Volvo XC90 Complaints

1,540 consumer complaints on file.

#11603372July 19, 2024
FORWARD COLLISION AVOIDANCE: AUTOMATIC EMERGENCY BRAKING, BACK OVER PREVENTION: SENSING SYSTEM: CAMERA, EXTERIOR LIGHTING:TURN SIGNAL
Since purchasing this vehicle in October 2023 I have had multiple issues with the fuel door not opening, the turn indicator light not working, the backup cmera and sensors continue to engage the rear brake intervention system when there's nothing behind the vehicle.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11603169July 18, 2024
FORWARD COLLISION AVOIDANCE: ADAPTIVE CRUISE CONTROL, FORWARD COLLISION AVOIDANCE: WARNINGS, STRUCTURE:BODY
Same issue as complaint #11416043. Leak in sunroof has caused several electrical issues with the car. I had noticed occasional drips from the rear view mirror but had no idea that water was pooling under the spare tire in the trunk where several electrical components are located. When I originally brought it to the dealer (when I noticed the occasional drips) they said I needed to replace a major part of the sunroof which would have cost around $2,000. They did not mention that the water could/would reach the under carriage (not sure if that is the correct term) and could cause major electrical issues. I've since noticed that many others with this vehicle have had issues with the sunroof. I also had multiple times when my battery had to be replaced in the rear of the car when it should have been fine (was relatively new) which looking back could have been a result of the sunroof leak.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11602688July 16, 2024
VISIBILITY/WIPER, ELECTRICAL SYSTEM
This morning and a few days ago, ice cold water was dripping onto my control display pad and on me. The leakage came from the ourside down the plastic compartment behind my rearview mirror. This was distracting while I was driving since there was now water on me, and it was shorting out and affecting my control display. It would continue to be buggy while driving. I believe this issue is a result from a cracked seal between the windshield and the car body. I have seen other documented cases on volvo forums.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11601082July 11, 2024
UNKNOWN OR OTHER
Rear passenger door handle inoperable from both inside and outside the car. A quick google search shows this is a common, well known issue in all 2016 - 2024 and beyond Volvo XC90s. Concerning is this prevents egress from the vehicle in case of emergency. Confirmed issue exists while car is unlocked and child locks deactivated as can be seen in video. Rear driver door works as appropriately, rear passenger fails to open. No warning lights or codes. Issue first appeared 7/10/2024 and persists. Door cannot be opened. Videos available upon request.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11601276July 11, 2024
LATCHES/LOCKS/LINKAGES:DOORS:LATCH
The exterior door handle stopped being able to open from the outside. This poses a serious safety risk; as well as an overall inconvenience for the driver. To get inside the vehicle, one must crawl through the passenger side to open the driver's side door from the inside.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11600947July 10, 2024
SERVICE BRAKES, HYDRAULIC
The contact owns a 2019 Volvo XC90. The contact stated that while stopped and attempting to accelerate, the brake became inoperable. There were no warning lights illuminated. The vehicle was towed two times and taken to the local dealer, where it was diagnosed three times that the brake booster had failed. The vehicle was repaired, but the failure persisted. The manufacturer was not contacted. The failure mileage was unknown. The VIN was not available.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11600070July 8, 2024
ENGINE
The contact owns a 2016 Volvo XC90. The contact stated that after starting the vehicle, the vehicle failed to accelerate above 15 MPH while depressing the accelerator pedal. The contact stated that a turtle warning symbol appeared on the instrument panel along with an "Engine System Reduced Performance" message displayed. The contact called the dealer and had the vehicle towed to the dealer location. After two days of diagnostic testing, the contact was informed that the engine needed to be replaced due to engine failure. The manufacturer was not notified of the failure. The vehicle was not repaired. The failure mileage was approximately 175,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11600171July 8, 2024
POWER TRAIN, VEHICLE SPEED CONTROL, FUEL/PROPULSION SYSTEM
Third instance of reduced engine performance warning system taking over the car, which results in the "turtle mode" coming on and throttling vehicle speeds. The car does not respond to gas except at lower speeds. Then the Check Engine light also came on.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11599703July 7, 2024
