe a solution should have been provided from the manufacturer by now
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11766743September 24, 2026
POWER TRAIN
Driving highway I70 over Vail Pass, vehicle downshifted on it's own nearly causing someone to rear-end my vehicle. Took it to three local automotive business's for a diagnostic service; they all reported the same issue PP07F7-00 CDF drum and the 10th-gear not engaging. This should not be occurring when I've maintained service of my vehicle. I've paid for one diagnostic and shouldn't have to pay for one at my Ford dealer where it was purchased by I will have to again. I know of several owners with the exact same issue and no one is supporting them for this. I've owned four Ford trucks and this is unacceptable. Ford Case# CXH-09395547-R9D3S2
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Ford F-150