Ford F-150 Complaints

39,812 consumer complaints on file.

#11751275July 18, 2026
POWER TRAIN
Typical known issue with the 10speed transmission. Stall shifting between 3rd and 5th gear. When shifting under acceleration and shifting from 3rd to 5th the transmission hangs and then slams into 5th. Happens frequently.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11751295July 18, 2026
UNKNOWN OR OTHER
The skid plate came off. It’s fabric screwed in by metal so it rips off over time. I know and have seen many other Ford owners who have experienced this same problem. It’s a hazard and a concern that will keep occurring if you replace it with the same fabric and it’s costly to replace with a metal skid plate. It’s a manufacturing problem that should be recalled.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11750981July 17, 2026
UNKNOWN OR OTHER
I had the recall number 05s28 repaired at high desert ford on July sixth as a part of a California safety inspection to register my vehicle. Per ford they are done however they refuse to update the system which holds my vehicle unable to be registered even after the services were rendered and complete. Multiple attempts to trendy have failed any results thus ford is holding my vehicle hostage from legal use in the state
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11750996July 17, 2026
POWER TRAIN
At about 15000 mile (under warranty) I had to take it to the dealer for hard shifting. At around 58000 mile and still under warranty I started to have intermittent hard shifting and searching for gears. At 63000 (out of warranty) I had complete transmission failure with gear lockouts occuring on 2nd and 7th gear and hard shifting. Applied for to FORD for after warranty assistance and was told to keep driving the truck while they worked it out with Customer Service Assistance. AI is reflecting to STOP driving the vehicle immediately as it is a known safety issue from FORD. WTH!
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11751067July 17, 2026
LATCHES/LOCKS/LINKAGES:DOORS:LOCK, ELECTRICAL SYSTEM
The contact owns a 2012 Ford F-150. The contact stated that while the vehicle was parked, the contact was unable to unlock the door while using the remote unlock feature. The lights to indicate that the vehicle was unlocked flashed, but the contact was unable to open the door. Additionally, the contact attempted to open the door manually right after using the key, but the door failed to open. The dealer was not contacted. The manufacturer was not aware of the failure. The failure mileage was approximately 147,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11751105July 17, 2026
SERVICE BRAKES
My 2014 Ford F-150 previously received Ford's brake master cylinder recall repair under the previous owner in November, 2016. On XXX, at approximately 108,372 miles, we were towing our travel trailer and had just begun a planned vacation. Within approximately five minutes of leaving home, a warning chime sounded and a "Brake Fluid Low" warning appeared on the instrument panel. I immediately exited the roadway and pulled into the nearest gas station to determine the cause. Within moments, the brake pedal traveled completely to the floor, leaving the vehicle with virtually no braking capability and making it unsafe to operate. Because the truck was towing our travel trailer, we had to disconnect the trailer in the gas station parking lot. The truck could not be driven safely and had to be towed to Kent Parsons Ford in [XXX]. My son had to bring his own truck to tow our travel trailer home because our truck was no longer capable of doing so safely. Kent Parsons Ford inspected the vehicle and documented the following diagnosis on the repair order: "Verified customer's concern. Found master cylinder seal failed and filled booster with DOT fluid." The dealership replaced the brake master cylinder, brake booster, brake fluid, and related components. The failed components may no longer be available for inspection because they were replaced during the repair. I paid $1,793.38 for the repair. The dealership's diagnosis documents the same failure mechanism described in NHTSA Recall 20V-332 (Ford Safety Recall 20S31), involving failure of the master cylinder seal that allows brake fluid to leak into the brake booster, reducing braking performance. Because this vehicle had already received Ford's recall remedy in November 2016, I am submitting this complaint to document that an authorized Ford dealership identified the same failure mechanism after the recall repair had already been completed. I respectfully request that NHTSA investigate. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11751114July 17, 2026
POWER TRAIN, ENGINE
The contact owns a 2016 Ford F-150. The contact stated that while driving approximately 50 MPH on three occasions, the transmission unexpectedly downshifted to first gear and the vehicle decelerated to 20 MPH. The vehicle became uncontrollable momentarily; however, the contact was able to regain control of the vehicle. The contact was concerned about driving the vehicle. The check engine warning light was illuminated. The powertrain service warning light was illuminated. The contact received notification of NHTSA Campaign Number: 26V237000 (Power Train). The vehicle was taken to the local dealer to be diagnosed, and it was determined that the transmission lead frame needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure, and a ticket was opened. The failure mileage was approximately 182,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11751152July 17, 2026
POWER TRAIN
Transmission downshifted rapidly. Wrench came on and then the transmission quit.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11751181July 17, 2026
ENGINE
