Ford F-150 Complaints

39,812 consumer complaints on file.

#11756860August 13, 2026
POWER TRAIN
Went to speed up as I was approaching a ramp going uphill and almost towards the top the truck decided to down shift to first gear going about 45 mph. No accident occurred as no one was around me.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11756866August 13, 2026
POWER TRAIN
What happened is i bought a truck that Ford knows good & well has a defective CDF drum and outer shell but they refuse to issue a recall to fix the transmissions in those year models! Yet in late 2022 they acknowledged the problem and updated the 22+ year models with the correct parts while leaving those of us with the prior 4yrs of trucks out in the cold! My truck is currently undergoing getting a new transmission and it hasn't even reached 70K yet. At 61K I had to have all timing components along with a new oil pump replaced due to the common oil consumption issues on the 13th gen models. Now 8K miles later I'm having to have a new transmission because it started with all the common problems and known issues that everyone else has had with the 13th gen trucks. This is absolutely ridiculous and no if's, and's or but's about it Ford should be liable for it! Every single one of us especially those of us below 100K should be reimbursed. It is a disgrace to own and pay for a vehicle that spends more time at the shop than it does in your driveway! I am fuming mad. Due to my age and health condition this was supposed to be the last vehicle I ever buy yet being on a fixed income I now have a truck that I cannot trust to get me safely to my Dr's appointments or even the local places I have to visit on a weekly basis. Absolutely ludicrous! I have all invoices of all work that has been done and that info has also been put into the Carfax records. The shop i use is very proficient when it comes to recording the information. Within a week once the new transmission is installed I will have that invoice as well as it being loaded into the Carfax records.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11756713August 13, 2026
POWER TRAIN
Subject: Formal Customer Complaint – 2025 Ford F-150 Powertrain Malfunction / Reduced Power I am requesting that Ford Motor Company open a formal Customer Relationship Center case concerning an unresolved powertrain malfunction affecting my 2025 Ford F-150. Vehicle: 2025 Ford F-150 VIN: [XXX] Mileage: Approximately 19,215 miles Servicing Dealer: Gary Yeomans Ford, Daytona Beach, Florida On XXX my Ford mobile application generated an “Action needed” vehicle health alert stating: “Powertrain Malfunction / Reduced Power.” My vehicle is also displaying an illuminated wrench warning and a “Service Engine Soon” message. The Ford application continues to show the Powertrain Malfunction / Reduced Power condition and states that service is recommended. I contacted Gary Yeomans Ford regarding the condition. I was informed that a part necessary to repair the problem is on national backorder. However, I have not been provided with the diagnostic trouble codes, exact diagnosis, failed component, Ford part number, estimated part availability, estimated repair date, or written confirmation regarding whether Ford considers the vehicle safe to continue operating while this condition remains unresolved. At this time, I have not experienced an actual loss of power, stalling, abnormal shifting, accident, or other drivability event. Nevertheless, I am concerned about continuing to operate a vehicle that Ford’s own system identifies as having a “Powertrain Malfunction / Reduced Power” condition while the repair remains unavailable. I am requesting that Ford: 1. Open a formal Customer Relationship Center case and provide me with the case number. 2. Obtain the complete diagnosis and diagnostic trouble codes from Gary Yeomans Ford. 3. Provide the name and part number of the failed component. 4. Confirm the warranty coverage for this repair. 5. Escalate the nationally backordered replacement part. 6. Provide an estimated part availability and repair date. 7. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA),
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11756385August 12, 2026
POWER TRAIN
I bought my 2019 F-150 a few months ago used. Since then it’s been nothing but problems and honestly, terrifying one’s. The truck has shifted and driven rough since I bought it. But on some occasions it goes from rough driving to potentially accident causing. The truck will randomly decide it does not want to shift from a gear, meaning I can’t speed up on busy 95 traffic or move out of the way of aggressive drivers when needed. The truck also will occasionally shift up or down on its own without warning causing me to slow down quickly while already at interstate speeds. At this point, because I have no choice but to drive it to work, it’s a matter of waiting for the day it downshifts too far while in the interstate causing a crash. The fact that I am scared at times to drive my own vehicle and the manufacturer not being willing to fix it is alarming. Alarming because if this is something they can get away with now, what will they get away with in the future.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11756402August 12, 2026
POWER TRAIN
