Chevrolet Corvette Complaints

5,302 consumer complaints on file.

#11700899November 21, 2025
FUEL/PROPULSION SYSTEM
cracked fuel pump housing causing vapors to vent out possibly causing a fire if stored extended periods of time indoors, and if crack is big enough fuel will drip down the back of the fuel tank onto the exhaust and possibly starting a vehicle fire
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11699673November 16, 2025
FUEL/PROPULSION SYSTEM
Known Fuel Tank crack GM Memo "Special Coverage Adjustment 17469 Fuel Leaks at the Primary Fuel Pump Module Flange", whose previous warranty extension has expired and shouldn't be! GM assumes no responsibility for notifying vehicle owners who purchased used vehicles from non-dealers, which is what I did. I never received any notices about this leak from them since 2018, when I bought the vehicle used from a non-GM dealer. I just recently discovered the leak and had it repaired for $ 5,300.00. I had been driving a vehicle that could have exploded for over 7 years and did not know it. There must be others who are still driving these without knowing. Below is my request to GM to reconsider their 'not covered' response to my email. I suggest that a known Special Coverage Adjustment 17469 Fuel Leaks at the Primary Fuel Pump Module Flange of the gas tank is a life-threatening issue and should never expire! Especially, since many of us bought these vehicles used, 2018 in my case, and have NEVER received any notifications from dealers or GM about this issue. How many others are still outstanding and could blow someone up? The pictures below were taken at my Watson Chevrolet dealer in Tucson, AZ this month, which shows that the crack is exactly what was outlined in your publication 17469, that I never received. Total bill was $5,330.89 (copy attached). I am asking GM to reimburse me for this horrible adventure, not to mention the danger that I've been in for these many years. While I should have detected this issue sooner, how was I to know? I finally gave a friend a ride who said she smelled a really bad gas odor, which led me to the dealer! Now, GM says "you're too late" for us to cover our known defect? Again, this is a life-threatening issue, and your warranty should never expire!
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11699586November 15, 2025
FUEL/PROPULSION SYSTEM
Transmission gets stuck in park position and I am unable to shift it into any other gear. Unable to move the car if it's in a dangerous location.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11697148November 3, 2025
UNKNOWN OR OTHER
Water trapped under vehicle and in the doors of the vehicle!
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11695865October 27, 2025
FUEL SYSTEM, GASOLINE
The contact owns a 2025 Chevrolet Corvette. The contact received notification of NHTSA Campaign Number: 25V536000 (Fuel System, Gasoline); however, the part for the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact called a local dealer and was advised to bring the vehicle to their location, and the vehicle could remain at the dealer until the part became available to repair the vehicle. The contact declined the suggestion. The manufacturer was not informed of the issue. The contact had not experienced a failure.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11694955October 22, 2025
EQUIPMENT
The contact owns a 2014 Chevrolet Corvette equipped with Silver's North America NEOMAX coil-overs. The contact stated that while driving through a parking garage at less than 10 MPH, there was an abnormal popping sound coming from the vehicle after driving over a speed bump. The rear driver’s side of the vehicle lowered as the subframe detached from the vehicle. Due to the failure the vehicle remained stuck in the parking garage because the vehicle could not be towed out of the parking garage. The contact also stated that the vehicle could not be moved without causing further damage to it. The contact stated that the vehicle became an obstruction to the other motorist entering the parking garage. The manufacturer was notified of the failure, and an agent attempted to assist the contact; however, the agent stated that any attempts to move the vehicle could be dangerous and cause more damage to the vehicle. The part was not yet replaced. The failure mileage was approximately 6,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11694731October 21, 2025
FUEL/PROPULSION SYSTEM
Bought this vehicle recently and filled it up with fuel and fumes overtook the cabin area and some leaked out the top of the tank down through the tank support. From the research I have done, this is a common problem that Chevy has ignored. The parts are too expensive to just replace everything with new.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11694194October 17, 2025
FUEL SYSTEM, GASOLINE
