Ford Bronco Sport Complaints

1,315 consumer complaints on file.

#11673973July 16, 2025
POWER TRAIN, ELECTRICAL SYSTEM
The contact owns a 2021 Ford Bronco. The contact stated while driving 60 MPH, the vehicle started to lose motive power and was shaking abnormally. The contact depressed the accelerator pedal, and the RPM became elevated; however, the vehicle failed to respond as intended. The contact stated there was no warning light illuminated. The contact was able to exit the high and parked in a parking lot. The contact turned off and restarted the vehicle and became aware that the wrench symbol was displayed. The contact shifted into reverse to exit the parking lot and "Low Power Mode” warning light flashed on the instrument panel. The contact was able to drive the vehicle to a dealer at speeds below 30 MPH. The dealer diagnosed the vehicle and determined that the transmission had failed and needed to be replaced. The vehicle was not repaired. The contact researched online and related the failure to NHTSA Campaign Number: 25V158000 (Power Train, Electrical System). The contact had replaced the 12-Volt battery prior to the failure because the battery failed to charge. The contact had the alternator checked by a battery shop and the battery was in operational condition. The manufacturer was informed of the failure and informed the contact that the vehicle was not covered under warranty. The failure mileage was approximately 82,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11673918July 16, 2025
UNKNOWN OR OTHER
What component or system failed or malfunctioned, and is it available for inspection upon request? AutoNation Ford Corpus Christi found purge valve making abnormal clicking sound, valve sticking and closed. I replaced the valve with a new OEM part. Code P04F0 came off but vehicle would still lag and sputter when accelerating. How was your safety or the safety of others put at risk? feels like vehicle can hesitate or stop while accelerating and get rear ended Has the problem been reproduced or confirmed by a dealer or independent service center? Took vehicle back to AutoNation Corpus Christi and the tech's cannot find anything wrong with the vehicle but there is definitely an obvious issue. Has the vehicle or component been inspected by the manufacturer, police, insurance representatives or others? Inspected by AutoNation Corpus Christi technicians and they cannot pinpoint the issue. Were there any warning lamps, messages or other symptoms of the problem prior to the failure, and when did they first appear? Warning light code P04F0 comes on, recommended purge valve replaced but issue vehicle still lags and sputters when accelerating.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11673709July 15, 2025
VISIBILITY:WINDSHIELD
The contact owns a 2024 Ford Bronco Sport. The contact stated that while the vehicle was parked outside, the front windshield cracked. The front windshield had a long horizontal crack. There was no warning light illuminated. Upon inspection, the crack had started from the inside of the windshield. The vehicle was taken to the dealer where it was inspected. The contact was informed that the windshield had cracked due to stress from sun exposure. The vehicle was not yet repaired. The manufacturer was not notified of the failure. The approximate failure mileage was 3,500.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11673205July 13, 2025
ENGINE, ELECTRICAL SYSTEM, POWER TRAIN
Since I have bought this used vehicle in September 2024, it has been shutting off completely with having to restart the engine. There was a recall for the battery in January 2025 that was finally approved to be replaced maybe in May or so. Battery was replaced but it keeps shutting off. I just took it in July 7 for the fuel pump to be replaced as they said that was the final cause. I drove it home the same day when it was finished and it has been shutting off still. It has shut off while I have been at the light, in reverse and as well as putting my vehicle into reverse by itself which could cause an accident. This situation has since be unresolved. I have taken it to the ford dealership with them many times with them saying there is nothing wrong with it.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11673068July 12, 2025
ENGINE, FUEL/PROPULSION SYSTEM
Vehicle stutters when driving at slower speeds, usually between 22-27 MPH. After purchasing my vehicle used I have found that others have been reporting the same issue, to include in brand new Bronco Sports, and have been advised that is just how they are. Switching to sport mode does seem to help but the stutters occurs at different speeds. There has been no known part identified as causing the issue. There are no warnings displayed and no codes showing.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11672946July 11, 2025
POWER TRAIN
