Mazda CX-90 Complaints

526 consumer complaints on file.

#11727400March 27, 2026
ENGINE
I am submitting this complaint regarding my 2025 Mazda CX-90 PHEV, leased in April 2025. Since early in my lease, the vehicle has had ongoing drivability issues that have worsened over time and now present a serious safety concern.From the beginning, the vehicle exhibited jerking and hesitation while driving. Initially minor, this has become more frequent and now includes stalling behavior during normal driving conditions, including acceleration and traffic flow. This creates a risk of collision, especially when merging or at intersections.Approximately six months into my lease, the radiator failed and had to be replaced. More recently, while driving, multiple warnings appeared at once: Hybrid System Malfunction, Battery System Malfunction, Oil Monitoring Malfunction, and i-ACTIVSENSE partially disabled. These warnings were documented.Two weeks prior, the dealership reported no diagnostic codes. However, on my most recent visit, I was told via video that the active air shutter is now the issue. The required part is on backorder until August. I was told I could either remain in a non-comparable loaner while still making full lease payments, or continue driving the vehicle in its current condition until the part arrives. I find this unacceptable given the safety concerns.I expressed that I do not feel safe driving this vehicle, but the service advisor stated this is “not a safety concern.” I disagree. A vehicle that jerks, hesitates, or stalls while driving, combined with multiple system malfunctions and disabled safety features, presents a clear safety risk.I also disclosed prior to leasing that I do not have access to charging. I was told this would not be an issue. I am now being told that not charging the vehicle may be contributing to the problem. Service advisors have also indicated these vehicles have known hybrid battery issues.I no longer feel safe driving this vehicle and am concerned for my safety and my family’s safety.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11727397March 27, 2026
UNKNOWN OR OTHER
The vehicle caught fire while in operation/driving and later engulfed entie cabin. No warning lamps, in-vehicle alerts, or other warning signs were activated or displayed. Car has not yet been inspected.
Crash:
No
Fire:
Yes
Injuries:
0
Deaths:
0
#11727341March 26, 2026
STEERING
steering gets stuck or requires intense effort to move from center, specially on freeway or slight turns. feels dangerous specially when being on the freeway. took it to get looked at & they want me to pay for a repair that is listed on other cars that were recalled.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11727216March 26, 2026
VEHICLE SPEED CONTROL
I have taken my car to service in January, and it has had all the recalls fixes done, supposedly. Just the last two weeks I have been feeling a notchy sensation when steering, it resists and then jumps to the next notch when turning. Not a smooth feeling as it did during the first year of usage.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11727151March 26, 2026
POWER TRAIN, ELECTRICAL SYSTEM, UNKNOWN OR OTHER
Started the car to go to work and the check engine light came on, I stop started flashing and wouldn’t turn off. Message says there is a malfunction with the hybrid system and to visit Mazda dealer. I had to drive it to work, so it drove fine. But the lights never went off.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11727048March 25, 2026
AIR BAGS, ELECTRICAL SYSTEM, SEAT BELTS
Vehicle experienced multiple safety-related failures at approximately 500 miles. The failures included complete instrument cluster loss (no speedometer or gauges), unpredictable windshield wiper operation, headlight flickering, complete loss of brake lights and turn signals, rear liftgate malfunction, and airbag/seatbelt warning indicators. These issues created unsafe operating conditions, including inability to monitor vehicle speed, loss of rear signaling and brake indication to other drivers, and uncertainty regarding airbag system functionality. This presented a risk to both the driver and surrounding traffic. The failures occurred intermittently and in combination, indicating a potential systemic electrical issue rather than a single isolated component failure. The vehicle has been taken to an authorized Mazda dealership and is currently under inspection and repair. The dealership has indicated the instrument cluster requires replacement and is currently on backorder. Full root cause has not been confirmed. Warning indicators, including airbag and seatbelt system alerts, were observed prior to and during the failures. Additional symptoms included erratic system behavior across multiple vehicle functions. Vehicle remains at dealership with no confirmed repair completion date. Component is available for inspection upon request through the servicing dealership.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11726952March 25, 2026
