Volvo XC60 Complaints

656 consumer complaints on file.

#11558778December 6, 2023
ELECTRICAL SYSTEM
The contact owns a 2022 Volvo XC60. The contact stated that on several occasions while the vehicle was turned on, the radio cluster and instrument panel failed to illuminate. Additionally, the contact stated that he and his wife observed a clicking sound coming from the engine compartment when the vehicle was turned off. The vehicle was taken to a dealer however, the failure could not be duplicated. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was approximately 1,500.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11557991December 1, 2023
VISIBILITY:WINDSHIELD
The windshield leaks when I am driving from the passenger side and the driver side. Last rain a lot of water got into the car which makes it very dangerous to drive and obviously to break since it gets slippery. I live in the mountains, and we get a lot of rain and now I have to pay out of pocket to get it diagnosed when even the service advisor said that that particular year and models leaks a lot.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11557746November 30, 2023
VISIBILITY/WIPER
Water enters from the front of the windshield while driving.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11555887November 19, 2023
STRUCTURE:BODY, LATCHES/LOCKS/LINKAGES:DOORS:LATCH
The rear passenger door on this 4 year old car will not open from inside, nor outside. This is a huge safety issue, as any emergency egress from that point will not be possible. I can imagine the outcome if we were in an accident and needed to try to exit via that door. I chatted with Volvo and they simply recommended opening a case with their 800 number. I've seen forums with many other people having this same problem with Volvos for many years.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11555338November 15, 2023
ELECTRICAL SYSTEM, AIR BAGS, SUSPENSION
Water intrusion via a faulty sunroof seal and drain system. Water drains into the vehicle and collects under the flooring carpets and is not detectable. Water then disables and shorts out electrical components and computer modules eventually rendering the vehicle completely inoperable … including airbags, suspension system and electronic engine components. All control is lost. System also displays a number of random and often times confusing and erroneous error message to display console. This is an extremely dangerous problem, and extremely expensive to remedy, and appears to be related to a significant design flaw. According to internet reports, this is a known issue. Dealer is the one who diagnosed the problem. Given this problem affects electronics - there is a threat of fire.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11554722November 12, 2023
ELECTRICAL SYSTEM, UNKNOWN OR OTHER
On November 11, 2023 @ between 10:30 and noon, the vehicle infotainment system completely failed. The screen went blank and functions for heat, radio, navigation, cameras, indicator lights in the mirror and the ability to call Volvo emergency services were all lost. A message on the screen said, "Stop the vehicle. This vehicle's infotainment system has encountered a problem. You can reboot or reset factory settings. If this doesn't help, please contact a workshop." This is the second such failure. The first occurred on September 22, 2023. I filed a report with Volvo (REF#[XXX]), and repairs were effected at a local dealer in Maryland. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11554394November 9, 2023
UNKNOWN OR OTHER
I recently leased a Volvo XC60 and the Camera system is not working at night time. During the daytime the Camera is working and able to capture images….At nighttime, the camera is not able to “see” and the images on the onboard screen are all dark. I have a Volvo XC90 VIN: YV4A22PK4M1765940 with a backup camera and it works at night time and is able to capture images at night time and the images are clearly defined and viewable…. The Volvo XC60 is not able to transmit images to the onboard screen. I believe this maybe a software issue…but I am not sure. I believe this is a safety issue and respectfully request your help to resolve this issue.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11553934November 7, 2023
TIRES
PIRELLI SCORPION ZER ALL SEASON 255/40R21 The tread is falling off in chuncks. Both the front and back tires.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11552620October 30, 2023
TIRES
The contact owns a 2021 Volvo XC60 equipped with Continental Tires, Tire Line: Cross Contact, Tire Size: 255/45/R20, DOT: (N/A). The contact stated while driving approximately 65 MPH, the rear passenger’s side tire had a blowout. The vehicle was taken to an independent mechanic where it was confirmed that there was a sidewall blowout. The tires were not replaced. The tires were the original tires. The manufacturer was notified of the failure. The approximate failure mileage was 17,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11551676October 24, 2023
VISIBILITY/WIPER
Front windshield completely separated from vehicle driver side top If side window open it flaps open. Very dangerous at freeway speeds. Known issue of faulty primer on window glass for XC60 vehicles.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11551241October 22, 2023
UNKNOWN OR OTHER
I have had an issue several times with the hatch of my Volvo xc60. It has a feature where if you wave your foot under the rear door, the hatch will open or close automatically. This has been triggered inadvertantley several times, nearly injuring several people. This is especially dangerous for small children. You can be trapped by the closing door. In one incident, while parked in our garage, the hatch inadvertently opened and pinned me against the wall while holding a small child. The force could injure a child without question. I tried to disable this feature and couldn’t find a way to do it. If you google it, this is a common issue that others have had happen too.