I have a 2021 Bronco sport Big Bend with only 27,000 miles on it. it I started to notice a binding sensation and accompanying noise from the rear of the vehicle when making sharp low speed turns. I took it to the dealership and they thought it was a brake problem but nothing was found from this inspection and the noise persisted. Then I took it in and had the rear differential inspected and found that the axle retaining clip is broken or has fallen off and the axle is pounding on the retaining pin. The Tech told me that this is a very common problem with Bronco sport Big Bends and requires replacement of the entire differential and the axel shaft, this is a four thousand dollar repair on a lightly used vehicle with low miles. The dealer says there is a national back order on these parts as this is such a common problem with this model.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11672731July 11, 2025
POWER TRAIN, VEHICLE SPEED CONTROL, ENGINE
The Powertrain of this Ford Bronco Sport (2024) with only 12,000 miles on it malfunctioned while the driver was on a major highway. No control over gears, engine power, etc. Had to pull over in heavy traffic. Fortunately there was a shoulder, or this would have been a major safety risk for the driver and other vehicles and would likely have resulted in an accident. Apparently, this malfunction is related to battery issues as well and can affect the emergency caution flashers. The vehicle was inspected by Ford after being towed to a local dealership and was told that this was part of a recall on other Ford Broncos. A few days later, was told that Ford dealership was replacing the transmission and other parts.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11672645July 11, 2025
SEAT BELTS, UNKNOWN OR OTHER, ELECTRICAL SYSTEM
I bought my vehicle brand new and have received several recall notices and have had to have repairs done for common issues not featured in recalls but maybe service bulletins. I have had the water pump replaced 2x in the last 2 years Rear differential replaced completely linked to the recalled issue. PCM software is being recalled for the second time in 2 years. I’ve have owned exclusively ford and this model has been a near nightmare. I get my cars serviced regularly so it’s definitely not due to lack of maintenance but instead seems as if the 2022 bronco sport model was tainted from the manufacturer.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11672335July 9, 2025
VISIBILITY/WIPER, UNKNOWN OR OTHER
The vehicle was bought brand new in February of this year, 2025. Was bought and has been driven by my daughter who turned [XXX] this year. She went to camp and the vehicle sat behind the house till she got back. the vehicle and front windshield face west and is exposed to the summer sun from 11:30 till 8pm. When she got back and went to drive the car on [XXX], there was a large stress crack in the middle of the windshield. (will attach pictures if possible with this online form). I had my neighbor check his security camera to see if anyone had vandalized the vehicle or if there had been any large object fall on the vehicle. after reviewing his recorded video, we both saw that no one touched the vehicle and that nothing fell on the windshield during the time it sat. I contacted Ford Motor Co. and they instructed me to take it to the dealership and have them take a look and then submit a claim if they thought it was a stress crack from the sun. I took the vehicle in to the dealership on June 26, 2025 and was told I would hear updates over the next few days. Over a week went by and I had to call the service dept at Wyatt Johnson Ford in Nashville. The Assistant service manager stated that Ford Warranty was denying the claim and stated that something else must have caused the crack. The Assistant Manager told me that the technician had written that they believed it was a stress crack from sun exposure and had submitted photos that backed up that claim. Also, on the work order, the Assistant Manager also wrote that it was a stress crack from sun exposure. There is a deep, horizontal crack in the middle of the windshield that has no origination marks or indentations which one would expect from the way that Ford Motor Warranty is denying the claim. I have asked the Assistant Manager to resubmit the claim and I sent him the photos I had taken as soon as it was first noticed. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11671668July 7, 2025
ENGINE AND ENGINE COOLING:ENGINE:GASOLINE:TURBO/SUPERCHARGER
The contact owns a 2021 Ford Bronco Sport. The contact stated that while her daughter was driving at an undisclosed speed, the vehicle inadvertently lost motive power and was unable to accelerate above 30 MPH. The failure persisted; however, the contact was able to drive to the intended destination. No warning lights were illuminated. The vehicle was taken to the dealer, who diagnosed a failure with turbo charger. The contact was informed that the turbo charger needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure, a case was opened, and the contact was referred to the NHTSA Hotline for assistance. The failure mileage was 70,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11671650July 7, 2025
ELECTRICAL SYSTEM
My screen suddenly went black and now I have no back-up camera. My VIN is not associated with the recent camera recall, but it probably should be. This car has been reprogrammed several times for various different recalls (6).
