Ford F-150 Complaints

39,812 consumer complaints on file.

#11646595March 5, 2025
POWER TRAIN
The contact's husband owns a 2012 Ford F-150. The contact's husband stated that while driving at various speeds, the transmission unexpectedly downshifted into first gear. The contact's husband stated that the engine warning light and maintenance reminder light were illuminated. The contact's husband drove the vehicle onto the shoulder of the residence. The contact stated that an employee from the dealer stopped by the residence and updated the Power Control Module (PCM). The vehicle was able to restart; however, the failure recurred. The vehicle was towed to the dealer. The vehicle was not diagnosed or repaired. The manufacturer was notified of the failure. The contact was provided with the Manufacturer Recall Number: 25S37; but the vehicle was not included. The failure mileage was unknown.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11646419March 5, 2025
ENGINE AND ENGINE COOLING
The contact owns a 2019 Ford F-150. The contact stated that while driving at approximately 35 MPH, there was an abnormal knocking sound coming from the engine compartment. The contact stated that the check engine and low oil pressure warning lights were illuminated. The contact stated that the vehicle lost motive power and stalled. The contact was unable to restart the vehicle and the vehicle was towed to a dealer. The dealer diagnosed the vehicle and determined that the engine had failed and needed to be replaced. The contact stated that recently the cam phasers on the vehicle were replaced. The contact stated that the cam phasers had been replaced twice. The vehicle was being repaired. The manufacturer was informed of the failure and referred the contact to file a complaint with the NHTSA Hotline. The failure mileage was approximately 85,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11646420March 5, 2025
ENGINE
The contact owns a 2017 Ford F-150. The contact’s husband attempted to start the vehicle; however, the vehicle failed to start. The contact tested the battery, but no issue was found. The vehicle was towed to the dealer who diagnosed the vehicle and determined that the starter had failed. The starter was replaced; however, the vehicle failed to start. The dealer then diagnosed the vehicle and determined that the engine had seized and needed to be replaced. The dealer informed the contact that it could be 1 - 2 months before the engine would be received to perform the engine replacement. The vehicle was not repaired. The manufacturer was informed of the failure and opened a case. The manufacturer referred the contact to the NHTSA Hotline to report the failure. The failure mileage was 118,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11646429March 5, 2025
POWER TRAIN
The contact owns a 2013 Ford F-150. The contact stated while driving at various speeds, the vehicle unexpectedly downshifted to first gear with the wrench warning symbol displayed. The contact was forced to reset the vehicle by turning off the vehicle, disconnecting and then reconnecting the battery, for the vehicle to resume normal operation. Upon investigation, the contact discovered NHTSA Campaign Number: 19V075000 (Power Train); which was linked to the failure. The contact used a code reader that showed a defect with the speed sensor inside the transmission control unit. The manufacturer was notified of the failure but offered no assistance. The contact was referred to the NHTSA Hotline to report the failure. The vehicle was not repaired. The failure mileage was approximately 103,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11646454March 5, 2025
POWER TRAIN
When on interstate or main road it shifts from 6th gear to first gear called Ford they said there is no recalls for my vehicle it shifts down so hard that my back tires slide without warning it is a danger
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11646515March 5, 2025
POWER TRAIN
Repeated failure of transmission after multiple repairs.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11646523March 5, 2025
UNKNOWN OR OTHER
The backup camera on my F150 starting glitching and would not display a clear picture of what was behind the vehicle. Below is what was on the invoice: C/S VEHICLE'S BACKUP CAMERA INOP. THE SCREEN IS BLANK WHEN IN REVERSE.CHECK AND ADVISE 24E12 POWERTRAIN CONTROL MODULE PCM REPROGRAMMING 2 new wiring harnesses and the control reprogramming came to about $1200. In my opinion, failure of a backup camera is a safety critical item. Failure such as this is no different than a sensor going bad- actually worse as visibility is non-existent.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11646428March 5, 2025
ENGINE
My truck has a 2.7 eco boost engine than has failed around 134,000 miles. The truck had a couple of misfires over the last couple of months, but otherwise no issues. I drove the truck one Saturday, did not drive Sunday, and on Monday I am told the engine is completely seized and I am responsible for replacing the engine. Ford will not attempt to determine if the recall for the valve intake stem has caused the issue and now I am spending over $12,000 to replace a 4 year old engine with no other issues.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11646158March 4, 2025
ENGINE AND ENGINE COOLING
The contact owns a 2017 Ford F-150. The contact stated while starting the vehicle, there was an abnormal knocking sound coming from the vehicle. There were no warning lights illuminated. The vehicle was taken to the local dealer, where it was diagnosed that the cam phasers needed to be replaced. The vehicle was repaired, but the failure recurred. The manufacturer was contacted, but no assistance was provided. The failure mileage was approximately 63,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11646215March 4, 2025
WHEELS:LUGS/NUTS/BOLTS/STUDS
The contact owns a 2018 Ford F-150. The contact stated that upon attempting to change a tire, the contact became aware that the provided tools were unable to be used to complete the wheel replacement. The vehicle was taken to the dealer, who determined that the lug nuts were swollen. The contact was informed that the lug nuts needed to be forcefully removed. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was 85,000. The VIN was not available.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11646251March 4, 2025
POWER TRAIN
