Ford F-650 Service Bulletins
22 manufacturer communications on file.
- June 4, 2026•Document ID: 11033763Service Bulletin/Repair InstructionsPOWER TRAIN
- Mfr Comm. #:
- SSM 54899
- Date Added:
- June 9, 2026
- Manufacturer:
- FORD
SummarySome 2023-2026 F-53 Motorhome Chassis/F-59 Commercial Stripped Chassis and 2024-2026 F-650/F-750/E-Series vehicles equipped with a 6R140 transmission may be limited to 5th gear and reverse gear only. Additionally, the driver will be able to shift back to park. Diagnostic trouble codes (DTC) P2701, P2704, P0757, and/or P0733 may be stored in the powertrain control module (PCM). This may be due to PCM software being unable to command the transmission solenoid clutch actuators when the battery has a low state of charge (SOC) and/or the vehicle has been jump started. To restore proper transmission functionality, charge the battery as stated in the Workshop Manual (WSM), Section 414-01 Charging System > General Information. Cycle the ignition on then off and leave the vehicle off for 5 minutes to confirm the condition is no longer present. To prevent this issue from reoccurring, refer to the Owner's Manual > Storing Your Vehicle > Preparing Your Vehicle for Storage > 12V Battery. Replacement of transmission components will not resolve this condition.
Associated Products (7)Associated Documents - February 17, 2026•Document ID: 11029081Service Bulletin/Repair InstructionsPOWER TRAIN
- Mfr Comm. #:
- SSM 54592
- Date Added:
- February 27, 2026
- Manufacturer:
- FORD
SummaryFor 20172026 vehicles equipped with a 10R transmission, a revision to the Road Testing Vehicle procedure has been made in the WSM, located in Section 307-01 > Diagnosis and Testing. This updated procedure improves the diagnosis of customer reported transmission concerns and aids in locating the proper root cause. During diagnosis and testing, details regarding whether the condition is more prevalent when the vehicle is hot or cold, throttle percentage at the time of occurrence, vehicle speed, the specific shift involved, and whether the issue occurs during transmission engagements (N>R, N>D, R>D, or D>R) should be noted. Engineering requests including these detailed operating conditions that will significantly assist with root cause analysis. Diagnosis, testing, and repair should use established labor times outside this article.
Associated Products (43)2026 Ford Bronco2026 Ford Expedition2026 Ford Explorer2026 Ford F-1502026 Ford F-6502026 Ford Mustang2026 Ford Ranger2026 Lincoln Aviator2026 Lincoln Navigator2025 Ford Bronco2025 Ford Expedition2025 Ford Explorer2025 Ford F-1502025 Ford Mustang2025 Ford Ranger2025 Ford Transit2025 Lincoln Aviator2025 Lincoln Navigator2024 Ford Bronco2024 Ford Explorer+ 23 moreAssociated Documents - February 9, 2026•Document ID: 11028800Service Bulletin/Repair InstructionsPOWER TRAIN
- Mfr Comm. #:
- SSM 54559
- Date Added:
- February 12, 2026
- Manufacturer:
- FORD
SummarySome 2026 F-Super Duty and F-650/F-750 vehicles equipped with a 10R140 automatic transmission may exhibit fluid leakage from the transmission fluid pan area. Prior to performing any repairs, thoroughly clean the transmission fluid pan area to ensure accurate identification of the leak source. Before replacing the transmission fluid pan or gasket, verify the torque of the fluid pan bolts and stud bolts. If the torque is incorrect, tighten the pan bolts and stud bolts to the specified torque following the proper torque sequence in Workshop Manual (WSM), Section 307-01. After tightening, verify that the leak has been repaired. If the pan bolts and stud bolts are already torqued correctly, proceed with standard leak diagnosis. Should the diagnosis indicate that pan replacement is required, mark the area of the pan where the leak is present. This information will assist engineering with root cause analysis. For claiming, use causal part 7A194 and labor operation 7000E.