ENGINE
Excessive Oil consumption. Volvo knowingly allows for the sale and resale of their 2013-2016 vehicles all makes and models even though they know there is an engine issue causing excessive oil consumption due to bad pistons and o rings in the engine. They’ve tried to hide this for years and since has covered a limited number of vehicles to be repaired based on stringent requirements eliminating most of the vehicles that actually should be covered. This oil consumption issue is dangerously causing vehicle to over consumption oil possibly causing the engine to seize or costly repairs up to but not limited to $13,000. This issue has cost me excessive oil changes and oil purchases in just a matter of months since its purchase date. A warranty was issued for this issue but Grubbs Volvo of Grapevine Texas has stated that due to the requirements my vehicle does not qualify to be covered because of the time limitations Volvo put on the repairs. This is a manufacturing issue with defective engine parts which should have been a recall not a warranty allowance. Volvo is deceiving consumers. Not only is this an issue for repairs, this could potentially cause accidents should and engine seize while operating on a roadway and who knows how many lives are at stake. The years 2013-2016 should be cover 100% by recall no matter what if vehicle falls in the all models 2013-2016 manufacturer dates. This has caused me excessive oil change purchases of $189.00 and 1 liter of oil weekly after just driving 1500 miles in 3 weeks. This is a huge problem and is well documented and should be recalled and corrected.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11597916July 1, 2024
ENGINE
Engine began to misfire. According to Volvo, there is a problem with the valve ring(s) not sealing, oil coming into the #4 piston chamber and excessive oil consumption. Vehicle has under 95K miles, and has been properly maintained, but Volvo is saying we are outside warranty period.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11593127June 7, 2024
ENGINE
We are a repair facility and the vehicle arrived for a concern with a weak battery and a battery warning light. The battery was testing bad and was replaced but the other issues persisted. The vehicle was scanned for codes and the codes present in the computer were B139F11, P26DC00 & P059700. After researching these codes we discovered a technical service bulletin related to the same issue and codes (Ref. No: TJ 30268.6.0). The bulletin states "If any of above DTC´s are set in the ECM or CEM for the pre-heated thermostat in the cooling system, and/or if the customer complains of a charging system warning message in the Driver’s Information Module (DIM), follow advice under SERVICE". The bulletin then describes the required service "Replace the thermostat according to instructions in VIDA and erase DTC. Not replacing the thermostat can cause consequential damages". After reading this we followed the service in the bulletin and replaced the thermostat but the issue persist. At this point we have replaced multiple components in compliance with the service bulletin but the battery warning light is still displayed as well as auto start stop disabled & the A/C blower not operating correctly. The bulletin also states that if the issue persist to "submit a vehicle report using function group 2627" but it does not state where the report can be submitted.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11592932June 6, 2024
ELECTRICAL SYSTEM
There have been three incidents where the following happens: While driving in regular suburban driving, the entire infotainment system and cluster panel (all digital--odometer, tachometer, everything) shut off entirely (go black) and the climate system also shuts off. It goes through some reset cycle and then eventually restarts after several seconds. Both times it has been right after pressing some button on the steering wheel that controls the infotainment or doing some operation with the infotainment system such as skipping a track or making a call. Apple Car Play has not been in use. The first time it was 4-5 months ago (2024). The second time was about 2 months ago. The third time was on June 6, 2024. This third time, while at a red light, everything went black and even the car shut off. Luckily, the car was not moving and within a couple of seconds, without touching anything or changing anything, it restarted itself and the infotainment system and cluster rebooted. I am concerned that this may eventually happen while the car is moving. Will be taken to the dealer for review/repair immediately.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11592531June 4, 2024