STEERING
Description of the issue: While driving, the steering wheel suddenly develops a significantly increased resistance. This resistance can only be overcome by applying noticeably higher force. The steering feels as if it is “sticking” or momentarily binding. Driving conditions where the issue occurs: - Frequently on highways - Also on rural roads - Occurs both while cornering and while driving straight ahead
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11726918March 25, 2026
STEERING
According to your recall that states: Recall date 2024-01-17 Recall no. 24V022000 Mazda North America Operations (Mazda) is recalling certain 2024 CX-90 vehicles. An assembly issue with the worm gear in the steering system may result in a sudden loss of power steering assist. Recall consequence Loss of power steering assist while driving increases the risk of a crash. My car is not included in this recall according to my VIN number, however my car is doing the same thing described above in the recall. I am requesting that ALL Mazda CX 90 vehicles be in this recall. I took it to the dealership and although there hasn’t been a serious injury yet, there absolutely could be if it is not fixed.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11726858March 24, 2026
WHEELS, EXTERIOR LIGHTING, ENGINE
I am reporting multiple ongoing safety and reliability issues with my 2024 Mazda CX-90, which have persisted despite multiple service visits and the vehicle being under warranty. Issues include: •Premature tire wear: OEM Falken tires worn to unsafe levels (approximately 3/32”) before 15,000–20,000 miles •Faulty fuel gauge providing inaccurate readings •Intermittent headlight malfunction, creating visibility and safety concerns •Battery failure requiring replacement at approximately 24,000 miles •Engine malfunction warnings advising the vehicle should not be driven •Loud and abnormal brake noise •Remote start system failure The vehicle has been out of service for an extended period (10+ days), and I no longer feel it is safe or reliable to operate. I am particularly concerned about the overall safety of this vehicle given the pattern of system failures and reports of similar issues. Mazda has not provided a resolution beyond continued repairs, and I have lost confidence in the vehicle’s safety.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11726775March 24, 2026
STEERING
Purchased the Mazda Cx-90 2024 and was told that all recalls had been cleared and completed. Steering recall for worm gear and grease had been cleared. Not consistent but when taking turns will have a sudden jerk and increase in steering, especially with left turns. called and reported to Mazda dealership and told by mechanic that this needed to be reported due to an undergoing investigation on recalls that were not truly resolved by Mazda. The vehicle was cleared of inspection in 2024 prior to our purchase. No wrecks but concerned this could lead to one.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11726771March 24, 2026
STEERING, LANE DEPARTURE: ASSIST
Stick steering wheel. Excessive force need to steer while making a turn.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11726526March 23, 2026
POWER TRAIN
On several occasions, both starting from stop and at 45 mph, on harder acceleration while operating as EV in normal mode, the vehicle will start accelerating then SLOW suddenly and hard for a few seconds before engaging the gas engine and accelerating as expected. Dangerous when pulling into traffic or attempting to pass.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11726522March 23, 2026
LANE DEPARTURE: ASSIST
At highway speeds, even with lane keeping assist disabled/turned off, if the ADAS is turned on LKA seems to remain active. Steering effort is unpredictable making it difficult to maintain a line through the corner. Effort will suddenly decrease resulting in oversteer. This is particularly dangerous when next to other cars, guardrails, barriers and the like. The behavior is greatly reduced with all ADAS off. This is largely repeatable over the last 18 mos/24,000 miles.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11726479March 23, 2026
STEERING
Mazda did the "increase in steering effort" recall 03/18/2024. At 10,455 miles. Campaign 6524A. At that time, we had never experienced problems with the steering. But now, with 33, 627 miles, the steering has a sort of kickback feel when in a sustained turn; either direction. It's most noticeable on an interstate highway on or off ramp. Seems as if it's trying to center the steering wheel to straight ahead. It's a mild, but definite concern. I've contacted Mazda, and the dealer where we have our CX-90 serviced.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11726361March 23, 2026
STEERING
