Hyundai Ioniq 5 Complaints

1,350 consumer complaints on file.

#11751511July 20, 2026
ELECTRICAL SYSTEM
EV system not working on car with 8k miles on it. Dealer backed up and cannot offer rental car. This is a safety issue for me . This is a KNOWN issue for Hyundai and they are not recalling and their dealers are not equipped to resolve quickly.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11751250July 18, 2026
ELECTRICAL SYSTEM, FUEL/PROPULSION SYSTEM
Systemic failure of the electrical architecture and Integrated Charging Control Unit (ICCU) resulting in a sudden, catastrophic loss of motive power. Over 14 months of ownership, this vehicle has suffered four distinct, electrical and charging failures. On June 6, 2026, the vehicle experienced a total ICCU failure. All lights in the car went dark and lost all power without warning, creating an immediate and life-threatening hazard to myself . The vehicle had to be towed. Three prior repair attempts for charging and 12V battery failures were made by the dealer/. They replaced the ICCU, the car currently runs.. The replaced ICCU has not been redesigned and as a result the car is unsafe to take out on the highway or on a long drive.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11750932July 16, 2026
SERVICE BRAKES
The vehicle repeatedly displays a "Stop Vehicle and Check Brake System" warning together with an ABS warning, accompanied by a loss of normal braking response. On XXX, while driving at approximately 60 mph on I-85 northbound near Exit XXX in [XXX], the warnings appeared and the brakes did not respond normally. I was maintaining a substantial following distance, and the braking system restored itself before I reached the point of needing to brake hard, so no crash or injury occurred. Had hard braking been required in that window, I do not believe the vehicle would have stopped as commanded. This is a recurring fault. The vehicle, purchased certified pre-owned and still under the Hyundai factory warranty, has been taken to the dealer (Ed Voyles Hyundai, [XXX]) three times for the same condition. On the first visit the Integrated Electronic Brake (IEB) unit was replaced; on the second, the Smart Junction Box was replaced; on the third, the dealer removed an aftermarket tracking device wired to the data link connector and referenced Hyundai TSB 24-GI-011H, representing the problem as corrected. The braking-loss event on XXX occurred after that repair. The vehicle has been out of service approximately 30 days total. Because the failure is an intermittent loss of braking response at highway speed, I consider it a serious safety hazard and no longer drive the vehicle. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11750575July 15, 2026
ELECTRICAL SYSTEM
Control box on main battery (iccu)
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11750561July 15, 2026
FUEL/PROPULSION SYSTEM, ENGINE
The car entered a failed ICCU state (not confirmed until the car was looked at by Hyundai at the dealership) while I was driving down to Ano Nuevo regional park. Received a warning on the dash that said that electrical system has failed and to pull over. It restricted me from going over 10 mph on Highway 1 and I eventually pulled over the side of the road and got towed to the dealership. The car is home with me now but I do not feel safe driving this vehicle after all of the reports of ICCU failures. I am very concerned this will happen again and in a more dangerous situation. I was also stranded by this car in March 2026 with a dead battery.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11750379July 14, 2026
STEERING
Vehicle steering or at least power steering failed catastrophically. Started with some electronic sounds at extremes of turning radius but subsequently failed completely and rendered car undriveable. Hyundai repair center attributed this to "excessive dirt and dust" or some external force, but was unable to substantiate or demonstrate any damage to parts they say need replacing. Ultimately this remains undiagnosed with regards to cause but dealer clearly identifies need to replace P/S motor and rack and pinion assembly. Insurance inspection documents no sign of external involvement in the failure. No warning lights/messages. Problem is repeatable. While failure would have been a safety risk at higher speed, it went from "noise at edge of turning radius" to "cannot steer the car" at a point in time where the car was moving at low speeds.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11749766July 11, 2026
POWER TRAIN, UNKNOWN OR OTHER
I was slowing down, actively pressing the brake pedal to bring the vehicle to a full stop. As the car decelerated to what my senses and perception registered as a full stop, I pressed the “P” (Park) button while keeping my foot on the brake pedal. I felt the physical click of the “P” button under my thumb while still holding the brake, and my mind registered that the vehicle had successfully transitioned into Park. Before turning around, I visually confirmed that the vehicle had come to a complete stop. Believing it was fully secured in Park, I turned my head to check on my child in the back seat and naturally released the brake pedal completely. However, the system had actually rejected my command. I assume that the vehicle likely still had a small amount of speed at the exact millisecond I pressed the button, and the computer automatically blocked the “Park” command and kept the car in gear. Because an electric vehicle operates in almost complete silence, with no engine noise or vibration to indicate that it is still in gear, there was no auditory or physical cue to alert me that the car was moving when I released the brake. While my attention was turned toward the back seat for a few seconds, the car quietly began to creep forward, leading directly to the collision with the car in front of me. Following the accident, I found that the vehicle produces slightly different sounds when Park is rejected and when it is successfully engaged. However, the owner’s manual describes only the dashboard message and does not describe these sounds or explain how to distinguish them, so their meanings may be learned only through the failure. At the time of the incident, I was not familiar with the distinction between these two sounds. Because my brain processed the physical press of the button as a successful action, and I had visually confirmed that we were not moving, my focus immediately shifted to my child. I was entirely misled by the digital interface.