The contact owns a 2020 Ford F-150. The contact stated that while attempting to start the vehicle, there was an abnormally loud sound coming from the vehicle. Additionally, while driving at an undisclosed speed, the vehicle was idling abnormally rough. No warning lights were illuminated. The vehicle was taken to the dealer several times, however the failure was not duplicated. The contact stated that the failure was a known failure with the vehicle. The manufacturer was made aware of the failure but provided no assistance. The failure mileage was approximately 28,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11751190July 17, 2026
FUEL/PROPULSION SYSTEM
On July 15, 2026, I took the vehicle to Lafontaine Ford for maintenance and to address open recalls. I was informed that the open recall for the low-pressure fuel pump (campaign 25S75) did not have a solution available. Due to the severity of the recall, I contacted the Ford Customer Care Center. A representative stated that a solution would be available on July 17, 2026, and that they would contact Lafontaine Ford to prioritize the vehicle for repair on July 18, 2026. On July 17, 2026, I followed up with Lafontaine Ford and confirmed they had received no contact or notation from Ford regarding prioritization. Lafontaine Ford also stated they had no information on when parts would become available and that nothing could be done at that time. I then contacted the Ford Customer Care Center again because no action had been taken, even though the recall has been open since approximately July 8, 2025. A Ford Customer Care Center representative confirmed that no remedy was available for my model year and that they did not know when one would be available. Due to the seriousness of the recall, I requested a courtesy vehicle. The Ford representative contacted Lafontaine Ford regarding this request and then disconnected the call. The Lafontaine Ford representative informed me they could not provide a courtesy vehicle without written confirmation from Ford due to the dealership having no reasonable timeframe of when parts/remedy would be available. When I called the Ford Customer Care Center back and explained what Lafontaine Ford had told me, I was treated indifferently and was disconnected twice. I eventually spoke with a supervisor who refused to escalate the concern or provide any assistance with the documentation Lafontaine Ford said they needed in order to provide a courtesy vehicle. The low-pressure fuel pump is the component identified in the recall and can fail, resulting in loss of engine power or stall while driving. This creates a significant safety risk, part
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11751050July 17, 2026
FUEL SYSTEM, GASOLINE
The contact owns a 2022 Ford F-150. The contact received notification of NHTSA Campaign Number: 25V455000 (Fuel System, Gasoline); however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11750770July 16, 2026
POWER TRAIN
The vehicle has gotten stuck in 7th gear before, it also has almost completely stopped, wouldn't accelerate and shifted down and up. It is not drivable now with only 58500 miles on it. I am afraid to drive it by myself and I would never take my family anywhere in it as it poses a safety hazard / danger.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11750772July 16, 2026
POWER TRAIN
The contact owns a 2016 Ford F-150. The contact stated that the vehicle was previously repaired under NHTSA Campaign Number: 26V237000 (Power Train); however, after the recall repair, the vehicle made abnormal grinding sounds and went into LIMP Mode before shifting to second gear while driving. The transmission warning light was illuminated. The vehicle was taken back to the dealer, who determined that the transmission needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 186,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11750778July 16, 2026
POWER TRAIN, VEHICLE SPEED CONTROL
The contact owns a 2019 Ford F-150. The contact stated that while driving at various speeds and depressing the accelerator pedal, the vehicle hesitated. The contact stated that while attempting to reverse, there was a loud sound coming from the front of the vehicle. A dealer was contacted. The vehicle was taken to the dealer to be diagnosed; however, the diagnostic result was unknown. The vehicle was not repaired. The manufacturer was notified of the failure and informed the contact that the issue would be escalated. The approximate failure mileage was 35,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11750806July 16, 2026
POWER TRAIN
While driving on the highway Vehicle appeared to downshift into to low of a gear range causing me to almost lose control of the vehicle
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11750882July 16, 2026
STEERING, POWER TRAIN
The contact owns a 2017 Ford F-150. The contact stated that while driving approximately 30 MPH, there was an abnormal whistling and dinging sound coming from the vehicle, and the powertrain malfunction warning light was illuminated. The contact stated that the vehicle independently downshifted, and the rear driver’s side of the vehicle slid to the left, and the front passenger’s side of the vehicle crashed into another parked vehicle. The contact exited the vehicle and discovered that due to the impact, there was windshield fluid leaking out of the windshield washer fluid reservoir onto the ground, and the vehicle caught on fire. The contact entered a local AutoZone, retrieved a fire extinguisher, and extinguished the fire. The local fire department was contacted. The contact stated that no air bag was deployed. A police report was filed. A Fire Department report was not filed. The contact had a cut on the right arm, and the medical team in the ambulance patched up the arm; no further medical attention was needed. The vehicle was towed to the residence, where it was self-diagnosed that the steering and ball joint assembly needed to be replaced. The vehicle was not repaired. The contact received notification of NHTSA Campaign Number: 26V237000 (Power Train); however, the part to do the recall repair was not yet available. A dealer was contacted and stated that the remedy was not yet available and would not be available until July 26th. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not notified of the failure. The failure mileage was approximately 100,000.
