Ford F-150 Complaints

2,276 consumer complaints on file.

#11583557April 17, 2024
SERVICE BRAKES, FORWARD COLLISION AVOIDANCE: WARNINGS
Normal brakes fail. Only the emergency brake functions and locks up one of the rear tires.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11582935April 14, 2024
VISIBILITY/WIPER, UNKNOWN OR OTHER
2023 F-150 with only 12k miles, air not blowing on A/C. No cold air blowing at all. Blower can be heard on but no flow. Happening intermittently and of course no defrost or defog when present affecting visibility. Issue described and reported by many drivers. Ford not acknowledging issue since not easy to replicate. Happens randomly.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11582762April 13, 2024
SERVICE BRAKES
My family and I were driving to a local coffee shop when my dash went off with a low brake fluid warning, I pull over to check and it was bone dry. That pretty odd so I immediately start looking for leaks and discovered the passenger side rear brake line where it connects to the rubber hose and goes to the caliper has a MAJOR leak. I videoed the leak so show how bad it was and where it was leaking from. The rubber hose itself if fine the leak is coming from the metal part of the hose but unfortunately the way to fix the issue is by replacing the hose assembly and according to ford that part is a wearable item, so my extended warranty I paid for it does not cover it. I find it absurd and extremely dangerous that a three-year-old truck has a major brake fluid leak like that and Ford has been no help at all. I’ve spent all day on the phone with them arguing and they don’t seem to care. This is a major safety issue from a clearly faulty part from the manufacturer, and I don’t feel as though I should be responsible with the bill.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11582685April 12, 2024
VEHICLE SPEED CONTROL, SERVICE BRAKES, HYDRAULIC:PEDALS AND LINKAGES
The contact owns a 2023 Ford F-150. The contact stated while driving 45 MPH, the vehicle unintendedly accelerated. The brake pedal was depressed; however, the vehicle failed to decelerate. The contact shifted into neutral, and the brake pedal responded as needed. The contact merged to the side of the road. A local dealer was contacted. The vehicle was not diagnosed or repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 18,060.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11582560April 12, 2024
POWER TRAIN
Transmission has failed/malfunctioned resulting in two separate inspections/repairs by Ford of West Covina, CA. First inspection on [XXX] and mileage in at 8,954. Complaint of harsh downshift in transmission. Service involved the teardown of the transmission found E clutches burnt. Found excessive clutch material in the main control body valves and scored sticking unable to return freely. Performed overhaul. Replaced E clutches and seals. Replaced main control body. Installed new solenoid strategy. Post road test vehicle OK, however the mileage out of shop was 8,952 on [XXX]. Second inspection on [XXX] and mileage in at 11011. Complaint of clunking noise heard when shifting and going into gear. Service found leaking hydraulic circuit. Teardown found CDF cylinder bushings scored and HUB scored rings torn. Found main control body valves scored sticking unable to return freely Performed overhaul replaced seals. Replaced CDF cylinder and HUB. Replaced main control body. Installed new solenoid strategy. Post road test vehicle OK. Mileage out of shop was 11020 on [XXX]. Two days after this service, transmission made very loud clunk and jerking movement when going into gear and continues to have harsh downshift, clunking noises, and jerking movement when going into gear causing the vehicle to jump forward when braking. This action is putting others at risk of injury/death in the event the transmission fails and is unable to change gear. No warning lamps messages or have appeared. Problems first started to appear within the first six months of purchase date [XXX]. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11582469April 11, 2024
ELECTRICAL SYSTEM, POWER TRAIN, FORWARD COLLISION AVOIDANCE: WARNINGS
On numerous occasions all of the vehicles electronics, including screens, would shut off. Sometimes this happens while driving at highway speeds causing the vehicle to lose all power. When approaching the car to unlock there is often no power to access the vehicle, which requires manually unlocking the vehicle with the key, opening the hood, then touching metal to the battery terminal to reset the electronics. The vehicle has lost power in the middle of intersections, on the highway, and in parking lots. There are times when the car signals a fault with several of the ADAS features. When this happens it’s usually probable that once the vehicle is shut off, I won’t be able to get it started again without touching metal to the battery terminal. I have started to document the failures through video to show to the technicians just in case the OBD doesn’t match what I describe. The date I’m including is the most recent occurrence but does not reflect the many occurrences since purchasing the vehicle last spring.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11582149April 10, 2024