I have a 2019 f150, 5.0 w/ 10r80 trans. The vehicle will slip from 7 gear to 1st. 10th to 2nd, and some times just finds itself in neutral with no propelling motion. This happens. While driving, when taking off from a stop. Causing hard jerking and extreme discomfort to me and my passengers. Ford says no recall and to replace the trans. Seeing 100s and f complaints (I’m sure it would be more of people understood hot to report) and NHTSA says they don’t see an issue or need for a recall is unacceptable. Does it take a major accident or someone to get hurt from FORDs outright disregard to fix the issue. Built ford tough is long gone and forgotten. NHTSA is now letting down the consumer, and the people on the road for the disregard for safety and holding these car manufacturers accountable. Do better, recall the 10r80 and make ford pay. Or is ford paying the NHTSA to disregard this multi million dollar fix.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11646258March 4, 2025
POWER TRAIN
am concerned the 6r80 transmission has had problems with the lead frame.it has been acting up where causes not to go in traffic. Seen that my truck has numerous tsb & recalls for this trans.made at the Dearborn plant for f150 oct.11 2011 through feb 27 2012.see the multiple technical service bulletins for 6r80 16n02,19s07, nhsta 16v248000 & safety recall 16s19 powertrain control module programming. I believe this should also be also extended to cover my transmission.it is a safety issue also.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11646284March 4, 2025
SERVICE BRAKES, HYDRAULIC
The contact owns a 2017 Ford F-150. The contact stated while driving 45 MPH, the vehicle hesitated and stalled. The vehicle was restarted; however, the failure recurred a short distance afterward. The message to "Shift to Park and Restart Vehicle" was displayed with the check engine warning light flashing intermittently. The vehicle was then taken to the dealer, where it was diagnosed and determined that the plastic oil pan was warped and needed to be replaced. The vehicle was not repaired due to the cost. The manufacturer was informed of the failure and referred the contact to the NHTSA Hotline to report the failure. The contact researched online and related the failure to the NHTSA Campaign Number: 22V150000 (Service Brakes, Hydraulic); however, the VIN was not included. The failure mileage was approximately 125,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11646321March 4, 2025
POWER TRAIN
The transmission is experiencing delayed engagement, harsh shifting, and slipping out of gear. It is at the dealership and available for inspection at this time. The dealer has inspected the transmission and reported that it failed and needs to be replaced. Ford company has been notified and will be conducting their own inspection soon. There were no warning lamps, but this has happened before. This will be the third transmission for this truck. The original transmission was replaced in April 2022 for the same issues. Now three years later, it needs to be replaced again for the same issues. There are several lawsuits against Ford for this particular transmission and multiple TSB’s.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11646322March 4, 2025
POWER TRAIN
Transmission light came on and downshifted to first gear
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11646335March 4, 2025
ENGINE
The cam phaser broke down and would have destroyed the engine if left unattended. This could have led to the car breaking down in the middle of the road. Problem has been reproduce by Ford, this has happened with countless other trucks as well. The item has been fixed by Ford but costed $4000. there were no alarms, letting me know that this was happening, but there was a distinct sound when starting up my truck and accelerating my car. It made a rattling noise in the engine bay.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11646370March 4, 2025
ELECTRICAL SYSTEM, UNKNOWN OR OTHER, POWER TRAIN
A year ago we took our Truck in because it was knocking, we were told it was dry starting and they had to repair it, it was 5200. A couple weeks ago we’re driving and it started shifting funny and jerking, had no get up and go, we limped to the nearest dealership. Told our transmission went out and it will cost 11k.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11646393March 4, 2025
POWER TRAIN
I purchased my truck in March of 2024 with an undisclosed problem from a dealership in Texas. I contacted them two weeks after it began and they said they couldn't do anything as is the greatest business disappointment of American commerce when used vehicles are purchased under the "As Is" clause. The undisclosed problem is this, my truck loses acceleration power for up to 20 seconds in dangerous situations when I attempt to increase speed from a stop or slower speeds and the truck doesn't shift to accelerate to reasonable speeds. This situation happens each time I drive this truck. The scarier situations happen when changing lanes, turning left, or right, or making U-turns. Each of these conditions threatens safety every time this happens, but more so when there is fast-moving traffic coming behind after changing lanes or if on-coming traffic approaches my now power-less truck when making a left/u-turn. My local dealership shop found the CBF drum in the transmission to be faulty causing internal leaks which fail to engage the gearing system. The repair cost to make my truck safe again is over $7.2k. If this truly is a safety failure problem, I request NHTSA for payment to my dealer or reimbursement, please.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11645977March 3, 2025
ENGINE
The contact owns a 2018 Ford F-150. The contact stated over time upon starting his vehicle an abnormal rattling noise could be heard coming from the engine, and no warning lights were illuminated. The vehicle was taken to a local dealer where the vehicle was diagnosed and the contact was advised that the camshaft phasers were faulty and that they would have to be replaced. The vehicle was not repaired. The manufacturer was not notified of the failure. The approximate failure mileage was 113,445. The contact referenced Customer Satisfaction Programs 21B10, 21N03, and 21N08 as probable cause for the failure.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11645982March 3, 2025
POWER TRAIN, ENGINE
The contact's wife owns a 2016 Ford F-150. The contact stated that while driving at various speeds, the vehicle jerk and hesitate upon depression of the accelerator pedal. In addition, the contact stated that the transmission unexpectedly downshifted with the check engine warning light illuminated. The vehicle was taken to several independent mechanics and the spark plugs, sensor coils, and other various engine parts were replaced; however, the failure persisted. The manufacturer was notified of the failure but offered no assistance. The failure mileage was approximately 80,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Ford F-150