Around 108018 miles started to experience rough, harsh, slamming shifts and skipping gears from 1 to 4 or 3 to 6 and then from 8 slamming to 1st gear at times very unsafe and erratic and through my research this transmission has been a big problem on Fords. I took to a local transmission repair shop they drove and confirmed the shifting issues and said yes the valve body/shift solenoids need replaced and also the CDF drum/cylinder is going bad they also dropped the oil pan and confirmed metal/aluminum shavings in the bottom of the pan. I was quoted $8,800 to repair and this is a huge expense that Ford knows of the problem and needs to be held accountable. there needs to be a recall to replace these bad transmissions with new updated units.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11756407August 12, 2026
POWER TRAIN
The contact owns a 2016 Ford F-150. The contact stated that the vehicle was taken to the dealer for a software update. Upon retrieving the vehicle, the transmission failed to shift out of low gear. There were no warning lights illuminated. The vehicle was towed back to the local dealer, and the contact was informed that the vehicle needed to be driven for 250 miles. The vehicle was not diagnosed or repaired. The manufacturer was contacted and opened a case. The failure mileage was approximately 109,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11756409August 12, 2026
POWER TRAIN
2016 f150 transmission downshift recall was preformed, didn’t fix the intermittent downshift at highway speeds. A week and a half after it caused a skid on a wet road. Was told at the dealership, they’re not allowed to do anything else without an active engine code
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11756430August 12, 2026
POWER TRAIN
Vehicle was traveling at highway speeds when the transmission decided to shift from 10th gear into 1st gear at 70mph. Had vehicle at dealership and the transmission had to be replaced. Could have destroyed the motor or caused massive accident on highway shifting into 1st gear at 70mph.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11756470August 12, 2026
SERVICE BRAKES
Brake master cylinder failed at only 98000 miles
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11756484August 12, 2026
POWER TRAIN
I have 40,000 miles on this truck and the torque converter shutters when towing, the transmission is slow to shift fome 3-4. No one has looked at it. Since its out of warranty I am just going to run it until it fails.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11756492August 12, 2026
POWER TRAIN
The internal mechanical failure of the Ford 10r80 transmission due to design fault causes unsafe driving conditions as the transmission stalls (fails to power at request) or lunges (powers forward without driver input) causing unsafe conditions for vehicle occupants and nearby vehicular & pedestrian traffic. My vehicle exhibits two well known and documented conditions; stalling and lunging forward. The most common failure is that the transmission fails to shift from 1st to 3rd gear in a low speed condition (e.g. navigating parking lots amongst pedestrians). Upon the failure to shift, the vehicles computer system senses this, overrides by raising the vehicle RPMs significantly without driver input to do so, the vehicle then hard shifts and jerks forward several feet in an uncontrollable manner. Anticipating the jerk and overriding with the brakes fails to stop the vehicle from lunging forward. The second most common failure is the transmission totally failing to provide drive. A common scenario would be sitting at a traffic light waiting to make a left turn. Upon the opportunity to make a safe left turn, the vehicle at times will roll slightly forward (in its first gear), it will then attempt a shift while the vehicle may potentially still be in cross-traffic, and the vehicle at times will fail to drive, without any inputs (brake, gas, manual shift) getting the vehicle out of the no-drive condition, and leaving the vehicle subject to a dangerous potential for collision or safety hazard. The issues with the 10r80 transmission failures are well documented, well understood by Ford Motor Company, and specific to my vehicle have been identified by a reputable dealer as requiring repair. My vehicle's transmission is exhibiting failure at 47,000 miles. No warning indications exist prior, during or after this repeatable incident. Ford has since fixed the design flaw, but refuses to address the safety issue with vehicles manufactured before the re-design.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11756512August 12, 2026
POWER TRAIN
The contact owns a 2017 Ford F-150. The contact stated that while driving at various speeds, the transmission unexpectedly downshifted to a lower gear, causing the powertrain warning light to illuminate. The contact received notification of NHTSA Campaign Number: 26V237000 (Power Train), and the vehicle was taken to a dealer where the PCM software update was completed; however, the failure recurred two days later. An independent mechanic was contacted, but the contact later received a remedy notification letter that the molded leadframe would be replaced as necessary under an extended coverage program. The vehicle was returned to the dealer, where it was diagnosed and determined that the leadframe had failed and needed to be replaced; however, the contact was informed that the repair was not covered under the recall or program because the diagnostic trouble code did not match the required specifications. The manufacturer was notified of the failure, but no assistance was provided. The contact stated that the manufacturer had failed to honor the recall repair. The vehicle was not repaired. The failure mileage was approximately 185,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11756525August 12, 2026
