Lincoln Aviator Service Bulletins (2022)
186 manufacturer communications on file.
- March 6, 2024•Document ID: 10251952Service Bulletin/Repair InstructionsENGINE AND ENGINE COOLING
- Mfr Comm. #:
- SSM 52335
- Date Added:
- March 20, 2024
- Manufacturer:
- FORD
SummaryFor 2015-2024 Ford and Lincoln vehicles equipped with turbocharged engines and customer concern of an engine oil leak, refer to Workshop Manual (WSM), Section 303-00 for oil leak inspection and testing methods. Ford has evaluated turbochargers replaced for oil leak symptoms and although oil may collect on the external surface of a turbocharger, it is extremely rare for a turbocharger assembly to be the root cause of the oil leak. Careful inspection of the turbocharger oil feed and drain tubes should be performed along with the recommended WSM procedures as needed. Warranty claims for turbocharger replacement going forward will be assessed.
Associated Products (60)2024 Ford Bronco2024 Ford Bronco Sport2024 Ford Edge2024 Ford Escape2024 Ford Expedition2024 Ford Explorer2024 Ford F-1502024 Ford Maverick2024 Ford Mustang2024 Ford Ranger2024 Ford Transit2024 Lincoln Aviator2024 Lincoln Corsair2024 Lincoln Nautilus2023 Ford Bronco2023 Ford Bronco Sport2023 Ford Edge2023 Ford Escape2023 Ford Expedition2023 Ford Explorer+ 40 moreAssociated Documents - March 6, 2024•Document ID: 10251950Service Bulletin/Repair InstructionsELECTRICAL SYSTEM:BODY CONTROL MODULE/BCM
- Mfr Comm. #:
- SSM 52333
- Date Added:
- March 20, 2024
- Manufacturer:
- LINCOLN
SummaryMany body control module C (BCMC) warranty return parts are coming back with no trouble found. To verify that the BCMC is at fault prior to replacing, perform the following. First, disconnect the battery then check all BCMC connectors for terminal pushout, pin damage, spread terminals, and corrosion. Refer to Workshop Manual Section 100-00 Wire Terminal Inspection and Replacement. If none found, reconnect the BCMC and battery terminals then recheck functionality. If concern still exists, proceed with BCMC replacement.
Associated Products (8)Associated Documents - March 1, 2024•Document ID: 10251934Service Bulletin/Repair InstructionsPOWER TRAIN
- Mfr Comm. #:
- SSM 52314
- Date Added:
- March 20, 2024
- Manufacturer:
- FORD
SummaryDuring service and repair requiring removal and replacement of a crankshaft bolt and/or crankshaft damper, achieving proper torque of the crankshaft pulley bolt is critical. Incorrect torque may allow the bolt to loosen resulting in the timing gear breaking and engine damage. Replacement of the bolt is critical to the repair and accurately following the installation procedure in the Workshop Manual (WSM) Section, 303-01 is extremely important. The bolt torque procedure can be found in the crankshaft front seal removal and installation procedure or in the engine assembly procedure.
Associated Products (67)2024 Ford Bronco2024 Ford Bronco Sport2024 Ford E-3502024 Ford E-4502024 Ford Edge2024 Ford Escape2024 Ford Expedition2024 Ford Explorer2024 Ford F-1502024 Ford Maverick2024 Ford Mustang2024 Ford Transit2024 Lincoln Aviator2024 Lincoln Corsair2024 Lincoln Nautilus2024 Lincoln Navigator2023 Ford Bronco2023 Ford Bronco Sport2023 Ford E-3502023 Ford E-450+ 47 moreAssociated Documents - February 29, 2024•Document ID: 10250852Service Bulletin/Repair InstructionsELECTRICAL SYSTEM
- Mfr Comm. #:
- SSM 52307
- Date Added:
- March 5, 2024
- Manufacturer:
- FORD
SummarySome 2020-2023 Ford and Lincoln SYNC3 equipped vehicles may experience an inaccurate notification in the FordPassî/LincolnWayî app indicating Vehicle Has Entered Deep Sleep Mode. Vehicle Has Entered Deep Sleep Mode message is expected if the vehicle has not been started for 14 consecutive days, battery voltage is at/below 9.5 volts or the body control module (BCM) 12 volt battery state of charge (SoC) drops below 50%. If the vehicle is going into deep sleep due to one of these conditions, follow normal Workshop Manual (WSM) Section 414-01 procedure to correct the concern. If the vehicle is going into deep sleep outside these conditions, this may be due to the telematics control unit (TCU) software. To correct this condition, follow the Service Procedure to update the TCU to the latest software. For claiming, use causal part 14G229 and applicable labor operations in Section 10 of the Service Labor Time Standards (SLTS) Manual.
