Ford F-650 Service Bulletins (2020)

46 manufacturer communications on file.

• April 17, 2023•Document ID: 10234593

  Service Bulletin/Repair Instructions
  EQUIPMENT

  Mfr Comm. #:

  TSB 23-2115

  Date Added:

  May 4, 2023

  Manufacturer:

  FORD

  Summary

  Some 2015-2020 F-150 and 2017-2022 F-Super Duty vehicles may exhibit a lack of heat or cooling from the cabin vents when the climate control settings are adjusted between hot and cold. This may be due to a stuck/binding temperature door within the climate control housing or binding/inoperative temperature door actuator. Diagnostic trouble code (DTC) B1081:07 may be present in the front controls interface module (FCIM) or heating ventilation and air conditioning (HVAC) module. To correct the condition, follow the Service Procedure to remove the climate control housing and replace the temperature door cam(s), lubricate the temperature blend door bearing surface, and apply flock tape to actuator to seal out debris.

  Associated Products (45)

  2022 Ford F-2502022 Ford F-3502022 Ford F-4502022 Ford F-5502022 Ford F-6002022 Ford F-6502022 Ford F-7502021 Ford F-2502021 Ford F-3502021 Ford F-4502021 Ford F-5502021 Ford F-6002021 Ford F-6502021 Ford F-7502020 Ford F-1502020 Ford F-2502020 Ford F-3502020 Ford F-4502020 Ford F-5502020 Ford F-600+ 25 more
  Associated Documents

  • DownloadMC-10234593-0001.pdf↗
• April 4, 2023•Document ID: 10235153

  Service Bulletin/Repair Instructions
  STRUCTURE

  Mfr Comm. #:

  SSM 51536

  Date Added:

  May 4, 2023

  Manufacturer:

  LINCOLN

  Summary

  For 2000-2024 Ford and Lincoln vehicles, swapping a module from a vehicle for diagnosis purposes is likely to cause errors and is not recommended. It is also not recommended to order a replacement module using a vehicle identification number (VIN) from a different vehicle. Most modules on these affected vehicles are VIN/vehicle specific and hardware variations between modules do exist. Swapping a module from a vehicle or ordering a module using a different vehicle/VIN can cause ineffective repairs and additional vehicle down time. Make sure all appropriate Workshop Manual (WSM) procedures are followed when diagnosing the condition prior to all module replacements and only order modules using the correct VIN.

  Associated Products (305)

  2023 Ford Bronco2023 Ford Bronco Sport2023 Ford Edge2023 Ford Escape2023 Ford Expedition2023 Ford Explorer2023 Ford F-1502023 Ford F-2502023 Ford F-3502023 Ford F-4502023 Ford F-5502023 Ford F-6502023 Ford F-7502023 Ford Maverick2023 Ford Mustang2023 Ford Mustang Mach-E2023 Ford Ranger2023 Ford Transit Connect2023 Lincoln Aviator2023 Lincoln Corsair+ 285 more
  Associated Documents

  • DownloadMC-10235153-0001.pdf↗
• July 29, 2022•Document ID: 10216963

  Service Bulletin/Repair Instructions
  ELECTRICAL SYSTEM:SOFTWARE; ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL; EQUIPMENT

  Mfr Comm. #:

  SSM 50974

  Date Added:

  August 2, 2022

  Manufacturer:

  FORD

  Summary

  Some 2020-2022 Escape/Corsair/F-53 Motorhome/F-59 Commercial Stripped Chassis, 2021-2023 F-650/F-750/E-Series, and 2021-2022 Bronco Sport vehicles may exhibit a communication fault with emissions inspection equipment. This may be due to the software in the gateway module (GWM). To correct this condition, reprogram the GWM to latest software level using the appropriate Ford diagnostic scan tool. Use causal part 14F642 and applicable labor times from Section 10 of the Service Labor Time Standards (SLTS) Manual.

