FORD IS RECALLING CERTAIN MODEL YEAR 2010 FUSION, EXPLORER, EXPLORER SPORT TRAC, AND MERCURY MILAN AND MOUNTAINEER VEHICLES MANUFACTURED BETWEEN DECEMBER 15, 2009 THROUGH FEBRUARY 3, 2010 EQUIPPED WITH FRONT SEAT MANUAL RECLINERS. THESE VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 202, "HEAD RESTRAINT." THE RECLINER GEAR PLATE TEETH MAY BE OUT OF DIMENSION SPECIFICATION WHICH COULD RESULT IN LIMITED PAWL TO GEAR PLATE TOOTH ENGAGEMENT.
FORD IS RECALLING MODEL YEARS 1995-2003 WINDSTAR, 2000-2003 EXCURSION DIESEL, 1993-1997 AND 1999-2003 F-250 SD THROUGH F-550 SD DIESEL, 1992-2003 E-150 THROUGH E-550, 1995-2002 EXPLORER, 1997 AND 2002 MERCURY MOUNTAINEER, 1995-1997 AND 2001-2003 RANGER, AND 1994 F53 VEHICLES EQUIPPED WITH THE TEXAS INSTRUMENTS SPEED CONTROL DEACTIVATION SWITCH (SCDS). THE SCDS MAY LEAK INTERNALLY AND THEN OVERHEAT, SMOKE, OR BURN.
CERTAIN CURVED TEMPERED REPLACEMENT GLASS MANUFACTURED BY HANGZHOU SAFETY GLASS LTD AND SUPPLIED TO SAFELITE BY AUTO TEMP INC., IDENTIFIED AS DOT-430, AND SOLD FOR USE ON CERTAIN DOMESTIC AND FOREIGN VEHICLES MAY NOT BREAK INTO SMALL PIECES AS EXPECTED OF TEMPERED GLASS AND FAILS TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 205, "GLAZING MATERIALS."
ON CERTAIN SPORT UTILITY VEHICLES EQUIPPED WITH THE 4.6L ENGINE AND 6R TRANSMISSION, THE BOLT SECURING THE TRANSMISSION OIL COOLER LINE FITTINGS AT THE TRANSMISSION MAY NOT HAVE BEEN SUFFICIENTLY TORQUED DURING VEHICLE ASSEMBLY. AS A RESULT, THE BOLT MAY LOOSEN AND THE TRANSMISSION OIL COOLER LINES MAY DISENGAGE FROM THE TRANSMISSION, CAUSING A TRANSMISSION FLUID LEAK.
ON CERTAIN PICKUP TRUCKS, PASSENGER VEHICLES, SPORT UTILITY VEHICLES, AND MOTOR HOMES CHASSIS, THE SPEED CONTROL DEACTIVATION SWITCH MAY, UNDER CERTAIN CONDITIONS, LEAK INTERNALLY AND THEN OVERHEAT, SMOKE, OR BURN.
The contact owns a 2008 Mercury Mountaineer. The contact stated that the check engine warning light was illuminated. The contact stated the vehicle stalled while driving at an undisclosed speed. The contact stated that several attempts were needed to restart the vehicle to continue driving. The contact stated that the gear shifter intermittently failed to move to the intended position. The contact stated that there was an abnormal fuel odor inside the cabin of the vehicle, and the fuel level was lowered sooner than normal. The vehicle was taken to the dealer to be diagnosed; however, the result was not provided. The contact stated that there was a code for an EVAP failure. The vehicle was not repaired. The vehicle was taken to another dealer, Peoria Ford (9130 W Bell Rd, Peoria, AZ 85382) however, the contact was not provided the cause for the failure. The vehicle was taken to an independent mechanic; however, the vehicle was not repaired. The manufacturer was not informed of the failure. The failure mileage was approximately 200,000.
No injuries · No fire · No crash
The contact owns a 2007 Mercury Mountaineer. The contact stated that after shifting the transmission from park(P) to reverse(R), the vehicle failed to respond. The contact removed and reinserted the fob key in the ignition to correct the failure. The vehicle was taken to an independent mechanic, who diagnosed that an unknown transmission part needed to be replaced. The vehicle was not repaired. The mechanic instructed the contact to pull the park release lever each time to shift the vehicle out of park (P). The manufacturer was made aware of the failure and advised the contact to file a complaint with the NHTSA Hotline. The failure mileage was approximately 78,000.
No injuries · No fire · No crash
I buckle the seat belt and it just comes unbuckled spontaneously when I’m driving. I check to see if the seat belt is secure by pulling on it. It seems secure but still unbuckles. I usually have to redo my seatbelt every 5 minutes. I do not feel like it will keep me safe in a collision
No injuries · No fire · No crash
The contact's daughter owns a 2000 Mercury Mountaineer. The contact stated that while her husband and her daughter were inspecting the engine compartment of the vehicle, the hinges of the hood failed, causing the hood to drop inadvertently. The contact's husband sustained a laceration on the arm but did not seek medical assistance. The vehicle was taken to an independent mechanic, where the hood hinges were replaced. Additionally, the contact purchased a stick to hold the hood open. The vehicle was repaired. The dealer and the manufacturer were not notified of the failure. The failure mileage was unknown. The VIN was not available.
My husband had purchased 4 brand new COOPER TIRES EVOLUTION H/T M+S size P235 / 65 R 18 a number of years ago. My husband has since passed away. I cannot find my sales receipt due to the fact my husband had paid for the tires in question. I do not know what he did with the sales receipt. I have a few good-faith efforts and attempts to bring this matter to COOPER TIRES but each and every time I got the same reply from them "NO we cannot help you. We will not be able to warranty your tires for you......we need a sales receipt......" I had my good friend take my vehicle to a local tire dealer and installer recommended by COOPER TIRES and this tire dealer found that: (1) all 4 COOPER TIRES on my vehicle look and are brand new (2) tire tread depth on all 4 COOPER TIRES on my vehicle are 8/32 " (3) three COOPER TIRES on my vehicle show a DOT date code of 2017 and one COOPER TIRE on my car shows a DOT date code of 3817 (4) all four COOPER TIRES on my vehicle have numerous cracks on the sidewall of the tires which is a manufacture defective and COOPER TIRES should replace all 4 tires on my car (5) the right-rear COOPER tire on my vehicle is leaking air from the sidewall due to the cracks. (6) COOPER TIRES should under the law include my tires under their national recall list because the COOPER TIRES on my vehicle have the same (1) make and model tire (2) the exact same size tire (3) all 4 COOPER TIRES on vehicle were made in the same factory as the rest of the recall tires (4) three of the COOPER TIRES on my vehicle have an issue with the date code (see recall NHTSA Campaign Number: 21T014000 for more info). I could go on and on but I think you get the idea. Also, I will hold COOPER TIRES legally liable if I get into a car accident due to its manufacture defective COOPER tires. The exact dates my good friend has contacted COOPER TIRES are: (1) May 01, 2024 (four times); (2) May 02, 2024 (three times). I asked for a call back but nobody returned my call.
No injuries · No fire · No crash