POWER TRAIN, ENGINE, FUEL/PROPULSION SYSTEM
The vehicle exhibits excessive oil consumption due to defective oil control rings, as highlighted by Quality Bulletin P10186. Additionally, the sunroof leaks, as noted in Technical Journal 31272 and TJ 35503.3.0, and there are further issues with the windshield wiper/turn signal system, the parking brake system, and the steering wheel module. Yes, the vehicle is available for inspection upon request. The excessive oil consumption and related engine issues can lead to engine damage and potential failure while driving, posing a serious safety risk. The sunroof leakage could impair visibility and cause electrical failures. The persistent dashboard warning messages and system malfunctions further distract and endanger the driver and others on the road. Yes, the problem has been reproduced and confirmed by various dealers and independent service centers, as indicated by numerous customer cases, court rulings, and a class-action lawsuit. Yes, the vehicle has been inspected by the manufacturer and documented in various technical journals and bulletins. There is no specific mention of inspection by police or insurance representatives. Yes, there were several warning lamps and messages, including the low oil light, Check Engine light, and messages related to the parking brake and windshield wiper/turn signal system. Symptoms such as slow acceleration, loss of power, higher tailpipe emissions, and a foul odor from the exhaust were also observed. These issues appeared shortly after acquiring the vehicle and persisted despite multiple repair attempts. The incident is primarily caused by engineering flaws and faulty materials, particularly the defective oil control rings leading to excessive oil consumption. Despite engine replacements, the problem persisted, indicating a fundamental design flaw. The sunroof leakage and other system malfunctions further suggest widespread safety and durability issues in the vehicle, rendering it unsafe to operate.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11592156June 3, 2024
ENGINE, FUEL/PROPULSION SYSTEM, POWER TRAIN
Check engine light comes on every few weeks. Dealer inspects, resets, and says software issues. Now engine performance lights and "turtle mode" has come on twice throttling my speed while driving. Again no known cause and just resetting. Currently in a loaner vehicle while they research.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11592028June 2, 2024
SERVICE BRAKES, SUSPENSION
Brake Vacuum Booster: P/Q BRAKE BOOSTER. P/Q BRAKE FLUID $3271.36 Other]: P/Q ENGINE VACUUM PUMP SEAL KIT Front Suspension vibration and while vibration
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11590899May 27, 2024
SERVICE BRAKES
Pressing P button does not engage the parking brake 100% of the time. Multiple times I have pressed the P button when concluding a drive and pulling into a spot with the normal friction brakes engaged, and nevertheless the car keeps rolling once the brake pedal is released, until the P button is pressed again in a much more deliberate fashion. This is a big safety issue. Pressing the P button with normal force should cause the parking brake to engage. At this point I now bypass the P button and switch the car off, which I know works 100% of the time to auto-engage the parking brake. Volvo needs to address the failure of the P button to perform its function.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11590688May 25, 2024
SEAT BELTS, FORWARD COLLISION AVOIDANCE: AUTOMATIC EMERGENCY BRAKING, BACK OVER PREVENTION: REARVIEW SYSTEM BRAKING
I've owned several vehicles in my life. The Volvo XC 90 advanced "safety features" have caused more near accidents in the first 10 months of owning this vehicle than anything I have ever experienced. The collission prevention and auto-braking features cannot be disabled on this car and they are defective and extremely dangerous. On sevreal occasions (four in the last two weeks alone) the auto-braking has engage when performing simple task and common suburban style shopping center parking lots. Backing into spots (which is proven to be safer -- my employer used to require it) the auto braking SLAMS onthe brakes and tightens the seatbelts. I am not exagerrating I've almost had a heart attack it's so jarring. Once I performed a u-turn (was perfectly legal) but due to something in the road had to back up to do a three point turn -- the auto braking engaged. I was stuck without the ability to move quickly and was almost hit. In short, many false positives from this sytem that cause MORE HARM than good. It has prevented zero accidents and has caused me to almost get into an accident or scared