Mercury · Model Report
Mercury Mountaineer2002
Showing safety data for the 2002 model year only.
Recalls
Checking records…
Complaints
Checking records…
Investigations
Checking records…
Service Bulletins
Checking records…
Mercury · Model Report
Showing safety data for the 2002 model year only.
FORD IS RECALLING MODEL YEARS 1995-2003 WINDSTAR, 2000-2003 EXCURSION DIESEL, 1993-1997 AND 1999-2003 F-250 SD THROUGH F-550 SD DIESEL, 1992-2003 E-150 THROUGH E-550, 1995-2002 EXPLORER, 1997 AND 2002 MERCURY MOUNTAINEER, 1995-1997 AND 2001-2003 RANGER, AND 1994 F53 VEHICLES EQUIPPED WITH THE TEXAS INSTRUMENTS SPEED CONTROL DEACTIVATION SWITCH (SCDS). THE SCDS MAY LEAK INTERNALLY AND THEN OVERHEAT, SMOKE, OR BURN.
CERTAIN CURVED TEMPERED REPLACEMENT GLASS MANUFACTURED BY HANGZHOU SAFETY GLASS LTD AND SUPPLIED TO SAFELITE BY AUTO TEMP INC., IDENTIFIED AS DOT-430, AND SOLD FOR USE ON CERTAIN DOMESTIC AND FOREIGN VEHICLES MAY NOT BREAK INTO SMALL PIECES AS EXPECTED OF TEMPERED GLASS AND FAILS TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 205, "GLAZING MATERIALS."
VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES. THE RIGHT SIDE TIRES MAY HAVE HORIZONTAL CUTS ON THE EDGE OF THE TREAD THAT COULD HAVE OCCURRED DURING VEHICLE ASSEMBLY.
THIS IS NOT A SAFETY RECALL IN ACCORDANCE WITH THE SAFETY ACT. HOWEVER, IT IS DEEMED A SAFETY IMPROVEMENT CAMPAIGN BY THE AGENCY. VEHICLE DESCRIPTION: 2002 FORD EXPLORER AND MERCURY MONTAINEER SPORT UTILITY VEHICLES. THE BRACKETS CONNECTING THE LEFT CYLINDERS TO EACH SIDE OF THE LIFTGATE GLASS COULD ROTATE OUT OF POSITION IF EITHER THE URETHANE BOND OR TORQUE ARE NOT SUFFICIENT.
Aftermarket rack and pinion system re-manufactured by Detroit Axel began leaking fluid and caused a loss of power steering within 3 months of purchase. A second unit was installed and after about a year had the exact same failure as the first unit. Also resulting in the loss of power steering. It is my contention that Detroit Axel is not capable of re-manufacturing to a satisfactory safety standard. I believe they should be investigated and perhaps subject to a product recall. I pray nobody has yet been killed by their ineptitude!
No injuries · No fire · No crash
Body : to much rust, corrosion, on rear of truck other failure or detachment of exterior body like rear gate frame components, and other structural components that may present a safety hazard. Electrical : electrical systems and items such asa wiring and cable on or inside the door, ignition switch cover detach ,instrument panel and gauges blinking that causes motors and actuators that power mechanical devices like (windows, sunroofs, seats, etc.) Generate some kind of electrical problem that may present a safety hazard. Power train :transmissions, transfer cases fluid hard to check ,electronic control units and shift lever inacurated, drive axles, hubs, shafts, differentials, CV joints star vibration that may present a safety hazard.
No injuries · No fire · No crash
Heard a pop noise under hood. Engine shut off battery light came on. Went to open hood and there was a fire.
TL* THE CONTACT OWNS A 2002 MERCURY MOUNTAINEER. THE CONTACT STATED THAT THE REAR LIFT GATE FAILED TO LATCH SECURELY ON SEVERAL OCCASIONS. THE CONTACT STATED THAT THE FAILURE WAS INTERMITTENT. THE CONTACT STATED ON ONE OCCASION WHILE DRIVING THE VEHICLE, THE LIFT GATE AJAR WARNING LIGHT ILLUMINATED. THE CONTACT'S SON WENT TO CLOSE THE LIFT GATE AND GLASS SHATTERED. THE CONTACT HIRED A GLASS REPAIRMEN TO FIX THE WINDOW FOR $250.00. THE DEALER NOR THE MANUFACTURER HAD BEEN NOTIFIED OF THE FAILURE. UPON INVESTIGATION, THE CONTACT ASSOCIATED NHTSA CAMPAIGN NUMBER: 01I010000 (VISIBILITY) WITH THE FAILURE. THE FAILURE MILEAGE WAS UNKNOWN.
No injuries · No fire · No crash
TL* THE CONTACT OWNED A 2002 MERCURY MOUNTAINEER. WHILE DRIVING, THE VEHICLE SLID ON ICE. THE CONTACT LOST CONTROL OF THE VEHICLE AND CRASHED INTO A DITCH. THE AIR BAGS FAILED TO DEPLOY. THE CONTACT SUSTAINED HEAD, CHEST, LOWER AND UPPER BACK, ABDOMINAL, AND NECK INJURIES THAT REQUIRED MEDICAL ATTENTION. A POLICE REPORT WAS FILED. THE VEHICLE WAS TOWED TO THE CONTACT'S RESIDENCE. THE VEHICLE WAS NOT TAKEN TO A DEALER OR AN INDEPENDENT MECHANIC FOR DIAGNOSTIC TESTING. THE VEHICLE WAS DESTROYED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 250,000.