Ram 3500 Complaints

2,367 consumer complaints on file.

#11466048May 25, 2022
SERVICE BRAKES, ELECTRICAL SYSTEM, FORWARD COLLISION AVOIDANCE: ADAPTIVE CRUISE CONTROL
The ABS Anti lock lights came on and says check Electrical Brake System. Dealer said The ABS anti lock brake pump assembly was bad and it was on me to replace it. This is a big safety Issue to me. I got a 2018 3500 ram and paying big money for a truck and my safety, there should be a recall before some people get kill.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11464844May 16, 2022
ELECTRICAL SYSTEM
The contact owns a 2018 Ram 3500. The contact stated while driving approximately 35 MPH, the contact observed that the check engine warning light was illuminated and the coolant temperature warning light was also illuminated. The contact pulled over safely and turned off the vehicle. The contact drove the vehicle to a dealer where it was diagnosed and determined that the thermostat, coolant sensor, and air intake heater relay needed to be replaced. The vehicle had not been repaired. The contact researched online and related the failure to NHTSA Campaign Number: 21V798000 (Electrical System) however, neither the VIN nor the vehicle year was included. The manufacturer had been informed of the failure. The failure mileage was approximately 67,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11464183May 11, 2022
SERVICE BRAKES, ELECTRICAL SYSTEM, FORWARD COLLISION AVOIDANCE: AUTOMATIC EMERGENCY BRAKING
ABS and Traction control pump system electrical failure. Went to a Dodge Dealer and had the system read due to light coming on and off. Originally started around 38,000 miles on the truck. A code came up C0020-01. ABS pump motor control electrical failure. Researched on the net. Seems to be a big issue from 2013 on up on trucks. Chaffing wires? Pump failure? Dealer said the ABS Pump could Possibly be bad. Wondering if there is a safety Recall or will have one. I have my truck scheduled for repair next week. Estimated cost of $700.00 according to service department.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11464203May 11, 2022
FUEL SYSTEM, DIESEL
The contact owned a 2020 Ram 3500. The contact stated that the vehicle would surge whenever he depressed the accelerator pedal while driving. There were no warning lights illuminated. The contact then received notification of NHTSA Campaign Number: 21V880000 (Fuel System, Diesel). The contact notified several unknown dealers of the failure. The dealers informed the contact that though the failure was associated to the recall, they could not assist as the manufacturer had not authorized them to repair the vehicle. The contact then inquired assistance with obtaining the parts for repair and the dealer informed the contact that the manufacturer did not authorize them to sell the parts for repair. The manufacturer was notified of the failure and informed the contact that they would not assist as the vehicle was safe to drive. The vehicle was not diagnosed or repaired. The contact later sold the vehicle to an auction. The failure mileage was approximately 13,300.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11463903May 9, 2022
ENGINE
The contact owns a 2020 Ram 3500. The contact stated while driving 5 MPH, the oil pressure warning light illuminated. The contact then drove back to his residence. Upon opening the hood to check the oil pressure, the contact noticed that the oil consistency was like jelly. The vehicle was towed to the dealer where it was diagnosed that lack of engine oil, caused engine to cease and the engine needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure and a case was opened. The manufacturer then followed up with the dealer who provided an estimate for the repair. The manufacturer informed the contact that the engine replacement would not be covered under the warranty however, a vehicle buy back would be considered. The failure mileage was approximately 140,867.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11463709May 7, 2022
ENGINE, FUEL/PROPULSION SYSTEM, VISIBILITY/WIPER
0N 4/4/2022 while traveling on interstate 64 E in WV ,towing an R V camper , no warning signals on the dash screen, my truck started losing power and went completely dead,just missed by a tractor trailer rear ending me, as I rolled off to the side of the road. Iwas towed to the nearest Dodge dealership. When I arrived at the dealership a mechanic came and open the hood, he found diesel leaking and a metal rod of the camshaft sitting on top of the engine, which he stated shot through the engine block. Warranty company doesn't want to tear down engine after I gave approval to investigate issue. This is my work truck and source of income. Four weeks later, I am not getting help from dealership that sold me the truck and warranty. Warranty company is trying to use loop hole to get out of paying. I found similar complaints, reported to the NHTSA, engines falling apart while driving down the road. I had to pay for my truck to tow from WV to Charlotte NC to my driveway. I have a case# with the Dodge Customer Care Department and they are just informing me that the truck has recalls, but parts are not avaible at this time.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11463664May 6, 2022
UNKNOWN OR OTHER
Driving the Ram on the expressway, my son in law went from 70 miles per hour ( 30 lbs of boost) to 45 miles per hour (10 LBS of boost). So thankful it did not cause a rear end accident. Taking it in to the dealership to get fixed they said it was the turbocharger actuator then gave me the price.$11,314.32. I have a trucking company so I bought the part for $1409.71 and my diesel mechanic did the repairs for a fraction of the cost. Then I get a letter in the mail from FCA US LLC Customer Center Reimbursement, for this same problem BUT on my 2015 Ram 3C63R3EL4FG523122. My issue is this it's the same part, for the 2013 and 2015 Ram Pickup truck 3500. It should have been a recall not an extended warranty for all the vehicle years that this part is in their trucks . Someone is going to get hurt. The Customer Center declined the reimbursement and to even discuss the situation they hung up on me for the representative told me I was wasting his time and he had other calls to take.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11462539April 28, 2022
SERVICE BRAKES, ELECTRICAL SYSTEM, VEHICLE SPEED CONTROL
