Ford Bronco Complaints

938 consumer complaints on file.

#11580054March 29, 2024
TIRES
The contact owns a contact owns a 2023 Ford Bronco equipped with Continental Tires, Tire Line: ProContact, Tire Size: 225/65/R17, DOT Number: IP50GBV3K. The contact stated that while driving approximately 20 MPH, the contact heard a loud booming sound. The contact stated that after stopping and inspecting the vehicle, it was discovered that the rear driver’s side tire had experienced a blowout and the tire was flat. The cause of the failure was not yet determined. The local dealer was notified of the failure. The manufacturer was not yet contacted. The failure mileage was 15,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11579763March 27, 2024
STEERING, UNKNOWN OR OTHER
I customer Ordered 2023 Bronco from Ford in 1/2023. It was delivered on [XXX]. I paid for vehicle in full. Upon getting in Bronco to drive home I noticed a Defective Steering Wheel with bumps all over it. They cut into my fingers. I notified Ford right then on [XXX]. I also noticed Defective knuckle punch on rear tail door of Bronco that holds Spare Tire, etc. I notified Ford. They have wasted a year lying to me by email and telephone messages telling me they are not responsible for these defects. I documented and photographed issues and had Crown Ford in Lynbrook, NY inspect vehicle and photograph issues and send them to Ford Headquarters in Michigan. Ford refuses to made repairs/corrections under a Manufacturer's Warrent or through the Lemon Law, etc. This was a brand New Factory Built and Delivered Ford Bronco. It was never on a showroom floor or test driven. It was ordered, paid, and picked up by me. I have offered to have work done and provide Ford the Receipts but they refuse to do anything to rectify the situation. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11579371March 25, 2024
POWER TRAIN, ELECTRICAL SYSTEM
The contact owns a 2023 Ford Bronco. The contact stated that upon reversing into the garage, he placed the gear shifter into park(P) and shut off the engine. Upon exiting the vehicle and approaching the home, the contact heard a loud crash and saw that the vehicle had rolled backed into the garage door. The contact initially thought the vehicle was not shifted into park(P); however, upon entering the vehicle, the contact saw that the vehicle was in park(P). The contact stated that two panels on the garage door. The vehicle was taken to the dealer and the dealer was informed of the failure. The manufacturer was also notified of the failure and the contact was referred to the NHTSA Hotline. The vehicle was not diagnosed or repaired. The failure mileage was approximately 22,700.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11579199March 24, 2024
ENGINE
My 2023 Bronco with 6k miles died without any warning back in late January 2024. Ford service dept said it was a failed catalytic converter. After it was in the shop for a 1.5 months, waiting on the back ordered part, we picked up our truck around March 10. Fast forward to today, truck has 7k miles. We were southbound on the interstate in bumper to bumper traffic heading to Disney World when the truck’s engine died, yet again. Luckily we were not traveling typical interstate speed and we safely maneuvered the vehicle to the side of the road and contacted Ford roadside assistance and a tow truck was quickly dispatched. The truck is currently sitting at a Ford dealership on a Sunday, 485 miles from home and a lot of money tied up in our vacation plans. Just thankful nobody was hurt, but waiting for this to happen a third time just to file a lemon law is reckless to customers and everyone else on the road, for that matter.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11579108March 24, 2024
ENGINE
2.7 engine failure while accelerating on to a hwy. Loss of acceleration and power. I was unable to get fully off the road. Engine was replaced under warranty only 3,636 miles on car. No warning lights prior to this failure. Once engine failed and started smoking the check engine light came on.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11578277March 19, 2024
STRUCTURE
The contact owns a 2024 Ford Bronco. The contact stated while pulling out of the driveway two days after purchasing the vehicle, the contact noticed water leaking on the rear seats through the driver’s and the passenger’s side of the roof. The vehicle was taken to the dealer, where it was determined that the water was leaking through the front seals of the roof while the vehicle was parked on an incline with the front of the vehicle facing up. The dealer informed the contact that it was a common failure, and that the vehicle needed to be parked in a different direction to prevent the failure from recurring. The vehicle was not repaired. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 35.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11576824March 12, 2024
STRUCTURE
