Alfa Romeo Stelvio Complaints

215 consumer complaints on file.

#11741375June 1, 2026
FUEL SYSTEM, GASOLINE
The contact owns a 2018 Alfa Romeo Stelvio. The contact stated while driving at an undisclosed speed, the accelerator pedal was depressed, however the vehicle failed to accelerate as intended. In addition, the vehicle overheated. The vehicle was towed to the dealer, however the contact was informed that the parts were unavailable. The contact stated that the vehicle was taken to the dealer multiple times. In addition, the contact stated that the failure was persistent. The vehicle was towed to the residence five times. In addition, the contact was advised not to drive the vehicle a far distance. The contact received a recall notification, NHTSA Campaign Number: 25V586000 (Fuel System, Gasoline) however the parts were unavailable. The manufacturer was made aware of the failure. The failure mileage was approximately 99,180.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11739593May 22, 2026
FUEL SYSTEM, GASOLINE
The contact owns a 2018 Alfa Romeo Stelvio. The contact stated that while driving at an undisclosed speed, the vehicle unexpectedly entered limp mode, with the start/stop warning light illuminated and a “Throttle Unavailable” warning message displayed. The contact also stated that the vehicle failed to properly accelerate. The contact received notification of NHTSA Campaign Number: 25V586000 (Fuel System, Gasoline); however, the parts required for the recall repair were not yet available. The dealer was contacted. The vehicle was not diagnosed or repaired. The dealer confirmed that the remedy parts were not yet available. The manufacturer was not made aware of the failure. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The approximate failure mileage was 70,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11739247May 21, 2026
ELECTRICAL SYSTEM
The contact owns a 2020 Alfa Romeo Stelvio. The contact stated that while the vehicle was parked, the vehicle became inoperable and failed to start with no warning lights illuminated. The vehicle was taken to the dealer, where it was diagnosed that the ground strap had failed due to corrosion and needed to be replaced. The vehicle was repaired. The dealer informed the contact that if the corrosion had not been repaired in time, it could have caused a more severe vehicle failure. The manufacturer was made aware of the failure. The failure mileage was not available.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11739082May 20, 2026
ENGINE
The engine oil cooling system failed on my 2021 Alfa Romeo Stelvio 2.0T at approximately 45,000 miles. The failure caused engine oil to contaminate the engine coolant system, creating a brown/milky “milkshake” substance inside the coolant reservoir and throughout the cooling system. The dealership diagnosed the issue as an internal oil cooler/oil filter housing failure. The contamination affected multiple cooling system components, and the dealership estimated approximately $8,300 in repairs, including replacement of multiple cooling system parts. The manufacturer offered partial goodwill assistance toward the repair cost. Prior to diagnosis, the vehicle displayed low coolant and low oil symptoms. I had to add approximately one quart of engine oil. I am concerned this premature failure could create a safety risk due to possible overheating or engine failure while driving. The vehicle had been maintained normally and had not previously overheated. The issue was confirmed by an authorized Alfa Romeo dealership.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11738804May 19, 2026
FUEL/PROPULSION SYSTEM
The car was recalled in September 2025 and there is no fix at this point. I have contacted the Alfa dealership and there is no fix. I am loosing money because the car was listed on turo and I cannot rent the car because of the recall
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11738025May 15, 2026
FUEL/PROPULSION SYSTEM
NHTSA safety recall 25V-586 was issued on September 9, 2025. It has now been eight months without a resolution from the manufacturer, and per the FCA recall notice (accessed at [XXX] ) "The Fuel Delivery Module (FDM) on your vehicle may contain internal parts that can be affected by heat, which can reduce fuel flow and lead to a loss of drive power while driving. A loss of drive power can cause a vehicle crash without prior warning." This is a critical safety issue and the lengthy delay in providing a remedy puts lives at risk. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11737796May 14, 2026
FUEL SYSTEM, GASOLINE
The contact owns a 2018 Alfa Romeo Stelvio. The contact received notification of NHTSA Campaign Number: 25V586000(FUEL SYSTEM, GASOLINE); however, the part to do the recall repair was unavailable. The local dealer was contacted and it was confirmed that the part was not available. The contact stated that the manufacturer exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had experienced the failure. No further information was available.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11737420May 12, 2026
ENGINE
I am writing to formally file a complaint regarding serious engine issues I have experienced with my Alfa Romeo vehicle. The ongoing mechanical problems have created significant inconvenience, financial hardship, and concerns regarding the safety and reliability of the vehicle. Since owning the vehicle, I have experienced persistent engine-related problems including [loss of power/engine stalling/check engine light/oil consumption/rough idling/etc.]. Despite attempts to address the issue through repairs and maintenance, the problem continues to occur. These recurring issues have negatively impacted my ability to reliably use the vehicle for daily transportation. In addition, I am concerned that these issues may reflect a manufacturing defect or unresolved mechanical problem that has not been properly corrected. I have made efforts to have the vehicle inspected and repaired, yet the condition persists, resulting in continued frustration and unexpected expenses. I respectfully request the following: * reimbursement for repair costs related to the engine issue * Documentation regarding any recalls, technical service bulletins, or known engine defects associated with this model * Assistance in resolving this matter promptly and fairly I would appreciate a written response outlining the next steps to resolve this complaint. I hope to settle this issue professionally without needing to escalate the matter further through consumer protection agencies, warranty enforcement, or legal channels. Please contact me at your earliest convenience regarding this matter.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11737275May 12, 2026
