Ford Bronco Sport Complaints

1,315 consumer complaints on file.

#11759822August 26, 2026
POWER TRAIN, ENGINE
Unresolved/unrepairable safety recall Engine RPM's revving abnormally high without corresponding acceleration; extremely slow and delayed acceleration. Sudden and unexpected jolts or surge of power following periods of inadequate acceleration. Significant difficulty safely accelerating and merging onto a freeway. Loss or lack of expected power when accelerating. Rattling and vibrating at the front of the vehicle when it is hot outside or car is hot. Inaccurate fuel gauge at times when hot All concerns above have been discussed and worked on by Walnut Creek Ford Service Center, California. I was told that the recall remedy is not ready, to drive the car in Sport Mode and that they lowered power in the fuel area. The safety recall concerns me due to the risk of fire and the lack of acceleration is definitely a hazard on the road. There were no warning lights, only the feel of the loss of acceleration. Copies of all documents and service records have been sent for a formal complaint to the NHTSA. They will not be uploaded to this complaint.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11759471August 25, 2026
POWER TRAIN
I am experiencing severe drivetrain binding and violent shuddering/chatter from the Rear Drive Unit (RDU) during low-speed turns in both directions. The vehicle hesitates and can stop violently on its own while turning. When the vehicle is parked and shut off, it also violently jerks backward, indicating the RDU is binding and storing mechanical tension. This is a significant safety hazard. The symptoms match the current Ford Technical Service Bulletin TSB 26-2328 (Chatter/Shudder During Low Speed Turning Events), which supersedes earlier bulletins including 26-2194 and 25-2351. I first reported the RDU issue along with a rear brake noise at the dealership and provided the relevant TSB numbers. The dealership stated the RDU was fine, performed only the brake TSB, and attributed the shudder to the brakes. After the vehicle was released, the RDU symptoms returned approximately 100 times worse within two days. On the return visit the dealership said they could not reproduce the concern and initially documented it as “just a noise.” I have repeatedly asked Ford (case management and Business Operations) whether the vehicle is considered safe to drive or sell in its current condition. I have not received a clear written answer. The original dealership has also refused to give a direct safety answer. I am requesting that this safety-related RDU condition be properly investigated and repaired.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11758564August 21, 2026
FUEL SYSTEM, GASOLINE
The contact owns a 2021 Ford Bronco Sport. The contact received notification of NHTSA Campaign Number: 25V467000 (FUEL SYSTEM, GASOLINE); however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11758228August 20, 2026
POWER TRAIN
See attached document for complaint.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11757998August 19, 2026
ENGINE, FUEL/PROPULSION SYSTEM
My vehicle is subject to NHTSA Recall 25V467 / Ford Recall 25S76 for a fuel injector that may crack and leak fuel into the engine compartment, creating a risk of fire. The recall was issued in July 2025 and remains open more than a year later. Ford has provided an interim PCM software update intended to detect a leaking injector and mitigate the fire risk, but this does not replace the defective fuel injectors and the recall remains open. Ford states that a final remedy is still being developed / is not currently available for my vehicle. I am concerned about the length of time this safety defect has remained without an available permanent repair. The vehicle continues to be operated while subject to a known fuel-leak and underhood-fire risk, and I do not have the ability to have the defective components permanently repaired despite the recall having been open since July 2025. I am requesting that NHTSA review the delay in Ford providing the final remedy for Recall 25V467. The vehicle is available for inspection upon request. I have not experienced a fuel leak, fire, crash, or injury at this time.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11757676August 18, 2026
ELECTRICAL SYSTEM, ENGINE, FUEL/PROPULSION SYSTEM
I purchased a new 2024 Ford Bronco Sport on XXX from Sayville Ford in [XXX]. They failed to disclose an unremedied safety recall (24V-267) on the vehicle that was issued on XXX and still sold me the vehicle. When I went back to them after seeing that there was a recall on the car, they denied the existence of the recall despite me showing them the recall notice on both the NHTSA and Ford websites. Last year there was another safety recall for leaking fuel injectors (25V-467) that I brought my car in for service, and they claimed to have done a software fix. Upon checking the recall checked on the NHTSA website (6 months after service) it lists that the safety recall work was never performed, despite the dealership keeping my car for the entire day and telling me the work was performed. This dealership has been evasive and deceptive when I have confronted them about these issues and should be examined and fined for their practices. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11757631August 18, 2026
FUEL SYSTEM, GASOLINE
