Ford F-250 Service Bulletins (2014)
167 manufacturer communications on file.
- August 18, 2026•Document ID: 11036338Service Bulletin/Repair InstructionsENGINE; POWER TRAIN; UNKNOWN OR OTHER
- Mfr Comm. #:
- SSM 55098
- Date Added:
- August 25, 2026
- Manufacturer:
- FORD
SummarySome 2013-2016 Super Duty vehicles equipped with a 6.7L diesel engine and 2015-2019 Transit vehicles equipped with a 3.2L diesel engine may not pass a state smog test due to the exhaust gas system (EGS) monitor that will not run after completing the exhaust gas sensor drive cycle located within Section 2 of the Powertrain Control/Emissions Diagnostics (PC/ED) Manual > Drive Cycles. This may be due to the vehicles diesel oxidation catalyst (DOC) age counter being under the 120-minute age requirement. There is an all-new "PCM Catalytic Converter Age Evaluation" application within the latest version of the Ford Diagnosis and Repair System (FDRS). Use this new FDRS application to determine the age (in minutes) of the DOC. If the age is less than 120 minutes, perform manual regenerations to increase the catalyst age counter to satisfy the monitor age requirement. If further assistance is needed, contact the technical assistance center (TAC). Note: this article only applies to the EGS monitor. Problems with other vehicle monitors not running successfully must be addressed using normal diagnostics located i
Associated Products (21)2019 Ford Transit2018 Ford Transit2017 Ford Transit2016 Ford F-2502016 Ford F-3502016 Ford F-4502016 Ford F-5502016 Ford Transit2015 Ford F-2502015 Ford F-3502015 Ford F-4502015 Ford F-5502015 Ford Transit2014 Ford F-2502014 Ford F-3502014 Ford F-4502014 Ford F-5502013 Ford F-2502013 Ford F-3502013 Ford F-450+ 1 moreAssociated Documents - March 26, 2026•Document ID: 11030810Service Bulletin/Repair InstructionsENGINE
- Mfr Comm. #:
- SSM 54690
- Date Added:
- April 6, 2026
- Manufacturer:
- FORD
SummarySome 2013-2016 Super Duty vehicles equipped with a 6.7L diesel engine and 2015-2019 Transit vehicles equipped with a 3.2L diesel engine may not pass a state smog test due to the exhaust gas system (EGS) monitor that will not run after completing the Exhaust Gas Sensor drive cycle located within Section 2 of the Powertrain Control/Emissions Diagnostics (PC/ED) Manual > Drive Cycles. This may be due to the vehicles diesel oxidation catalyst (DOC) age counter being under the 120-minute requirement. Engineering is investigating this issue and working on a solution.
Associated Products (17)Associated Documents - February 24, 2026•Document ID: 11029052Service Bulletin/Repair InstructionsELECTRICAL SYSTEM; STRUCTURE:BODY; UNKNOWN OR OTHER
- Mfr Comm. #:
- SSM 54601
- Date Added:
- February 27, 2026
- Manufacturer:
- FORD
SummaryFord and Lincoln vehicles equipped with wired keyless entry keypad systems and accessory wireless keyless entry keypad systems may or may not come with a wallet card containing the master code. Unlike the integrated wired keypad, the accessory wireless keypad master code cannot be retrieved from the vehicle using a diagnostic scan tool or from the label printed on the body control module (BCM). The Factory Keyless Entry Code application within the diagnostic scan tool will not provide an applicable master code for the accessory wireless keypad. If the wallet card for an accessory keypad is not available, the "Wireless RF Keypad Diagnosis Guide" can be referenced and provides direction on how to retrieve the master code. This guide is located under the Workshop Manual tab > Accessories > Installation > Wireless RF Keypad Diagnosis Guide > PPT C > Step C2.<br /><br /> Note: The only available keypad for some vehicles from the assembly plant is the accessory wireless keyless entry keypad. The integrated wired keypad cannot be installed on vehicles not equipped from the factory with a wired keyless entry k
