Ford F-150 Service Bulletins (2023)
378 manufacturer communications on file.
- June 19, 2025•Document ID: 11020160Over The AirFORWARD COLLISION AVOIDANCE: ADAPTIVE CRUISE CONTROL; ELECTRICAL SYSTEM; LANE DEPARTURE: WARNING; LANE DEPARTURE: ASSIST
- Mfr Comm. #:
- SYNC-25.2.1.6.5 F-150
- Date Added:
- July 3, 2025
- Manufacturer:
- FORD
SummaryQuality improvements include: -Improved CarPlay experience -BlueCruise enhancements
Associated Products (2)Associated Documents - June 9, 2025•Document ID: 11019421Service Bulletin/Repair InstructionsPOWER TRAIN
- Mfr Comm. #:
- TSB 25-2246
- Date Added:
- June 10, 2025
- Manufacturer:
- FORD
SummaryThis article supersedes TSB 25-2165 to update the labor operation allowance and update the Service Procedure. Some of the vehicles listed in the Model statement above may exhibit an illuminated malfunction indicator lamp (MIL) with diagnostic trouble code (DTC) P2450 stored in the powertrain control module (PCM). This may be due to the software level of the PCM.
Associated Products (5)Associated Documents - June 5, 2025•Document ID: 11019494Service Bulletin/Repair InstructionsPOWER TRAIN
- Mfr Comm. #:
- SSM 53878
- Date Added:
- June 11, 2025
- Manufacturer:
- LINCOLN
SummarySome 2021-2025 Expedition/Navigator and 2021-2025 F-150 non-Lightning/non-PowerBoost vehicles may exhibit a rattle/scraping noise from the bellhousing area on start-up. This may be due to the torque converter studs contacting the engine to transmission spacer plate (separator plate). To correct this condition, inspect the engine to transmission spacer plate and torque converter studs for wear/damage. If wear/damage is found, replacement of the torque converter is not necessary. Replace only the engine to transmission spacer plate. Refer to Workshop Manual (WSM) Section 303-01 > Engine to Transmission Spacer Plate for full spacer plate removal and installation. When reinstalling the starter motor, make sure the starter is flush with the engine to transmission spacer plate prior to tightening the studbolts. Failure to do so may result in damaging the newly installed engine to transmission spacer plate.
Associated Products (15)Associated Documents - June 2, 2025•Document ID: 11019418Service Bulletin/Repair InstructionsPOWER TRAIN
- Mfr Comm. #:
- TSB 25-2236
- Date Added:
- June 10, 2025
- Manufacturer:
- FORD
SummaryThis article supersedes TSB 25-2155 to add labor time for F-150 Lightning. Some of the vehicles listed in the Model statement above may exhibit at least one of the following conditions: * "Active Air Dam System Fault See Manual" warning message in the instrument panel cluster (IPC) * Diagnostic trouble code (DTC) C0604:00 stored in the PCM This may be due to the software level in the powertrain control module (PCM).
Associated Products (3)Associated Documents - June 2, 2025•Document ID: 11018782Service Bulletin/Repair InstructionsPOWER TRAIN
- Mfr Comm. #:
- TSB 25-2229
- Date Added:
- June 2, 2025
- Manufacturer:
- FORD
SummaryThis article supersedes TSB 23-2429 to change the labor operation from actual time to fixed time. Some vehicles listed in the Model statement above may exhibit an illuminated powertrain malfunction (wrench) indicator with diagnostic trouble code (DTC) P084B stored in the powertrain control module (PCM). This may be due to the software level of the PCM. To correct this condition, perform the Service Procedure below to reprogram the PCM to the latest software level via the Ford Diagnosis and Repair System (FDRS).
Associated Products (3)Associated Documents - May 30, 2025•Document ID: 11018783Service Bulletin/Repair InstructionsPOWER TRAIN
- Mfr Comm. #:
- TSB 25-2233
- Date Added:
- June 2, 2025
- Manufacturer:
- FORD
SummaryThis article supersedes TSB 24-2124 to change the labor operation from actual time to fixed time. Some of the vehicles listed in the Model statement above may exhibit an illuminated MIL with diagnostic trouble codes (DTCs) P0420 and/or P0430 stored in the powertrain control module (PCM). This may be due to calibration and controls sensitivity.
Associated Products (2)Associated Documents - May 15, 2025•Document ID: 11019220Over The AirUNKNOWN OR OTHER
- Mfr Comm. #:
- 25-SYNC-25.2.1.6.5 F-150
- Date Added:
- June 5, 2025
- Manufacturer:
- FORD
Summary"Quality improvements include: -Improved CarPlay experience"
Associated Products (2)Associated Documents - May 15, 2025•Document ID: 11018526Service Bulletin/Repair InstructionsVISIBILITY/WIPER
- Mfr Comm. #:
- TSB 25-2201
- Date Added:
- May 21, 2025
- Manufacturer:
- FORD
SummarySome of the vehicles listed in the Model statement above equipped with one-touch up/down front windows may exhibit a window not responding to one-touch controls, not opening all the way and/or bouncing back when using the one-touch close function. This may be due to a calibration parameter in the driver door module (DDM) and/or passenger door module (PDM).