FUEL SYSTEM, GASOLINE
The contact owns a 2018 ALFA ROMEO Stelvio. The contact stated that while driving at an undisclosed speed, the vehicle randomly shuts off and comes to a complete stop before restarting on its own. Additionally, the vehicle tends to stall randomly after fueling, and the contact noted flickering within the electronic system The contact received notification of NHTSA Campaign Number: (25V586000 (FUEL SYSTEM, GASOLINE) however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The failure mileage was 86,500.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11736833May 10, 2026
FUEL/PROPULSION SYSTEM
I took the vehicle to Auto Zone for a basic diagnostic and it came back that the fuel pump is failing and defective. I only recently purchased the vehicle and found that there’s a recall on it for this reason. The yellow check engine light came on and it stalled while driving home.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11736282May 7, 2026
UNKNOWN OR OTHER, FORWARD COLLISION AVOIDANCE: ADAPTIVE CRUISE CONTROL
Regarding a recall I was told the remedy would be available by now vin number Zasfaknn9j7b75385
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11735819May 5, 2026
ELECTRICAL SYSTEM
Ground strap is faulty. I have owned the vehicle for less than 2 years and am already on my 4th battery because the ground strap keeps draining it. The dealership is finally replacing the ground strap under my warranty but on several occasions I have been left essentially stranded away from home because the vehicle was acting completely fine then will randomly not start due to the faulty ground strap not allowing the alternator to actually charge the battery. Every time this happens it has to go to the dealership because it cannot be jumped and all the lights in the dash come on and need to be reset. This failure happens at random and no lights ever come on in the dash as a warning before it happens. The warranty also will not cover the battery even though it’s being drained due to the faulty strap and I must pay almost $900 for the dealership to install a new one.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11732816April 21, 2026
FUEL SYSTEM, GASOLINE
The contact owns a 2019 Alfa Romeo Stelvio. The contact received notification of NHTSA Campaign Number: 25V586000 (Fuel System, Gasoline); however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact stated that while driving, the vehicle failed to exceed 60 MPH and the vehicle went into LIMP Mode. The vehicle was taken to the dealer, and the failure was associated with the recall and confirmed that parts were not yet available. The vehicle was not repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 95,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11732496April 20, 2026
FUEL/PROPULSION SYSTEM
1. What component or system failed or malfunctioned, and is it available for inspection upon request? Fuel delivery system – specifically the low-pressure fuel pump failed, causing poor engine performance and ultimately requiring replacement. The repair was completed by an authorized Alfa Romeo dealer. 2. How was your safety or the safety of others put at risk? The vehicle began running rough and could have stalled unexpectedly, which presents a safety risk if it occurs in traffic or at highway speeds. Loss of engine performance can reduce the driver’s ability to accelerate or maintain speed, increasing the risk of a collision. 3. Has the problem been reproduced or confirmed by a dealer or independent service center? Yes. The issue was diagnosed and confirmed by an authorized Alfa Romeo dealership, which replaced the fuel pump under extended warranty. 4. Has the vehicle or component been inspected by the manufacturer, police, insurance representatives or others? The vehicle was inspected and repaired by an authorized Alfa Romeo dealer. No inspection was conducted by police or insurance representatives, as no accident occurred. 5. Were there any warning lamps, messages or other symptoms prior to the failure, and when did they first appear? Yes. The vehicle exhibited rough running conditions along with repeated safety warning lights over a period of approximately two weeks prior to the failure. The warnings became more frequent leading up to the repair, indicating a worsening condition. Given the nature of the failure and its similarity to issues identified in prior model years, I request that this matter be evaluated for a potential defect trend and considered for further investigation.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11731408April 15, 2026
ELECTRICAL SYSTEM, EXTERIOR LIGHTING
I am reporting a safety issue with my 2018 Alfa Romeo Stelvio (VIN: [XXX] ). The vehicle has experienced repeated failures of critical lighting systems, including the headlights, brake lights, and turn signals, which have stopped working while driving. The issue began around 42,000 miles and occurred while the vehicle was covered under a Mopar Maximum Care warranty. There have been four repair attempts for the same issue. The problem was initially misdiagnosed as a headlight issue, but was later determined to involve the Body Control Module (BCM). I was also initially told this repair was not covered under warranty, which was later determined to be incorrect. Despite repairs, the issue has persisted. The vehicle also has an open recall with no available remedy. This creates a serious safety concern, as failure of headlights, brake lights, and turn signals increases the risk of an accident. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11731419April 15, 2026