Associated Products (387)2026 Ford Bronco2026 Ford Bronco Sport2026 Ford Escape2026 Ford Expedition2026 Ford Explorer2026 Ford F-1502026 Ford F-2502026 Ford F-3502026 Ford F-4502026 Ford F-5502026 Ford Maverick2026 Ford Mustang2026 Ford Ranger2025 Ford Bronco2025 Ford Bronco Sport2025 Ford Escape2025 Ford Expedition2025 Ford Explorer2025 Ford F-1502025 Ford F-250+ 367 moreAssociated Documents - September 24, 2025•Document ID: 11023852OtherUNKNOWN OR OTHER; ENGINE
- Mfr Comm. #:
- 24L05
- Date Added:
- October 3, 2025
- Manufacturer:
- FORD
SummaryCertain 2011-2022 Model Year Super Duty Vehicles Equipped with 6.7L Engine - Emission Control Information Label Update for Qualified Vehicles
Associated Products (39)2022 Ford F-2502022 Ford F-4502022 Ford F-5502021 Ford F-2502021 Ford F-3502021 Ford F-4502021 Ford F-5502020 Ford F-4502020 Ford F-5502019 Ford F-3502019 Ford F-4502019 Ford F-5502018 Ford F-3502018 Ford F-4502018 Ford F-5502017 Ford F-4502017 Ford F-5502016 Ford F-4502016 Ford F-5502015 Ford F-450+ 19 moreAssociated Documents - August 23, 2025•Document ID: 11022355OtherUNKNOWN OR OTHER; ENGINE
- Mfr Comm. #:
- 24L05
- Date Added:
- September 3, 2025
- Manufacturer:
- FORD
SummaryCertain 2011-2022 Model Year Super Duty Vehicles Equipped with 6.7L Engine - Emission Control Information Label Update for Qualified Vehicles
Associated Products (48)2022 Ford F-2502022 Ford F-3502022 Ford F-4502022 Ford F-5502021 Ford F-2502021 Ford F-3502021 Ford F-4502021 Ford F-5502020 Ford F-2502020 Ford F-3502020 Ford F-4502020 Ford F-5502019 Ford F-2502019 Ford F-3502019 Ford F-4502019 Ford F-5502018 Ford F-2502018 Ford F-3502018 Ford F-4502018 Ford F-550+ 28 moreAssociated Documents - October 10, 2024•Document ID: 11008948Service Bulletin/Repair InstructionsUNKNOWN OR OTHER
- Mfr Comm. #:
- SSM 53040
- Date Added:
- October 16, 2024
- Manufacturer:
- FORD
SummaryWhile performing a transmission repair on some 2012-2024 Ford and Lincoln vehicles, a transmission seal kit may be on backorder due to supply chain interruptions. While performing a transmission repair on some 2012-2024 Ford and Lincoln vehicles, a transmission seal kit may be on backorder due to supply chain interruptions.
Associated Products (322)2024 Ford Bronco2024 Ford Bronco Sport2024 Ford E-3502024 Ford E-4502024 Ford Edge2024 Ford Escape2024 Ford Expedition2024 Ford Explorer2024 Ford F-1502024 Ford F-2502024 Ford F-3502024 Ford F-4502024 Ford F-5502024 Ford F-6502024 Ford F-7502024 Ford Maverick2024 Ford Mustang2024 Ford Mustang Mach-E2024 Ford Ranger2024 Ford Transit+ 302 moreAssociated Documents - April 24, 2024•Document ID: 10254138Service Bulletin/Repair InstructionsEQUIPMENT
- Mfr Comm. #:
- SSM 52476
- Date Added:
- May 3, 2024
- Manufacturer:
- FORD
SummaryAll accessory stick-on keyless entry keypads come with a wallet card containing the master code. If the accessory keypad was factory installed, this card will be placed in the glove box and should be handed to the vehicles owner during initial delivery. Unlike the integrated (wired) factory keypad, the accessory keypad master code cannot be retrieved from the vehicle using a diagnostic scan tool. If the wallet card for an accessory keypad is lost, follow these steps to recover the code. Dealer Key Code access is granted through the Dealer Program Enrollment System (DPES); dealership management can authorize users. The authorized user must go to FMCDealer.com > Parts and Service > Parts Product Line Information > Keys/Entry Devices > Aftermarket Keyless Entry Keypad Code Access. Follow the instructions on the screen to obtain the master code for the accessory keypad.
