Ram 5500 Service Bulletins (2025)
267 manufacturer communications on file.
- April 19, 2025•Document ID: 11017133Service Bulletin/Repair InstructionsELECTRICAL SYSTEM
- Mfr Comm. #:
- S2508000017 REV.A
- Date Added:
- April 23, 2025
- Manufacturer:
- RAM
SummaryRadio Frequency Hub (RFH) Module has an Active Diagnostic Trouble Code (DTC) B22A9-00 ECU Internal Performance.
Associated Products (4)Associated Documents - April 17, 2025•Document ID: 11017081Service Bulletin/Repair InstructionsSEATS
- Mfr Comm. #:
- 9100548
- Date Added:
- April 17, 2025
- Manufacturer:
- RAM
Summary"ADJUSTER Seat DJ D2 DP 1st Row Power Seat Fore/Aft Adjuster Inspection TSB is also released for this concern. SYMPTOM/CONDITION: Fore-aft function does NOT work when actuating the seat switch. DIAGNOSIS: 1) Put seat in position for inspection. 2) Disconnect seat wire harness motor connector from the fore-aft motor on the seat adjuster, wait 10 seconds, and reconnect. 3) Verify function of the fore/aft adjuster. Step 1. Open 2nd row door and function rear seat cushions up to stowed position. Step 2. Adjust the driver front seat to the full up position. Use switches on the side shield to move power seat fully up. Step 3. Remove the 4 bolts that hold the seat to the truck floor and discard. The bolts have lock patch that is not reusable. Step 4. Lay the seat down so its laying on its back so the underside of the seat is easily accessible. Step 5. Remove the fore/aft wire harness motor connector from the fore/aft motor (back right of the seat adjuster). Push on the tab to remove the motor wire harness connector from the motor. Leave disconnected for 10 seconds. Step 6. Reconnect the fore/aft wire harness motor connector to the fore/aft motor. Push / Pull / Push the connector with fingers to ensure the wire harness connector is fully seated to the fore/aft motor connector. Step 7. Before assembling the seat back to the truck floor, cycle the seat to check that the motor is working properly by pressing the fore/aft switch. If fore/aft motor does not function, please refer to Replacement Procedure below. Step 8. If the seat is working properly, carefully reassemble the seat back to the truck floor using the four new bolts. Use a torque wrench to verify 47 Nm. Step 9. *Note: Checking the passenger seat will be the same procedure as the driver seat. REPLACEMENT PROCEDURE Only for seats rejected after inspection. Replace Power Seat Adjuster per MOPAR service part replacement instructions. MOPAR Part Numbers: 68455847AA, 68455848AA, 68455849AA"
Associated Products (14)Associated Documents - April 16, 2025•Document ID: 11017146Service Bulletin/Repair InstructionsELECTRICAL SYSTEM
- Mfr Comm. #:
- 08-119-25
- Date Added:
- April 23, 2025
- Manufacturer:
- RAM
Summary"Flash: Security Gateway Module(SGW Update) Customers may experience the following: ● Map data not working properly. This bulletin involves updating the SGW with the latest available software."
Associated Products (2)Associated Documents - April 16, 2025•Document ID: 11017120Service Bulletin/Repair InstructionsUNKNOWN OR OTHER; ENGINE
- Mfr Comm. #:
- S2518000002
- Date Added:
- April 22, 2025
- Manufacturer:
- RAM
SummaryWait To Start/Delayed Engine Crank Feature Inoperative When Cold.
Associated Products (4)Associated Documents - April 11, 2025•Document ID: 11016953Service Bulletin/Repair InstructionsSTRUCTURE:BODY
- Mfr Comm. #:
- S2523000027
- Date Added:
- April 11, 2025
- Manufacturer:
- RAM
SummaryDriver And Or Passenger Window Inoperative.