Associated Products (30)2023 Ford Bronco Sport2023 Ford Explorer2023 Ford Maverick2023 Ford Mustang2023 Ford Ranger2023 Ford Transit Connect2023 Lincoln Aviator2022 Ford Bronco Sport2022 Ford Ecosport2022 Ford Escape2022 Ford Explorer2022 Ford Maverick2022 Ford Mustang2022 Ford Ranger2022 Ford Transit2022 Ford Transit Connect2022 Lincoln Aviator2022 Lincoln Corsair2021 Ford Bronco Sport2021 Ford Ecosport+ 10 moreAssociated Documents - February 22, 2024•Document ID: 10251468Service Bulletin/Repair InstructionsSTRUCTURE; EQUIPMENT
- Mfr Comm. #:
- TSB 24-2044
- Date Added:
- March 7, 2024
- Manufacturer:
- FORD
SummaryThis article supersedes TSB 23-2181 to add 2024 vehicle model year. Some 2020-2024 Explorer/Aviator vehicles may exhibit a lack of audio and/or a water leak in the rear liftgate area and/or water in the spare tire area. The customer may indicate that this concern is more noticeable after a car wash or rainfall. To correct the condition, follow the Service Procedure to identify the leak path.
Associated Products (8)Associated Documents - February 22, 2024•Document ID: 10251467Service Bulletin/Repair InstructionsEQUIPMENT:ELECTRICAL:RADIO/TAPE DECK/CD ETC.; ELECTRICAL SYSTEM
- Mfr Comm. #:
- TSB 24-2043
- Date Added:
- March 7, 2024
- Manufacturer:
- LINCOLN
SummaryThis article supersedes TSB 23-2208 to add 2024 model year vehicles. Some 2020-2024 Explorer/Aviator non-hybrid vehicles may exhibit radio static and/or poor radio sound quality when moving. This may be more noticeable on AM radio stations. This may be caused by an electromagnetic interference concern
Associated Products (8)Associated Documents - February 16, 2024•Document ID: 10250526Service Bulletin/Repair InstructionsSTRUCTURE:BODY:HATCHBACK/LIFTGATE; EQUIPMENT
- Mfr Comm. #:
- SSM 52269
- Date Added:
- February 23, 2024
- Manufacturer:
- FORD
Summary2022-2024 Explorer/Aviator vehicles built on or after 28-May-2022, 2022-2024 Expedition/Navigator vehicles built on or after 08-Jun-2022, 2022-2024 Escape vehicles built on or after 01-Jun-2022 and 2022 Corsair vehicles built on or after 01-Jun-2022 are no longer equipped with a hands free liftgate system. The vehicle is not misbuilt. The addition of any parts is not a warrantable repair. Do not submit a claim for this condition.