The contact owns a 2026 Mazda CX-90. The contact stated that while driving at undisclosed speeds, the steering wheel was pulling to the left, causing the vehicle to merge into the left lane unintendedly. The contact firmly held the steering wheel to prevent the failure. Additionally, the vehicle jerked to the right lane while the lane keep steering assist function was activated because the steering wheel was pulling to the left. No warning light was illuminated. The vehicle was taken to the dealer, but no cause of failure was found. The failure persisted, and the vehicle was taken back to the dealer, and an alignment of 0.1 degrees was performed; however, the failure recurred. The vehicle was taken back to the dealer for the third time, and the contact was informed that no repair was available and was advised to contact the manufacturer for assistance. The vehicle was not repaired. The manufacturer was made aware of the failure, and a case was filed. The failure mileage was approximately 100.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11726340March 23, 2026
SEAT BELTS, SEATS
Seatbelt got stuck between seat and seat frame. Seatbelt was stuck in the locked position and was neither able to be retracted or pulled out rendering the seatbelt unusable. This is a huge safety concern as we were stranded at night with small children and unable to use the seatbelt. A recall should be made to this vehicle (Mazda cx90). Further Mazda is claiming that seatbelts are not part of the warranty (it’s a <1 year old car) and they are charging $1000 to fix this. This is a huge safety issue to not have a functioning seatbelt and a design flaw that should be fixed. It is too easy under normal use for this to occur.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11725814March 20, 2026
ENGINE, ELECTRICAL SYSTEM, VEHICLE SPEED CONTROL
On 3/19/2026, the vehicle ignition was turned on. Immediately, we received a variety of warnings, including: "charging system malfunction", "i-ACTIVESENSE Partially Disabled", "Hybrid System Malfunction", "i-stop Malfunction", "Charging System Malfunction", and "Critical Systems Failure". Vehicle has only 20,040 miles. On 3/20/2026 8:30 AM, we contacted the Mazda dealer where vehicle was purchased new and they said "we are not sure when we can get to it--it could be several weeks". We had the vehicle towed to this dealer since they were involved in addressing the recall about "fuel sensors". An email was also sent to Mazda corporate so they would be aware of the response we received from the dealer and help with a car rental. It was very fortunate that we were not on the highway when this happened as it would have been an extreme safety risk.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11725659March 19, 2026
UNKNOWN OR OTHER, VEHICLE SPEED CONTROL, ENGINE
I am reporting a serious safety defect involving unintended acceleration in my 2024 Mazda plug-in hybrid vehicle. On multiple occasions, the vehicle has suddenly accelerated without input from me, creating dangerous situations where I nearly lost control and risked a collision. This issue has occurred at least four times since January 2026. I previously brought the vehicle to an authorized Mazda dealership, where it remained for approximately two weeks; however, they were unable to replicate the problem and returned the vehicle, stating no faults were found. Despite this, the unintended acceleration continues to occur intermittently. I have attempted to follow up with both the dealership and Mazda corporate without receiving a response. This ongoing issue poses a significant safety risk to myself, my passengers, and others on the road.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11725635March 19, 2026
STEERING, ENGINE, ELECTRICAL SYSTEM
The car had a recall repair to the steering system done due to it being sticky. But the issue has coma back again while driving on ramps and curvy roads. The steering requires significantly more effort and also has a feel of a ratchet. It also feels like a ratchet, when moving very slow and making tight turns. The car also had a recall battery replacement done for the MHEV battery and now the problem is back again within a few months and it shows "Hybrid system failed" and "Engine malfunction".
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11725503March 19, 2026
STEERING
The 2024 Mazda CX-90 has a steering issue. The steering wheel sticks and is jumpy when turning. I took it to the dealer and demonstrated the issue by driving slowly, turning the wheel, releasing it and watching the car continue to turn while the wheel remained in the position I had left it.This anomaly was easily overcome by applying reverse steering pressure or by accelerating the vehicle. After inspection by the Mazda tech at Crown Mazda in Holland, Mi. the work summary stated in part:"This is a design matter, and not an actual problem. No problem found".
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Mazda CX-90