Associated Products (5)Associated Documents - May 13, 2025•Document ID: 11018521Service Bulletin/Repair InstructionsENGINE; POWER TRAIN
- Mfr Comm. #:
- SSM 53764
- Date Added:
- May 21, 2025
- Manufacturer:
- LINCOLN
SummarySome 2020 Continental, 2020-2024 Edge/Nautilus, 2020-2025 Explorer/Aviator/Escape/Corsair/F-150/F-Super Duty/Ranger/Transit/E-Series, 2021-2025 Bronco, and 2022-2025 Maverick vehicles may require an engine cooling system flush to be performed for various concerns. Workshop Manual (WSM), Section 303-03 has been updated to eliminate the need to remove and install the radiator assembly to perform a radiator flush.
Associated Products (65)2025 Ford Bronco2025 Ford E-3502025 Ford E-4502025 Ford Escape2025 Ford Expedition2025 Ford Explorer2025 Ford F-1502025 Ford Maverick2025 Ford Mustang2025 Ford Ranger2025 Ford Transit2025 Lincoln Aviator2025 Lincoln Corsair2024 Ford Bronco2024 Ford E-3502024 Ford E-4502024 Ford Edge2024 Ford Escape2024 Ford Expedition2024 Ford Explorer+ 45 moreAssociated Documents - May 6, 2025•Document ID: 11018318Service Bulletin/Repair InstructionsPOWER TRAIN
- Mfr Comm. #:
- TSB 25-2165
- Date Added:
- May 14, 2025
- Manufacturer:
- FORD
SummarySome of the vehicles listed in the Model statement above may exhibit an illuminated malfunction indicator lamp (MIL) with diagnostic trouble code (DTC) P2450 stored in the powertrain control module (PCM). This may be due to the software level of the PCM.
Associated Products (5)Associated Documents - May 1, 2025•Document ID: 11018197Service Bulletin/Repair InstructionsUNKNOWN OR OTHER
- Mfr Comm. #:
- TSB 25-2142
- Date Added:
- May 8, 2025
- Manufacturer:
- FORD
SummaryThis article supersedes TSB 24-2442 to update the service procedure Some 2021-2024 F-150 vehicels equipped with a 3.5L PowerBoost engine, may exhibit at least one of the following conditions: * "12V Battery State of Charge Low" message displayed in the instrument panel cluster (IPC) * "Charging System Service Soon" message displayed in the IPC * "Remote Features Disabled To Preserve Battery" in FordPass * DTC B11D9:09 stored in the body control module (BCM) * Center display screen message of "System Off To Save Battery" * No crank/no start condition and or a discharged 12v battery This may be due to an erroneous calculation of battery state of charge (SOC) by the battery monitoring system (BMS), the software in the air conditioning control module (ACCM) and/or the software in the transfer case control module (TCCM).
Associated Products (4)Associated Documents - April 26, 2025•Document ID: 11017335Service Bulletin/Repair InstructionsUNKNOWN OR OTHER
- Mfr Comm. #:
- TSB 25-2155
- Date Added:
- April 30, 2025
- Manufacturer:
- FORD
SummaryThis article supersedes TSB 24-2404 and TSB 23-2126 to change the labor operation from actual time to fixed time. Some of the vehicles listed in the Model statement above may exhibit at least one of the following conditions: * "Active Air Dam System Fault See Manual" warning message in the instrument panel cluster (IPC) * Diagnostic trouble code (DTC) C0604:00 stored in the PCM This may be due to the software level in the powertrain control module (PCM).
Associated Products (3)Associated Documents - April 11, 2025•Document ID: 11017055Service Bulletin/Repair InstructionsUNKNOWN OR OTHER
- Mfr Comm. #:
- TSB 25-2144
- Date Added:
- April 16, 2025
- Manufacturer:
- FORD
SummarySome of the vehicles listed in the Model statement above may exhibit one or more of the following conditions that lead to needing to perform the calibration (alignment) procedure on exhaust tailpipe actuators: * An illuminated malfunction indicator lamp (MIL) and an Exhaust mode not available message in the instrument panel cluster (IPC) with diagnostic trouble codes (DTCs) P26FE, P2BFB, P26C5:78, and/or P2BF8:78 stored in the powertrain control module (PCM) * A condition/symptom that requires the installation of an exhaust tailpipe actuator when undergoing normal diagnosis and repair * Exhaust tailpipe actuators failing alignment procedure after installation with parameter identification (PID) "EFCV_A_MON_STAT" and/or PID "EFCV_B_MON_STAT" reading "3" * No audible difference in exhaust tone when transitioning between exhaust modes These exhaust tailpipe actuators require alignment after installation. These vehicles may require an update to the PCM prior to attempting exhaust tailpipe actuator alignment.