The contact owns a 2022 Ford Bronco. The contact received notification of NHTSA Campaign Number: 25V467000 (Fuel System, Gasoline); however, the part to do the recall repair was unavailable. The vehicle was taken to the dealer, and the contact was informed that the part to do the recall repair was unavailable. The contact was advised to take the vehicle to the dealer if the vehicle experienced the failure. The manufacturer was contacted. The contact had not experienced a failure.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11757551August 17, 2026
Carry Handle, Shell, Base
Locking device to secure car seat to the base broke, on this REPLACEMENT infant car seat. Graco Case #49771285, 10/19/25 (I no longer have pictures or videos of defective car seat, Graco should have them on file. The infant seat was returned to Graco QA, the Graco replaced it with current defective car seat on 10/24/25). Current Graco infant car seat Case # 5195437 with Reference # 520230003. I have pictures of this one. In addition, our daughter gave us her back up car seat to use with her son, the one we bought the above car seats for. This SSME & 3rd infant car seat had the SAME DEFECT! We asked Graco to RECALL these seats. They said they don’t make them any longer. We requested a recall again and said we would also be submitting a report of defect to NHTSA, this is it. We are concerned for the safety of thousands of infants nationwide that are still using these infant car seats. PLEASE follow up with Graco AND recall these infant car seats. Thank you from a concerned grandparent.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11757469August 17, 2026
POWER TRAIN
Both the valve included in Ford's TSB 24-2185 and the clutch pack included in TSB 26-2328 both defaulted in the vehicle, causing debris and metal shavings to accumulate in the RDU which resulted in pitting of the gears and parts. This has resulted in a complete RDU replacement. The vehicle has only 65,700 miles.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11757286August 16, 2026
POWER TRAIN, ELECTRICAL SYSTEM, ENGINE
The vehicle was slowing down after leaving a stop light and within a short distance completely shut down no lights no power nothing wouldnt start to put in neutral so we can get it from the middle of traffic on a 2 lane highway. After about 15 minutes of trying to see what the issues was it turned over and we put the car in gear and pushed ot to the side of the road
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11757261August 16, 2026
SERVICE BRAKES, ELECTRICAL SYSTEM, VEHICLE SPEED CONTROL
Pre-Collision System warning activated unexpectedly. The vehicle then accelerated by itself unexpectedly and the accelerator/throttle was engaged by itself. Breaks were then hard to push and vertically impossible to slow down. At the time, there was no vehicle or obstruction immediately around the vehicle other than a possible box, or small obstruction in the road. Yes the vehicle is available for inspection upon request. Due to the unexpected activation of the pre-collision system followed by unexpected acceleration by itself, caused the vehicle to move unexpectedly and resulted in a collision with another vehicle, creating a safety risk to the occupants of both vehicles. No. The problem has not yet been reproduced or confirmed by a dealer or independent service center. No. The vehicle has not yet been inspected by the manufacturer, police, insurance representatives, or any other party. The police did come to the accident and a police report was filed. Yes. The vehicle's Pre-Collision System warning activated unexpectedly immediately prior to the incident. There were no other known warning lamps or messages before the vehicle unexpectedly accelerated by itself and collided with another vehicle.
Crash:
Yes
Fire:
No
Injuries:
0
Deaths:
0
#11756971August 14, 2026
FUEL SYSTEM, GASOLINE
The contact owns a 2021 Ford Bronco Sport. The contact received notification of NHTSA Campaign Number: 25V467000 (Fuel System, Gasoline); however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was not made aware of the issue. The manufacturer was not made aware of the issue. The contact had not experienced a failure.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11756954August 14, 2026
FUEL SYSTEM, GASOLINE
The contact owns a 2023 Ford Bronco Sport. The contact received notification of NHTSA Campaign Number: 25V467000 (Fuel System, Gasoline); however, the part to do the recall repair was not yet available. The local dealer was contacted and confirmed that the part was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11756886August 14, 2026
FUEL SYSTEM, GASOLINE
The contact owns a 2021 Ford Bronco Sport. The contact received notification of NHTSA Campaign Number: 25V467000 (FUEL SYSTEM, GASOLINE); however, the part to do the recall repair was unavailable. The local dealer was contacted, and it was confirmed that the part was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11756679August 13, 2026
STRUCTURE:BODY:HOOD
The contact owns a 2024 Ford Bronco Sport. The contact stated that while driving at an undisclosed speed, the hood independently unlatched and flew open. The front windshield was cracked, and other damage to the vehicle was sustained. The vehicle was taken to the dealer; however, the failure was not duplicated. The contact stated that the failure was a known failure with similar vehicles. The manufacturer was made aware of the failure, and a case was filed. The contact was informed that an inspector had inspected the vehicle. The contact was informed that the failure was not a manufacturer defect and the case was denied. The failure mileage was approximately 31,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11756497August 12, 2026
