Ford F-250 Complaints

11,199 consumer complaints on file.

#11503774January 26, 2023
SUSPENSION
The contact owns a 2012 Ford F-250. The contact stated upon making a turn, the wheel seized, and the vehicle failed to move. There was no warning light illuminated. The vehicle was towed to the dealer where it was diagnosed that the front passenger’s side axle shaft had fractured at the wheel. The dealer diagnosed that the outer shaft and seals needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure and referred the contact the NHTSA hotline. The failure mileage was approximately 229,020.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11503621January 25, 2023
ELECTRICAL SYSTEM
The contact owns a 2019 Ford F-250. The contact stated that while driving at an undisclosed speed, the instrument panel and vehicle lost electrical and motive power and then stalled. The contact’s husband was able to maneuver the vehicle off the roadway; however, the contact stated that she was trapped in the vehicle due to the loss of power. The vehicle was towed to dealer where it was diagnosed that the vehicle lost power due to the door sensor. The vehicle was repaired. The contact stated that she was concerned for her safety. The manufacturer was notified of the failure and the contact was assisted with warranty coverage. The failure mileage was approximately 48,000. The VIN was unavailable.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11503649January 25, 2023
SUSPENSION, STEERING
While driving at highway speeds, the vehicle may encounter a bump in the road that causes the front-end of the vehicle to jump one direction or another and/or shake violently. This causes the steering wheel to shake back and forth violently, requiring two hands and a fair amount of force to control the vehicle. The vehicle will not stop shaking until speed is reduced below 50 mph. The most recent issue was during a 100+ mile interstate trip with speed limit travel (70 mph). The truck experienced this issue on 4 seperate occasions during this trip; twice in moderate traffic where other vehicles around me were at risk of collision due to my vehicle swerving and my sudden braking to maintain control. There are no warning lamps and no other indication when the truck is going to experience the issue. It has repeated regularly at various speeds over 55 mph and under a variety of conditions Local Ford dealer is aware of the issue and offered to replace a steering damper and examined the front suspension for loose or worn parts. Dealer made me aware this was a common problem that Ford is aware of but the only resolution is replacement of the steering damper. Dealer indicated all font suspension components are still in good condition. The part is on backorder and estimated to be a month or more before they can get it. It is my understanding this is not warranty work and I should expect to pay for the labor to install it. My truck only has 25,000 miles and the suspension, wheels, tires, brakes, etc. are all original stock from the manufacturer, there are no after-market parts. The vehicle is available for inspection and no parts have been replaced to date. This vehicle is driven daily and remains a safety concern at highway speeds over 55 mph.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11503361January 24, 2023
ENGINE
The contact owns a 2017 Ford F-250. The contact stated while driving 60 MPH, the low fuel pressure and reduced power warning lights appeared on the instrument panel. The vehicle stalled and failed to restart. The vehicle was towed to a dealer where the contact was informed that the high-pressure fuel pump had failed. The contact was informed that metal shaving had spread throughout the engine, resulting in engine failure. The manufacturer was notified of the failure. The vehicle was not repaired and remained in the possession of the dealer. The failure mileage was 64,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11503497January 24, 2023
ENGINE
A TSB has been made by ford for the wiring harness on the emission system that causes the Nox sensors to fail and can cause the unit to have a major reduction of power while moving. The TSB states water can potentially get in the harness connector that is mounted on the right outside part of the frame, and cause's corrosion which can cause a short and have the Nox sensor to throw a P2209 code and fail. I have experienced this while driving with a major loss of power. For having a TSB open and researching many other having the same issue, it should be an automatic fix by Ford. Not only is it an expensive fix for a flaw in design, but I was lucky to not get rear-ended at highway speeds at the time this happened to me with my kids in the truck. Speaking to the dealership they mentioned they are aware of the problem, because the truck is 2000 miles above the 8/80,000 miles emission factory warranty, they want to charge $1600 plus for a problem they are aware of.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11503106January 23, 2023
SUSPENSION, STEERING, VEHICLE SPEED CONTROL