The contact owns a 2023 Chevrolet Corvette. The contact received notification of NHTSA Campaign Number: 25V536000 (Fuel System, Gasoline); however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was made aware of the issue and confirmed that parts were not yet available. The manufacturer was made aware of the issue and confirmed that parts were not yet available. The contact had not experienced a failure.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11693431October 14, 2025
FUEL/PROPULSION SYSTEM, ENGINE
On August 1st, my '24 Z06 unexpectedly caught fire after a short evening of driving — 7 miles to dinner, 7 miles to a store, then 2 miles to drop my wife off at the grocery store. I was heading to refuel when the fire started. The car was in Sport Mode, so the fans were running. Thankfully, we were able to put it out. GM sent three inspectors, including an independent expert who noted that most fire cases he sees result in the car being reduced to a blob. On August 28, Scott Bell (VP of Global Chevrolet) told our dealer he would expedite a replacement. We placed the order — but the following week, GM reversed course, claiming the fire was caused by "non-car material" and not their responsibility. Meanwhile, our insurance company determined the fire originated from the gas vent system. They’ll cover the damage ($9,000), but not the cause — leaving us to pay $1,000 out-of-pocket for the vent system. No safety lights were indicated while driving, or even after the fire (it still starts). The car is in the process of being repaired, so probably no longer available to inspect. I, as the insurance company, believe this is related to the recall on this car
Crash:
No
Fire:
Yes
Injuries:
0
Deaths:
0
#11693301October 14, 2025
WHEELS
When having the stock tires changed to all-season tires, the technician found a rear wheel with 2 cracks in the inside bead area. Car had about 8500 miles and an inspection of the old tires showed no damage to the tread or sidewall. No leaking had been noted.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11693203October 13, 2025
ELECTRICAL SYSTEM, STEERING
I would be driving and get a notification in the panel that says power steering is out and to drive with care. It is extremely difficult to drive my vehicle, with no power steering. I would just be driving, and I would get the notification that power steering is out. The problem has been recently confirmed by a dealership. The mechanic at the dealership confirmed it was the same issue reported for the 2017 Chevrolet Corvette (N182182760). The first appearance of the issue was at 3800 miles on my 2016 Chevrolet Corvette. I was sitting at a red light, and the notification came on and said I didn't have power steering. The second time I was driving down the interstate at 70mph and it went out, not good. I was able to get it safely back to my sister's home and did not move it again until I took it straight to the dealership today, in which time it went out again. All this with 4085 total miles on my car at this time. I believe this should be covered under the same recall as the 2017 Chevrolet Corvette. My vehicle is available for inspection if someone would like to come out.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11693156October 13, 2025
FUEL/PROPULSION SYSTEM
2006 Corvette convertible. Has a strong gas smell after filling up. I understand this is a common problem, but Chevrolet will not acknowledge it. The gas can drip down on the hot exhaust system, and start a fire, burning down our house, or out on the road with us in it! Please help us get this deadly problem resolved, with little expense heaped upon us. Thank you, [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11693052October 13, 2025
POWER TRAIN, VEHICLE SPEED CONTROL
On 10/13 after refuling my 2023 Chevy Corvette. I was cruising on a freeway when the car started showing signs of staying in 5th gear. The rev limiter was going from 500 to 2500 rpm rhythmically at a cruising speed of 65mph. At this time, I noticed the loss of response from the gas pedal. The car was then placed in manual shifting mode so that i can attempt to regain population control and maintain the flow of traffic as this was a high crash area. Unfortunately, this attempt did not work and the dash cluster illuminated with the following alerts "rear axil system offline" "idle creep disabled," "service transmission" at this time. The gear indicator on the dash that shows the mode and gear, for example: D3 (drive 3rd gear), completely disappeared and the gas pedal completely went unresponsive. At this point i used the momentum of the car in motion to exit off of the freeway into a parking center. The vehicle proceeded to not respond in regards to going into park, reverse, or drive. The only thing that worked was the electronic parking brake. This was a very scary situation that, without my federal law enforcement driving training I may not have coasted safely out of traffic.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11692236October 9, 2025
FUEL/PROPULSION SYSTEM