The warning chirp occurred and the ABS and ESC lights came on the first two times. The incident happened so quickly I could not clearly determine which warning lights illuminated. On April 18 with just over 39,000 miles on the vehicle the chirping alarm and the ABS and ESC light illuminated. In addition two warnings appeared in the dash: "Service Antilock Brake System" and "Service Electronic Braking System." The warnings happened multiple times per minute in some cases. Other times the vehicle would go for many miles without the warning. Every time the warning chirp was heard the cruise control would disengage. I did not notice any problems with the brakes of the truck. In researching the issue I learned that many people are having this problem. I contacted Ram and they directed me to a dealer who diagnosed the C0020-01 fault code and that the hydraulic control unit (HCU) for the ABS system was defective. According the the TSB Ram has put out about the issue the ABS module could also be bad, but the first part of the repair it to replace the HCU and if the problem persists to then replace the ABS module. Ram apparently has an inconsistent level of support for owners experiencing this malfunction with some getting the repair done out of warranty, while others have to pay for the repair. Because it is brake related it seems this should be an item replaced as a safety issue, no matter what the mileage on the vehicle.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11462552April 28, 2022
ELECTRICAL SYSTEM
Uconnect screen delamination causes phantom button pushing while driving down the road. This causes random buttons to be selected and for things to start happening while driving. Driving distracted is dangerous driving. It will randomly call people, including using the SOS functionality. Making non-emergency calls to the emergency line is unacceptable. Once while driving, it turned the radio on and my volume was cranked up. I almost crashed into the car next to me because it scared me half to death. This is a known issue from what I've been reading on RAM forums and almost always shows up outside of warranty. The manufacturer should be held accountable for this to prevent future wrecks, distracted driving, and unnecessary SOS phone calls.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11462653April 28, 2022
FUEL SYSTEM, DIESEL
The contact owns a 2019 Ram 3500. The contact received notification of NHTSA Campaign Number: 21V880000 (Fuel System, Diesel) however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11462482April 27, 2022
ELECTRICAL SYSTEM, ENGINE
Our vehicle was involved in a total loss fire from the engine compartment while driving. We were driving the unit and noticed smoke, when we were merging to pull of the road flames started coming up and we immediately exited the vehicle and had to run, because it started popping. We were lucky to escape unharmed physically, but the situation could have been much worse. There were no indications or lights warning of engine failure or fire. This occurred on September 2, 2021. At this point in time there were no recalls on the vehicle. When we contacted Stellantis to report the incident, they concluded their investigation they denied responsibility. A few months after the fact we received notice of the recall. To date we have not been reimbursed for the loss of the vehicle, our personal belongings in the vehicle, and the loss of income from no longer having the vehicle. Our insurance company, Stellantis, etc all inspected the unit related to the claim and confirmed the fire began in the engine compartment.
Crash:
No
Fire:
Yes
Injuries:
0
Deaths:
0
#11461108April 18, 2022
SERVICE BRAKES
Service ABS light intermittent flashing and error code when checked. ABS is a safety issue that SHOULD not be defective at 40K miles. The ABS does NOT always work in inclement conditions such as rain, snow. When towing a 15K lb fifth wheel ram should FIX these issues as seen on many online communities
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11461142April 18, 2022
WHEELS
The contact owns a 2018 Ram 3500. The contact received notification of NHTSA Campaign Number: 21V398000 (Wheels) however, the part to do the recall repair was unavailable. The dealer had been notified about the issue; however, the contact was informed that parts were not yet available. The manufacturer had been notified of the issue. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact had not experienced a failure. Parts distribution disconnect.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11460432April 11, 2022
SERVICE BRAKES, ELECTRICAL SYSTEM
Service electronic brake system with the traction control light lit. Seems to be a common occurrence
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11460350April 10, 2022
SERVICE BRAKES
Ram has issued a service bulletin to replace the ABS control module on 2018 Ram 2500 and 3500. This needs to be a recall as Ram is forcing customers to pay out of pocket or drive a vehicle without functioning ABS.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11460109April 8, 2022
UNKNOWN OR OTHER
Vehicle caught fire shortly after initiating OEM remote start. video is available
Crash:
No
Fire:
Yes
Injuries:
0
Deaths:
0
#11459840April 6, 2022
UNKNOWN OR OTHER, FUEL/PROPULSION SYSTEM, ENGINE
While towing 5th wheel vehicle check engine light came on I was out of state in arizona vehicl then started to stall I canceled my trip checking all fluids headed back to California as I was nowhere near a dealership made a appointment at ram dealer when I got there light went out I talked with technician he said would have to leave it for 3 weeks before they could look at vehicle needless to say I took it home then in early Feb about 3 weeks after the first incident the check engine light came on again made appointment which was 3 weeks away just to check it in shop and a week before they even looked at the issue they found a cracked hose on inter cooler dealer stated vehicle ok well again on March 4 2022 vehicle again has check engine light on I took to auto store to check code same as before vehicle regeneration frequency it Regenerates ever 100 miles runs poorly uses excessive fuel hesitates when pedal depressed and long cranking time so now I have to be without a vehicle again
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11459416April 3, 2022
UNKNOWN OR OTHER
Vehicle Exhaust System Failure See Dealer warning displayed with truck becoming sluggish and shutting down on road, very likely causing accidents. It’s scary. Got to a parking lot, shut off, cranked, warning went away, but for how long and what damage will Result in driving if warning comes back on?
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11458896March 29, 2022
TIRES, TIRES:SIDEWALL
LT 275 / 70 R 18 (tire size) The sidewall of the tire is splitting/failing. In parallel with the bead.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11458626March 28, 2022
TIRES:TREAD/BELT
Both front tires inner belts separated causing the vehicle to become underivable at 55 mph. The vehicle shook causing the steering wheel to radically move side to side. Took vehicle to dealer for service. Found both front tires to be defective at 29000 miles for inner belts separating from the tire.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Ram 3500