Chevrolet Suburban Complaints

9,782 consumer complaints on file.

#11675684July 23, 2025
ENGINE
Its been over a month and the dealership is unable to remedy this defect. I also called GM and they said the recall in incomplete and its in the preliminary stage. We are concerned that this is a serious safety recall and GM will not offer alternative solutions in a reasonable time.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11674355July 17, 2025
ENGINE, ELECTRICAL SYSTEM, FUEL/PROPULSION SYSTEM
Driving down to Florida, No warning, no lights, never any issues except a belt replacement. I get oil changes, tire rotation every 3500 miles. Almost got killed doing 75 miles per hour, engine sputtered, totally shut down. Coasted onto an exit ramp thank God it was right there or we could of been killed. Tow truck towed to Davis Chevy Gainsville, they called me on Monday said good news I have a warranty bad news Total Engine Failure, will take 3-4 weeks to replace. Now I am trying to find a GM rental large enough to get me and my family back to TN since GM said they will only pay for a GM rental car. Scary, could of gotten killed. NO NOTICE FROM GM ABOUT ANY POSSIBE PROBLEMS....WE ALMOST GOT KILLED AND CRASHED along with the other drivers on the road. Thank God it was a Sunday and 6 am so not much traffic or it would of been worst.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11674084July 16, 2025
SERVICE BRAKES
My wife was driving the vehicle and was pulling into a parking lot. The brakes failed and would not stop the vehicle. She pressed on the brakes very hard, multiple times, for several seconds, before the vehicle finally came to stop. She then proceeded into a parking spot where the brakes again failed to stop the vehicle promptly. Several lights illuminated and a “System Brake Failure 43 MPH Top Speed” message appeared, alternating with several other messages appearing. The vehicle is in for service at Classic Chevrolet in Granbury, Texas. They are telling me that they reset the codes and that the codes are not returning. I am extremely concerned that if I pick up the vehicle at this point, the brakes could fail again and cause an accident with serious injury.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11673614July 15, 2025
POWER TRAIN
The contact owns a 2019 Chevrolet Suburban. The contact stated that there was a winding sound coming from underneath the body of the vehicle in the center of the cabin. The tow light was intermittently illuminated without the vehicle being placed in tow mode. The contact stated that while accelerating and shifting gear, the vehicle hesitated and was sluggish while accelerating. The vehicle was taken to a certified mechanic who diagnosed that the transmission fluid was black, due to the transmission burning. The mechanic stated that flushing the fluid would cause more issues and advised the contact that the transmission needed to be replaced. The vehicle was not repaired. The vehicle was taken to the dealer; however, the contact was only quoted the cost for the repair because the vehicle was not covered under warranty. The manufacturer was informed of the failure and confirmed that there was no recall on the vehicle. The manufacturer also confirmed that the VIN was outside of the 60,000 miles warranty. The manufacturer opened a case for the failure. The manufacturer referred the contact to the NHTSA Hotline to report the failure. The failure mileage was approximately 77,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11673837July 15, 2025
UNKNOWN OR OTHER
There is an issue with the transmission when i accelerate at a slow pace. The car shakes and vibrates. Theres a possibility of an issue with the transfer case 4x4. When i turn the steering wheel and drive, it feels like it locks. It feels like 4x4 is on and theres a odd sound as well. I took my car to Hamilton Chevrolet and paid for inspection. They told me that there was no issue, but the issues i mentioned earlier in this message was mentioned to them. Those issues are still occurring. This is a recall issue but when i put my VIN number in, my car shows that there is no recall on it. There was many people who mentioned this problem.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11673702July 15, 2025
POWER TRAIN
Our 2022 suburban with the diesel motor has had 3 separate incidents where by all accounts the wheels have locked up while driving. The incidents mirror what has been described in the recall N242454440. The first time the incident occurred, we were driving while towing a light load (boat ~2500 lbs) at a steady speed of 60 mph. While driving the vehicle shook violently once, and then again about 2-3 seconds later. I immediately pulled over suspecting that maybe there was an issue with our trailer. After finding nothing we drove home without incident. Shortly after this incident we had the transmission flushed for regular maintenance at about 50,000 miles. Approximately 5-6 months later the second incident occurred. While driving with no trailer, up a mountain in NC at a steady speed of 35 mph, the vehicle shook violently and then again approximately 2-3s later. Each time the vehicle shook a loud "BUMP" noise would be heard. The road was smooth and was later driven on without issue so it was not the terrain. I once again got out and inspected the vehicle and was unable to find an issue. We drove to where we were staying and immediately took the vehicle to a dealer the following day to be inspected. The dealer found no issues and we did not report any similar problems. The last incident occurred after another 8 months while towing a light utility trailer at a steady speed of 60mph. Same thing happened with a shake and loud BUMP. However this time it was not followed immediately by an other instance. Those came approximately a minute later and then again after about 10 more minutes. I cannot recreate the issue and it seems to be at complete random and is happening while driving steady rates of speed where the transmission shouldn't be trying to shift. It seems like a safety hazard that could cause an accident.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11673386July 14, 2025
FORWARD COLLISION AVOIDANCE: AUTOMATIC EMERGENCY BRAKING, TRACTION CONTROL SYSTEM
The contact owns a 2022 Chevrolet Suburban. The contact stated while driving at various speeds or while accelerating from a complete stop, the automatic emergency braking system engaged while there was no other vehicle nearby, and the vehicle skidded. The contact stated that the traction control warning light was illuminated. The contact stated that while her husband was driving at an undisclosed speed in the rain the failure reoccurred, causing the vehicle to skid. The vehicle was taken to the dealer, where it was test-driven, but the failure could not be duplicated. The vehicle was not diagnosed or repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 89,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11673122July 13, 2025
ENGINE