Crash:
Yes
Fire:
No
Injuries:
0
Deaths:
0
#11749630July 10, 2026
ELECTRICAL SYSTEM
Failure of ICCU and high voltage fuse. Known issue in this vehicle. 2022-24 have been recalled. 2025 needs to be recalled. Warning on dash when it occurred, then 12V battery died. Undrivable. Towed in and repaired under warranty by dealer. But apparently it can happen again because Hyundai doesn’t know how to permanently address the problem.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11749438July 9, 2026
ELECTRICAL SYSTEM
On 5/27/26, when the car was parked in parking lot, received an alert on dashboard, "check electric vehicle system", when the car was turned on. The car would not shift in to drive or reverse so had to get towed to nearby Hyundai dealership. The EV system was recalibrated and test driven 122 miles to verify proper operation. Then on 6/23/26, when driving on road received an alert on dashboard "power limited". The car would not accelerate and had to get it towed again to same dealership. The dealership performed tests on ICCU and 12V battery but came back negative.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11749425July 9, 2026
ELECTRICAL SYSTEM, POWER TRAIN
During a family road trip, my 2025 Hyundai Ioniq 5 (~9,000 miles, less than one year old) suddenly showed red "Check Electric Vehicle System" and 12V battery warning lights and then completely lost power. The 12V system failed entirely - the vehicle could not be driven or shifted, and the doors and the rear hatch could not be locked or unlocked. It had to be flat-bedded to a Hyundai dealer because it was completely inoperable. The dealer diagnosed a failed ICCU (Integrated Charging Control Unit) and a blown ICCU safety fuse (fault code P1A9096) and is replacing both under warranty; the component is available for inspection. The ICCU converts high-voltage battery power to charge the 12V system; when it fails, the vehicle loses all electrical power and drive capability. The warning lamps appeared immediately before total power loss, with no prior symptoms at the last scheduled service. This is a known, safety-critical failure on this platform: a sudden, complete loss of power can strand occupants and, if it occurs while driving, cause loss of motive power - a serious crash risk. My vehicle was stationary when it failed, but the same failure at speed would be extremely dangerous. I have video evidence of the car completely bricked out.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11749330July 9, 2026
ELECTRICAL SYSTEM
The contact owns a 2023 Hyundai Ioniq 5. The contact stated that while driving at higher speeds occasionally, the vehicle suddenly lost motive power. The "Smart Smooth Cruise Control Conditions Not Met" warning message was displayed on the instrument panel. The contact restarted the vehicle as a temporary fix; however, the failure recurred. The vehicle was taken to a local dealer where it was diagnosed with an unknown electrical failure. The vehicle was repaired; however, the failure recurred. The vehicle was taken back to the same local dealer; however, the cause of the failure could not be determined. The vehicle was not repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 47,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11748828July 7, 2026
ELECTRICAL SYSTEM, FUEL/PROPULSION SYSTEM
Complaint Summary: Mandated federal safety recall remedies performed on my vehicle have directly induced a cascading, critical safety failure of the vehicle's high-voltage propulsion management system. My 2022 Hyundai IONIQ 5 (VIN: [XXX]) was brought to an authorized dealer on XXX at 200,224 miles to complete safety recall Campaign 272 / NHTSA Recall 24V-204 (ICCU Software Update and Fuse Inspection). After receiving this software flash, the vehicle's electrical charging system failed (DTC P0D5C00), requiring a full hardware replacement of the Integrated Charging Control Unit (ICCU) on XXX. 142 miles after the physical replacement of the high-voltage ICCU, the vehicle displayed an emergency battery malfunction message on the dashboard. Diagnostic scans reveal active fault code P1BC700 in the Battery Management System. The manufacturer's dealership is now charging $1,909.77 out-of-pocket to replace the Power Relay Assembly (PRA).The current recall modifications for the E-GMP platform are failing to safely mitigate high-voltage current spikes. The electrical strain or servicing procedure required by the recall has directly compromised the adjacent power relays. This creates a severe safety hazard, leaving drivers exposed to subsequent high-voltage component failure immediately after completing mandated federal safety recalls. NHTSA should investigate cascading high-voltage component failures occurring in vehicles directly following the completion of Recall 24V-204. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11748715July 7, 2026
SERVICE BRAKES, ELECTRICAL SYSTEM, VEHICLE SPEED CONTROL