FUEL SYSTEM, GASOLINE
The contact owns a 2020 Alfa Romeo Stelvio. The contact stated that while driving at an undisclosed speed, there was an abnormal sound coming from the vehicle, and the vehicle was jerking. The failure was intermittent. The vehicle was taken to the dealer, where it was diagnosed with a fuel system failure. The manufacturer was not notified of the failure. The approximate failure mileage was 86,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11729905April 8, 2026
FUEL SYSTEM, GASOLINE
The contact owns a 2019 Alfa Romeo Stelvio. The contact received notification of NHTSA Campaign Number: 25V586000 (Fuel System, Gasoline); however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11728569April 1, 2026
ENGINE, FUEL/PROPULSION SYSTEM
I experienced an unexpected Loss of Motive Power (LOMP) event. Late afternoon traffic was fast, estimate 75-80 MPH. I attempted to change lanes get to the righthand shoulder and was very nearly involved in a high-speed collision with a semi-petroleum tank truck. He applied his brakes to avoid hitting me and started to jackknife, but regained control and continued. The truck missed by inches. At this point I had NO remaining power and was essentially coasting until I managed to cross the remaining two lanes of traffic to the shoulder emergency lane. I reset the error codes and continued home with no further occurrences. The incident produced the following warning lamps: Electronic Throttle Control Failure, Start/Stop System Failure and Check Engine, then a few seconds later the Limp Mode/LOMP event. I carry an OBD Scanning Tool with me to be able to clear the error codes when I encounter them. They are typically a cascading event that can result in LOMP. I have experienced a total of 26 of these error lamp events since 4/19/22 which have resulted in 3 LOMP's. The remaining 23 events I was able to reset before the inevitable LOMP. This is the first LOMP that nearly caused a fatal accident, the remainder I was able to safely find a place to stop to perform the resets. There is an active Manufacturer Recall Number93C, NHTSA Recall Number25V-586 that may cover this issue. The Recall Status is "Incomplete, remedy not yet available." The Alfa Romeo dealership has noted the P0191-00 error and replaced the fuel pressure sensor on 2/23/23, but this did not solve the problem. Owner's forums, and now the Manufacturer/NHTSA recall have reported this as a known problem, so I have been clearing my own error codes in order to at least have a car to drive. In my mind, this nuisance has now become a potentially very dangerous condition.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11727879March 30, 2026
UNKNOWN OR OTHER
Subject: Formal Demand for Remedy – Safety Recall / 2019 Alfa Romeo Stelvio (VIN: [XXX] ) To Whom It May Concern, I am writing to formally demand immediate resolution regarding a serious safety recall affecting my 2019 Alfa Romeo Stelvio (VIN: [XXX] ). The recall, issued in September 2025, involves a defect in the fuel delivery module that may result in a loss of motive power. This defect presents a significant safety hazard, increasing the risk of a crash, injury, or worse. Despite the severity of this issue, I have not been provided with a remedy, repair timeline, or adequate alternative solution. It is unacceptable that I am expected to continue operating—or assume the risk of operating—a vehicle with a known safety defect and no available fix. This situation has caused ongoing concern, inconvenience, and diminished confidence in the safety and reliability of the vehicle. Given the lack of a timely and effective remedy, I am formally requesting that Alfa Romeo take one of the following actions immediately: Provide a permanent repair within a reasonable and clearly defined timeframe; OR Repurchase (buy back) the vehicle at fair market value; OR Provide a comparable replacement vehicle at no cost to me If this matter is not resolved promptly, I am prepared to pursue further action, including but not limited to filing additional complaints with the National Highway Traffic Safety Administration (NHTSA), seeking relief under applicable state lemon laws, and exploring other legal remedies available to me. Please treat this matter with the urgency it requires. I request a written response within 10 business days of receipt of this letter outlining the steps Alfa Romeo will take to resolve this issue. Thank you for your immediate attention to this serious safety concern. [XXX] and [XXX] [XXX] [XXX] or [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11727913March 30, 2026
FUEL/PROPULSION SYSTEM
Despite the seriousness of the outstanding recall (25V-586), which Stellantis acknowledges can result in a sudden and complete loss of engine power at high speeds, Alfa Romeo/Stellantis have provided exactly zero updates in nearly 8 months since the recall was announced. In speaking with my dealer, I’ve learned that Alfa Romeo/Stellantis were initially providing vague estimates for when they expected a recall fix to be available but have since stopped providing information to the dealers altogether. The manufacturer’s behavior in the face of such a serious safety risk is alarming and leads me to question whether a fix is actually even under development or will ever be available. Without action or the threat of action by the government to force the manufacturer to comply with their obligations to vehicle owners I have no confidence that this serious safety issue will be satisfactorily addressed at all, much less in a timely manner.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Alfa Romeo Stelvio