POWER TRAIN
The contact owns a 2021 Ford F-150. The contact received notification of NHTSA Campaign Number: 23V896000 (Power Train) however, the part to do the recall repair was not yet available. The contact stated while driving at various speeds, there was an abnormal sound coming from the rear end of the vehicle. The vehicle was taken to the dealer to be diagnosed. The contact was informed that the hub nut was fractured. The dealer replaced the hub nut and the rear axle and informed the contact that the repair was temporary. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the failure. The failure mileage was approximately 40,000. VIN tool confirms parts not available.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11582114April 10, 2024
ELECTRICAL SYSTEM, ELECTRICAL SYSTEM:ADAS:DRIVER MONITORING:CAMERA/SENSOR
The vehicle will occasionally freeze on the infotainment splash screen. This prevents the rear view camera from activating when the vehicle is in reverse. Furthermore, the vehicle has already been serviced for a prior issue where the infotainment system (and rear view camera video) would momentarily freeze (1-4 seconds) when the camera was activated
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11582043April 10, 2024
SUSPENSION
IWE issues in 2WD mode, experiencing random vibration from the front end, particularly when cold 32 degrees and below. Vibration wont stop until you pull over and stop vehicle. Sounds like hitting rumble strips. It is an intermittent problem. It has happened so far 3 times since ownership. Once in Decemeber, February, and March with each time 2 miles away from my home and the temps being 32 degrees and below. There are numerous reports on this problem with the 2023 F150 on the f-150 forum page. Some users have tagged ford as they posted their frustration over this annoying problem. You pay so much for these vehicles only to be left with additional problems and the company not doing anything for you to remedy the issue. These vehicles are are mortgages anymore.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11581890April 9, 2024
POWER TRAIN:DRIVELINE:DIFFERENTIAL UNIT, POWER TRAIN:AXLE ASSEMBLY, WHEELS
The contact owns a 2022 Ford F-150. The contact stated that while driving at various speeds and turning, there was an abnormal sound coming from the front end. There were no warning lights illuminated. The vehicle was taken to the local dealer, where it was diagnosed that the integrated wheel end needed to be replaced. The vehicle was not repaired. The manufacturer was contacted and referred the contact to the NHTSA Hotline. The failure mileage was approximately 5,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11581716April 8, 2024
VISIBILITY:DEFROSTER/DEFOGGER/HVAC SYSTEM
I recently purchased a new 2023 Ford F150, XL Trim, Crew Cab truck. This weekend on a trip, the vehicle's air conditioning began to malfunction. After operating for less than an hour and without adjusting the fan motor speed, the volume of air coming out of the vents gradually decreases to nothing and the cab of the vehicle begins to warm. With only 350 miles on the vehicle, I pulled off of the road, turned off the engine, and let the vehicle set for 20 minutes, hoping everything would reset. After the 20-minute period, I started the vehicle and the AC seemed to be working as it should. After driving another 20-30 minutes, the cab began to warm again and upon checking the air coming from the vents, it was minimal to none. I turned up the fan to max speed and the volume of air coming from the vents remained minimal and the temperature in the cab continued to rise. This time I turned the system AC off (no compressor) and left the fan on to bring in outside air in hopes of dropping the cabin temp. Immediately after turning the AC system off the air flow from the vents increased to a normal level. After operating with the AC off for 20 minutes, I turned the AC back on and the system, and yet again, the AC System operated as it should. This went on for my entire 8-hour trip. Not only an uncomfortable inconvenience, but this issue could also be safety issue (visibility) when depending on the vehicle's defog/defrost system as the AC system (compressor and condenser) is used for defogging/defrosting the vehicles windows. A similar issue has been noted in previous year models under Ford Tech Service Bulletin 22-2089. Being my issue is duplicated in the issue section of the service bulletin, the year model of my vehicle is not included. In performing some internet research, it seems that many owners of 2023 Ford F150 models are experiencing this exact issue. This issue does not cause panel lights to illuminate. Currently awaiting call back from Ford Dealer.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11581482April 6, 2024