the living you know what out of me and my passengers all but too many times. In adidtion to these issues, the infortainment system (Android based) has hung on sevreal ocassions. In those instances I cannot control the air conditioning, defroster, etc. Lastly, the last, the lane departure feature is similarly flawed to the auto braking features. Correcting or warning when there is nothing. These features that are supposed to help are in fact making my driving experience more dangerous. It has happened so many times, I'm considering involing an attorney. I have warned friends and family of the dangers of Volvo's flawed technology platform and "advanced safety features." I also shared thsi feedback withthe dealer who offered a simple "wipe and restore" of the infortainment system. At the core, the system is broken and flawed.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11590302May 23, 2024
ENGINE AND ENGINE COOLING
The contact owns a 2016 Volvo XC90. The contact stated that after arriving at his workplace and parking the vehicle, he was alerted that the vehicle was smoking. The contact became aware that coolant was leaking from underneath the front of the vehicle and was puddling underneath the vehicle. The contact drove the vehicle to a local dealer, where it was diagnosed and determined that the coolant hose had failed and needed to be replaced. The vehicle was not repaired. The manufacturer was not informed of the failure. The contact researched online and related the failure to NHTSA Campaign Number: 19V308000 (Engine and Engine Cooling). The failure mileage was approximately 110,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11587090May 5, 2024
FUEL/PROPULSION SYSTEM, ENGINE
On Monday [XXX] I started my car and immediately a warning signal on the dashboard read ENGINE LOW Performance , and the dashboard went black and the engine cut off. The car was then towed to the Glen Cove Volvo. After a diagnostic I was informed the following needed to be replaced - FUEL FILLER PIPE 2) FUEL PRESSURE LOW FUEL indicator 3) the aforementioned replacements will require calibrated software update. . I bought this car brand new and I am the only owner and it has only been serviced by Volvo. This car ONLY has 59, 300 miles. I researched the problem online and noted it was a common problem with the. same make and year of my car and could not understand why there is not a recall for my car, by Volvo for this issue no matter the mileage. I came across correspondence on the internet from [XXX] referencing service action S29843 - fuel tank filler pipe insert was manufactured out of specification for ONLY T8 engines. I reached out to Volvo Car USA customer care and inquired about them covering the cost of the repairs and also informing them that this problem is not only affecting T8 engines. I just received a response for my concern stating THEY ARE SORRY THEY CAN NOT ASSIST ME WITH THIS MATTER. I cannot begin to express how sadden and disappointed in the corporation, to experience their lack of compassion and. concern about their product after I spent thousands of dollars of my hard earned money on this defective car. I have no faith in Volvo and no longer feel safe driving this car. I will tell all my relatives and friends of my experience to save them from Volvo's lack of concern about their CUSTOMERS' safety. This is clearly no wear and tear. There are multiple posts on the internet. There's a case of replacement at 10,000 miles, another case where it was replaced and failed again and the dealer is requesting the owner to pay. This this not right. There should be a recall for the entire system when it fails.-clearly defective INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11586538May 2, 2024
FUEL/PROPULSION SYSTEM, ENGINE
The contact owns a 2016 Volvo XC90. The contact stated that both oil and coolant would frequently be added to the engine as both the check engine and oil warning lights would appear on the instrument panel. The vehicle was taken to the dealer on multiple occasions where the crank shaft seal and fuel injectors were replaced; however, the failure persisted. One day while driving at 50 MPH, the vehicle began to hesitate upon depression of the accelerator pedal as the turtle warning light appeared on the instrument panel which indicated that there was reduced engine performance. The contact managed to drive the vehicle to Herb Chambers Volvo Cars of Norwood(1120 Providence Hwy #1, Norwood, MA 02062) where they were informed that contact that the fourth engine chamber had burned out which lead to engine failure. The manufacturer was notified of the failure. The vehicle had yet to be repaired. The failure mileage was approximately 93,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Volvo XC90