Associated Products (4)Associated Documents - April 11, 2025•Document ID: 11016951Warranty Program/ExtensionUNKNOWN OR OTHER
- Mfr Comm. #:
- 104558
- Date Added:
- April 11, 2025
- Manufacturer:
- JEEP
SummaryFCA Caribbean Warranty Newsletter – Volume 11, Issue 4
Associated Products (60)2025 Alfa Romeo Tonale2025 Dodge Hornet2025 Jeep Compass2025 Jeep Gladiator2025 Jeep Grand Cherokee2025 Jeep Grand Cherokee L2025 Jeep Grand Wagoneer2025 Jeep Wagoneer2025 Jeep Wrangler2025 Ram 25002025 Ram 35002025 Ram 55002024 Alfa Romeo Tonale2024 Dodge Hornet2024 Fiat 500e2024 Jeep Compass2024 Jeep Gladiator2024 Jeep Grand Cherokee2024 Jeep Grand Cherokee L2024 Jeep Grand Wagoneer+ 40 moreAssociated Documents - April 9, 2025•Document ID: 11016939Warranty Program/ExtensionUNKNOWN OR OTHER
- Mfr Comm. #:
- 104557
- Date Added:
- April 10, 2025
- Manufacturer:
- JEEP
SummaryWarranty Newsletter – Volume 11, Issue 4
Associated Products (60)2025 Alfa Romeo Tonale2025 Dodge Hornet2025 Jeep Compass2025 Jeep Gladiator2025 Jeep Grand Cherokee2025 Jeep Grand Cherokee L2025 Jeep Grand Wagoneer2025 Jeep Wagoneer2025 Jeep Wrangler2025 Ram 25002025 Ram 35002025 Ram 55002024 Alfa Romeo Tonale2024 Dodge Hornet2024 Fiat 500e2024 Jeep Compass2024 Jeep Gladiator2024 Jeep Grand Cherokee2024 Jeep Grand Cherokee L2024 Jeep Grand Wagoneer+ 40 moreAssociated Documents - April 4, 2025•Document ID: 11016708Service Bulletin/Repair InstructionsELECTRICAL SYSTEM
- Mfr Comm. #:
- S2523000023
- Date Added:
- April 7, 2025
- Manufacturer:
- RAM
SummaryTrailer Tow Lights Inoperative. Diagnostic Trouble Codes (DTCs) B166E-13 B17AD-13 May Be Set.
Associated Products (25)2025 Jeep Grand Cherokee2025 Jeep Grand Cherokee L2025 Jeep Grand Wagoneer2025 Jeep Wagoneer2025 Jeep Wagoneer S2025 Ram 15002025 Ram 25002025 Ram 35002025 Ram 45002025 Ram 55002024 Jeep Grand Cherokee2024 Jeep Grand Cherokee L2024 Jeep Grand Wagoneer2024 Jeep Wagoneer2024 Jeep Wagoneer S2023 Jeep Grand Cherokee2023 Jeep Grand Cherokee L2023 Jeep Grand Wagoneer2023 Jeep Wagoneer2022 Jeep Grand Cherokee+ 5 moreAssociated Documents - April 4, 2025•Document ID: 11016619Service Bulletin/Repair InstructionsELECTRICAL SYSTEM
- Mfr Comm. #:
- S2508000025
- Date Added:
- April 4, 2025
- Manufacturer:
- RAM
SummaryInstrument Panel Cluster (IPC) and Radio Compass Display has Dashes (--)
Associated Products (4)Associated Documents - April 4, 2025•Document ID: 11016617Service Bulletin/Repair InstructionsELECTRICAL SYSTEM; STRUCTURE:BODY
- Mfr Comm. #:
- S2523000024
- Date Added:
- April 4, 2025
- Manufacturer:
- RAM
SummaryRear Defogger Solder Terminals Detached.
Associated Products (54)2025 Jeep Gladiator2025 Jeep Wrangler2025 Ram 15002025 Ram 25002025 Ram 35002025 Ram 45002025 Ram 55002024 Jeep Gladiator2024 Jeep Wrangler2024 Ram 15002024 Ram 25002024 Ram 35002024 Ram 45002024 Ram 55002023 Jeep Gladiator2023 Jeep Wrangler2023 Ram 15002023 Ram 25002023 Ram 35002023 Ram 4500+ 34 moreAssociated Documents - April 3, 2025•Document ID: 11017409Service Bulletin/Repair InstructionsELECTRICAL SYSTEM
- Mfr Comm. #:
- 104407
- Date Added:
- May 1, 2025
- Manufacturer:
- RAM
SummaryRECEIVER - WIRELESS CONTROL MODULE
Associated Products (4)Associated Documents - March 26, 2025•Document ID: 11015963Service Bulletin/Repair InstructionsELECTRICAL SYSTEM
- Mfr Comm. #:
- 9100525
- Date Added:
- March 26, 2025
- Manufacturer:
- RAM
Summary"Base led headlamp RT 25 MY HDCC Ignition DTC (U300A-29 Ignition Switch - Signal Invalid) in stored state for SLML and SLMR. All headlamps on the Heavy Duty with SW 24.43.00(Premium) or 24.44.00(Base) will show a U300A-29 -> Ignition Switch-Signal Invalid as a stored DTC. If you experience this condition, please clear the DTCs on SLML and SLMR once and restart the truck and check if the DTC is in active state 10 seconds after the engine is turned ON, check the hardware ignition line and repair as required. If the DTC reappears as stored DTC (See Figure 1), no repair is required. The headlamps are good. The DTCs will appear every time the Ignition is cycled, and should be ignored."