UNKNOWN OR OTHER
I am reporting ongoing infotainment and electrical failures in two 2024 Ford Bronco Sport vehicles (same trim), unresolved after two years of ownership on both. Apple CarPlay/Android Auto frequently freezes, disconnects, or becomes unresponsive while driving, forcing the driver to interact with the screen to restore functionality — a distraction hazard that can cause loss of navigation or hands-free operation while driving, increasing collision risk. Recovery often requires powering the vehicle off for several minutes. The center display screen also becomes hot to the touch during normal use, and the wireless charging pad overheats connected phones after 10–30 minutes, suggesting a hardware thermal design defect, not a software/app compatibility issue. Both vehicles have been to the dealership multiple times; only brief diagnostic scans were performed, with no reproduction of the overheating and no repair. Staff repeatedly claim they are "waiting on an iOS update," which does not explain hardware symptoms like screen heat or the multi-minute power-cycle required. Ford's 2025–2026 Bronco Sport received major hardware/software upgrades (larger screens, updated SYNC, standard wireless CarPlay), consistent with a redesign — leaving 2024-and-earlier owners stuck with hardware Ford has since replaced, with no recall or retrofit offered. Separately, Ford's July 2025 recall (25S76) for cracked fuel injectors/underhood fire risk on 2021–2024 Bronco Sport has only received an interim software alert update; the permanent hardware fix remains incomplete. This pattern of infotainment instability, overheating, and an unresolved fire-risk recall reflects unaddressed hardware/design defects warranting investigation.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11756436August 12, 2026
UNKNOWN OR OTHER
RDU CLUTCH FAILURE Vehicle shutter at low speeds and during deceleration. Issue diagnosed after I had the vehicle inspected by ford dealership Ford TSB for this issue is 26-2328. I believe recall 21S02 should have been expanded to include more. My car was not manufactured during the dates listed for that recall. Ford parts have now switched manufacturers for the RDU CLUTCH which is now on back order. I suspect this issue may be related to the large amounts of PCM software issues ford has had with these vehicles and I believe this RDU failure was from faulty parts. No warning lights
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11756393August 12, 2026
POWER TRAIN, ENGINE, UNKNOWN OR OTHER
Oil pump solenoid has been replaced 3 times and the vehicle is under 100,000 miles. There is a low oil light illuminates on dash board in addition to acceleration lose and a white smoke coming from under the hood and the back end of the vehicle. The 6th or 7th time this happened the Bronco had to be towed. There were many more problems included in this tow, powertrain failure, engine misfire, loss of power, crackling, popping sound from under the hood.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11756264August 11, 2026
FUEL SYSTEM, GASOLINE
The contact owns a 2023 Ford Bronco Sport. The contact received notification of NHTSA Campaign Number: 25V467000 (FUEL SYSTEM, GASOLINE); however, the part to do the recall repair was not yet available. The local dealer was contacted, and it was confirmed that the part was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11756077August 10, 2026
POWER TRAIN
I am reporting a safety concern involving the transmission in my 2022 Ford Bronco Sport equipped with the 1.5L engine and 8-speed automatic transmission (8F35). I purchased this vehicle new in May 2022 with approximately 6 miles on it. At approximately 83,000 miles, the vehicle displayed a “Powertrain Malfunction/Reduced Power” warning through FordPass. The notification stated that a transmission clutch had not applied within the expected amount of time and warned that I may experience limited functionality, including unavailable gears. I took the vehicle to an authorized Ford dealership, All Star Ford Denham Springs, for diagnosis. On August 4, 2026, the dealership informed me in writing that the vehicle has an internal transmission failure and metal in the transmission fluid. The technician determined that the transmission requires complete replacement. I was subsequently quoted approximately $13,000 for the repair. I am concerned that an internal transmission failure of this nature could result in reduced propulsion, unavailable gears, abnormal shifting, or loss of vehicle mobility. Which it did in the middle of a airline hwy in baton rouge, La I am requesting that NHTSA review this failure and determine whether similar transmission/clutch failures are occurring in other 2022 Ford Bronco Sport vehicles equipped with the 8F35 transmission and whether this represents a broader safety defect. Ford has previously issued Customer Satisfaction Program 22B38 involving certain 2022 Bronco Sport vehicles equipped with the 8F35 transmission. That program described a manufacturing issue involving a transmission clutch component and a potential long-term durability concern. I understand that my vehicle has not been confirmed to be included in that program, and I am not claiming that it caused my failure. I am providing this information because of the similarity to the clutch-related warning and subsequent internal transmission failure diagnosed in my vehicle.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Ford Bronco Sport