UNKNOWN OR OTHER
The display screen went black. Without it there is no back up camera ( and many other features). This is a king cab long bed. Very dangerous to drive without these important safety features working properly. The dealer says it is a “common problem”. It is a $1500 repair if it were not still under warranty.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11581441April 5, 2024
POWER TRAIN
High-speed highway travel this morning. Switched lanes and pressed accelerator; engine cut out. Seemed to be in no gear for 6-9 seconds before lurching into power again. Incident was very dangerous and forced a rapid slowing in fast lane affecting traffic behind me. This has happened 4 times in the past 8 months.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11581295April 5, 2024
SERVICE BRAKES, HYDRAULIC
The contact owns a 2021 Ford F-150. The contact stated that the brake power booster was emitting a hissing sound when the brake pedal was being depressed. The contact used an excessive amount of pressure to depress the brake pedal. The ABS warning light was illuminated but deactivated independently. The vehicle was taken to the dealer, but the cause of the failure was not determined. The dealer confirmed that the failure was related to NHTSA Campaign Number: 21V533000 (Service Brakes, Hydraulic) however, the VIN was not included. The vehicle had not been repaired. The manufacturer was made aware of the failure, and it was confirmed that the VIN was not included in the recall. The contact was referred to the NHTSA Hotline to file a complaint. The failure mileage was 28,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11580841April 3, 2024
VISIBILITY/WIPER
My windshield wipers stopped working. It seems the wiper motor still kicks on and I can hear it move, but the wipers don’t move and are stuck. It’s almost as if the wipers are off track or something. Once my vehicle was stopped, I was able to move the wipers back down, but it won’t move after that. I can still hear the motor turning on though.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11580759April 2, 2024
ELECTRICAL SYSTEM: INSTRUMENT CLUSTER/PANEL
The contact owns a 2021 Ford F-150. The contact stated that while driving 65 MPH, several unknown warning lights were illuminated on the instrument panel and then turned off independently. The instrument panel then failed to operate as designed. The vehicle was not diagnosed or repaired. The manufacturer was made aware of the failure and referred the contact to the NHTSA Hotline. The failure mileage was approximately 57,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11580280March 31, 2024
ELECTRICAL SYSTEM
The on board generator auxiliary fails to work because of "ground fault". Complaint to dealer (McDonald Ford, Freeland, MI) who stated has been receiving numerous complaints of this failure but has no remedy nor direction from Ford. This has been a continuous problem for the last few months.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11579759March 27, 2024
ELECTRICAL SYSTEM, VISIBILITY/WIPER, STRUCTURE:BODY
F150 is experiencing interior leaking from the windshield and other areas that Ford is unable to identify the cause. This can cause visibility issues and damage to electrical components resulting in a safety issue. The leaking causes the floor mats to be wet, which have also caused my foot to slip off the control petals. This could cause an accident. Ford is not able to identify the source, they were able to reproduce the leaks in the firewall but can't identify the source. Ford doesn't acknowledge this is a major issue and has only offered to caulk and seal in the most common areas. It was in the shop for four days March 25-27 and 22-23 2024. There are no warning issues just went floor mats and visible water on the interior of my windshield which I demonstrate to the dealership.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11579686March 27, 2024
EXTERIOR LIGHTING, LANE DEPARTURE: BLIND SPOT DETECTION
Tail lamp assembly both sides, allowing moisture within the lighting assembly potentially resulting in short circuit or fire if water comes in contact with electrical connections.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11579685March 27, 2024
ELECTRICAL SYSTEM, FUEL/PROPULSION SYSTEM, UNKNOWN OR OTHER
OBDii reader which connect to vehicle ECM reads perfectly independently, however when connected to a state emissions inspection machine, machine indicates no vehicle information available and results in failures due to ECM not responsive. Ford says it is a known issue but will not replace ecm unless recall is issued.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Ford F-150