While driving, my 2022 Ford F-150 equipped with the 2.7L EcoBoost experienced abnormal engine operation, a check-engine light, and reduced engine power. The unexpected reduction in available engine power created a safety concern because loss of acceleration or propulsion can be dangerous when merging, crossing traffic, passing, or traveling at highway speeds. The vehicle was inspected and diagnosed by an authorized Ford dealership. The PCM stored DTC P0332, Knock/Combustion Vibration Sensor “B” Circuit Low. The dealer performed Ford Pinpoint Test DG. Testing reportedly found no open circuit, short to ground, short to voltage, or intermittent circuit fault. The dealer determined that the knock-sensor assembly required replacement.The repair involves replacement of Ford knock-sensor assembly FT4Z-12A699-E, which contains both knock sensors. Access to the assembly requires extensive disassembly of engine fuel and cooling-system components. Ford’s service procedure includes removal of both direct-injection fuel rails, draining the cooling system, removal of the coolant pump, and removal of the coolant outlet connector.I am concerned about the possibility of coolant leakage or contamination affecting the knock-sensor assembly because of its location in relation to cooling-system components. I do not currently know whether coolant contamination caused this particular failure. I request that NHTSA investigate whether coolant leakage or contamination in this area contributes to premature knock-sensor failures on 2.7L EcoBoost engines. I have also identified another 2022 Ford F-150 with the 2.7L EcoBoost that was diagnosed by a Ford dealership with a similar knock-sensor circuit-low fault, P0327 also quoted replacement of the same FT4Z-12A699-E assembly. I request investigation knock-sensor failures on 2.7L EcoBoost F-150s, including Ford warranty/field data and whether coolant leakage or contamination contributes to failures capable of causing unexpected reduced engine powe
No injuries · No fire · No crash
Ford Motor Company (Ford) is recalling certain 2021-2026 F-150, 2022-2026 F-250 SD, F-350 SD, F-450 SD, F-550 SD, Maverick, 2024-2026 Ranger, 2023-2026 F-600 SD, 2022-2027 Lincoln Navigator, Expedition, and 2026 E-Transit vehicles. When towing a trailer, the integrated trailer module (ITRM) may lose communication with the vehicle, possibly causing a loss of brake and turn signal lights, or a loss of brake function. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 108, " Lamps, Reflective Devices, and Associated Equipment."
Ford Motor Company (Ford) is recalling certain 2021-2022 Expedition, Lincoln Navigator, 2021-2023 F-150, 2022 F-250 SD, F-350 SD, and F-450 SD vehicles. The moonroof wind deflector clips may be inadequately attached to the moonroof frame, which can result in the wind deflector detaching from the vehicle.
Ford Motor Company (Ford) is recalling certain 2022 F-150 vehicles that were repaired incorrectly under recall 22V686. The parking lights may flicker when the headlights are activated. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 108, "Lamps, Reflective Devices, and Associated Equipment."
I was driving and went to press the brakes and the pedal went to the floor. The truck would not stop right away and then the rear tires locked up. Light came on the dash ABS, service traction control and brake system failure, this was a similar issue with the 2021 and 2025 model having issues with the EBB/ECU that was on recall.
No injuries · No fire · No crash
My truck was parked on a slight slope in my driveway. I got in to move the truck to my normal parking space. When I started the truck I noticed the emergency brake was on. I put the truck into drive- the truck accelerated with my foot on the brake. The truck struck the corner of my deck and didn't stop until I hit the corner at my house. I had the brake pushed to the firewall and the truck would kept accelerating. Thankfully the airbags did not deploy. Significant damage was done to my house and my truck.
Recall first fuel pump issue unresolved. It has been over a year since recall was issued
No injuries · No fire · No crash
There is an issue with my cowl which has 1 drain hole, on passenger side which if gets clogged with debris, causes water to build up and water to intrude from cowl into interior truck causing water intrusion to the body control module and electrical issues, and carpet is wet and creates mold smell and other safety issues. Cowl is not removable
No injuries · No fire · No crash
Ford Motor Company (Ford) is recalling certain 2022 F-150 vehicles that were repaired incorrectly under recalls 22V686 and 23V802. The parking lights may flicker when the headlights are activated. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 108, "Lamps, Reflective Devices, and Associated Equipment."
Ford Motor Company (Ford) is recalling certain 2021-2023 Bronco, Explorer, Lincoln Aviator, F-250 SD, F-350 SD, F-450 SD, F-550 SD, 2021-2022 Lincoln Navigator, Mustang, F-150, and 2022 Expedition vehicles. The low-pressure fuel pump may fail, which can result in an engine stall while driving.