  Associated Products (32)

  2023 Ford E-1502023 Ford E-2502023 Ford E-3502023 Ford E-4502023 Ford F-6502023 Ford F-7502022 Ford Bronco Sport2022 Ford E-1502022 Ford E-2502022 Ford E-3502022 Ford E-4502022 Ford Escape2022 Ford F-6502022 Ford F-7502022 Lincoln Corsair2021 Ford Bronco Sport2021 Ford E-1502021 Ford E-2502021 Ford E-3502021 Ford E-450+ 12 more
  Associated Documents

  • DownloadMC-10216963-0001.pdf↗
• July 22, 2022•Document ID: 10216489

  Service Bulletin/Repair Instructions
  LATCHES/LOCKS/LINKAGES; EQUIPMENT; STRUCTURE:BODY:TAILGATE

  Mfr Comm. #:

  21M05-S1

  Date Added:

  July 28, 2022

  Manufacturer:

  FORD

  Summary

  Certain 2017-2022 Model Year Super Duty Vehicles Equipped with a Power Release Tailgate - Unintended Tailgate Opening. In the affected vehicles, some customers report experiencing an unintended tailgate opening and may have previously serviced their vehicle for this concern. Ford had developed an enhanced remedy for customers who may want this enhanced repair performed n their vehicle.

  Associated Products (39)

  2022 Ford F-2502022 Ford F-3502022 Ford F-4502022 Ford F-5502022 Ford F-6002022 Ford F-6502022 Ford F-7502021 Ford F-2502021 Ford F-3502021 Ford F-4502021 Ford F-5502021 Ford F-6002021 Ford F-6502021 Ford F-7502020 Ford F-2502020 Ford F-3502020 Ford F-4502020 Ford F-5502020 Ford F-6002020 Ford F-650+ 19 more
  Associated Documents

  • DownloadMC-10216489-0001.pdf↗
• June 6, 2022•Document ID: 10213709

  Service Bulletin/Repair Instructions
  EQUIPMENT ADAPTIVE/MOBILITY; ENGINE AND ENGINE COOLING

  Mfr Comm. #:

  SSM 50830

  Date Added:

  June 17, 2022

  Manufacturer:

  FORD

  Summary

  Some 2020-2022 F-Super Duty vehicles equipped with a 7.3L engine and built on or before 11-May-2022 may exhibit a ticking/clicking/tapping noise at idle that is loudest at the front of the engine where the front timing cover meets the oil pan. This may be due to a cracked oil pump drive gear. If the noise originates from the lower front of the engine, remove the accessory drive belt and retest. If the noise is still present, remove the oil pan and rotate the crankshaft 360 degrees to inspect for cracking. If cracked, replace the oil pump drive gear (LC3Z-6306-A).

  Associated Products (21)

  2022 Ford F-2502022 Ford F-3502022 Ford F-4502022 Ford F-5502022 Ford F-6002022 Ford F-6502022 Ford F-7502021 Ford F-2502021 Ford F-3502021 Ford F-4502021 Ford F-5502021 Ford F-6002021 Ford F-6502021 Ford F-7502020 Ford F-2502020 Ford F-3502020 Ford F-4502020 Ford F-5502020 Ford F-6002020 Ford F-650+ 1 more
  Associated Documents

  • DownloadMC-10213709-0001.pdf↗
• June 2, 2022•Document ID: 10213733

  Service Bulletin/Repair Instructions
  EQUIPMENT:ELECTRICAL

  Mfr Comm. #:

  21P19-S1

  Date Added:

  June 10, 2022

  Manufacturer:

  FORD

  Summary

  Certain 2020-2021 Model Year Super Duty Vehicles - Reconfigure the RCM with As-Built Data. In all of the affected vehicles, the event data recorder (EDR) was inadvertently disabled. In the event of a crash or near crash-like situation, the event data recorder within the restraint control module (RCM) will not collect and store data used to help understand how the safety systems performed. There is no impact to normal vehicle operation or the vehicle’s safety systems.