Fuel pump feeder is known to be a major issues on these cars. These should be a safety recall with no explanation. Feeder fitting tends to crack overtime. Recently purchased and wasn’t aware of that previous recall which the previous owner didn’t handle.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11692326October 9, 2025
FORWARD COLLISION AVOIDANCE: AUTOMATIC EMERGENCY BRAKING
As I'm driving, the brakes are deployed "hard" without any action on my part. "CHECK ACTIVE HANDLING SYSTEM" shows up on the screen. I have not het had the vehicle inspected.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11692336October 9, 2025
UNKNOWN OR OTHER
Sometimes (intermittently), when I push the start button to start the car, it just makes a "click" sound, the car does not start and the steering wheel will lock and all other functions of the car will be disabled. "CHECK COLUM LOCK" will be displayed on the screen. I have to take a battery cable off to reset the software before I can once again start and drive the car.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11691306October 3, 2025
FUEL/PROPULSION SYSTEM
There is a strong smell of gas in the passenger compartment and a very strong smell of gas gas on the drivers side near the rear tire. The Chevy dealer has confirmed the the gas smell is due to a know defect where the fuel pump develops cracks in the housing because of the poor quality plastic used. The dealer estimates that it will cost between $3,000 to $4,000 to repair. This is a very dangerous problem. I'm afraid with the very strong smell of gas that an electric spark might cause the car to explode or when it's stored inside cause a vehicle and structure fire. Why has the NHTSA not made GM do a recall for this defect. It is a very serious problem. Owners of any C6 corvette are sitting on a time bomb and their life is in danger. GM has already admitted that it is a design defect but has only issued a service bulletin. Do something before people die.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11691017October 2, 2025
FUEL/PROPULSION SYSTEM
Per recall NHTSA ID Number: 25V536000 GM dealers still have No notice of this recall and known corrective actions to fix this fire risk. I’ve called several local dealerships in my area for the past several weeks to have vehicle repaired with zero help! These dealerships had to stop the sales of their z06/zr1 inventory until this issue was resolved which they have because they are now selling them but keep stating NO notice from GM is on file of corrective action to resolve fire risk on the vehicles privately owned that are affected.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11689471September 24, 2025
POWER TRAIN:AUTOMATIC TRANSMISSION:TORQUE CONVERTER, VEHICLE SPEED CONTROL:ACCELERATOR PEDAL
The contact owns a 2016 Chevrolet Corvette. The contact stated that while depressing the accelerator pedal, the vehicle hesitated while shifting from second gear to third gear. The transmission was skipping a gear. The contact believed that the vehicle was not working properly. The vehicle was not responding as needed. There were no warning lights illuminated. The vehicle was taken to the local dealer, where it was diagnosed with torque converter failure. The dealer contacted the surveyor for the protection plan approval. The vehicle was not repaired. The manufacturer was not contacted. The contact called the attorney general and was referred to the NHTSA Hotline. The approximate failure mileage was 33,025.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11689542September 24, 2025
WHEELS
Two of the wheels of my 2019 Corvette have cracked. GMC has turned this issue over to Analytics Consulting LLC to reimburse those owners that have had a problem with cracked wheels. I submitted a claim for one of the wheels, in July of 2025 and have yet to hear from them. In the mean time I had another wheel crack but I can not claim that one because it's beyond the date they set. I contacted GMC and their response was they couldn't do anything for me. My point in this whole matter is that I've had two wheels crack but I still have two that might crack. GMC admits to defective wheels and yet there was never a recall. They are playing Russian roulette with Corvette wheels that are on the road daily. I've had costly repair bills for wheels that were defective when GMC put them on my car. These wheels could crack at any point while I'm driving or God forbid when my wife is driving. She doesn't want to ride in the car anymore because she feels it's unsafe. I can't sell it because I would have to affirm that these wheels might crack. Who would buy my car? The value of my dream car has plummeted. I'd like reimbursed for the two I've already paid for and all four wheels replaced with wheels that have been tested and new ones that are proven to be safe. Is it too much to ask GMC to build safe cars? They say it is important to them that the customer satisfaction and safety is utmost. I'm asking them to live up to that so I need your help to see that they do.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Chevrolet Corvette