Associated Products (394)2024 Ford Edge2024 Ford Explorer2024 Ford F-1502024 Ford F-2502024 Ford F-3502024 Ford F-4502024 Ford F-5502024 Ford F-6002024 Ford F-6502024 Ford F-7502024 Ford Mustang2024 Ford Ranger2023 Ford Bronco2023 Ford Bronco Sport2023 Ford Edge2023 Ford Escape2023 Ford Explorer2023 Ford F-1502023 Ford F-2502023 Ford F-350+ 374 moreAssociated Documents - January 18, 2024•Document ID: 10249175Service Bulletin/Repair InstructionsSTEERING
- Mfr Comm. #:
- SSM 52188
- Date Added:
- January 24, 2024
- Manufacturer:
- FORD
Summary2024 F-Super Duty vehicles are equipped with XL-22 (WSS-M2C184-A1) high temperature power steering fluid that looks like clear hydraulic fluid. This fluid is an improvement in high temperature and thermal oxidative stability compared to Mercon LV. This power steering fluid is also compatible and highly recommended to use when filling or topping off power steering systems of all 2012-2023 F-Super Duty vehicles originally equipped with Mercon LV.
Associated Products (82)2024 Ford F-2502024 Ford F-3502024 Ford F-4502024 Ford F-6502024 Ford F-7502023 Ford F-2502023 Ford F-3502023 Ford F-4502023 Ford F-5502023 Ford F-6002023 Ford F-6502023 Ford F-7502022 Ford F-2502022 Ford F-3502022 Ford F-4502022 Ford F-5502022 Ford F-6002022 Ford F-6502022 Ford F-7502021 Ford F-250+ 62 moreAssociated Documents - August 10, 2023•Document ID: 10241626Service Bulletin/Repair InstructionsPOWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE (TCM/PCM/TECM); POWER TRAIN:MANUAL TRANSMISSION:CONTROL MODULE (TCM/PCM/TECM)
- Mfr Comm. #:
- SSM 51854
- Date Added:
- September 4, 2023
- Manufacturer:
- FORD
SummaryVarious 2013-2019 vehicles may exhibit an illuminated malfunction indicator lamp (MIL) with diagnostic trouble code (DTC) P264F after powertrain control module (PCM) replacement. This DTC indicates that the engine serial number (ESN) must be programmed into the PCM. The ESN is located on PTS > Diagnostics tab > HVBoM > Features > Engine Serial Number. Once the ESN is obtained from the historical vehicle bill of materials (HvBOM), it can be programmed into the PCM using the appropriate Ford diagnostic scan tool. Navigate to the toolbox tab> powertrain menu> Service Functions> ESN.
Associated Products (54)2019 Ford E-3502019 Ford E-4502019 Ford F-2502019 Ford F-3502019 Ford F-4502019 Ford F-5502019 Ford F-6502019 Ford F-7502018 Ford E-3502018 Ford E-4502018 Ford F-2502018 Ford F-3502018 Ford F-4502018 Ford F-5502018 Ford F-6502018 Ford F-7502017 Ford E-2502017 Ford E-3502017 Ford E-4502017 Ford F-250+ 34 moreAssociated Documents - August 8, 2023•Document ID: 10241547Service Bulletin/Repair InstructionsPOWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE (TCM/PCM/TECM)
- Mfr Comm. #:
- SSM 51849
- Date Added:
- September 1, 2023
- Manufacturer:
- FORD
SummaryVarious 2013-2019 vehicles may exhibit an illuminated malfunction indicator lamp (MIL) with diagnostic trouble code (DTC) P264F after powertrain control module (PCM) replacement. This DTC indicates that the engine serial number (ESN) must be programmed into the PCM. The ESN is located on PTS> OASIS> Features> Engine Serial Number. Once the ESN is obtained from the historical vehicle bill of materials (HvBOM), it can be programmed into the PCM using the appropriate Ford diagnostic scan tool. Navigate to the toolbox tab> powertrain menu> Service Functions> ESN.