When I drove over 50mph and hit any bump the front of the truck shakes wildly. Online says DEATH WOBBLE. This has been going on for 4 months. When taking my children to school 20+ miles away on the highway this has happened several times to and from school on the same day. Other vehicles move out of my line to avoid me while I slow the truck to under 45 mph. They are scared and nervous about getting to school safely. My mother and wife refuse to drive the truck after experiencing this while driving. The fuel injector now also has a problem. The truck is going in to be serviced for the failing fuel injector and death wobble hopefully today if Waldorf MD Ford has openings I am awaiting a call back. It has not been inspected yet only diagnostic at AutoZone showing the fuel injector error code. No warning was given prior to this happening, the truck was riding smoothly, hit a bump in the highway and went crazy. Then it did it again and again and again.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11502910January 21, 2023
SUSPENSION, STEERING
On 6 January 2023, while increasing speed to 55 mph my steering wheel began to vibrate to the point where it was almost uncontrollable and the front end was shaking badly. Vehicle has been in the shop for repair since 12 January 2023 at Henderson Ford dealership in Bay Saint Louis, MS. My safety and others near me on the road was at risk until I could slow the vehicle back down to 45 mph. No symptoms or warnings occurred beforehand. Vehicle was inspected and found to have issues with Drag Link, Stud Right Outer Tie Rod, Adjust Sleeve, and Track Bar. Parts were ordered and repair is ongoing and was supposed to be completed yesterday, 20 January 2023. Vehicle is still in the shop.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11502769January 20, 2023
STEERING, SUSPENSION, UNKNOWN OR OTHER
WHILE DRIVING THE TRUCK GOING OVER 50 MILES PER HOUR, IT GOES INTO A WOBBLE, SHAKING, VIBRATION MODE. I FEEL LIKE I'M IN A EARTHQUAKE. SOME TIMES IT COMES ON JUST NORMAL DRIVING AND MOST OF THE TIMES HAPPENS DRIVING OVER BUMPY UNEVEN SURFACE AND POTHOLES ROAD DOING OVER FIFTY MILES PER HOUR. I HAVE TAKEN IT TO THE DEALERSHIP RED MCCOMBS IN SAN ANTONIO TEXAS ABOUT THREE OR FOUR TIMES BEFORE WITH THIS PROBLEM. THEY CAN'T FINE THE PROBLEM. THE SURVICE ADVISER DID STATE THAT ONE OF THERE TECHNICIAN DID KNOWDICE A SLIDE VIBRATION WHILE TEST DRIVING IT BUT OTHER THEN THAT NO PROBEMS. THEY DID REPLACE A PART AT ONE TIME BUT IT DID NOT SOLVE THE PROBLEM. I HAVE AN APPOINTMENT [RED MCCOMB] ON 6TH OF FEBRUARY TO DROP OFF THE TRUCK TO CHECK OUT AGAIN. I DON'T KNOW WHAT TO DO ANY MORE. THIS LAST TIME THE VIBRATION WAS REAL BAD. HAD HARD TIME GETTING IT UNDER CONTROL ON A MAJOR CITY HIGHWAY. I THOUGH I WAS GOING TO GET KILL. I FEAR FOR MY LIFE AND SAFETY DRIVING THAT TRUCK. I DON'T WANT TO SELL IT AND PUT SOMEBODY ELSE LIFE IN DANGER. I CALLED FORD MANUFACTURE ON AROUND THE 17 OR 18 OF JANUARY AND INFORMED THEM ABOUT IT. THE CONVERSATION WAS RECORDED ACCORDING TO THEM. THEY ACTED LIKE THERE HAS BEEN NO PROBLEM WITH THOSE TRUCKS. THEY CONTACTED ME BACK WITH THE DEALERSHIP. THATS WHEN I MADE THE APPOINTMENT. I BOUGHT THAT TRUCK NEW IN TEMPLE TEXAS FROM THE JOHNSON BROTHERS DEALERSHIP IN JUNE 2012. RED MCCOMB HAS MAINTAIN ALL OF THE REQUIRED MAINTANACE AND MECHANICLE PROBLEMS SINCE I BOUGHT IT NEW. JUST ABOUT EVERYTHING IS DOCUMENTRED THERE.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11502855January 20, 2023
POWER TRAIN
The contact owns a 2022 Ford F-250 SD. The contact stated that while driving approximately 60 MPH in the center lane of a busy highway, the transmission suddenly malfunctioned and the vehicle abruptly decelerated. The contact was able to maneuver the vehicle to the shoulder. The contact stated that after turning off and restarting the vehicle, the vehicle operated as needed. The contact indicated that the vehicle had experienced the failure on five separate occasions. The vehicle was taken to the local dealer who diagnosed that the transmission coolant pump was faulty and that the transmission needed to be replaced. The vehicle was not yet repaired. The failure mileage was approximately 46,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11502893January 20, 2023
SUSPENSION
I hit a small bump or go across rumble bars in the road my vehicle wobbles violently until I can slow down or stop
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11502733January 20, 2023
STEERING, SUSPENSION
While driving at freeway speeds, my vehicle’s front end and steering wheel started to vibrate and shake violently (steering oscillation). I had to slow down immediately and pull to the side of the road to avoid being involved in a collision. This continues to occur on a regular basis and I feel that this vehicle has an engineering flaw and a premature failure in the vehicle’s steering and suspension components. I believe this vehicle is unsafe to be driven on the road, because this issue may lead to a traffic collision which could result in serious injury or death.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11502576January 19, 2023
