Ram 1500 Service Bulletins
2,018 manufacturer communications on file.
- May 28, 2025•Document ID: 11018861Service Bulletin/Repair InstructionsENGINE
- Mfr Comm. #:
- 09-012-25
- Date Added:
- June 2, 2025
- Manufacturer:
- RAM
Summary"Flexplate Bolts Loose Customers may experience the following: ● Noise coming from under the hood. This bulletin involves replacing all flexplate to crankshaft bolts."
Associated Products (3)Associated Documents - May 28, 2025•Document ID: 11018809Service Bulletin/Repair InstructionsUNKNOWN OR OTHER
- Mfr Comm. #:
- 104970
- Date Added:
- June 2, 2025
- Manufacturer:
- RAM
SummaryCORE - HEATER
Associated Products (33)2025 Jeep Grand Wagoneer2025 Jeep Wagoneer2025 Ram 15002025 Ram 25002025 Ram 35002025 Ram 45002025 Ram 55002024 Jeep Grand Wagoneer2024 Jeep Wagoneer2024 Ram 15002024 Ram 25002024 Ram 35002024 Ram 45002024 Ram 55002023 Jeep Grand Wagoneer2023 Jeep Wagoneer2023 Ram 15002023 Ram 25002023 Ram 35002023 Ram 4500+ 13 moreAssociated Documents - May 28, 2025•Document ID: 11018666Service Bulletin/Repair InstructionsELECTRICAL SYSTEM
- Mfr Comm. #:
- 9100599
- Date Added:
- May 29, 2025
- Manufacturer:
- JEEP
SummaryUnderhood start/stop safety The customer may experience a Malfunction Indicator Lamp (MIL) illumination. Upon further investigation the technician may find the following Diagnostic Trouble Code (DTC): - P152E Engine -Hood Switch 2 Circuit High. - DTC P152F Customers may also experience: - Start/Stop system warning light. - Start/Stop inoperable. - Remote start inoperable. Diagnosis: - Using a Scan Tool (wiTECH) with the appropriate Diagnostic Procedures available in DealerCONNECT/Service Library, verify all related systems are functioning as designed. If DTCs or symptom conditions, other than the one listed are present, record the issues on the repair order and repair as necessary before proceeding further with this bulletin. - If any vehicle exhibits any of the symptoms listed above in the customer symptom section, perform the Repair Procedure. - Special Tools/Equipment: wiTECH or equivalent. Repair Procedure: 1. Open the hood and locate the hood switch 2. Push in on the two locking tabs and pull them out. 3. Disconnect the wire connector from the switch. 4. Connect the wires to the same hood switch. 5. Push the switch back into the hold until both lock tab are engaged. 6. Clear all DTCs that may have been set in any module during this repair procedure. 7. In case the P152F/P152E DTCs persist, repeat the procedure with a new/spare/known good switch and repeat steps 5 and 6. 8. Replace switch installed during previous step for the original switch of the vehicle. If DTCs P152F/P152E are not present, leave the original switch installed and do not document the change of the switch in the repair process/narrative.
Associated Products (39)2026 Jeep Grand Wagoneer2026 Ram 15002025 Chrysler Pacifica2025 Chrysler Voyager2025 Dodge Durango2025 Dodge Hornet2025 Jeep Compass2025 Jeep Gladiator2025 Jeep Grand Cherokee2025 Jeep Grand Cherokee L2025 Jeep Grand Wagoneer2025 Jeep Wagoneer2025 Jeep Wrangler2025 Ram 15002024 Chrysler Pacifica2024 Chrysler Voyager2024 Dodge Durango2024 Dodge Hornet2024 Jeep Compass2024 Jeep Gladiator+ 19 moreAssociated Documents - May 28, 2025•Document ID: 11018662Service Bulletin/Repair InstructionsELECTRICAL SYSTEM
- Mfr Comm. #:
- 9100592
- Date Added:
- May 29, 2025
- Manufacturer:
- RAM
SummaryLAMP Courtesy/Ambient Courtesy / Ambient Lamp: Light guide not fully seated into the retainer during IP sub-assembly due to inconsistent operator installation effort, leading to latent BSR issue that manifests under customer usage conditions. Solution: remove and reinstall light guide to be fully seated in the bracket retainer.