Associated Products (16)2024 Ford Escape2024 Ford Expedition2024 Ford Explorer2024 Lincoln Aviator2024 Lincoln Navigator2023 Ford Escape2023 Ford Expedition2023 Ford Explorer2023 Lincoln Aviator2023 Lincoln Navigator2022 Ford Escape2022 Ford Expedition2022 Ford Explorer2022 Lincoln Aviator2022 Lincoln Corsair2022 Lincoln NavigatorAssociated Documents - February 15, 2024•Document ID: 10250524Service Bulletin/Repair InstructionsEQUIPMENT; STRUCTURE
- Mfr Comm. #:
- SSM 52264
- Date Added:
- February 23, 2024
- Manufacturer:
- LINCOLN
SummarySome 2020-2024 Aviator vehicles may exhibit concerns that reqiure loadspace trim panel vent register replacement. The vent register is now available separately (service base part number 19893). It is no longer necessary to replace the entire loadspace trim panel.
Associated Products (4)Associated Documents - January 18, 2024•Document ID: 10249176Service Bulletin/Repair InstructionsELECTRICAL SYSTEM
- Mfr Comm. #:
- SSM 52189
- Date Added:
- January 24, 2024
- Manufacturer:
- FORD
SummarySome 2020-2024 Explorer/Aviator vehicles may exhibit poor speaker sound quality and/or tick-tock noise while activating turn signals and streaming audio over Bluetooth. Customers may describe static heard during a Bluetooth phone call or a door speaker buzz or tick noise with the pulse of the turn signal. This may be due to concerns with the 14401/14A005 wiring harnesses or connector damage. Prior to the replacement of the affected speaker, inspect for incorrect pin fit/crimp, bent pins, broken wire strands, or other damage at inline connectors C202, C2383A, and/or C4240B. These circuits join the accessory protocol interface module (APIM) and audio front control module (ACM) components. If wiring/connector concerns are found, repair per Wiring Diagram Cell 5.
Associated Products (8)Associated Documents - January 17, 2024•Document ID: 10249841Service Bulletin/Repair InstructionsUNKNOWN OR OTHER; ELECTRICAL SYSTEM: INSTRUMENT CLUSTER/PANEL
- Mfr Comm. #:
- 23B49 S2
- Date Added:
- February 7, 2024
- Manufacturer:
- LINCOLN
SummaryCertain 2021 - 2023 Model Year Aviator Vehicles Equipped With SYNC - Reprogram Accessory Protocol Interface Module Owner letter submitted 09/06/23
Associated Products (3)Associated Documents - December 21, 2023•Document ID: 10248062Service Bulletin/Repair InstructionsELECTRICAL SYSTEM
- Mfr Comm. #:
- SSM 52152
- Date Added:
- January 2, 2024
- Manufacturer:
- LINCOLN
SummarySome 2020-2023 Explorer/Aviator vehicles equipped with all-wheel drive (AWD) may exhibit an illuminated powertrain malfunction (wrench) indicator and/or 4WD Fault Service Required message with diagnostic trouble codes (DTCs) C00A6:71, C00A6:74, C00A6:99, C00A7:11, C00A7:13, C00A8:11, and/or C00A8:13 present in the AWD module. This may be due to a damaged wiring harness rubbing against the underbody heat shield where it routes over and into the transfer case actuator motor. Inspect the wire harness for damage and repair as necessary following the procedures in the Wiring Diagram Manual. If no damage is found, continue with normal diagnostics.
Associated Products (6)Associated Documents - November 15, 2023•Document ID: 10246073Service Bulletin/Repair InstructionsELECTRICAL SYSTEM:SOFTWARE
- Mfr Comm. #:
- 23B49 S1
- Date Added:
- December 5, 2023
- Manufacturer:
- LINCOLN
SummaryCertain 2021 - 2023 Model Year Aviator Vehicles Equipped With SYNC - Reprogram Accessory Protocol Interface Module
Associated Products (3)Associated Documents - November 15, 2023•Document ID: 10246123Service Bulletin/Repair InstructionsPOWER TRAIN
- Mfr Comm. #:
- TSB 23-2351
- Date Added:
- December 5, 2023
- Manufacturer:
- FORD
SummarySome 2021-2023 F-150, 2022-2023 Expedition/Navigator, 2022-2023 Mustang, 2020-2023 Transit, 2020-2023 Explorer/Aviator vehicles equipped with a 10R80/10R80MHT transmission may exhibit a harsh/delayed engagement and/or harsh/delayed shift, an illuminated malfunction indicator lamp (MIL) with diagnostic trouble codes. stored in the powertrain control module (PCM) or transmission control module (TCM). This may be due to the software in the powertrain control module (PCM) or transmission control module (TCM), the transmission solenoid ID strategy, sticking valves in the main control valve body and/or axial movement of the CDF clutch cylinder (7H351) sleeve.
