Ram 3500 Complaints

2,367 consumer complaints on file.

#11604331July 24, 2024
SERVICE BRAKES, AIR:ANTILOCK:ABS WARNING LIGHT, TRACTION CONTROL SYSTEM, VEHICLE SPEED CONTROL:CRUISE CONTROL
The contact owns a 2018 Ram 3500. The contact stated that while operating the vehicle, the ABS and traction control warning messages were displayed, and the cruise control feature became inoperable. The cause of the failure was not yet determined. The manufacturer and local dealer were not yet notified of the failure. The failure mileage was 6,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11603149July 18, 2024
SERVICE BRAKES
ABS and HCU are defective , loss of braking ability in the vehicle and braking ability on the travel trailer. unable to stop in adequate distance when pulling 12000 pounds through mountains putting others at risk of collision had vehicle in for repairs three different times since 2019 ABS light luminates when system fails had vehicle in for repairs on 10/19/2020 , 2/5/2021, 6/20/2024, 7/18/2024
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11603222July 18, 2024
SERVICE BRAKES, VEHICLE SPEED CONTROL
Vehicle produces code C0020-1 ABS pump motor control failure, vehicle disengaged cruise control unexpectedly causing rapid deceleration. Dealer states ongoing problem with 2018 Ram 3500 HD trucks
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11603264July 18, 2024
SERVICE BRAKES
Abs lights started flashing on and off rapidly. Had same issue fixed at dealer 40,000 miles ago and now it started again seems like a money racket or something now I’m quite scared to drive it if the brakes was to lock up it could be bad
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11602617July 16, 2024
POWER TRAIN
I placed my truck in park and got out to close the door to my hangar. I turned around and my truck was rolling forward. It rolled into a small two seat plane and pushed it into another plane causing significant damage. When I saw what was happening I ran to the truck but got to it a little too late. I went to put the truck into park, but it was already in park. This confused me a lot because this is not suppose to happen. This morning after I started my truck I tested the gear shifter and to my surprise I am able to shift the truck out of park and all the way into drive for about 1 second or more after removing my foot from the brake. You should not be able to shift a vehicle out of park when your foot is not on the brake. After this incident I have gone online and have ready about large recalls for similar issues with RAM trucks and vans. I even seen some issues posted about my same year truck. Ram had a recall that ended with year model 2018 vehicles for this, but I dont think the issue was resolved completely, or there is a different issue causing this that needs to be investigated. I took a couple videos to prove that my truck shifts out of park without the brake being depressed.
Crash:
Yes
Fire:
No
Injuries:
0
Deaths:
0
#11601637July 12, 2024
SERVICE BRAKES
Abs / hcu has malfunctioned again, has already been replaced once around 20,000 miles now I’m around 58,000 miles and having same issues. Abs and traction control not working. In a truck with this much torque it is a serious problem. This is a well documented issue with the system and FCA should make it right. I found a video on line that explains the issue is with the brushes on the motor being held in to tightly. Should be a simple solution and is obviously a design flaw. There should be a safety recall asap. I assume that this problem happens with most of the heavy duty trucks.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11601297July 11, 2024
SERVICE BRAKES, ELECTRICAL SYSTEM
ABS braking system, electronic braking system warning light and signal is coming on every few seconds when driving. This renders the cruise control to shut off when it comes on. There are numerous safety issues with this coming on and off not to mention it is annoying as…..well let me just leave it there. Have talked to dealers (2) and have been told that dodge has a fix but the parts are still on back order. I have been having this issue for about 6 to 7 months and it is making the truck undrivable for any distance at all due to the nuisance alarm every mile or so.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11601315July 11, 2024
POWER TRAIN
Transmission had 2 loud clunk, while stopped, and shifting into drive, lost all forward gears. Reverse works. Truck has 17000 miles.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11600466July 9, 2024
ENGINE
The contact owns a 2016 Ram 3500. The contact stated while driving at an undisclosed speed and towing a horse trailer with horses inside, there was a message displayed that the vehicle would enter LIMP Mode. The contact was able to drive a short distance to the destination. The vehicle was taken to a local dealer where it remained undiagnosed and unrepaired. The manufacturer was made aware of the failure. The failure mileage was approximately 60,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11600141July 8, 2024
ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL:GAS RECIRCULATION VALVE (EGR VALVE)
The contact owns a 2017 Ram 3500. The contact stated while driving 40-45 MPH, the vehicle started shuddering. An unknown warning light was illuminated. The contact continued driving uphill and the vehicle stalled. The vehicle failed to restart. The contact was able to push the vehicle to the side of the road with assistance. The vehicle was towed to an independent mechanic, where it diagnosed that the emission control system had failed. The mechanic replaced the EGR cooler, the EGR valve and the temperature sensor. Additionally, the mechanic performed other unknow repairs. The vehicle was repaired out-of-pocket. The local dealer was notified of the failure. The contact stated that she had received an unknown recall notification related to the failure. The manufacturer was contacted for reimbursement; however, the reimbursement claim was denied. The manufacturer was notified of the failure. The failure mileage was unknown.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11600146July 8, 2024
ELECTRICAL SYSTEM, VEHICLE SPEED CONTROL, FORWARD COLLISION AVOIDANCE: ADAPTIVE CRUISE CONTROL
ABS system - flashes on and off dash, ABS has been inspected by dealership. Dealership said, could replace ABS but it could very likely have the same issue due to part malfunction. This malfunction causes- no cruise control, no traction control, sounding and lighting up on dash constantly.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11599873July 7, 2024
FORWARD COLLISION AVOIDANCE: AUTOMATIC EMERGENCY BRAKING
Pulling a travel trailer in the mountains on vacation this month my Service ABS light started coming on and off intermittently and the alarm would sound each time. Each time my cruse control would turn off and I wasn't sure if my emergency ABS brakes were going to work, or not, if I needed them to pulling my trailer with my wife in the truck. I was 1,500 mile away from home and this created a stressful circumstance for me the rest of the trip. Upon arriving home, I discovered on the web that this is a know problem with Dodge RAMs of this year model. I also saw recall notices associated with 2018 models, just one year younger than mine with the exact same symptoms. Obviously, this problem didn't get fixed for the 2018 model year. I am quite concerned that my truck may not be safe and the ABS problem needs to be addressed. I am going to pay to have it fixed, but I feel confident that a recall notice needs to be executed, and executed NOW so others dont't have to die from a problem that was known and unaddressed. Thank you. [XXX] [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11599516July 6, 2024
SERVICE BRAKES
Abs service light stays on and dings. service electronic brake..