  Associated Products (14)

  2021 Ford F-2502021 Ford F-3502021 Ford F-4502021 Ford F-5502021 Ford F-6002021 Ford F-6502021 Ford F-7502020 Ford F-2502020 Ford F-3502020 Ford F-4502020 Ford F-5502020 Ford F-6002020 Ford F-6502020 Ford F-750
  Associated Documents

  • DownloadMC-10213733-0001.pdf↗
• May 17, 2022•Document ID: 10212102

  Service Bulletin/Repair Instructions
  ELECTRICAL SYSTEM

  Mfr Comm. #:

  TSB 22-2191

  Date Added:

  May 24, 2022

  Manufacturer:

  FORD

  Summary

  Some 2018-2021 F-150 vehicles equipped with a 3.0L diesel engine, 2016-2022 F-650/F-750 vehicles equipped with a 6.7L engine, and 2017-2022 F-Super Duty vehicles equipped with a 6.7L engine and built on or before 08-Mar-2022 may exhibit an illuminated malfunction indicator lamp (MIL) with diagnostic trouble codes (DTCs) P21DD, P20BA. P20B9, P204C, P208A, P208B, P208C, P203B, P205B, P21CD and/or U02A2 in the powertrain control module (PCM). This may be due to water intrusion within connectors C3613 and/or C4851/C3610 on the reductant harness going to the reductant pump/heater assembly and the reductant level sensor/quality module. This may also be due to movement of the wiring harness causing terminal fretting. To correct the condition, follow the Service Procedure to replace the reductant tank harness, the reductant pump/heater assembly and/or the reductant tank, as well as securing the wiring harness using a cable zip tie fastener.

  Associated Products (42)

  2022 Ford F-2502022 Ford F-3502022 Ford F-4502022 Ford F-5502022 Ford F-6502022 Ford F-7502021 Ford F-1502021 Ford F-2502021 Ford F-3502021 Ford F-4502021 Ford F-5502021 Ford F-6502021 Ford F-7502020 Ford F-1502020 Ford F-2502020 Ford F-3502020 Ford F-4502020 Ford F-5502020 Ford F-6502020 Ford F-750+ 22 more
  Associated Documents

  • DownloadMC-10212102-0001.pdf↗
• May 4, 2022•Document ID: 10211726

  Service Bulletin/Repair Instructions
  ELECTRICAL SYSTEM; POWER TRAIN

  Mfr Comm. #:

  SSM 50742

  Date Added:

  May 14, 2022

  Manufacturer:

  FORD

  Summary

  Some 2020-2022 F-Super Duty vehicles may exhibit an illuminated malfunction indicator lamp (MIL) with diagnostic trouble code (DTC) P0073 for the ambient air temperature sensor stored in the powertrain control (PCM). When performing pinpoint test BF in Workshop Manual (WSM), Section 413-01, the ambient air temperature sensor/outside air temperature display reset procedure has been added to the Ford Diagnostic Repair System (FDRS) diagnostic scan tool. Depending on how the vehicle is equipped, run the FCIM or HVAC. Reset the Outside Air Temperature Sensor Learned Values application. Clear DTCs and retest after performing the reset procedure.

  Associated Products (21)

  2022 Ford F-2502022 Ford F-3502022 Ford F-4502022 Ford F-5502022 Ford F-6002022 Ford F-6502022 Ford F-7502021 Ford F-2502021 Ford F-3502021 Ford F-4502021 Ford F-5502021 Ford F-6002021 Ford F-6502021 Ford F-7502020 Ford F-2502020 Ford F-3502020 Ford F-4502020 Ford F-5502020 Ford F-6002020 Ford F-650+ 1 more
  Associated Documents

  • DownloadMC-10211726-0001.pdf↗
• March 24, 2022•Document ID: 10209384

  Service Bulletin/Repair Instructions
  EQUIPMENT; POWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE:SOFTWARE; ENGINE AND ENGINE COOLING

  Mfr Comm. #:

  SSM 50636

  Date Added:

  March 29, 2022

  Manufacturer:

  FORD

  Summary

  2011-2022 F-Super Duty and 2016-2023 F-650/F-750 vehicles equipped with a 6.7L engine may exhibit an elevated idle condition. During prolonged idle time, vehicles may experience this elevated idle to reduce unburned hydrocarbons from the SCR. The powertrain control module estimates hydrocarbon levels in the SCR and may increase idle speed to remove them. Idle speed will be increased to 1000 RPM for ambient temperatures near 26°C (80°F) and may increase to 1200 RPM at -40 °C (-40°F). Vehicles may exhibit exhaust smoke and diesel exhaust fluid smell during elevated idle condition. Exhaust smoke and smell condition will not affect reliability or durability of the engine. Power take-off (PTO) use and idle set point control will disable elevated speed. It is required that the operator monitor the vehicle and adhere to any Exhaust Filter warning messages.

  Associated Products (64)

  2023 Ford F-6502023 Ford F-7502022 Ford F-2502022 Ford F-3502022 Ford F-4502022 Ford F-5502022 Ford F-6502022 Ford F-7502021 Ford F-2502021 Ford F-3502021 Ford F-4502021 Ford F-5502021 Ford F-6502021 Ford F-7502020 Ford F-2502020 Ford F-3502020 Ford F-4502020 Ford F-5502020 Ford F-6502020 Ford F-750+ 44 more
  Associated Documents

  • DownloadMC-10209384-0001.pdf↗
• December 7, 2021•Document ID: 10205446

  Service Bulletin/Repair Instructions
  ENGINE AND ENGINE COOLING

  Mfr Comm. #:

  SSM 50323

  Date Added:

  December 26, 2021

  Manufacturer:

  FORD

  Summary

  Some 2017-2022 F-Super Duty and 2016-2022 F-650/F-750 with 6.7L diesel engines, 2015-2019 Transit with 3.2L diesel engines and 2018-2021 F-150 with 3.0L diesel engines may exhibit an illuminated malfunction indicator lamp (MIL) with diagnostic trouble code (DTC) P206C in the powertrain control module (PCM). Review of repair data supports that P206C is often the result of incorrect diesel exhaust fluid (DEF) concentration. Per Powertrain Control/Emissions Diagnosis (PC/ED) Pinpoint Test (PPT) RJ, a DEF concentration reading below 28% will set P206C and cause vehicle derate. If low concentration is suspected, drain fluid and replace with known good DEF before replacing any parts. Low concentration of DEF is not a warrantable condition.

  Associated Products (47)

  2022 Ford F-2502022 Ford F-3502022 Ford F-4502022 Ford F-5502022 Ford F-6502022 Ford F-7502021 Ford F-1502021 Ford F-2502021 Ford F-3502021 Ford F-4502021 Ford F-5502021 Ford F-6502021 Ford F-7502020 Ford F-1502020 Ford F-2502020 Ford F-3502020 Ford F-4502020 Ford F-5502020 Ford F-6502020 Ford F-750+ 27 more
  Associated Documents

  • DownloadMC-10205446-0001.pdf↗
• January 21, 2021•Document ID: 10186621

  Service Bulletin/Repair Instructions
  POWER TRAIN

  Mfr Comm. #:

  SSM 49483

  Date Added:

  February 4, 2021

  Manufacturer:

  FORD

  Summary

  Some 2017-2021 F-Super Duty and 2016-2021 F650-750 with 6.7L diesel engines, 2015-2019 Transit with 3.2L diesel engines and 2018-2021 F-150 with 3.0L diesel engines may exhibit an illuminated malfunction indicator lamp (MIL) with diagnostic trouble code (DTC) P206C in the powertrain control module (PCM). Review of repair data supports that P206C is often the result of incorrect diesel exhaust fluid (DEF) concentration. Per Powertrain Control/Emissions Diagnosis (PC/ED) Pinpoint Test (PPT) RJ, a DEF concentration reading below 28% will set P206C and cause vehicle derate. If low concentration is suspected, drain fluid and replace with known good DEF before replacing any parts. Low concentration of DEF is not a warrantable condition.

