Mercury · Model Report
Mercury Mountaineer1997
Showing safety data for the 1997 model year only.
Recalls
Checking records…
Complaints
Checking records…
Investigations
Checking records…
Service Bulletins
Checking records…
Mercury · Model Report
Showing safety data for the 1997 model year only.
FORD IS RECALLING MODEL YEARS 1995-2003 WINDSTAR, 2000-2003 EXCURSION DIESEL, 1993-1997 AND 1999-2003 F-250 SD THROUGH F-550 SD DIESEL, 1992-2003 E-150 THROUGH E-550, 1995-2002 EXPLORER, 1997 AND 2002 MERCURY MOUNTAINEER, 1995-1997 AND 2001-2003 RANGER, AND 1994 F53 VEHICLES EQUIPPED WITH THE TEXAS INSTRUMENTS SPEED CONTROL DEACTIVATION SWITCH (SCDS). THE SCDS MAY LEAK INTERNALLY AND THEN OVERHEAT, SMOKE, OR BURN.
VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES EQUIPPED WITH 4.0L SOHC ENGINES AND STILL RETAIN THE ORIGINAL THROTTLE BODY (PART NUMBERS 97JF-9E926AB OR 97JF-9E926-AC). SOME OF THE ORIGINAL THROTTLE BODIES INSTALLED ALLOWED A GAP BETWEEN THE PLATE AND BORE TO BE BUILT TOO NARROW. THIS REDUCED CLEARANCE ALLOWED THE ENGINE DEPOSITS NORMALLY PRESENT IN THE THROTTLE BODY TO CONTACT OR BRIDGE THE GAP. IF THE ENGINE DEPOSITS BRIDGED THE GAP BETWEEN THE THROTTLE PLATE AND BORE AND THEN HARDENED, ON THE INITIAL APPLICATION OF THE ACCELERATOR PEDAL AFTER THE ENGINE HAS COOLED, THE OPERATOR WOULD NEED TO APPLY ADDITIONAL FORCE TO THE ACCELERATOR PEDAL TO BREAK THE BRIDGE.
VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES. UNDER CERTAIN CONDITIONS, A FRONT SWAY BAR LINK CAN FRACTURE.
TIRE DESCRIPTION: FIRESTONE WILDERNESS AT, SIZE P235/75R15, PRODUCED AT THE DECATUR, ILLINOIS TIRE PLANT AND ALL FIRESTONE RADIAL ATX AND RADIAL ATX II TIRES, SIZE P235/75R15. OPERATION OF THESE TIRES AT LOW INFLATION PRESSURES, HIGH SPEED, AND IN HOT WEATHER, CAN CONTRIBUTE TO SEPARATION OF THE TIRE TREAD.
VEHICLE DESCRIPTION: MULTI-PURPOSE PASSENGER VEHICLES EQUIPPED WITH 4.0L SINGLE OVERHEAD CAM ENGINES. THE ENGINE FUEL LINES CAN BE DAMAGED IF THE VEHICLE IS JUMP STARTED AND THE GROUND CABLE IS ATTACHED TO THE FUEL LINE BRACKET THAT IS LOCATED NEAR THE BATTERY. SINCE THE BRACKET IS NOT GROUNDED, THE STAINLESS STEEL FUEL LINE BRAID COULD ACT AS A GROUND POTENTIALLY OVERHEATING THE PTFE INNER LINER OF THE FUEL LINE RESULTING IN DAMAGE TO THE FUEL LINE.
TL* THE CONTACT OWNS A 1997 MERCURY MOUNTAINEER. THE CONTACT STATED WHILE THE VEHICLE WAS STATIONARY, THE VEHICLE STALLED. THE CONTACT STATED NO WARNING LIGHT WAS ILLUMINATED. THE VEHICLE WAS TAKEN TO AN UNKNOWN DEALER TO BE DIAGNOSED. THE CONTACT WAS INFORMED THAT THE FUEL PUMP NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER HAD NOT BEEN INFORMED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 385,000.
No injuries · No fire · No crash
DRIVERS SIDE SEAT BELT BUCKLE WILL NOT LATCH. 185,000 MILES.
No injuries · No fire · No crash
TL* THE CONTACT'S HUSBAND OWNS A 1997 MERCURY MOUNTAINEER. THE CONTACT STATED THAT WHEN THE BRAKE PEDAL WAS RELEASED, THE VEHICLE UNINTENTIONALLY ACCELERATED. AS A RESULT, THE CONTACT'S HUSBAND REAR ENDED ANOTHER VEHICLE. THE AIR BAGS DID NOT DEPLOY. A POLICE REPORT WAS FILED AND THERE WERE NO INJURIES. THE VEHICLE WAS NOT TAKEN TO A DEALER OR INDEPENDENT MECHANIC FOR DIAGNOSTIC TESTING OR REPAIRS. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 110,000.
DRIVER SIDE SEAT BELT REFUSES TO LATCH AND, IF IT DOES LATCH, COMES UNLATCHED ON ITS OWN. ON INSPECTION, THE 'GUTS' OF THE MECHANISM ARE GONE.
No injuries · No fire · No crash
I WAS AT A GAS STATION MAKING A PURCHASE WITH MY DISABLED MOTHER. WE LEFT THE STORE, AND GOT INTO MY TRUCK. I STARTED MY TRUCK AND PROCEED TO DIVE TOWARDS THE EXIT OF THE GAS STATION WHEN I SMELLED SOMETHING LIKE BURNING RUBBER. I SAID TO MY MOTHER THAT SOMETHING SMELLED FUNNY AND THEN LOOKED AND SAW A THIN STEAM OF SMOKE COMING UP FROM IN BETWEEN MY LEGS. I PARKED THE TRUCK AND JUMPERS OUT LEAVING MY OM IN THE CAR. I THEN SAW A FIRE INSIDE OF THE METAL TRACK IN WHICH MY SEAT MOVES MECHANICALLY UNDERNEATH MY SEAT, WHERE THE WIRES ARE. I RAN INTO THE GAS STATION PANICKED AND ASKED THE ATTENDANT FOR A FIRE EXTINGUISHER, TO WHICH HE REPLIED " NO, I DON'T KNOW I DON'T HAVE ONE" AND DID NOTHING. SO I RAN BACK OUTSIDE TO MY TRUCK WHERE MY MOTHER WAS HAVING TROUBLE EXITING MY TRUCK AS SHE HAS ANXIETY AND HEALTH ISSUES. SHE FINALLY GOT OUT AND A TOW TRUCK THAT WAS DRIVING BY, SAW THE SMOKE GETTING HEAVIER AND FLOWING OUT OF MY TRUCK, HE STOPPED AND OUT THE FIRE OUT WITH AN EXTINGUISHER. THE FLAMES WERE COMING THROUGH MY SEAT AND I WAS AT A GAS STATION. I WAS TERRIFIED. I HAVE PTSD AND THIS HASN'T HELPED MY SLEEP AT ALL. ALSO, WE WERE AT A GAS STATION AND AS YOU KNOW, FIRE IS VERY DANGEROUS AT A GAS STATION. WE COULD'VE BEEN SERIOUSLY HURT OR WORSE.