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11598550July 3, 2024
SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP:ABS WARNING LIGHT
The contact owns a 2017 Ram 3500. The contact stated while driving approximately 10 MPH and coming to a stop, the brake pedal felt abnormally loose, causing the braking distance to be extended. The ABS and traction control warning lights were illuminated. The vehicle was taken to a local dealer where it was diagnosed that the ABS control sensor and ABS control module needed to be replaced. The vehicle was repaired. The contact stated that several weeks later the message "Trailer Brake Connected - Go to Vehicle Settings - Check Vehicle Wiring" was temporarily displayed. The manufacturer was made aware of the failure, but no assistance was provided. The failure mileage was approximately 26,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11597836June 30, 2024
SERVICE BRAKES
The message “service electronic braking system” and service antilock brake system” periodically displays on the driver information screen. If I’m using cruise control when the message comes on the cruise control abruptly disengages causing a lurching slowdown. Often times it chimes and the message displays and disappears and comes back on and off numerous times.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11596807June 26, 2024
TIRES:TREAD/BELT, TIRES:BEAD
Tire Size: LT235/80R17. Tire installed [XXX]. Tire Dated Stamp: 4619. Mileage on tire: Approx 23K. Vehicle: 2017 Ram 3500 Laramie Longhorn Dually w/6.7L Diesel. Road Surface: Smooth. Hazards: none. Weather Condition: Excellent. Front right tire blow out occurred on [XXX] approx 10 miles east of Leesville LA. No indication of tire failure prior to blow out. Initial tire inflation was 80 PSI. Approx $8k damage to front right fender area. Front tires were rotated and balanced annually. Vehicle was traveling at 65MPH pulling a 20 ft empty cargo trailer. Contacted Goodyear and shipped them the tire for analysis, Goodyear File #[XXX]. Goodyear stated: "Tire condition occurred dure to an impact causing overdeflection of the tire and a fracture of the steel belt package, and/or fabric piles and/or line. No workmanship or material related condition contributed to the initial air loss." I have the tire in question. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11596921June 26, 2024
WHEELS
The contact owns a 2015 Ram 3500. The contact stated while driving 35-40 MPH, the vehicle started wiggling and wobbling abnormally. The contact was able to pull to the side of the road, where he noticed that the outer rear wheel had separated from the vehicle. Additionally, the contact noticed that the inner rear wheel had separated and pinched the axle, causing the wheel to support the vehicle. The vehicle was towed to the dealer, where an assessment was made. The dealer determined that the wheel studs needed be replaced under NHTSA Campaign Number: 21V398000 (Wheels); however, the wheel replacement was not covered. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 183,901.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11596982June 26, 2024
POWER TRAIN
On June 5th, 2024 while pulling a travel trailer on vacation, we stopped for a short break and left the truck running. When we went to get back on the highway, I put the truck in gear and nothing happened. Truck would only shift into reverse with a violent bang. Would not go forward. Unhooked my trailer and shifted into REVERSE a few times and finally got the truck to inch forward at HIGH RPM. Towed to a Ram dealer and they confirmed a snap ring failure caused the forward clutches to go out. Truck is still awaiting repairs 445 miles from home.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11596517June 25, 2024
SERVICE BRAKES
It appears that Ram years 2017-2018 have a known problem with the ABS pump. I have my 3500 ram in the shop now with only 30,000 miles and they are telling me the ABS pump needs to be replaced at a cost of roughly $1200.00. It is my understanding that there is a class action lawsuit and wondering why these vehicle have not been re-called? Major safety issue!
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11596178June 24, 2024
SERVICE BRAKES
Vehicle was purchased used in Feb 2024 with 77000 miles. As I was leaving the dealer (Carmax), gauge cluster lit-up with Service ABS System and chimes. Spoke with dealer and they said to take it to Ram Dealer for diagnosis. Unit was diagnosed as needing a new ABS electronic AND hydraulic control module. Dealer was unable to get parts due to issues with FCA and parts not being available. Parts were on backorder until June 204. Continued driving vehicle, with ABS light coming on/off and ABS intermittently working and not. In June 2024, spoke to Ram Dealer, and FCA is saying I have to get the Electronic module replaced first. Ram Dealer replaced this on Friday 6/21/24 and things seemed fine. About 50 miles after picking up the truck (Saturday the 22nd), while towing my 20000 pound trailer (with my wife/kid/dog inside) the vehicle started losing power while on the freeway. I was able to get the vehicle to the shoulder and the hydraulic brakes on the truck were fully locked up. I had to put the vehicle in 4-lo to overcome the brakes to get the truck separated from the trailer so it could be towed to the dealership. The dealer has 3 other 2018 ram trucks on their lot with the same issue.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Ram 3500