Associated Products (3)Associated Documents - April 8, 2025•Document ID: 11017061Service Bulletin/Repair InstructionsUNKNOWN OR OTHER
- Mfr Comm. #:
- SSM 53602
- Date Added:
- April 16, 2025
- Manufacturer:
- FORD
SummarySome 2022-2025 Ford or Lincoln vehicles may exhibit DTCs B142E:78, B1432:78, and/or B1433:54 diagnostic trouble codes (DTCs) in the CCM. This may be due to non-factory sized tires that may cause inaccurate speedometer readings that can impact the functionality of the CCM. When a vehicle is modified in this manner, replacement or realignment of the CCM may impact the normal operation of the system and/or performance of radar and camera-based features. Repair or replacement of the CCM when a vehicle is equipped with non-factory size tires may not be warrantable and subject to chargeback.
Associated Products (20)2025 Ford Bronco2025 Ford F-1502025 Ford Maverick2025 Ford Mustang2025 Ford Ranger2024 Ford Bronco2024 Ford F-1502024 Ford Maverick2024 Ford Mustang2024 Ford Ranger2023 Ford Bronco2023 Ford F-1502023 Ford Maverick2023 Ford Mustang2023 Ford Ranger2022 Ford Bronco2022 Ford F-1502022 Ford Maverick2022 Ford Mustang2022 Ford RangerAssociated Documents - April 7, 2025•Document ID: 11016927Service Bulletin/Repair InstructionsUNKNOWN OR OTHER
- Mfr Comm. #:
- TSB 25-2124
- Date Added:
- April 9, 2025
- Manufacturer:
- FORD
SummaryThis article supersedes TSB 25-2080 to remove the side obstacle detection control module C (SODCMC) in the Issue statement, Action statement and Service Procedure and update the causal part
Associated Products (4)Associated Documents - April 4, 2025•Document ID: 11016915Service Bulletin/Repair InstructionsUNKNOWN OR OTHER
- Mfr Comm. #:
- SSM 53569
- Date Added:
- April 9, 2025
- Manufacturer:
- FORD
SummarySome 2021-2025 Ford and Lincoln vehicles may exhibit diagnostic trouble code (DTCs) U2100 and/or U3002 stored in the cruise control module (CCM), side obstacle detection control module LH (SODL), side obstacle detection control module RH (SODR), side obstacle detection control module C (SODCMC) and/or side obstacle detection control module D (SODCMD) after a module replacement.
Associated Products (25)2025 Ford Bronco Sport2025 Ford Escape2025 Ford Explorer2025 Ford F-1502025 Ford Maverick2025 Ford Mustang2025 Ford Ranger2025 Lincoln Aviator2025 Lincoln Corsair2024 Ford Escape2024 Ford Expedition2024 Ford F-1502024 Ford Mustang2024 Ford Ranger2024 Lincoln Corsair2024 Lincoln Navigator2023 Ford Escape2023 Ford Expedition2023 Ford F-1502023 Lincoln Corsair+ 5 moreAssociated Documents - April 3, 2025•Document ID: 11016924Service Bulletin/Repair InstructionsUNKNOWN OR OTHER
- Mfr Comm. #:
- TSB 25-2089
- Date Added:
- April 9, 2025
- Manufacturer:
- FORD
SummarySome of the vehicles listed in the Model statement above may exhibit tailgate applique poor adhesion. This may be due to poor tape adhesion between the applique.
Associated Products (3)Associated Documents - April 1, 2025•Document ID: 11016853Service Bulletin/Repair InstructionsUNKNOWN OR OTHER
- Mfr Comm. #:
- SSM 53559
- Date Added:
- April 8, 2025
- Manufacturer:
- FORD
SummarySome 2021-2025 F-150 vehicles equipped with the rear parking aid feature may exhibit all of the following conditions:<br /> * A rear parking aid alarm activation when in reverse and no rear obstacles are present<br /> * No diagnostic trouble codes (DTCs) stored in the image processing module A (IPMA)<br /> The Workshop Manual (WSM) has recently been updated to address this condition. Refer to the WSM, Section 413-13A Parking Aid - Vehicles With: Front Parking Aid/Rear Parking Aid > Diagnosis and Testing > Parking Aid > Pinpoint Test R: Continuous Or Intermittent Tone When No Obstacles Or Fault Codes Are Present.
Associated Products (5)Associated Documents - March 26, 2025•Document ID: 11016457Over The AirUNKNOWN OR OTHER
- Mfr Comm. #:
- 25-OTA DDM-25.12.0 F-150
- Date Added:
- April 3, 2025
- Manufacturer:
- FORD
SummaryQuality improvements include: -Enhanced window operation by addressing bouncebacks and loss of one touch up feature
Associated Products (2)Associated Documents - March 26, 2025•Document ID: 11016089Service Bulletin/Repair InstructionsUNKNOWN OR OTHER
- Mfr Comm. #:
- SSM 53530
- Date Added:
- March 31, 2025
- Manufacturer:
- FORD
SummarySome 2021-2025 Ford vehicles may exhibit a condition where heated/cooled seats, heated steering wheel and/or front/rear defrost features will not turn on after a remote start is performed through the FordPass application or the key fob.
Associated Products (8)Associated Documents