  Associated Products (40)

  2021 Ford F-1502021 Ford F-2502021 Ford F-3502021 Ford F-4502021 Ford F-5502021 Ford F-6502021 Ford F-7502020 Ford F-1502020 Ford F-2502020 Ford F-3502020 Ford F-4502020 Ford F-5502020 Ford F-6502020 Ford F-7502019 Ford F-1502019 Ford F-2502019 Ford F-3502019 Ford F-4502019 Ford F-5502019 Ford F-650+ 20 more
  Associated Documents

  • DownloadMC-10186621-0001.pdf↗
• January 13, 2021•Document ID: 10186403

  Service Bulletin/Repair Instructions
  EQUIPMENT ADAPTIVE/MOBILITY; POWER TRAIN; EQUIPMENT

  Mfr Comm. #:

  SSM 49439

  Date Added:

  February 4, 2021

  Manufacturer:

  FORD

  Summary

  Some 2020-2021 F-Super Duty vehicles with 6.7L and 10R140 powertrain may exhibit an illuminated powertrain malfunction indicator (wrench) lamp with only DTC P07F6 stored in the transmission control module (TCM). The vehicle may also exhibit harsh engagements, poor shift quality and/or loss of 9th gear as a result of the DTC being set. If no additional DTCs or symptoms are present, clear keep alive memory and transmission adaptive tables with the appropriate Ford diagnostic scan tool, and perform an adaptive learning drive cycle. Transmission replacement is not necessary. Inform customers that a further improved calibration will be available in early March 2021. Let the customer know they can continue to drive the vehicle after performing this SSM, and schedule a service appointment for early March 2021. Monitor OASIS for updates.

  Associated Products (14)

  2022 Ford F-4502021 Ford F-2502021 Ford F-3502021 Ford F-4502021 Ford F-5502021 Ford F-6002021 Ford F-6502021 Ford F-7502020 Ford F-2502020 Ford F-3502020 Ford F-4502020 Ford F-5502020 Ford F-6502020 Ford F-750
  Associated Documents

  • DownloadMC-10186403-0001.pdf↗
• October 30, 2020•Document ID: 10181940

  Service Bulletin/Repair Instructions
  POWER TRAIN; ENGINE AND ENGINE COOLING:EXHAUST SYSTEM

  Mfr Comm. #:

  TSB 20-2380

  Date Added:

  November 5, 2020

  Manufacturer:

  FORD

  Summary

  Some 2020 F-Super Duty vehicles equipped with the 6.2L or 7.3L engine built on or before 05-Jun-2020 may exhibit an illuminated malfunction indicator lamp (MIL) with diagnostic trouble codes (DTCs) P0132, P0135, P0138, P0141, P0152, P0155, P0158 and/or P0161 stored in the powertrain control module (PCM). This may be due to water intrusion into heated oxygen sensor (HO2S) connectors C141, C142, C1571 and/or C1572 on the transmission harness where it connects to the engine exhaust sensors. To correct the condition, follow the Service Procedure steps to replace the transmission harness and the affected heated oxygen sensors (HO2S) and/or the catalyst monitor sensor.

  Associated Products (6)

  2020 Ford F-2502020 Ford F-3502020 Ford F-4502020 Ford F-5502020 Ford F-6502020 Ford F-750
  Associated Documents

  • DownloadMC-10181940-0001.pdf↗
• October 27, 2020•Document ID: 10181936

  Service Bulletin/Repair Instructions
  EXTERIOR LIGHTING; EQUIPMENT; ELECTRICAL SYSTEM

  Mfr Comm. #:

  SSM 49286

  Date Added:

  November 4, 2020

  Manufacturer:

  FORD

  Summary

  Some 2020 F-Super Duty vehicles equipped with an aftermarket bed may exhibit inoperative trailer lights on one or both sides of trailer after performing the FDRS Turn Signal Lamp Configuration application on the vehicle. Version 12 of this application is now available on the FDRS to address this trailer lighting condition. Make sure to download version 12 or later of the FDRS Turn Signal Lamp Configuration and follow the on screen prompts to configure the aftermarket bed. Verify the trailer lighting is operating correctly once complete. If the Turn Signal Lamp Configuration application was previously run on the vehicle, make sure to run the BCM Reset option before re-running the application.