Associated Products (56)2019 Ford E-3502019 Ford E-4502019 Ford F-2502019 Ford F-3502019 Ford F-4502019 Ford F-5502019 Ford F-6502019 Ford F-7502018 Ford E-3502018 Ford E-4502018 Ford F-2502018 Ford F-3502018 Ford F-4502018 Ford F-5502018 Ford F-6502018 Ford F-7502017 Ford E-2502017 Ford E-3502017 Ford E-4502017 Ford F-250+ 36 moreAssociated Documents - June 8, 2023•Document ID: 10237789Service Bulletin/Repair InstructionsPOWER TRAIN; ENGINE AND ENGINE COOLING:EXHAUST SYSTEM
- Mfr Comm. #:
- SSM 51691
- Date Added:
- June 16, 2023
- Manufacturer:
- FORD
Summary2011-2023 F-Super Duty and 2016-2024 F-650/F-750 vehicles equipped with a 6.7L engine may exhibit an elevated idle condition. During prolonged idle time, vehicles may experience this elevated idle to reduce unburned hydrocarbons from the SCR. The powertrain control module estimates hydrocarbon levels in the SCR and may increase idle speed to remove them. Idle speed will be increased to 1000 RPM for ambient temperatures near 26°C (80°F) and may increase to 1200 RPM at -40 °C (-40°F). Vehicles may exhibit exhaust smoke and diesel exhaust fluid smell during elevated idle condition. Exhaust smoke and smell condition will not affect reliability or durability of the engine. Power take-off (PTO) use and idle set point control will disable elevated speed. It is required that the operator monitor the vehicle and adhere to any Exhaust Filter warning messages.
Associated Products (83)2023 Ford F-2502023 Ford F-3502023 Ford F-4502023 Ford F-5502023 Ford F-6002023 Ford F-6502023 Ford F-7502022 Ford F-2502022 Ford F-3502022 Ford F-4502022 Ford F-5502022 Ford F-6002022 Ford F-6502022 Ford F-7502021 Ford F-2502021 Ford F-3502021 Ford F-4502021 Ford F-5502021 Ford F-6002021 Ford F-650+ 63 moreAssociated Documents - April 4, 2023•Document ID: 10235153Service Bulletin/Repair InstructionsSTRUCTURE
- Mfr Comm. #:
- SSM 51536
- Date Added:
- May 4, 2023
- Manufacturer:
- LINCOLN
SummaryFor 2000-2024 Ford and Lincoln vehicles, swapping a module from a vehicle for diagnosis purposes is likely to cause errors and is not recommended. It is also not recommended to order a replacement module using a vehicle identification number (VIN) from a different vehicle. Most modules on these affected vehicles are VIN/vehicle specific and hardware variations between modules do exist. Swapping a module from a vehicle or ordering a module using a different vehicle/VIN can cause ineffective repairs and additional vehicle down time. Make sure all appropriate Workshop Manual (WSM) procedures are followed when diagnosing the condition prior to all module replacements and only order modules using the correct VIN.
Associated Products (305)2023 Ford Bronco2023 Ford Bronco Sport2023 Ford Edge2023 Ford Escape2023 Ford Expedition2023 Ford Explorer2023 Ford F-1502023 Ford F-2502023 Ford F-3502023 Ford F-4502023 Ford F-5502023 Ford F-6502023 Ford F-7502023 Ford Maverick2023 Ford Mustang2023 Ford Mustang Mach-E2023 Ford Ranger2023 Ford Transit Connect2023 Lincoln Aviator2023 Lincoln Corsair+ 285 moreAssociated Documents - December 13, 2022•Document ID: 10228867Service Bulletin/Repair InstructionsENGINE AND ENGINE COOLING
- Mfr Comm. #:
- SSM 51251
- Date Added:
- January 5, 2023
- Manufacturer:
- FORD
SummarySome 2011-2022 F-Super Duty vehicles equipped with a 6.7L diesel engine may exhibit a ticking noise at idle after an engine oil change. It is often referred to as Typewriter Noise because of its similarity to the sound of a mechanical typewriter. When engine temperatures reach 150 ðF (65 ðC) or higher, (from engine idle up to approximately 1700 RPM's), this noise can typically be heard at the front wheel well and is often isolated to the transmission bell housing or oil pan area. Typewriter Noise is not detrimental to engine function or durability and has no short or long term effects on the engine. Do not attempt repairs to eliminate this noise. This noise is characteristic of the 6.7L diesel engine and will typically cease or diminish significantly within the oil change maintenance interval.