POWER TRAIN
Cdf drum went bad had to have transmission replaced because of how hard it was shifting
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11756587August 12, 2026
POWER TRAIN
I scheduled an appointment for a recall on my truck. The appt was set for Monday. The dealership in Pensacola, FL picked up my vehicle and claims they do not have the ability to service the recall. However, prior to scheduling the appt, the truck was driven from Seguin, TX to Pensacola without any issues because we have a family emergency with my father in the hospital. Upon arriving in Pensacola, the issue that has the recall started so I immediately set the appt. The dealership has had my truck for 3 days and plans on holding it for an unknown amount of time as they do not know how to service the recall. The recall service would fix the issue my truck is experiencing, and I know the remedy does not take multiple days to perform. I need my truck back, but the dealership does not understand that I need to go back to Texas with my truck functioning properly. So, I just wanted to make a complaint about the dealership in Pensacola, FL having little to no knowledge about to perform the recall remedy and attempting to perform multiple services that will cost me money I do not have because I was not prepared to pay when the recall service should be free. Highly disappointed with them and the fact that I have no way to go back to Texas with my truck.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11756603August 12, 2026
POWER TRAIN
When shifting from 3rd to 4th gear, the trucks RPM jumps and then downshifts into first gear. This happens around 40 mph and has almost caused two accidents for me.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11756468August 12, 2026
FUEL SYSTEM, GASOLINE
The contact owns a 2021 Ford F-150. The contact received notification of NHTSA Campaign Number: 25V455000 (Fuel System, Gasoline); however, the part to do the recall repair was not yet available. The dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was notified of the issue and referred the contact to the NHTSA Hotline for assistance. The contact had not experienced a failure.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11756461August 12, 2026
EXTERIOR LIGHTING
Daytime Running Light failure in headlight assembly. Second time it occurred. Had the first headlight assembly replaced while under warranty. I am now outside of the warranty mileage and the other side's headlight DRL has failed.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11756394August 12, 2026
FUEL/PROPULSION SYSTEM
I've noticed that the vehicle struggle when acceleration, specially at full stop (stoplight and intersection). Feels like the engine is going to die out if I step on gas pedal.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11756107August 11, 2026
POWER TRAIN
Harsh shifting in between gears. Jerky shifting and shudders while shifting as well
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11756109August 11, 2026
POWER TRAIN
I am filing a safety complaint regarding the transmission in my 2019 Ford F-150 equipped with the 5.0L V8 and 10-speed automatic transmission. My vehicle currently has approximately 88,000 miles. The transmission began experiencing abnormal shifting, including skipping/hesitating between gears, harsh shifting, shuddering, and delayed engagement. At times it would appear to skip 2nd gear and go directly into 3rd. I brought the vehicle to a Ford dealership for diagnosis. Ford of Spartanburg performed testing and a road test. Their written diagnosis states that the PCM was tested and had no related DTCs. The technician documented delayed 1-2-3, 2-4 and 3-4 shifts, a 400-500 RPM flare during the 2-4 and 3-4 shifts, and a shudder during the 1-2 shift. The technician checked the transmission fluid and documented that the level was good but that the fluid appeared “super burnt.” The technician further stated “suspect CDF drum bushing shifted” and recommended replacement of the entire transmission assembly. The Ford dealership's estimate for the recommended transmission replacement is $8,737.05. I am concerned that a major internal transmission failure involving the CDF drum/bushing can occur at approximately 88,000 miles and result in delayed, erratic, harsh or unexpected shifting. I am particularly concerned about the potential safety implications if the vehicle unexpectedly loses acceleration or does not respond normally while entering traffic, passing, or traveling at highway speeds. I am requesting that NHTSA document this complaint and investigate whether this represents a broader safety-related defect affecting Ford vehicles equipped with this transmission. I have retained the Ford dealership's diagnostic documentation and can provide it if needed.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Ford F-150