The contact owns a 2021 Ford Bronco. The contact stated while driving 55 MPH, the contact heard an abnormal popping sound from the rear of the vehicle. When the contact stopped at his destination, he observed that the rear removable soft top had come loosened, and the plastic clips used to hold the soft top in place had fractured due to the force of the air blowing over the roof of the vehicle. The contact had not taken the vehicle to a local dealer or independent mechanic. The vehicle was not diagnosed and was not repaired. The contact stated that the failure had occurred for the second time and had been previously repaired a year prior. The manufacturer was informed of the failure. The contact researched online and related the failure to Technical Service Bulletin Number: 23-2091 Loose Exterior Fabric on Rear Window (Structure). The failure mileage was 42,725.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11576611March 11, 2024
ENGINE, POWER TRAIN
I have a 2023 Ford bronco that has the 2.3 L engine and seven speed manual transmission. It was originally purchased in January 2023. I live in Colorado so it is cold and on cold mornings, since I have received delivery of the vehicle, It has made and continues to make a grinding, scraping sound when the vehicle is in neutral, or the transmission is not engaged. The grinding, scraping sound will occur when driving in first, second, and third gear. If the weather is warm, as over last summer, it does not make the grinding, scraping sound. It has been consistently documented amongst other owners of this particular vehicle, the new sixth generation Ford bronco full-size vehicle with the 2.3 L engine and seven speed manual transmission , that these transmissions make this grinding, scraping sound. I have had it investigated by my local Ford dealership on two separate occasions, and although the tech on site at the dealership states that he can hear the grinding sound and agrees that it is an abnormal sound for a vehicle transmission to make, the Ford motor company has refused to do any type of repair or modification, or replacement of the transmission in my particular vehicle to correct the problem. However, when discussing this problem with other Ford bronco owners, Ford motor company’s response has been very irregular, one friend, in particular, has had his transmission replaced. I am very concerned that as transmissions tend to suffer with wear and tear, that should this transmission fail early due to the grinding, scraping sound, ford motor company will not replace it under warranty, stating that it was my fault or expected wear and tear, that the transmission failed early, when, in reality, it is just as likely that the early failure would be due to this abnormal, grinding, scraping sound.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11576255March 8, 2024
ENGINE, FUEL/PROPULSION SYSTEM
While driving the vehicle began to misfire and became unsafe to drive. It was towed to the local dealer where error codes confirmed that cylinder 4 had misfired. Ford was unable to duplicate the issue nor where they able to find any issues that would have caused the misfire after trouble shooting.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11576224March 8, 2024
STRUCTURE
The contact owns a 2022 Ford Bronco. The contact stated while driving at approximately 55 MPH, the driver's side windshield pillar trim separated from the vehicle. The vehicle was taken to a local dealer, where it was determined that the windshield pillar trim needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 18,880.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11576102March 7, 2024
EXTERIOR LIGHTING
I live in Northern California and we have snow. I was driving after dark about 6:30PM and it was snowing. [XXX]. I was on the freeway to head to a high school performance and picking up passengers. I was on the road about 15 minutes and I was suddenly unable to see the road, it was dark and I thought my lights went off. I pulled over, with 3 passengers to find that my headlights were covered in snow and the light was not illuminating the road. I removed the snow and was able to exit at the next offramp about a half mile ahead. I stayed on the side roads that were a bit more protected by large pine trees. I was able to make it to safely, but I was at risk, with my passengers and other vehicles on the road. Thankfully, I was able to move my car later that night to get it home when it stopped snowing. I then called Ford in Auburn the next day and they said they were not aware of this issue but would see me and made an appointment. I then looked online and found many people complaining about this on many vehicles. It stems from the fact that LED lights do not emit heat. The heat is what keeps the snow from accumulating in the first place. The lights continue to be on, but you are only able to see a small glow under the snow until there is enough snow they are not seen at all. I was at the service department today at Auburn Ford that they looked at the vehicle and then looked online and can see other people with the same issue. Ford has not addressed this issue. They suggested I try Rain X or other non stick product. They said I can call ford and place a complaint and I did that today. Case #[XXX] I was then informed that I need to make a claim with the NHTSA to have this claim reviewed. I was absolutely terrified when the road went dark and I was not able to see and I could not be seen by other cars. THIS IS A SAFETY ISSUE!! There were no warning lamps or messages, no other symptoms or failures. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11575990March 7, 2024