Associated Products (48)2022 Ford F-2502022 Ford F-3502022 Ford F-4502022 Ford F-5502021 Ford F-2502021 Ford F-3502021 Ford F-4502021 Ford F-5502020 Ford F-2502020 Ford F-3502020 Ford F-4502020 Ford F-5502019 Ford F-2502019 Ford F-3502019 Ford F-4502019 Ford F-5502018 Ford F-2502018 Ford F-3502018 Ford F-4502018 Ford F-550+ 28 moreAssociated Documents - May 24, 2022•Document ID: 10212957Service Bulletin/Repair InstructionsELECTRICAL SYSTEM
- Mfr Comm. #:
- SSM 50804
- Date Added:
- June 1, 2022
- Manufacturer:
- FORD
SummarySome 2013-2023 Ford or Lincoln vehicles with modems activated through FordPass or LincolnWay may experience 12 volt battery drain symptoms when the customer uses non-Ford/Lincoln phone applications as an alternate channel to access vehicle commands such as door lock/unlock, remote start, vehicle location, etc. The battery drain may be caused by excessive calls for data through the vehicle network keeping it in an activated state. Recommend that the customer uninstall the app to ensure this is not contributing to battery symptoms experienced. Advise the customer that unaffiliated third-party app developers do not work directly with Ford to adhere to security, vehicle communication, and privacy requirements.
Associated Products (174)2023 Ford E-1502023 Ford E-2502023 Ford E-3502023 Ford E-4502023 Ford F-6502023 Ford F-7502022 Ford Bronco2022 Ford E-1502022 Ford E-2502022 Ford E-3502022 Ford E-4502022 Ford Edge2022 Ford Escape2022 Ford Expedition2022 Ford Explorer2022 Ford F-1502022 Ford F-2502022 Ford F-3502022 Ford F-4502022 Ford F-550+ 154 moreAssociated Documents - May 17, 2022•Document ID: 10211955Service Bulletin/Repair InstructionsENGINE AND ENGINE COOLING
- Mfr Comm. #:
- 21M04
- Date Added:
- May 19, 2022
- Manufacturer:
- FORD
SummaryCertain 2011-2014 Model Year Super Duty Vehicles Equipped with a 6.7L Diesel Engine Exhaust Gas Recirculation Cooler with Diagnostic Trouble Codes P0401 and/or P2457 - In some of the affected vehicles, customers may experience an illuminated malfunction indicator light due to the EGR cooler becoming plugged with hydrocarbon or soot at high mileage. Diagnostic trouble codes (DTCâÂÂs) for EGR cooler efficiency below threshold (DTC P0401) and/or insufficient EGR flow at idle (DTC P2457) are stored when the malfunction indicator light is illuminated.
Associated Products (16)Associated Documents - March 24, 2022•Document ID: 10209384Service Bulletin/Repair InstructionsEQUIPMENT; POWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE:SOFTWARE; ENGINE AND ENGINE COOLING
- Mfr Comm. #:
- SSM 50636
- Date Added:
- March 29, 2022
- Manufacturer:
- FORD
Summary2011-2022 F-Super Duty and 2016-2023 F-650/F-750 vehicles equipped with a 6.7L engine may exhibit an elevated idle condition. During prolonged idle time, vehicles may experience this elevated idle to reduce unburned hydrocarbons from the SCR. The powertrain control module estimates hydrocarbon levels in the SCR and may increase idle speed to remove them. Idle speed will be increased to 1000 RPM for ambient temperatures near 26°C (80°F) and may increase to 1200 RPM at -40 °C (-40°F). Vehicles may exhibit exhaust smoke and diesel exhaust fluid smell during elevated idle condition. Exhaust smoke and smell condition will not affect reliability or durability of the engine. Power take-off (PTO) use and idle set point control will disable elevated speed. It is required that the operator monitor the vehicle and adhere to any Exhaust Filter warning messages.