Associated Products (1)Associated Documents - January 5, 2026•Document ID: 11027852OtherPOWER TRAIN
- Mfr Comm. #:
- 25B65
- Date Added:
- January 28, 2026
- Manufacturer:
- FORD
SummaryCertain 2024-2026 Model Year F-650 - F-750 Medium-Duty Trucks equipped with 7.3L engine and 6R140 Transmission Reprogram the Powertrain Control Module
Associated Products (1)Associated Documents - December 22, 2025•Document ID: 11026871OtherPOWER TRAIN; ENGINE
- Mfr Comm. #:
- 25B65
- Date Added:
- December 30, 2025
- Manufacturer:
- FORD
SummaryCertain 2024-2026 Model Year F-650 - F-750 Medium-Duty Trucks equipped with 7.3L engine and 6R140 Transmission Reprogram the Powertrain Control Module
Associated Products (1)Associated Documents - October 29, 2025•Document ID: 11024900Service Bulletin/Repair InstructionsPOWER TRAIN
- Mfr Comm. #:
- SSM 54338
- Date Added:
- November 4, 2025
- Manufacturer:
- FORD
SummarySome 2021-2025 F-150 vehicles equipped with a 5.0L/5.2L engine, 2021-2025 F-Super Duty/F-53 Motorhome/F59 Commercial Stripped Chassis vehicles equipped with a 6.8L/7.3L engine and 2021-2026 E-Series/F-650/F-750 vehicles equipped with a 7.3L engine may exhibit a rattle/scraping noise upon startup that may remain after the engine is running. This may be due to the starter motor drive gear not retracting after starting. To correct this condition, inspect the starter motor drive gear and shaft. If the starter motor drive gear slides back and forth by hand and/or shows signs of scoring or damage, replace the starter motor following Workshop Manual (WSM), Section 303-06 Starting System > Removal and Installation > Starter.
Associated Products (18)Associated Documents - October 27, 2025•Document ID: 11024523Service Bulletin/Repair InstructionsPOWER TRAIN; ELECTRICAL SYSTEM
- Mfr Comm. #:
- TSB 25-2515
- Date Added:
- October 28, 2025
- Manufacturer:
- FORD
SummarySome of the vehicles listed in the Model statement above may exhibit an incorrectly illuminated MIL with DTC P0384 stored in the powertrain control module (PCM). This may be due to the calibration in the PCM. This condition does not affect vehicle drivability or durability.
Associated Products (1)Associated Documents - September 1, 2025•Document ID: 11022905OtherELECTRICAL SYSTEM; UNKNOWN OR OTHER
- Mfr Comm. #:
- SSM 54190
- Date Added:
- September 8, 2025
- Manufacturer:
- FORD
SummaryIf the vehicle is built with minor feature code "(IEPAA) - LESS CELLPHONE INTERFACE SYSTM", the vehicle is not misbuilt. Do not submit a claim for this condition. To confirm a vehicle is built with a certain minor feature code, review the build information by double-clicking the vehicle identification number (VIN) in the upper left corner in the Professional Technician System (PTS).
Associated Products (2)Associated Documents - December 12, 2023•Document ID: 10248066Service Bulletin/Repair InstructionsEQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL
- Mfr Comm. #:
- 22N15
- Date Added:
- January 2, 2024
- Manufacturer:
- FORD
SummaryCertain 2020-2023 Model Year Bronco Sport, Escape, Corsair, E-Series, F-650/F-750, F-53 Motorhome Chassis, F-59 Commercial Stripped Chassis Vehicles Equipped with Smart Data Link Connector (SDLC) Gateway Module Reprogramming for Inspection and Maintenance (I/M) Testing
Associated Products (10)Associated Documents - August 31, 2023•Document ID: 10241949Service Bulletin/Repair InstructionsENGINE AND ENGINE COOLING
- Mfr Comm. #:
- 22L03
- Date Added:
- September 6, 2023
- Manufacturer:
- FORD
SummaryCertain 2021-2022 Model Year Econoline, Super Duty Chassis Cab, F53 Motor Home, F59 Step Van, and F650/F750 Medium Duty Chassis Cab Vehicles Equipped with a Premium Rated 7.3L Engine - Engine Horsepower Credit
Associated Products (6)Associated Documents - June 8, 2023•Document ID: 10240743Service Bulletin/Repair InstructionsEQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL
- Mfr Comm. #:
- SAN-Vol1 I1
- Date Added:
- August 16, 2023
- Manufacturer:
- FORD
SummaryThe Service Awareness Newsletter is an informal communication that contains information that may not be presently available in a TSB, SSM, GSB, or other electronic communication. This article includes information on warranty, technical service tips and other service information.