Our Chevrolet suburban has 57,000 miles on it. We have started getting a check engine light and I’m getting code P1098 for the cooling control valve. This is a very common issue on these vehicles I’m noticing now. From what I’m reading in February of this year (2025) gm gave this issue an e code so these valves would no longer be covered pay the powertrain and they would now fall under emissions for a much shorter warranty coverage. This has been and ongoing issue since 2020. These valves are also commonly found to be on national back order causing long lead times and driving of the vehicles without properly functioning. GM knows these are and issue and shortening the warranty is not the fix. These vehicles weren’t bought with a short warranty and shouldn’t be able to be reduced to a short warranty.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11673098July 12, 2025
ELECTRICAL SYSTEM
Issue: The vehicle intermittently displays a “Key Not Found” or “No Key Detected” message on the dash and refuses to start, despite both original factory-issued key fobs being present and having fresh batteries. The issue began in summer 2023 and has progressively worsened. The vehicle has stranded our family multiple times, sometimes requiring a tow, family impact, missed obligations. Luckily for all urgent needs like trips to the ER or Urgent care, we were able to use our other vehicle, but we no longer have that vehicle and it is important that our sole vehicle be a reliable one. Impact: •Two emergency room visits and multiple urgent pediatric appointments affected •Forced to rely on one family vehicle for months •Paid for tow and fob batteries •Multiple instances of no rental coverage •GM and dealers often declined documentation or action due to the issue being “intermittent” ⸻ Request: We believe there is a systemic defect in the Suburban’s keyless entry/ignition system (likely receiver or antenna module). We request that NHTSA investigate and that GM be required to issue a recall or permanent repair for affected models. This issue poses a safety concern and has created financial and logistical hardship for our family.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11672405July 10, 2025
ENGINE AND ENGINE COOLING
See attached document for complaint.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11672067July 8, 2025
ENGINE AND ENGINE COOLING
The contact owns a 2020 Chevrolet Suburban. The contact received notification of NHTSA Campaign Number: 25V274000 (Engine and Engine Cooling). The contact stated that on several occasions while checking the oil level, there was no oil on the "dip stick". The contact stated that the engine consumed 2-3 quarts of oil approximately 4,000 miles. Additionally, the contact stated that while driving on several occasions at various speeds, the low oil warning light illuminated. The vehicle was taken to a dealer where it was diagnosed that the piston and piston ring were damaged due to excessive wear and sticking. The vehicle was repaired but the failure persisted. The vehicle was taken to the same dealer where it diagnosed that the cylinder head had failed and needed to be replaced. The vehicle was repaired but the failure persisted. The vehicle was taken back to the same dealer where the failure was not replicated. The manufacturer was not notified of the failure. The failure mileage was approximately 3,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11672006July 8, 2025
POWER TRAIN, ENGINE
When attempting to drive from a stop light or stop sign, after taking your foot of the brake, the vehicle intermittently completely turns off. It will not immediately restart and you find yourself stuck in the middle of an intersection creating a safety issue. The vehicle has been in to Chevrolet to have this issue fixed once already and it continues to repeat. I doubt the dealer has been able to replicate the issue as they haven't gotten the vehicle back into the shop after it's been sitting there for a week. There were no warning lights, messages, or other symptoms. It has happened to both myself and my wife, most recently on or about 7/1/25 where it happened to my wife multiple times causing us to leave the vehicle at the dealership for service. Just to be clear, the issue with the vehicle turning off is different from the standard auto stop/start feature.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11671818July 7, 2025
POWER TRAIN
Engine is skipping when in reverse.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11671798July 7, 2025
ENGINE
Vehicle lost power, debris in cylinder from internal damage, crank case leaking air, oil leaking into cylinder, P0300, P0308, and P050D
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11671219July 4, 2025
ENGINE
Lifter stuck in cylinder 3. Cost to repair $13,000 on a 2019 Chevrolet Suburban with 101,000 miles. We have owned vehicle since new. Vehicle routinely maintained.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11670905July 2, 2025
ELECTRICAL SYSTEM:INSTRUMENT PANEL:SPEEDOMETER/ODOMETER, ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL:CATALYTIC CONVERTOR
Odometer Fraud. The contact purchased a 2015 Chevrolet Suburban. The contact stated that while attempting to have the vehicle inspected, it was discovered that the catalytic converter was missing, the wires were cut, and a pipe was inserted to muffle the noise. The contact was told that the check engine warning light was turned off and the carbon monoxide was not being cleaned, and that fumes were entering the cabin of the vehicle. The contact also discovered that there was a mileage discrepancy on the vehicle. The vehicle was a dealer sale. At the time of purchase, the mileage was 131,000 and at the time of the inspection, it was discovered that the mileage was approximately 231,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11670826July 2, 2025
ENGINE
Dealer attempting to sell 2023 Chevrolet Suburban with 6.2L engine and no corrective action under N252494000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11670111June 29, 2025
ENGINE, SEATS, ELECTRICAL SYSTEM
Had to replace motor. Had to replace the vibrater in the seat. Had to replace transmission. Electric shorted
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11670120June 29, 2025
POWER TRAIN
Valve Body issues under powertrain factory warranty. Recall needed due to unreasonable national parts delay.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11669692June 27, 2025
ENGINE, POWER TRAIN, STEERING
The contact owns a 2017 Chevrolet Suburban. The contact stated that while driving 65 MPH, the vehicle started shuddering violently, prompting the contact to discontinue driving over 60 MPH. Additionally, the contact stated that there was an abnormal clicking sound while making right or left turns. The check engine warning light was illuminated. The vehicle was taken to an independent mechanic to be diagnosed, but the cause of the failure could not be determined. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was 122,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Chevrolet Suburban