Associated Products (64)2023 Ford F-6502023 Ford F-7502022 Ford F-2502022 Ford F-3502022 Ford F-4502022 Ford F-5502022 Ford F-6502022 Ford F-7502021 Ford F-2502021 Ford F-3502021 Ford F-4502021 Ford F-5502021 Ford F-6502021 Ford F-7502020 Ford F-2502020 Ford F-3502020 Ford F-4502020 Ford F-5502020 Ford F-6502020 Ford F-750+ 44 moreAssociated Documents - January 14, 2022•Document ID: 10206863Service Bulletin/Repair InstructionsENGINE AND ENGINE COOLING
- Mfr Comm. #:
- 21M04
- Date Added:
- February 4, 2022
- Manufacturer:
- FORD
SummaryCustomer Satisfaction Program 21M04 Certain 2011-2014 Model Year Super Duty Vehicles Equipped with a 6.7L Diesel Engine Exhaust Gas Recirculation Cooler with Diagnostic Trouble Codes P0401 and/or P2457
Associated Products (16)Associated Documents - January 11, 2022•Document ID: 10206862Service Bulletin/Repair InstructionsENGINE AND ENGINE COOLING
- Mfr Comm. #:
- 21M01
- Date Added:
- February 4, 2022
- Manufacturer:
- FORD
SummaryCustomer Satisfaction Program 21M01 Certain 2013-2016 Model Year F-250-F-550 Vehicles Equipped with a 6.7L Diesel Engine - Reductant Heater and Sender Assembly Repair
Associated Products (16)Associated Documents - December 8, 2021•Document ID: 10205475Service Bulletin/Repair InstructionsENGINE AND ENGINE COOLING
- Mfr Comm. #:
- SSM 50330
- Date Added:
- December 26, 2021
- Manufacturer:
- FORD
SummarySome 20112014 F-Super Duty vehicles equipped with 6.7L diesel engine may experience an exhaust leak due to broken exhaust manifold studs. New parts have been released to service this condition. Replace the exhaust manifold on the side with a broken stud. On cylinders 1,2,3,5,6 and 7 use stud part number W715713-S431. If replacing the studs on cylinders 4 and/or 8 use stud part number W717172-S900 and replace both studs and install new spacers and heat shields on the affected side(s). Refer to Workshop Manual, Section 303-01. Part numbers: heat shield left side, FC3Z-9Y427-A and DC3Z-9A462-B for the right side. Spacer part number FC3Z-00810-A. Exhaust manifold part numbers: DC3Z-9430-A (right) and DC3Z-9431-A (left). Exhaust Manifold Gasket FC3Z-9448-A. Exhaust Manifold Nut W701706-S430.
Associated Products (16)Associated Documents - September 9, 2021•Document ID: 10201580Service Bulletin/Repair InstructionsPOWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE (TCM/PCM/TECM); ENGINE AND ENGINE COOLING
- Mfr Comm. #:
- SSM 50096
- Date Added:
- September 28, 2021
- Manufacturer:
- FORD
SummarySome 2013-2016 F-Super Duty vehicles equipped with a 6.7L engine may exhibit an Exhaust System Fluid Fault message and a forced idle mode with various diagnostic trouble codes (DTC) stored in the powertrain control module (PCM). A video explaining how to remove the vehicle from forced idle mode has been added to the Technical Support Videos under the Technical Assistance tab on PTS. The video can be accessed using the following web link, http://site-307934.bcvp0rtal.com/detail/videos/303---engine/video/6258842975001/2013-2016-f-super-duty-exhaust-fluid-fault-procedure.
Associated Products (16)Associated Documents