Associated Products (54)2024 Ford E-4502024 Ford Explorer2024 Ford Mustang2024 Ford Ranger2023 Ford Bronco2023 Ford Bronco Sport2023 Ford E-3502023 Ford E-4502023 Ford Edge2023 Ford Escape2023 Ford Expedition2023 Ford Explorer2023 Ford F-1502023 Ford Maverick2023 Ford Mustang2023 Ford Ranger2023 Ford Transit2023 Ford Transit Connect2022 Ford Bronco2022 Ford Bronco Sport+ 34 moreAssociated Documents - May 23, 2023•Document ID: 10236685Service Bulletin/Repair InstructionsELECTRICAL SYSTEM
- Mfr Comm. #:
- TSB 23-2161
- Date Added:
- May 31, 2023
- Manufacturer:
- FORD
SummarySome 2018-2021 F-150 vehicles equipped with a 3.0L diesel engine, 2016-2022 F-650/F-750 vehicles equipped with a 6.7L engine, and 2017-2022 F-Super Duty vehicles equipped with a 6.7L engine and built on or before 08-Mar-2022 may exhibit an illuminated malfunction indicator lamp (MIL) with diagnostic trouble codes (DTCs) P21DD, P20BA. P20B9, P204C, P208A, P208B, P208C, P203B, P205B, P21CD and/or U02A2 in the powertrain control module (PCM). This may be due to water intrusion within connectors C3613 and/or C4851/C3610 on the reductant harness going to the reductant pump/heater assembly and the reductant level sensor/quality module. This may also be due to movement of the wiring harness causing terminal fretting. To correct the condition, follow the Service Procedure to replace the reductant tank harness, the reductant pump/heater assembly and/or the reductant tank, as well as securing the wiring harness using a cable zip tie fastener.
Associated Products (3)Associated Documents - April 4, 2023•Document ID: 10235153Service Bulletin/Repair InstructionsSTRUCTURE
- Mfr Comm. #:
- SSM 51536
- Date Added:
- May 4, 2023
- Manufacturer:
- FORD
SummaryFor 2000-2024 Ford and Lincoln vehicles, swapping a module from a vehicle for diagnosis purposes is likely to cause errors and is not recommended. It is also not recommended to order a replacement module using a vehicle identification number (VIN) from a different vehicle. Most modules on these affected vehicles are VIN/vehicle specific and hardware variations between modules do exist. Swapping a module from a vehicle or ordering a module using a different vehicle/VIN can cause ineffective repairs and additional vehicle down time. Make sure all appropriate Workshop Manual (WSM) procedures are followed when diagnosing the condition prior to all module replacements and only order modules using the correct VIN.
Associated Products (47)2023 Ford Bronco2023 Ford Bronco Sport2023 Ford Edge2023 Ford Escape2023 Ford Expedition2023 Ford Explorer2023 Ford F-1502023 Ford Maverick2023 Ford Mustang2023 Ford Ranger2023 Ford Transit Connect2023 Lincoln Aviator2023 Lincoln Corsair2023 Lincoln Navigator2022 Ford Bronco2022 Ford Bronco Sport2022 Ford Edge2022 Ford Escape2022 Ford Expedition2022 Ford Explorer+ 27 moreAssociated Documents - September 30, 2022•Document ID: 10222307Service Bulletin/Repair InstructionsELECTRICAL SYSTEM
- Mfr Comm. #:
- TSB 21-2219
- Date Added:
- October 4, 2022
- Manufacturer:
- FORD
SummarySome 2021 F-650/F-750 vehicles built on or before 20-Nov-2020 may exhibit various electrical concerns and/or various illuminated warning lamps with various diagnostic trouble codes (DTCs) present. This may be due to the battery junction box (BJB) wiring harness contacting the coolant reservoir bracket. To correct the condition, follow the Service Procedure to repair any damaged circuits and secure the BJB wiring harness to the BJB.
Associated Products (2)Associated Documents - July 29, 2022•Document ID: 10216963Service Bulletin/Repair InstructionsELECTRICAL SYSTEM:SOFTWARE; ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL; EQUIPMENT
- Mfr Comm. #:
- SSM 50974
- Date Added:
- August 2, 2022
- Manufacturer:
- LINCOLN
SummarySome 2020-2022 Escape/Corsair/F-53 Motorhome/F-59 Commercial Stripped Chassis, 2021-2023 F-650/F-750/E-Series, and 2021-2022 Bronco Sport vehicles may exhibit a communication fault with emissions inspection equipment. This may be due to the software in the gateway module (GWM). To correct this condition, reprogram the GWM to latest software level using the appropriate Ford diagnostic scan tool. Use causal part 14F642 and applicable labor times from Section 10 of the Service Labor Time Standards (SLTS) Manual.
