Ford Motor Company (Ford) is recalling certain 2022-2026 Ford Escape and 2023-2026 Lincoln Corsair plug-in hybrid vehicles. A manufacturing defect in one or more of the high voltage battery cells may result in an internal short circuit and battery failure.
Ford Motor Company (Ford) is recalling certain 2020-2024 Ford Escape and 2021-2024 Lincoln Corsair plug-in hybrid vehicles. A manufacturing defect in one or more of the high voltage battery cells may result in an internal short circuit and battery failure.
Ford Motor Company (Ford) is recalling certain 2024-2025 Lincoln Nautilus, 2023-2025 Escape, 2023 Lincoln Corsair, 2025 Lincoln Corsair, Maverick, and Bronco Sport vehicles equipped with a 1.5L or 2.0L MPC engine and an engine block heater. The engine block heater may overheat when the vehicle is parked with the block heater plugged in.
Ford Motor Company (Ford) is recalling certain 2020-2023 Escape, 2021-2023 Corsair, and 2022-2023 Maverick vehicles equipped with 2.5L HEV or PHEV engines that were repaired incorrectly under recall 23V380. In the event of an engine failure, engine oil and fuel vapor may be released into the engine compartment and accumulate near ignition sources such as hot engine or exhaust components, possibly resulting in an engine compartment fire.
Ford Motor Company (Ford) is recalling certain 2020-2023 Lincoln Aviator and Lincoln Corsair vehicles equipped with a Revel Audio System that were repaired incorrectly under recall 22V-953. When the driver's seat belt is not buckled and the vehicle is started, the seat belt warning system may activate the audible warning chime for an insufficient amount of time of less than 4 seconds. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 208, "Occupant Crash Protection."
The contact owns a 2023 Lincoln Corsair. The contact received notification of NHTSA Campaign Number: 26V091000 (Electrical System); however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure.
No injuries · No fire · No crash
On May 10 a lighted wrench appeared on the instrument panel. The car felt as if I was loosing power. May 12 I got in the car, the wrench and check engine lights were both on. Called the dealer service department. They told me the car is not safe to drive as it cannot accelerator and will go into "limp mode". After having it towed to the Lincoln dealership, I was told the turbo in the engine failed. As of July 6, there is not a part available for this repair. Today I was told there are only 3 in the entire nation and they are all accounted for.
No injuries · No fire · No crash
The contact owns a (YMM) 2010 Hyundai Elantra. The contact received notification of NHTSA Campaign Number: (example: 20V315000 (Latches/Locks/Linkages) however, the part to do the recall repair was not yet available. The local dealer was/was not contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was/was not made aware of the issue. The contact had not experienced a failure. The VIN was invalid./The VIN was not available.
No injuries · No fire · No crash
Due to a safety recall for possible battery fires, we have not been able to charge the PHEV for more than a year. This significantly affects the vehicle's mileage and performance and reduces the car's value. •We are unable to use the plug-in charging function for an extended period •We leased the vehicle specifically as a plug-in hybrid •The recall materially reduced the vehicle’s usefulness and fuel savings •We remain concerned about leasing another Corsair hybrid Furthermore: •We leased the vehicle specifically for plug-in capability •We paid a premium for the hybrid model •We were unable to use charging/EV mode for a prolonged period •Fuel costs increased because the vehicle functioned more like a regular gas SUV
No injuries · No fire · No crash
The recall letter advised that for the time being, I should set software to limit charge to 80%. The car is noncompliant with the prescribed settings. If there is a danger to having settings no prescribed, I am in danger. I did set the settings in the car and in the Android app to 80%. Sometimes the 80% limit is respected, but often it charges to 100%. Even though the Android app always reports the setting as 80%. the car sometimes doesn't comply. I only charge in my garage, in the same spot, using a Level 2 charger. The recall letter also advised that the drive mode should be set to "Auto EV." But the Corsair does not have a setting called "Auto EV." I called several numbers at Ford, and no one was able to offer any help. Screenshots show charge settings on car and phone, and one charge respecting 80%, and one going past it.
No injuries · No fire · No crash