Associated Products (25)Associated Documents - May 28, 2025•Document ID: 11018620Service Bulletin/Repair InstructionsENGINE
- Mfr Comm. #:
- S2509000003REVA
- Date Added:
- May 28, 2025
- Manufacturer:
- RAM
SummaryEngine Overheating Customer Complaint/Technician Observation: Customer complaint may include engine “overheating”. Discussion: When dealing with a customer complaint of engine ”overheating”, it is most important to understand exactly what the customer’s definition is of “overheating”. An explanation from the customer of what exactly happened is necessary. Overheating descriptions could include warning lamp(s), messages in the cluster, steam/smoke coming from under the hood, gauge “running higher than normal”, actual engine temperature higher than what the customer considers normal, smells hot, coolant leaking under the vehicle, etc. Observed engine operating temperatures of 245 F (118 C) degrees or lower are typical and are NOT considered overheating.
Associated Products (6)Associated Documents - May 27, 2025•Document ID: 11018658Service Bulletin/Repair InstructionsPOWER TRAIN
- Mfr Comm. #:
- 9100576
- Date Added:
- May 29, 2025
- Manufacturer:
- RAM
SummaryTransfer Case Motor Gear: Confirm the attachment points from the wiring routes when they inspect a shift motor on the t-case. Review the connection of the connector X238A, make sure it's fully seated and that the lever is fully locked on the connector.
Associated Products (9)Associated Documents - May 24, 2025•Document ID: 11018682Service Bulletin/Repair InstructionsELECTRICAL SYSTEM
- Mfr Comm. #:
- 08-157-25 REV. A
- Date Added:
- May 30, 2025
- Manufacturer:
- RAM
Summary"R1H Radio Over The Air Update from T27.46 to U29.44 then U35.26 Software Version (FOTA)"
Associated Products (2)Associated Documents - May 22, 2025•Document ID: 11018603Service Bulletin/Repair InstructionsELECTRICAL SYSTEM
- Mfr Comm. #:
- S2524000005
- Date Added:
- May 28, 2025
- Manufacturer:
- RAM
SummaryCustomer Indicates Front Seat Comfort Seat Options Are Not Working Complaint/Technician Observation: Upon further inspection it can be found that the comfort seat options are intermittently operational. The heated and ventilated seat button on the display screen can show gray at times. Loss of communication faults may set in the system when this occurs, they can be active or stored faults.
Associated Products (1)Associated Documents - May 21, 2025•Document ID: 11018676Service Bulletin/Repair InstructionsSUSPENSION
- Mfr Comm. #:
- 02-002-25
- Date Added:
- May 30, 2025
- Manufacturer:
- CHRYSLER
Summary"Shock And Strut Diagnosis And Replacement Guidelines Leaking, noisy, or weak shocks or struts. "
Associated Products (89)2025 Alfa Romeo Stelvio2025 Chrysler Pacifica2025 Dodge Charger2025 Dodge Durango2025 Dodge Hornet2025 Jeep Compass2025 Jeep Gladiator2025 Jeep Grand Cherokee2025 Jeep Grand Cherokee L2025 Jeep Grand Wagoneer2025 Jeep Wagoneer2025 Jeep Wagoneer S2025 Jeep Wrangler2025 Ram 15002025 Ram 25002025 Ram 35002025 Ram 45002025 Ram 55002024 Alfa Romeo Stelvio2024 Alfa Romeo Tonale+ 69 moreAssociated Documents - May 21, 2025•Document ID: 11018639Service Bulletin/Repair InstructionsELECTRICAL SYSTEM; WHEELS
- Mfr Comm. #:
- 9100593
- Date Added:
- May 29, 2025
- Manufacturer:
- RAM
SummaryReceiver Module Tire pressure monitor receiver module: DT25 TPMS Issues - TPMS not working, TPMS working intermittently, TPMS displaying wrong values, TPMS warnings on cluster In case of TPMS concerns, please follow the below: - Perform TPMS Autolearn Procedure After Tire Rotation or Tire Change for Sensata TPM sensors. - Verify the sensor IDs are correct. If they are incorrect, autolearn the sensors. - If there are any issues in terms of tire pressure, inflate or deflate to the recommended pressure. - If DTCs - C15CB00 ("Front Axle Tire Pressure Placard Implausible") and/or C15CC00 ("Rear Axle Tire Pressure Placard Implausible") are being triggered, program the placard values. Also, check if the placard values were programmed previously. - If the sensors are loose, fix them to the wheel properly. - If there are aftermarket parts, any repairs will not be considered for warranty.