  Associated Products (6)

  2020 Ford F-2502020 Ford F-3502020 Ford F-4502020 Ford F-5502020 Ford F-6502020 Ford F-750
  Associated Documents

  • DownloadMC-10181936-0001.pdf↗
• October 20, 2020•Document ID: 10181924

  Service Bulletin/Repair Instructions
  ELECTRICAL SYSTEM

  Mfr Comm. #:

  TSB 20-2363

  Date Added:

  November 5, 2020

  Manufacturer:

  FORD

  Summary

  Some 2019 MKZ, 2019-2020 EcoSport/Mustang/Continental/Fusion/F-150/Transit Connect/Ranger/Edge/Nautilus and 2020 Escape/Corsair/Aviator/Explorer/Expedition/Navigator/F-Super Duty vehicles with SYNC 3 may experience various SYNC performance related concerns. To correct the condition, follow the Service Procedure.

  Associated Products (37)

  2020 Ford Ecosport2020 Ford Edge2020 Ford Escape2020 Ford Expedition2020 Ford Explorer2020 Ford F-1502020 Ford F-2502020 Ford F-3502020 Ford F-4502020 Ford F-5502020 Ford F-6502020 Ford F-7502020 Ford Fusion2020 Ford Mustang2020 Ford Ranger2020 Ford Transit Connect2020 Lincoln Aviator2020 Lincoln Continental2020 Lincoln Corsair2020 Lincoln Nautilus+ 17 more
  Associated Documents

  • DownloadMC-10181924-0001.pdf↗
• October 14, 2020•Document ID: 10181923

  Service Bulletin/Repair Instructions
  EQUIPMENT; LATCHES/LOCKS/LINKAGES

  Mfr Comm. #:

  TSB 20-2359

  Date Added:

  November 5, 2020

  Manufacturer:

  FORD

  Summary

  Some 2020 F-150/F-Super Duty vehicles built on 18-May-2020 and through 30-Jun-2020 may exhibit a concern where the right rear door lock is inoperative but the manual lock rod works. This may be due to stack up tolerances of the handle, cable and latch. To correct the condition, follow the Service Procedure to remove the cable barrel sleeve.

  Associated Products (7)

  2020 Ford F-1502020 Ford F-2502020 Ford F-3502020 Ford F-4502020 Ford F-5502020 Ford F-6502020 Ford F-750
  Associated Documents

  • DownloadMC-10181923-0001.pdf↗
• September 22, 2020•Document ID: 10180539

  Service Bulletin/Repair Instructions
  ELECTRICAL SYSTEM:SOFTWARE; ENGINE AND ENGINE COOLING; POWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE (TCM/PCM/TECM)

  Mfr Comm. #:

  TSB 20-2336

  Date Added:

  October 2, 2020

  Manufacturer:

  FORD

  Summary

  Some 2020 F-Super Duty vehicles equipped with a 6.7L engine built on or before 19-Aug-2020 may exhibit an illuminated malfunction indicator lamp (MIL) with diagnostic trouble codes (DTC) P0300-P0308, P0603, P203B, P208B, P208C, P2201, P24C2, P27B4, P07F6 and/or P27B5 stored in the powertrain control module (PCM). The vehicle may also exhibit a forced idle condition. This may be due to various strategies within the PCM software. To correct the condition, follow the Service Procedure to reprogram the PCM.