Associated Products (18)2023 Ford Expedition2023 Ford Explorer2023 Ford F-1502023 Ford Mustang2023 Ford Transit2023 Lincoln Aviator2023 Lincoln Navigator2022 Ford Expedition2022 Ford Explorer2022 Ford F-1502022 Ford Mustang2022 Ford Transit2022 Lincoln Aviator2022 Lincoln Navigator2021 Ford Explorer2021 Ford F-1502021 Ford Transit2021 Lincoln AviatorAssociated Documents - November 14, 2023•Document ID: 10246125Service Bulletin/Repair InstructionsPOWER TRAIN
- Mfr Comm. #:
- TSB 23-2352
- Date Added:
- December 5, 2023
- Manufacturer:
- FORD
SummarySome 2020-2023 Explorer/Aviator and 2021-2023 Bronco vehicles equipped with a 10R60 transmission may exhibit a harsh/delayed engagement and/or harsh/delayed shift, an illuminated malfunction indicator lamp (MIL) with diagnostic trouble codes stored in the powertrain control module (PCM) or transmission control module (TCM). This may be due to the software in the powertrain control module (PCM) or transmission control module (TCM), the transmission solenoid ID strategy and/or sticking valves in the main control valve body. To correct the condition, follow the Service Procedure to identify and correct the condition.
Associated Products (9)Associated Documents - November 10, 2023•Document ID: 10245358Service Bulletin/Repair InstructionsENGINE AND ENGINE COOLING; EQUIPMENT
- Mfr Comm. #:
- TSB 23-2347
- Date Added:
- November 21, 2023
- Manufacturer:
- LINCOLN
SummaryThis article supersedes TSB 23-2279 to update the Service Procedure. Some 2021-2023 F-150 vehicles equipped with a 3.5L PowerBoost hybrid engine, 2020-2023 Explorer vehicles equipped with a 3.3L hybrid engine and 2020-2023 Aviator vehicles equipped with a 3.0L hybrid engine may exhibit a powertrain malfunction indicator lamp (MIL) with diagnostic trouble code (DTC) P0A1E stored in the powertrain control module (PCM). This may be due to the belt integrated starter generator (BISG). To correct this condition, follow the Service Procedure to diagnose and repair this symptom.
Associated Products (7)Associated Documents - October 5, 2023•Document ID: 10244707Service Bulletin/Repair InstructionsELECTRICAL SYSTEM:SOFTWARE; UNKNOWN OR OTHER; EQUIPMENT:ELECTRICAL:INFOTAINMENT:SOFTWARE; EQUIPMENT:ELECTRICAL:NAVIGATIONAL SYSTEM(GLOBAL POSITIONING SYSTEM)
- Mfr Comm. #:
- TSB 23-2307
- Date Added:
- November 2, 2023
- Manufacturer:
- LINCOLN
SummarySome 2019-2020 Edge/F-150/Fusion/Continental/MKZ/Nautilus, 2019-2021 Mustang/Ranger/Transit Connect, 2020-2021 EcoSport/Escape/Expedition/Explorer/F-Super Duty/Aviator/Corsair/Navigator, 2021 Bronco Sport and 2020-2022 Explorer/Aviator vehicles with SYNC 3 may experience various SYNC performance related concerns. This may be due to the SYNC Software. To correct the condition, follow the Service Procedure to update the SYNC module (APIM) software.