Associated Products (14)Associated Documents - March 1, 2022•Document ID: 10208829Service Bulletin/Repair InstructionsPOWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE (TCM/PCM/TECM); EQUIPMENT
- Mfr Comm. #:
- SSM 50549
- Date Added:
- March 8, 2022
- Manufacturer:
- FORD
SummarySome 2018-2020 F-150, 2017-2022 F-Super Duty and 2016-2022 F-650/F-750 vehicles equipped with a diesel engine may exhibit diagnostic trouble code (DTC) P0000 stored in the powertrain control module (PCM) after an on-demand self test. This DTC is due to a processing error in the PCM as a result of on-demand self testing. P0000 is an invalid DTC that will not illuminate the malfunction indicator lamp (MIL) and no repairs should be performed.
Associated Products (2)Associated Documents - May 7, 2021•Document ID: 10194412Service Bulletin/Repair InstructionsFUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY:FILLER PIPE AND CAP; FUEL SYSTEM, DIESEL:STORAGE:TANK ASSEMBLY
- Mfr Comm. #:
- SSM 49785
- Date Added:
- June 1, 2021
- Manufacturer:
- FORD
SummarySome 2021 F-Super Duty and 2021-2022 E-Series vehicles equipped with a 6.2L or 7.3L gasoline engine may exhibit an illuminated malfunction indicator lamp (MIL) with diagnostic trouble code (DTC) P0457 stored in the powertrain control module (PCM). This may be due to a loose fuel filler cap. The fuel filler cap design has changed, requiring multiple turns to seal properly. Advise the customer to turn the fuel filler cap clockwise until there is at least one audible click to seal properly. For further diagnostics, refer to the Powertrain Control/Emissions Diagnosis (PC/ED) manual, pinpoint test HX.
Associated Products (9)Associated Documents - November 4, 2020•Document ID: 10183406Service Bulletin/Repair InstructionsEQUIPMENT; ENGINE; EQUIPMENT ADAPTIVE/MOBILITY; FUEL SYSTEM, GASOLINE
- Mfr Comm. #:
- 20B41
- Date Added:
- December 5, 2020
- Manufacturer:
- FORD
SummaryCertain 2020 Model Year Super Duty and 2021 Model Year Medium Duty Vehicles Equipped with a 6.7L Engine Left Hand Side High Pressure Fuel Rail Replacement. In some of the affected vehicles, the vehicle may have been built with a high pressure fuel rail where the internal fuel orifice may become dislodged. If the fuel orifice becomes dislodged, it can travel down and damage the pressure control valve pintle resulting in a Diagnostic Trouble Code (DTC) P0088. Before demonstrating or delivering any new in-stock vehicles involved in this program, dealers are to replace the left hand side high pressure fuel rail using the technical instructions, even if DTC P0088 is not present. This service must be performed on all affected vehicles at no charge to the vehicle owner.
Associated Products (2)Associated Documents - September 2, 2020•Document ID: 10180615Service Bulletin/Repair InstructionsEQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL
- Mfr Comm. #:
- HSB2020-09.02
- Date Added:
- October 2, 2020
- Manufacturer:
- FORD
SummarySales Bulletin - 2021 F-Series order guide released, Grove City Hotel break in notice, Cares Act notice, Ambulance Crash Testing link, HEPA filter availability update, Ohio Temporary tag notice, Dealer portal training material notice, Chassis/Vehicle availability notice
Associated Products (5)Associated Documents - September 1, 2020•Document ID: 10180352Service Bulletin/Repair InstructionsEQUIPMENT
- Mfr Comm. #:
- SSM 49147
- Date Added:
- October 6, 2020
- Manufacturer:
- FORD
SummarySome 2021 E-Series/F-650/F-750 vehicles may exhibit inoperative RKE key fobs resulting in key fob replacement or some customers may seek service to program additional key fobs to the vehicle. A new IDS procedure has been released with IDS version 119.01 to allow for RKE key fob programming. Start a vehicle session and click on the Toolbox Tab. Click on Body > Security > Remote Keyless Entry to begin programming new and/or additional key fobs. Only 4 RKE key fobs total can be programmed to each vehicle. All vehicles are equipped with a wired in connectivity device. If the customer elects to program this connectivity device it will take up 1 of the 4 available slots. The Workshop Manual procedure for RKE programming is also being updated.
Associated Products (4)Associated Documents