1. Sudden Unintended Acceleration On two (2) separate occasions, after coming to a complete stop at a red light with foot on the brake pedal, the vehicle suddenly lurched forward on its own. 2. Brake Pedal Malfunction On more than ten (10) occasions, when attempting to stop at a light, the brake pedal briefly behaves like the accelerator for approximately 1–2 seconds. Driver has to release the brake and press it again to restore normal braking function. 3. Doors Unlocking/Opening on Their Own On more than one hundred (100) occasions, approximately 10 minutes after parking — with no key fob or phone nearby — a door opens on its own. Confirmed via mobile app notification and visual confirmation from a distance each time. 4. Apple CarPlay Connectivity Issues CarPlay frequently fails to connect. During phone calls specifically, the connection drops in and out intermittently. 5. Sticky Residue on Door Handles A sticky, adhesive-like residue is present on the interior passenger door grab handle and rear door handles. Residue does not clean off and transfers to hands on every use.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11748714July 7, 2026
SERVICE BRAKES, ELECTRICAL SYSTEM, VEHICLE SPEED CONTROL
1. Sudden Unintended Acceleration On two (2) separate occasions, after coming to a complete stop at a red light with foot on the brake pedal, the vehicle suddenly lurched forward on its own. 2. Brake Pedal Malfunction On more than ten (10) occasions, when attempting to stop at a light, the brake pedal briefly behaves like the accelerator for approximately 1–2 seconds. Driver has to release the brake and press it again to restore normal braking function. 3. Doors Unlocking/Opening on Their Own On more than one hundred (100) occasions, approximately 10 minutes after parking — with no key fob or phone nearby — a door opens on its own. Confirmed via mobile app notification and visual confirmation from a distance each time. 4. Apple CarPlay Connectivity Issues CarPlay frequently fails to connect. During phone calls specifically, the connection drops in and out intermittently. 5. Sticky Residue on Door Handles A sticky, adhesive-like residue is present on the interior passenger door grab handle and rear door handles. Residue does not clean off and transfers to hands on every use.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11748510July 6, 2026
ELECTRICAL SYSTEM, FUEL/PROPULSION SYSTEM
Experienced ICCU failure under everyday conditions, driving home from an appointment. Car had sat in direct sun for 30 mins, and starting the car and driving away with the AC fully blasting is when the failure occurred.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11748404July 5, 2026
STRUCTURE:BODY, UNKNOWN OR OTHER
Rear hatch window spontaneously shattered for no apparent reason. Car was parked in a Florida parking lot, no use of rear hatch and no use of rear defroster. I understand there is a potential class action lawsuit for the Ioniq 5 model years 2022-2025 for this problem.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11748381July 5, 2026
LANE DEPARTURE: ASSIST
The ioniq 5 highway driving assist, which steers the car and keeps it centered in the lane, will disengage without clear warning - the small green steering wheel icon (which is at the top of the dash cluster) simply becomes grey and blinks, but there's no audible chime to indicate that the car has disengaged the steering assist. I have had multiple times on the highway where it disengaged and I don't notice (because I am looking at the road, not the dash) and one time on the highway it disengaged during a turn and hit the rumble strip, causing me to swerve back onto the road. My hands were on the steering wheel and I was paying full attention, but I was expecting the car to handle the turn, and it just disengaged without me noticing. Had there been another car in the middle lane or I reacted slower, it's likely a crash would have occurred. This has been documented as well on Reddit and confirmed by multiple owners, who have mentioned they have disclosed to the manufacturer: [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11748019July 2, 2026
ELECTRICAL SYSTEM
Description of Safety Defect:The integrated Forward Attention Warning (FAW) driver-monitoring camera located on the steering column continuously fails to track facial structures or pupils during routine daytime driving. This occurs despite maintaining a proper driving posture, adjusting the steering column layout, and removing any facial obstructions.Safety Consequences:When the system falsely registers a "distracted driver" state due to its faulty sensor calibration, it routinely triggers erratic high-pitched chimes and immediately disables active highway driver assistance systems, including Highway Driving Assist (HDA), Lane Keeping Assist (LKA), and Smart Cruise Control. This abrupt loss of active steering guidance and vehicle speed maintenance creates sudden, hazardous driving situations on open highways. Furthermore, to get the faulty alert chimes to clear, the driver is forced to take their eyes off the roadway to stare directly into the steering column sensor camera, actively causing driver distraction.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11747025June 28, 2026
ELECTRICAL SYSTEM, POWER TRAIN
I have a 2023 Hyundai Ioniq 5 Limited and had the ICCU "popped" (failed) which took about two weeks to replace. This time we were lucky that in happened at our home but had we been driving the car would it would have completed died. We regularly drive from from [XXX] to [XXX] were there are large section of [XXX] with no cell service. Meaning potentially walking for miles in extreme heat or cold. Hyundai right now seems only interested in continuously replacing the part rather than actually fixing the route cause, making it so the car is not trustworthy or safe to drive long distances. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11746882June 27, 2026
ELECTRICAL SYSTEM
iccu failure. Car completely disabled.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Hyundai Ioniq 5