Associated Products (1)Associated Documents - May 20, 2025•Document ID: 11018681Service Bulletin/Repair InstructionsELECTRICAL SYSTEM
- Mfr Comm. #:
- 08-117-25 REV. A
- Date Added:
- May 30, 2025
- Manufacturer:
- RAM
Summary"Smartphone As A Key (SPAAK) SOP 4.0 SW update (FOTA) Software Enhancements included: ● **Removes keyless sharing.** ● Apply Owner Pairing and Key Sharing. ● Passive Entry and Passive Start Features. ● Improve NFC entry timing from sleep state. This bulletin provides information regarding the latest Firmware Over The Air (FOTA) update and provides the service technician an overview of the steps a customer will need to take to complete the update. The SPAAK software will be updated to 4.0."
Associated Products (1)Associated Documents - May 20, 2025•Document ID: 11018631Service Bulletin/Repair InstructionsELECTRICAL SYSTEM
- Mfr Comm. #:
- 9100574
- Date Added:
- May 29, 2025
- Manufacturer:
- RAM
SummaryRadio: Capture software version from radio. Record or document software version prior to troubleshooting, as soon as any infotainment issue has been found or reported. Also always document in claim. Steps to capture Radio version number: 1. Go to "Vehicle" 2. Go to "Settings" 3. Go to "System Information" 4. Find the radio version from "Version information" Example software version: U37.2, U39.4, etc.
Associated Products (15)Associated Documents - May 20, 2025•Document ID: 11018630Service Bulletin/Repair InstructionsSTEERING
- Mfr Comm. #:
- 9100575
- Date Added:
- May 29, 2025
- Manufacturer:
- RAM
SummaryGear rack and pinion: Custodian would encounter steer feel being heavier and may feel some pulling. Customer may complain the steering feels heavy while returning to steering wheel to center during a lower speed turn. Customer may also complain the vehicles pulls slightly at highway speeds. There are no DTCs associated with that scenario. Older software pull drift compensation and zero-point learning is not optimized. New Software has optimized pull drift compensation and zero-point learning. Do not replace the steering gear for these scenarios when an EPS DTC is not present. Reflash software instead.
Associated Products (1)Associated Documents - May 18, 2025•Document ID: 11018490Service Bulletin/Repair InstructionsPOWER TRAIN
- Mfr Comm. #:
- 21-016-25 REV. A
- Date Added:
- May 20, 2025
- Manufacturer:
- JEEP
Summary"Valve Body Replacement Customers must experience a Malfunction Indicator Lamp (MIL) illumination and the vehicle must exhibit/set one or more of the following Diagnostic Trouble Codes (DTCs): ● U0101 - Lost Communication With The Transmission Control Module (TCM). ● U0402 - Implausible Data Received From TCM. ● U0418 - Implausible Data Received From Brake System Control Module 1. Customers may also comment on the following: ● Vehicle will go in limp-in mode. After the vehicle enters limp-in mode and has been shifted into Park, the vehicle will not shift into a forward or reverse gear This bulletin involves replacing the transmission valve body assembly."