SUSPENSION
The contact owns a 2020 Ford F-250. The contact stated while driving approximately 55 MPH, the vehicle experienced a death wobble. The front-end of the vehicle was shaking uncontrollably. The contact pulled over and regained control of the vehicle. There were no warning lights illuminated. The vehicle was not diagnosed or repaired. The manufacturer was not contacted about the failure. The failure mileage was approximately 24,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11502610January 19, 2023
STEERING
Ford death wobble, truck shakes very much after hitting a bump or pot hole It has happened many times in the course of two weeks. Overchristmas while traveling.⁶
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11502376January 18, 2023
STEERING, SUSPENSION
I was experiencing what is known as the "death wobble" in my 2016 Ford F250 FX4 truck. The truck only has 56,000 miles but is out of warranty. I recently spent $1326.00 to have the problem repaired. Apparently this is a major problem with these trucks. I have the repair bill but didn't include it with this statement.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11502110January 17, 2023
AIR BAGS
The contact owns a 2016 Ford F-250. The contact received notification of NHTSA Campaign Number: 22V337000 (Air Bags) however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11502160January 17, 2023
SERVICE BRAKES, HYDRAULIC
The contact owns a 2008 Ford F-250. The contact stated while driving 25 MPH and making a left turn, the brake pedal was depressed but failed to respond and went to the floorboard. There was no warning light illuminated. The contact stood on the brake pedal and the vehicle stopped. The contact was able to pull into a parking lot at a low speed. The contact stated that upon restarting the vehicle, the brake pedal responded as needed while driving to his residence. Upon investigating the failure, the contact became aware of NHTSA Campaign Number: 19V904000 (Service Brakes, Hydraulic). The contact repaired the vehicle. The manufacturer was notified of the failure and informed the contact that the vehicle was not under recall. The failure mileage was approximately 179,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11502201January 17, 2023
STEERING
FRONT END WOBBLES SERVERLY AFTER HITTING POTHOLES OR WAFFLED PAVEMENT! I have to almost stop the the truck under control and have almost been rear ended. I understand there is a class action lawsuit at this time. Took it to the local dealer and they quoted what the repair would cost but never let me know this was an issue with may of these truck, found out by searching on U-Tube.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11502233January 17, 2023
STEERING, SUSPENSION
My vehicle has the death wobble and it is getting worse. When the vehicle is operating over 50mlh and hits a bump, it can begin to shake violently and will not stop until I slow down to 25-30th. This is difficult on trips with my camper and on mountains on interstate highways.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11502236January 17, 2023
SUSPENSION, STEERING, POWER TRAIN
I was driving approximately 60 mph. There were several small bumps in the road and the Truck went into a Very Violent Shake and Wobble. This is commonly known as the FORD DEATH WOBBLE... Very Scary and Dangerous. The Vehicle was extremely hard to control. Luckily the service advisor at Coggin Ford had warned me about this possible condition. I was told if this wobble ever happened to let immediately back off the accelerator and not Touch the Brakes?? I did exactly as he said and was able to get the truck into the Emergency Lane where I slowed down in a slow and dangerous way. I took the Truck to Coggin Ford. The truck has only 21000 miles. They claim it just needs an alignment and a steering Dampener which was already changed by Ford at 2500 miles? The service department told me that the parts are unavailable but the think it needs an alignment? The alignment was fine until the Death Wobble?? This is a dangerous condition that could have killed myself, my daughter or other drivers... Please let me know what the NHTSA is doing to prevent this from causing accidents and let me know what my options are... Thank you, Philip Monson 904-487-8936
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11502300January 17, 2023
STEERING
Violent uncontrollable steer wheel shaking at high way speeds 65-75 MPH. Shaking is unforeseen happens randomly and suddenly without warning. I’m unable to steer the truck until I come to a complete stop. So how about you guys do your job before people get killed not after. I know there are hundreds of other complaints like this on here. It’s been to the dealer ship twice. once before the issue happened because of unusual noises when steering and once after the issue both times they said everything was normal.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Ford F-250