Associated Products (25)2023 Ford Bronco Sport2023 Ford Explorer2023 Ford Maverick2023 Ford Mustang2023 Ford Ranger2023 Lincoln Aviator2022 Ford Bronco Sport2022 Ford Escape2022 Ford Explorer2022 Ford Maverick2022 Ford Mustang2022 Ford Ranger2022 Lincoln Aviator2022 Lincoln Corsair2021 Ford Bronco Sport2021 Ford Ecosport2021 Ford Escape2021 Ford Expedition2021 Ford Explorer2021 Ford Mustang+ 5 moreAssociated Documents - September 28, 2023•Document ID: 10243655Service Bulletin/Repair InstructionsPOWER TRAIN
- Mfr Comm. #:
- SSM 51951
- Date Added:
- October 6, 2023
- Manufacturer:
- FORD
SummarySome 2020-2023 Explorer/Aviator vehicles equipped with a 10R80 MHT transmission may exhibit an illuminated powertrain malfunction (wrench) lamp with diagnostic trouble code (DTC) P084B stored in the PCM. The Workshop Manual (WSM) has recently been updated to provide new direction for DTC P084B.
Associated Products (6)Associated Documents - September 21, 2023•Document ID: 10243648Service Bulletin/Repair InstructionsPOWER TRAIN
- Mfr Comm. #:
- SSM 51939
- Date Added:
- October 6, 2023
- Manufacturer:
- FORD
SummarySome 2017-2023 Ford and Lincoln vehicles equipped with a 10R60/10R80/10R80 MHT/10R100 transmission may exhibit a whine noise at idle and/or while driving. This may be identified as coming from the bellhousing and the front of the transmission fluid pan. The whine noise may become louder when the transmission is at operating temperature and may increase with engine revolutions per minute (RPM) in the park (P) position. A small amount of whine noise is considered to be characteristic of the 10R60/10R80/10R80 MHT/10R100 transmissions due to the offset gear drivetrain in the front support and has no effect on durability. Use the Report a Vehicle Concern link at the bottom of OASIS to submit a report if there is a customer concern of whine noise describing operating conditions and noise severity.
Associated Products (27)2023 Ford Bronco2023 Ford Expedition2023 Ford Explorer2023 Ford F-1502023 Ford Mustang2023 Ford Ranger2023 Ford Transit2023 Lincoln Aviator2023 Lincoln Navigator2022 Ford Bronco2022 Ford Expedition2022 Ford Explorer2022 Ford F-1502022 Ford Mustang2022 Ford Ranger2022 Ford Transit2022 Lincoln Aviator2022 Lincoln Navigator2021 Ford Bronco2021 Ford Expedition+ 7 moreAssociated Documents - September 20, 2023•Document ID: 10243609Service Bulletin/Repair InstructionsEQUIPMENT
- Mfr Comm. #:
- SSM 51937
- Date Added:
- October 5, 2023
- Manufacturer:
- LINCOLN
SummarySome vehicles equipped with power folding mirrors may exhibit power folding mirrors that are inoperative or exhibit a clicking sound. This may be due to the mirrors being manually folded in, during transportation, going through a car wash, bumped in a parking lot, or found during pre-delivery inspection (PDI). Prior to the replacement of any components, attempt to synchronize the mirrors by following the Power Mirrors Synchronization procedure. Refer to Workshop Manual (WSM) Section 501-09 Rear View Mirrors - General Procedures - Power Mirrors Synchronization.
Associated Products (15)Associated Documents - September 20, 2023•Document ID: 10242845Service Bulletin/Repair InstructionsPOWER TRAIN
- Mfr Comm. #:
- TSB 23-2072
- Date Added:
- September 26, 2023
- Manufacturer:
- FORD
SummarySome 2020-2023 Explorer/Aviator all-wheel drive (AWD) vehicles with a hybrid powertrain may experience a harshness and/or vibration felt through the seat, steering wheel and/or center console at 25-50 mph (40-80 km/h). This may be due to constant velocity (CV) joint instability at dynamic angles close to zero. To correct the condition, follow the Service Procedure to install a driveline shim.
Associated Products (6)Associated Documents