  Associated Products (6)

  2020 Ford F-2502020 Ford F-3502020 Ford F-4502020 Ford F-5502020 Ford F-6502020 Ford F-750
  Associated Documents

  • DownloadMC-10180539-0001.pdf↗
• September 17, 2020•Document ID: 10180372

  Service Bulletin/Repair Instructions
  ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL:CRANKCASE (PCV); ELECTRICAL SYSTEM

  Mfr Comm. #:

  SSM 49185

  Date Added:

  October 6, 2020

  Manufacturer:

  FORD

  Summary

  Some 2020 F-Super Duty and 2021 F-650/F-750 vehicles equipped with a 6.7L diesel engine built on 01-Mar-2020 and through 31-Aug-2020 may exhibit an illuminated malfunction indicator light (MIL) with diagnostic trouble code (DTC) P0088. This may be due to the pressure control valve in the left fuel rail. To correct the condition, replace the left fuel rail along with the pressure control valve (PCV). For F-250 through F-550 vehicles refer to Workshop Manual (WSM), Section 303-04B. For F-650/F-750 vehicles refer to WSM, Section 303-04A. For claiming use causal part 9D280 and applicable labor operations in Section 09 of the Service Labor Time Standards (SLTS) Manual.

  Associated Products (8)

  2021 Ford F-6502021 Ford F-7502020 Ford F-2502020 Ford F-3502020 Ford F-4502020 Ford F-5502020 Ford F-6502020 Ford F-750
  Associated Documents

  • DownloadMC-10180372-0001.pdf↗
• September 9, 2020•Document ID: 10180339

  Service Bulletin/Repair Instructions
  EQUIPMENT ADAPTIVE/MOBILITY; ELECTRICAL SYSTEM:ADAS:DRIVER MONITORING:CAMERA/SENSOR

  Mfr Comm. #:

  TSB 20-2267

  Date Added:

  October 1, 2020

  Manufacturer:

  FORD

  Summary

  Some 2015-2020 F-150 except Raptor, 2017-2020 F-Super Duty, 2018-2020 Expedition vehicles equipped with a front camera washer may exhibit a washer fluid leak at the front camera washer jet when not in use. This may be due to the rubber seal internal to the jet. To correct the condition, follow the Service Procedure to replace the washer jet.

  Associated Products (33)

  2020 Ford Expedition2020 Ford F-1502020 Ford F-2502020 Ford F-3502020 Ford F-4502020 Ford F-5502020 Ford F-6502020 Ford F-7502019 Ford Expedition2019 Ford F-1502019 Ford F-2502019 Ford F-3502019 Ford F-4502019 Ford F-5502019 Ford F-6502019 Ford F-7502018 Ford Expedition2018 Ford F-1502018 Ford F-2502018 Ford F-350+ 13 more
  Associated Documents

  • DownloadMC-10180339-0001.pdf↗
• September 2, 2020•Document ID: 10180333

  Service Bulletin/Repair Instructions
  ELECTRICAL SYSTEM; ENGINE AND ENGINE COOLING; EQUIPMENT ADAPTIVE/MOBILITY

  Mfr Comm. #:

  TSB 20-2298

  Date Added:

  October 1, 2020

  Manufacturer:

  FORD

  Summary

  Some 2020 F-Super Duty vehicles may exhibit a condition where the engine will not turn off and/or have various electrical symptoms including a dead battery, horn stays on and no crank/no start. This may be a result of water/moisture intrusion into the battery junction box (BJB). The BJB is located under the hood of the vehicle. This water/moisture intrusion may be related to the BJB cover not installed completely or broken cover tabs/locking fingers allowing water/moisture into the BJB. To correct the condition, follow the Service Procedure steps to inspect for water/moisture intrusion into the BJB and replace the BJB if water/moisture intrusion is found.

  Associated Products (6)

  2020 Ford F-2502020 Ford F-3502020 Ford F-4502020 Ford F-5502020 Ford F-6502020 Ford F-750
  Associated Documents

  • DownloadMC-10180333-0001.pdf↗