Associated Products (4)Associated Documents - March 21, 2025•Document ID: 11015866Service Bulletin/Repair InstructionsELECTRICAL SYSTEM
- Mfr Comm. #:
- 9100530
- Date Added:
- March 24, 2025
- Manufacturer:
- RAM
Summary"Receiver Hub Please refer SOL ""S2508000017"" published in February 2025. DO NOT REPLACE RFHM module PN 68671484AD due to active RFH ECU internal performance DTC B22A9-00. Please refer SOL information below. Symptom/Vehicle Issue: Radio Frequency Hub (RFH) Module has an Active Diagnostic Trouble Code (DTC) B22A9- 00 ECU Internal Performance Technician Observation: RFH Module is setting an active DTC B22A9-00 Electronic Control Unit (ECU) Internal Performance with no customer complaints. Please do not replace RFH module if all the following conditions are TRUE 1-3. 1. Vehicle has RFH PN # 68671484AD 2. Active RFH DTC B22A9-00 ECU internal performance. 3. No functional issues observed or reported, DTC cannot be cleared. DO NOT REPLACE THE RFH IF THER ARE NO FUNCTIONAL ISSUES. Note:" Below are the functional tests that can be validated for complaints as needed. i. Remote Keyless entry (RKE) ii. Passive Entry (If equipped, sales code
Associated Products (4)Associated Documents - March 12, 2025•Document ID: 11015602Service Bulletin/Repair InstructionsELECTRICAL SYSTEM
- Mfr Comm. #:
- S2423000027 REV.C
- Date Added:
- March 13, 2025
- Manufacturer:
- RAM
SummaryHorn Sound Is Weak, Off Tone, Inoperative, Or Intermittent.
Associated Products (24)2025 Jeep Gladiator2025 Jeep Grand Wagoneer2025 Jeep Wagoneer2025 Jeep Wrangler2025 Ram 25002025 Ram 35002025 Ram 45002025 Ram 55002024 Jeep Gladiator2024 Jeep Grand Wagoneer2024 Jeep Wagoneer2024 Jeep Wrangler2024 Ram 25002024 Ram 35002024 Ram 45002024 Ram 55002023 Jeep Gladiator2023 Jeep Grand Wagoneer2023 Jeep Wagoneer2023 Jeep Wrangler+ 4 moreAssociated Documents - March 11, 2025•Document ID: 11015601Service Bulletin/Repair InstructionsENGINE
- Mfr Comm. #:
- S2409000002 REV.A
- Date Added:
- March 13, 2025
- Manufacturer:
- RAM
SummaryPerceived Oil Leak From The Rear Of The Engine
Associated Products (12)Associated Documents - February 26, 2025•Document ID: 11015032Service Bulletin/Repair InstructionsELECTRICAL SYSTEM
- Mfr Comm. #:
- S2508000017
- Date Added:
- March 5, 2025
- Manufacturer:
- RAM
SummaryRadio Frequency Hub (RFH) Module has an Active Diagnostic Trouble Code (DTC) B22A9-00 ECU Internal Performance
Associated Products (4)Associated Documents - February 24, 2025•Document ID: 11014911Service Bulletin/Repair InstructionsSTRUCTURE:BODY
- Mfr Comm. #:
- 103286
- Date Added:
- March 4, 2025
- Manufacturer:
- RAM
SummaryCUPHOLDER - CONSOLE
Associated Products (4)Associated Documents - February 17, 2025•Document ID: 11014887Service Bulletin/Repair InstructionsLANE DEPARTURE: BLIND SPOT DETECTION; BACK OVER PREVENTION: WARNINGS
- Mfr Comm. #:
- 103289
- Date Added:
- March 4, 2025
- Manufacturer:
- RAM
SummaryCAMERA - REAR VIEW
Associated Products (53)Associated Documents - February 17, 2025•Document ID: 11014869Service Bulletin/Repair InstructionsLANE DEPARTURE: BLIND SPOT DETECTION
- Mfr Comm. #:
- 103288
- Date Added:
- March 4, 2025
- Manufacturer:
- RAM
SummaryCAMERA - REAR VIEW
Associated Products (54)Associated Documents - February 5, 2025•Document ID: 11013882Warranty Program/ExtensionENGINE; UNKNOWN OR OTHER; ELECTRICAL SYSTEM
- Mfr Comm. #:
- 103318
- Date Added:
- February 6, 2025
- Manufacturer:
- RAM
SummaryWarranty Bulletin D-25-04 FFB Program - 6.7L Cummins Engine (Sales Codes ETM and ETN), Base Engine Comp, Electronic Comp, Cooling System Comp, Exhaust Gas Recirculation System, Fuel System and Aftertreatment System - Select 2025 2500/3500/4500/5500 Ram Pickup (DD/DJ/D2/DP)
Associated Products (4)Associated Documents