Crash:
No
Fire:
No
Injuries:
1
Deaths:
0
#11551178October 21, 2023
TIRES:TREAD/BELT
TWO PIRELLI SCORPION ZERO TIRES (255/40 R21) RECEIVED ON 2022 VOLVO XC60 RECHARGE AS ORIGINAL EQUIPMENT DEVELOPED MISSING SQUARES/ CHUNKS OF RUBBER IN THE TREAD AREA. THE TWO TIRES MISSING TREAD WERE ORIGINALLY ON THE FRONT AND WERE ROTATED TO THE REAR FOR ADDED SAFETY. ALL 4 MATCHING TIRES WERE DISPOSED AT THE VOLVO DEALER. VOLVO XC60 COULD NO LONGER BE SAFELY DRIVEN AFTER THE REAR DRIVER SIDE TIRE PICKED UP A SCREW. THE SAFETY ISSUE WAS POINTED OUT DURING AN ATTEMPT TO HAVE THE TIRE REPAIRED BECAUSE IT WAS LOSING AIR. THE TECHNICIAN STATED A TIRE REPAIR WOULD INVOLVE CUTTING/SCRAPING THE TREAD FOR INSTALLATION OF A PATCH. THEY BELIEVED THAT THE TIRE WOULD RUPTURE UPON APPLICATION OF A PATCH. SIMILAR DAMAGE WAS FOUND ON THE SECOND TIRE BUT IT WOULD STILL HOLD AIR. ON DIFFERENT OCCASIONS, TWO VOLVO DEALERS AND NTB/MAVIS EXAMINED THE TIRES. ON THE FIRST OCCASION, IT WAS THE VOLVO DEALERS OPINION THE DAMAGE WAS CAUSED BY ALIGNMENT. THEY WOULD NOT REPLACE THE TIRES UNDER WARRANTY. SECOND TIME AT NTB/MAVIS THEY BELIEVED THE TIRE CONSTRUCTION WAS FAULTY AND UNSAFE TO REPAIR. THIRD INSPECTION BY A VOLVO DEALER THOUGHT IT MAY HAVE BEEN CAUSED BY DRIVING OVER GRAVEL/SHARP ROCKS. A LOW PRESSURE WARNING APPEARED ON THE INSTRUMENT PANEL. THE TIRE HAD LOST SOME AIR AND WOULD NOT HOLD AIR LONG WHEN REFILLED. VOLVO'S DEALER REPLACED THE PIRELLI TIRE THAT WOULD NOT HOLD AIR, BUT WOULD NOT REPLACE THE OTHER THREE IN THE SET. MATCHING PIRELLI TIRES COULD NOT BE OBTAINED, SO A SET OF MICHELIN TIRES WERE INSTALLED. OWNER WAS REQUIRED TO PAY FOR THREE, VOLVO COVERED ONE TIRE COST BECAUSE IT WOULD NOT HOLD AIR. NTB/MAVIS ADVISED THEY HAVE DISCONTINUED STOCKING THE PIRELLI SCORPION ZERO TIRE.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11548899October 8, 2023
VEHICLE SPEED CONTROL, UNKNOWN OR OTHER, ELECTRICAL SYSTEM
I've experienced many problems with the Google built in system in this Volvo. But the one that keeps happening is the speed sensors. The car is supposed to read traffic signs, including speed signs and alarm when exceeding the posted speed limit. It does not work. For example on I66 East bound in Virginia, the speed limit is not 80mph, it is either 60, 65 or 70 if using the express lanes. The Volvo keeps showing the speed limit on this interstate as 80, see attached images showing speed limit sign at 80. Complained to Volvo, they blamed Google. Complained to Google, they blamed Volvo. Other roads have the same sign recognition. The car infotainment & safety features randomly shut down, or fail, while driving and the vehicle has to be reset often. Back up cameras quit working while backing up sometimes it will not go into reverse without shutting off the car or doing a reset.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11547425September 29, 2023
ENGINE
Purchased the vehicle sometime in 2021. Been dealing with oil consumption issues since then. Always maintained the vehicle per manufacturer recommendations. At first I had to top off the oil here and there and didn’t think much of it. Forward to Sept 2023 I have to add a quart every 500 miles. I began to research about the oil consumption problem and learned the following: There was a letter that was sent out to Volvo owners in Feb 2023 about a service bulletin regarding an oil consumption test and if the vehicle fails the oil consumption test then Volvo will replace piston rings or engine. They would also extend the warranty. The free oil test applies to vehicles within 8yrs or 100k. I never received the letter because I was the second owner. I called Volvo North America and they confirmed that the previous owner was listed on their end and that previous owner must’ve received the letter. If I had received the letter in Feb 2023 then I would be within that 8yr time frame and that would qualify me for repairs. I asked Volvo for grace to be included in the free oil consumption test. They said no because I was outside the time frame which was 3 months. Only 3 months! I never received the letter and I had to research on my own. I never received that letter and if I had received the letter then I would’ve taken it immediately to Volvo for the free oil test consumption. I believe this is a serious safety problem because at one point the engine will seize and could stall on the interstate due to the excessive oil consumption. Please look into this safety issue. A sudden seizure of engine leads to a sudden stall at interstate speeds which can cause a major collision and I know NHTSA is all about safety for operators of vehicles. Thank you!!