Associated Products (13)Associated Documents - May 18, 2025•Document ID: 11018482Service Bulletin/Repair InstructionsENGINE
- Mfr Comm. #:
- 09-011-25
- Date Added:
- May 20, 2025
- Manufacturer:
- CHRYSLER
Summary"Misfire Diagnostic Trouble Codes (DTCs), Rough Idle, Valvetrain Noise Customers may experience a Malfunction Indicator Lamp (MIL) illumination and the vehicle may exhibit/set one or more of the following Diagnostic Trouble Codes (DTCs): ● P0301 - Cylinder 1 Misfire. ● P0302 - Cylinder 2 Misfire. ● P0303 - Cylinder 3 Misfire. ● P0304 - Cylinder 4 Misfire. ● P0305 - Cylinder 5 Misfire. ● P0306 - Cylinder 6 Misfire. Customers may comment on one or more of the following: ● Rough idle. ● Valvetrain noise. "
Associated Products (40)2025 Chrysler Pacifica2025 Chrysler Voyager2025 Dodge Durango2025 Jeep Gladiator2025 Jeep Grand Cherokee2025 Jeep Grand Cherokee L2025 Jeep Wrangler2025 Ram 15002024 Chrysler Pacifica2024 Chrysler Voyager2024 Dodge Durango2024 Jeep Gladiator2024 Jeep Grand Cherokee2024 Jeep Grand Cherokee L2024 Jeep Wrangler2024 Ram 15002023 Chrysler Pacifica2023 Chrysler Voyager2023 Dodge Durango2023 Jeep Gladiator+ 20 moreAssociated Documents - May 18, 2025•Document ID: 11018480Service Bulletin/Repair InstructionsUNKNOWN OR OTHER
- Mfr Comm. #:
- 08-161-25
- Date Added:
- May 20, 2025
- Manufacturer:
- RAM
Summary"Global Telematics Box Module (TBM) Firmware Over The Air (FOTA) Update Customers may experience the following: ● Communication with phone app: setup as keys, wrong names, duplicates and add/delete not working properly. The following software enhancement is available: ● Optimization of VHR (Vehicle Health Report) & RDA (Remote Diagnostics Assistance). This bulletin provides information regarding the latest Firmware Over The Air (FOTA) update and provides the service technician an overview of the steps a customer will need to take to complete the update. The TBM software will be updated from R5C.1 or R5E.1 or R5E.2 or R5F or R5F1 to R5N software level. NOTE: National launch for this FOTA update is expected to begin: May 21, 2025"
Associated Products (5)Associated Documents - May 18, 2025•Document ID: 11018479Service Bulletin/Repair InstructionsUNKNOWN OR OTHER
- Mfr Comm. #:
- 08-160-25
- Date Added:
- May 20, 2025
- Manufacturer:
- RAM
Summary"International Maps Missing Customers may comment on the following: ● The vehicle has North American maps installed instead of the International maps This bulletin involves inspecting the navigation map region and possibly installing International maps to the radio via USB."
Associated Products (1)Associated Documents - May 17, 2025•Document ID: 11018450Service Bulletin/Repair InstructionsELECTRICAL SYSTEM
- Mfr Comm. #:
- S2508000039
- Date Added:
- May 19, 2025
- Manufacturer:
- JEEP
SummaryUniversal Garage Door Opener (UGDO) Inoperative, LED Indicator Lamps Not Illuminating
Associated Products (58)2025 Chrysler Pacifica2025 Chrysler Voyager2025 Jeep Compass2025 Jeep Gladiator2025 Jeep Grand Cherokee2025 Jeep Grand Cherokee L2025 Jeep Grand Wagoneer2025 Jeep Wagoneer2025 Jeep Wagoneer S2025 Jeep Wrangler2025 Ram 15002025 Ram 25002025 Ram 35002025 Ram 45002025 Ram 55002024 Chrysler Pacifica2024 Chrysler Voyager2024 Jeep Compass2024 Jeep Gladiator2024 Jeep Grand Cherokee+ 38 moreAssociated Documents - May 17, 2025•Document ID: 11018449Service Bulletin/Repair InstructionsELECTRICAL SYSTEM
- Mfr Comm. #:
- S2508000038
- Date Added:
- May 19, 2025
- Manufacturer:
- RAM
SummaryKey Fob is Damaged, Case is Separating
Associated Products (4)Associated Documents - May 16, 2025•Document ID: 11018447Service Bulletin/Repair InstructionsELECTRICAL SYSTEM
- Mfr Comm. #:
- S2323000002 REV.A
- Date Added:
- May 19, 2025
- Manufacturer:
- DODGE
Summary"Washer Light On And Will Not Turn Off After Adding Washer Solvent."
Associated Products (72)2025 Chrysler Pacifica2025 Chrysler Voyager2025 Dodge Durango2025 Jeep Gladiator2025 Jeep Grand Cherokee2025 Jeep Grand Cherokee L2025 Jeep Wrangler2025 Ram 15002025 Ram 25002025 Ram 35002025 Ram 45002025 Ram 55002024 Chrysler Pacifica2024 Chrysler Voyager2024 Dodge Durango2024 Jeep Gladiator2024 Jeep Grand Cherokee2024 Jeep Grand Cherokee L2024 Jeep Wrangler2024 Ram 1500+ 52 moreAssociated Documents