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11671479July 6, 2025
POWER TRAIN, FORWARD COLLISION AVOIDANCE: WARNINGS
In 2022 I bought my bronco and took it in for the transmission going into the wrong gear and coming out of park. They said yes that’s happening and did something with the programming. It continued to run funny and have occasional issues with shifting which I assumed was in my head. Yesterday however I found out it wasn’t. I turned my bronco on and put it in reverse but it just started reviving and didn’t move so I tried drive same thing so I turned it off then back on all of a sudden it made a bang and lunged into reverse in front of a car and I almost got hit. I also when to pull out a few weeks prior and my car didn’t go and I almost got hit. Today my bronco stalled on the highway I was able to coast off the road but it then sounded like a chainsaw and wouldn’t go into any gear so I had it towed. I get the three chance rule however I feel like in the case due to repeated and extensive safety concern they need to do something. I also am not the only 2022 bronco owner with these exact issues as I found others on online forums with the same things.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11670733July 2, 2025
POWER TRAIN
The contact owns a 2021 Ford Bronco Sport. The contact stated while driving at an undisclosed speed, the vehicle jerked abnormally. There was no warning light illuminated. The vehicle was taken to the dealer where it was diagnosed with a fractured and leaking CV boot. The contact was informed that the CV boot needed to be replaced. The vehicle was not repaired. In addition, the contact stated that the vehicle had been at the dealer several times due to the persistent failure. The manufacturer was made aware of the failure and a case was filed. The contact was informed that the repair was not covered under recall or special programs. The contact was advised to contact the NHTSA Hotline to report the failure. The failure mileage was approximately 70,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11670217June 30, 2025
SUSPENSION, STEERING
The contact owns a 2021 Ford Bronco Sport. The contact stated while attempting to make a left turn, the front and rear end of the vehicle was shaking abnormally. The contact stated that neither a dealer nor an independent was contacted. The vehicle was not taken to a dealer or an independent mechanic to be diagnosed. The vehicle was not repaired. The contact related the failure to an undisclosed Technical Service Bulletin; however, the vehicle was not included. The manufacturer was notified of the failure and opened a case. The contact was referred to the NHTSA Hotline for assistance. The failure mileage was 24,900.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11670167June 30, 2025
POWER TRAIN, ELECTRICAL SYSTEM
The contact owns a 2023 Ford Bronco Sport. The contact stated that while driving at various speeds, the vehicle stalled. The vehicle was taken to the local dealer and the contact was informed that the cold cranking amp battery installed during the vehicle assembly was incorrect and informed the contact that the battery needed to be replaced. The vehicle was not yet repaired. The manufacturer was notified of the failure, but no assistance was offered. The contact was informed that the VIN was not included in NHTSA Campaign Number: 25V158000 (POWER TRAIN, ELECTRICAL SYSTEM). The contact stated that the vehicle had experienced the failure listed in the recall. The failure mileage was 43,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11670152June 30, 2025
SERVICE BRAKES
Brake Valve Failure while driving
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11669716June 27, 2025
UNKNOWN OR OTHER
Backup camera is blue screened. Says to see dealer . Vehicle only has 28,009 miles on it. Thx
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11669024June 24, 2025
ELECTRICAL SYSTEM, ENGINE, POWER TRAIN
Vehicle: 2021 Ford Bronco VIN: [XXX] Mileage: Approximately 88,000 miles Complaint: I am reporting major safety and drivability concerns with my 2021 Ford Bronco, which is currently undrivable and in the shop at Ron DuPrat Ford in Dixon, California. Despite experiencing issues nearly identical to those covered under existing recalls, my vehicle’s VIN is not currently included. While driving on the freeway, the vehicle suddenly malfunctioned. Without warning, it dropped into first gear at high speed, causing a rapid and unexpected deceleration. This could have easily resulted in a serious accident or even death — not only for my family but for others on the road. This is a major safety issue. After pulling off the road, the vehicle would no longer go into reverse and became completely undrivable. I also received multiple dashboard alerts, including: “An electrical fault has occurred with the transmission fluid pressure sensor circuit and its associated wiring.” “Powertrain Malfunction / Reduced Power” “A Powertrain or All Wheel Drive (AWD)/Four Wheel Drive (4WD) fault has been detected.” This is our main family vehicle, used daily for commuting and travel. I am still making payments on it, and the fact that it has become unsafe and unusable at this mileage is unacceptable. If this vehicle was not built for long-term use or daily driving, that should be clearly stated not discovered through dangerous failures like this. I no longer feel safe transporting my children in this car. I strongly urge the NHTSA to investigate whether the current recall coverage should be expanded to include additional VINs like mine. This appears to be a serious safety defect that poses a risk to drivers and passengers and requires immediate attention. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11668532June 23, 2025
ELECTRICAL SYSTEM
The contact owns a 2022 Ford Bronco Sport. The contact stated that the vehicle slightly hesitated while depressing the start button. There was no warning light illuminated. The contact then received notification of NHTSA Campaign Number: 25V019000 (Electrical System). The contact scheduled an appointment to have the vehicle serviced; however, the dealer informed the contact that the vehicle needed to be kept overnight for the repair. Due to other commitments, the contact was unable to leave the vehicle overnight and declined the services at that time. The contact then stated that while driving 20 MPH, the vehicle shut off with the parking brake warning light flashing on the instrument panel. The contact was left stranded in the middle of the road, activated the hazard lights, and was able to restarted the vehicle, and drove to the residence. The contact stated that the vehicle had since failed to start with an unknown service message flashing on the instrument panel. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 32,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11668427June 22, 2025
STEERING, POWER TRAIN
Vehicle chutters especially turn low speed turns and after stopping and making turn. You can feel vibration in the steering wheel and can be jerky turning. I have read of multiple other reports of this happening to vehicles and there is a TSB (24-2185)out for the repair. Ford knows about it and should be liable for the fix.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Ford Bronco Sport