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11547155September 28, 2023
ELECTRICAL SYSTEM
There was (still is) an issue with my 2016 Volvo XC60's electrical wiring. I was driving, about to get onto the highway when my volvo stalled on the on ramp. It wouldn't start, it couldn't be jumped. It had to be towed to the repair shop. They charged me over $1,000.00 for a brand new starter, and after they did it started for one day and then it broke down again. I couldn't even drive it out of the repair shop. I had to get it towed again. The dealership said it was an electrical/wiring issue that could be very expensive. I have found out that there was a recall for 2015 XC60 Volvos for wiring/electrical issues causing the vehicle to stall. However my 2016 volvo XC60 does not qualify per the repair show due to the date it was manufactured. I'm submitting this form for a safety issue because volvo clearly KNEW about this issue enough to need recalls for 2015s. There should also be recalls for this same wiring/electrical issue in 2016s.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11546744September 27, 2023
UNKNOWN OR OTHER, ELECTRICAL SYSTEM
The drainage system from the roof of the vehicle is faulty and causes water to collect in the space between the carpet in the interior of the vehicle and the floor of the vehicle. Key electrical components are located beneath the front passenger seat of the vehicle. When the water collected, it caused key systems, such as collision warning and other systems to malfunction. When we took the vehicle to the dealership, several other vehicles had to be towed in due to more severe electrical failure as a result of the drainage malfunction.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11546855September 27, 2023
ELECTRICAL SYSTEM, POWER TRAIN
The contact owns a 2023 Volvo XC60. The contact stated upon shifting into park (P), the gear shift indicator light displayed that the transmission was in park (P); however, the vehicle continued to roll. The contact stated that he continuously pressed the park (P) button until the vehicle responded. There was no warning light illuminated. Additionally, the contact stated while driving at various speeds with adaptive cruise control (ACC) mode engaged, the steering wheel independently pulled to the right aggressively. The contact stated that he used physical strength to pull the steering wheel back to the left; however, the steering wheel failed to return to the center position and continuously turned to the left, then to the right. The contact also stated that while driving with auto centering feature activated, the vehicle was driving from side to side. The vehicle was taken to the dealer, where an unknown software upgrade was performed. Additionally, the contact received an unknown notice for mandatory software update. The contact stated that the software update was performed; however, the failure worsened. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 400.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11544920September 16, 2023
VISIBILITY/WIPER
Front windshield is not sealed properly. Leaks water at top of windshield and onto the steering wheel. This is not a problem with the sunroof.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11544928September 16, 2023
UNKNOWN OR OTHER
I was driving and the car started shaking and unable to accelerate. I pulled over and the car started smoking and a fire erupted under the hood. I vacated the vehicle and called 911. The car erupted in flames and burned down to the frame. The insurance inspector wasn't able to determine the cause of the fire.
Crash:
No
Fire:
Yes
Injuries:
0
Deaths:
0
#11541669August 30, 2023
ELECTRICAL SYSTEM, UNKNOWN OR OTHER
I recently was forced to use the pry-off cap and manual key entry to get into my 2013 Volvo XC60. This was due to the vehicle’s lack of response to the fob, there was no communication between the fob and the electrical system. Once inside, inserting the fob, the engine started but the entire instrument cluster was flashing intermittently the various warning lights, and the windows could not be lowered. The cluster showed failure of speedometer, tachometer, brake system, seat belts and all other gauges on the cluster. Not knowing whether it was safe to drive, I turned it off. I returned later and turned it on, same problem. I went around the block, contacted the Volvo dealer for consultation, and secured an emergency appointment to bring it in. On the next day/the appointment, I drove the car in, during which the systems seemed to have reset themselves, but halfway there the problem started again. At this point the vehicle has been there (Howard Orloff Volvo, 1924 N. Paulina St, Chicago, 1.877.570.6927) since the 28th, they have not been able to give me a diagnosis, and the bill is over $600. How can this problem NOT be a safety risk for ordinary person such as myself? It is my understanding, from researching this, that this is a common and recurring problem so why has there NOT been a recall for what is obviously a defect inherent in this make and model car? Kindly respond with a reference number for this complaint. Thank you very much.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Volvo XC60