ELECTRICAL SYSTEM
I had a light pop up that said “charging system service soon” so we took the vehicle in for service. Once the dealership got back to us, each of the ports on the wiring harness are corroded. The vehicle is barely over 36,000 miles and I’m already being advised to change out the entire wiring harness so there almost has to be some fault in the coverage of this equipment
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11575788March 6, 2024
BACK OVER PREVENTION: WARNINGS, BACK OVER PREVENTION: REARVIEW SYSTEM BRAKING
The rear parking sensors (all of them) stopped working. Whenever the vehicle is placed in reverse a warning message is displayed on the dash. The vehicle was taken to a Ford dealer and it turns out a wire was damaged in the rear wiring loom. This was most likely due to physical damage from something hitting the wiring loom behind the right rear tire. It seems that this is poor placement/protection of the wiring loom, especially considering that this is an 'off road' vehicle (Bronco). The dealership refused to fix the problem under warranty stating that it was due to 'external' damage.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11574823March 1, 2024
ENGINE
There is a major lag in the time from when you hit the pedal to when you start accelerating, almost like a pause. Hesitation, long lag or dead spot in accelerating. Failed to accelerate from a stop at least 3 times.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11573607February 23, 2024
ENGINE
I have the same complaint that many 2021-2023 Ford Bronco owners have had in regards to the 'scraping/grinding' noise in 1st and 2nd gear. I have seen this on dozens of forums and Ford acknowledged it is an issue. I was told to bring the car in when I was ready for an oil change. This is after being a second day reservation holder and waiting 2.5 years for my car to be built. The dealership told me that the transmission was bad and I needed a new transmission. It will take 10-15 weeks to get a new transmission, and in the meantime all that was offered was a less than ideal rental car (ford edge) and to wait patiently. This is a known issue that the transmissions were faulty, Ford has not been responsive in terms of getting any help/assistance otherwise, and I am not sure if this will even fix the problem. There are hundreds of other owners who have this same issue, and Ford has done nothing.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11573451February 22, 2024
SUSPENSION
The stock bilstein shocks lost the reservoir for hydraulic fluids causing shock absorber to fail while driving. the canister simply fell off. I didn't hit anything other than normal bumps in the road. The vehicle has never been in an accident or offroad to cause the canister to fall off. Many other owners have complained on different blog sites about this same issue. This causes the vehicle to bounce uncontrollably since the shocks are rendered useless without the hydraulic canister/reservoir. Bouncing down the highway is super dangerous, and Ford didn't really seem to be worried that this is happening when I called the 800 Ford Assistance number two different times. I think a recall of these shock absorbers is required. I ended up having to pay for brand new shocks after 36,600 miles and Ford told me I had to use OEM (same bad designed shocks) to maintain my extended warranty. Please research and recall this dangerous part. Here is one forum discussing the issue. [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11573450February 22, 2024
STRUCTURE:BODY
Hard top is unlaminating around rear fixed windows at around 40000 miles ford offered to pay a portion this is not an isolated issue
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11573241February 21, 2024
POWER TRAIN
A grinding/rattling sound is coming from the manual transmission while in 1st & 2nd gear. This is a known issue with Ford, complete with its own TSB 23-2019. I took the car to my local Ford dealer, described the issue, and referenced the TSB. I was told later that the tech could not duplicate the issue. I then offered to drive and have the tech ride with me. We both agreed that it was an odd noise. The next day, I was told they didn't know what the issue was, and as far as they were concerned, the transmission was supposed to sound like that. They have otherwise blown me off and won't help.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11572998February 20, 2024
SERVICE BRAKES
Parking Brake Fault Service Now came on. Took to dealer and no codes stored. Looked on google and multiple people are having same issue. Ford needs to look into this as it may not be safe to drive.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11572683February 19, 2024
ENGINE
My bronco started having issues randomly when it went into limp mode one day. I brought it in to get fixed and it continued to happen. Ultimately, they told me that it needed a brand new engine.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Ford Bronco