Crash:
Yes
Fire:
Yes
Injuries:
1
Deaths:
0
#11750895July 16, 2026
POWER TRAIN
Just had another incident where driving along about 30mph and all of a sudden vehicle slams into first gear from 4th gear. Luckily neither I or my dog was injured. And also lucky that another vehicle wasn’t following closely as this safety issue could easily cause a rear end collision. I have reported this to Ford customer support and their corporate office. This is a safety defect from years ago that wasn’t fixed from 2 other recalls. There are a lot of Ford F150 owners from many different gens and years now once again having this same dangerous issue. Ford refuses to my 012 F150 and says they closed the recall in 2019 and now address it as a Customer Service Program which they then put a ten year warranty/150k miles on. Well that might’ve been fair but they backdated that warranty to when truck was originally sold- well that unfair and unethical attempt to make trucks from 2015 and older pay for the lead frame replacement and updated software correction… I’ve heard it costs $1300 and up depending on which Ford Dealership is used. Now to add to their unfair and costly solution out of the blue they have decided to cover 2014 trucks on a new safety recall. Why not cover all 12th generation F150s experiencing this dangerous issue? Why are us 012 and 013 affected owners being discriminated against??Please investigate this sneaky, haphazard program for me. I just tried again to drive my truck but after driving 2 miles and shutting truck off then starting and driving it goes backfrom 3rd to first gear. Please advise . Ford has now issued at least 3 different recalls since 2015 and none of them have been a permanent, safe solution.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11750901July 16, 2026
POWER TRAIN
Typical 10r80 transmission problems you’ve guys seen a million times and have yet to force ford to issue a recall . I can’t even make it through an intersection without it stopping suddenly and putting me in danger . Please do something. This is gonna cost me a lot of money to fix .
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11750902July 16, 2026
UNKNOWN OR OTHER
I have had issues with my door locks one by one for the last year until now all of them have failed and no longer work. I have mentioned this issue multiple times at Bob Tomes Ford in McKinney Texas the last few times and got prices for the repair but it is a bit pricey. Recently I have just found out that Ford had campaign 20M04 to address these bad door lock actuator latches but the car has to be under 10 years old and under 150,000 miles. This service I am currently at the service department finally mentioned it to me and advised that I am out of the free repair window as I am now just over the 10 years and mileage and it will now be $2,400 dollars to repair this. I never received any kind of mailing announcing this recall campaign or was never told about it the numerous times I have been into the dealer in the past to bring my vehicle in for basic maintenance like I am usually told about other recalls. My very last trip here I was under the covered time period and nothing was said to me after I mentioned the door locks starting to go bad. I feel Ford and this dealership Bob Tomes Ford is deliberatly not telling customers about this so they do not have to repair it until the consumer will have to pay for the fix. This is incredible deceitful on Ford and the dealerships part and I feel that something should be done about this
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11750903July 16, 2026
ENGINE, POWER TRAIN
When accelerating from first to second gear, there is a power boost into second gear whether I want the power or not. Example: if I am turning I am not accelerating but my engine will continue to go up in rpm’s and make me go into second gear. Dangerous
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Ford F-150