Ford F-150 Complaints

39,812 consumer complaints on file.

#11679264August 8, 2025
ELECTRICAL SYSTEM, UNKNOWN OR OTHER
[XXX]- Vehicle did not start, instrument cluster blacked out, infotainment screen blacked out. disconnected/reconnected battery myself everything worked. [XXX]- Instrument cluster blacked out, disconnected/reconnected battery myself, everything worked, dealership still towed vehicle in to diagnose. Same day dealership said the battery was "a little low" so they put a small charge on it and everything checked out fine. They said when I disconnect/reconnect the battery the codes are reset. So i should hope that the issue does not happen again but if it does, don't disconnect/reconnect the battery. [XXX]- Instrument cluster blacked out, drove straight to dealership where the service writer witnessed the issue and started a service file. Codes were pulled and in just the four days since it was last in the dealership there were multiple codes recorded (appx 40 over the four days). Diagnosis was a bad instrument cluster/computer module that is attached. It was replaced and vehicle returned 04 August 2025. [XXX]- Instrument cluster blacked out, drove straight to the dealership, where Service Writer, Service Manager, and Parts Manager all witnessed the same issue. Started another service file. As of the writing of this information, 08 August 2025, the vehicle is still in the shop. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11678949August 7, 2025
UNKNOWN OR OTHER
I was driving into a parking space and my 2024 Ford F-150 Lightning had a sudden unintended acceleration, which caused vehicle to crash into the concrete block wall in front of the parking space.
Crash:
Yes
Fire:
No
Injuries:
0
Deaths:
0
#11678996August 7, 2025
POWER TRAIN, VEHICLE SPEED CONTROL
Transmission shifts hard and accelerates unexpectedly. Acceleration is not smooth as expected.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11679025August 7, 2025
VISIBILITY/WIPER
Wipers quite intermittently in rain or when using windshield washer Could not see clearly Problem intermittent dealer said wiper motor Yes No warning just quit Problem same as in recall NHTSA22v-142 on f150 2021 and 2022 and recall 22v842
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11679031August 7, 2025
SERVICE BRAKES, HYDRAULIC:PEDALS AND LINKAGES
The contact owns a 2014 Ford F-150. The contact stated that while driving at slower speeds, the vehicle hesitated while coming to a complete stop. In addition, the contact stated that the brake pedal was depressed to the floorboard while feeling loose before becoming stiff. The brake warning light was illuminated. The local dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 108,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11679062August 7, 2025
POWER TRAIN
Transmission down shifts while accelerating, slips when starting from a dead stop, and shifts extremely hard when shifting. It is a safety risk especially when pulling out at an intersection, as it stops (or will slip) in the middle of the intersection. It has not been confirmed by the manufacturer or dealer, only by the article from USA Today. The vehicle has not been inspected by anyone, as it just started yesterday. There were no early indications or warning signs prior to it starting yesterday (08/06/2025).
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11679077August 7, 2025
POWER TRAIN, ELECTRICAL SYSTEM
While driving at 60 mph my vehicle went from the 6th gear down to 1st gear on its own bringing the truck speed down very quickly the vehicle behind me almost hit me in the rear I pulled over speedometer stopped working and a imagine of a wrench was on the dashboard I cleared the wrench 🔧 image on the dashboard and tried to restart the truck turned the key and nothing happened tried again and truck started pulled out and started driving home 4 miles away and it happened again when I got home I googled it and found it is a known problem with the transmission in the 2015 ford f150 where the sensors in the transmission fail to read your speed and then reacts as if the vehicle is stopped so it then puts the transmission into 1st gear where it would be when you are stopped which creates a very dangerous situation especially if you are on a crowded road at higher speeds
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11679124August 7, 2025
ENGINE
Truck has 91,200 miles and was well maintained. Truck has a loud rattle (like rocks in a can) on dry start up after sitting for several days. Rattle goes away after starting and is consistent with worn CAM PHASERS, as shown in many videos on the internet describing this known problem with the Ford 3.5L ecoboost engine. Ford issued a customer reimbursement program for repairing this known defect but it does not apply to this vehicle, even though it was built with the defective cam phasers and is showing signs they are destroying themselves, which can lead to catastrophic engine failure. Ford redesigned the cam phasers to a better version after learning of the originally defective design. The repair is very expensive $3k to $5k.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11679190August 7, 2025
POWER TRAIN
At about [XXX] [XXX], Tuesday, I was N/B on [XXX] , my speed was approximately 60 mph. All of a sudden, my brakes locked up as if I slammed on by brakes. Although a safe distance behind my, vehicles behind me had to swerve out of my way due to the sudden breaking. After pulling over, I checked the undercarriage, thinking I might have hit something, but everything was clear. Not knowing what had just happened I got back onto the highway and when I reached a speed of approximately 65 mph it did it again causing my truck to swerve into the oncoming lane of traffic. I still didn't know what was going on because there were no physical signs indicating such and no warning lights illuminated. After pulling over once again I called a transmission shop and explained what had just happed and asked if they could look at my truck to see what was going on. They told me it would be about three months before they can get me in, but said they know what exactly had happened. When I asked them to please tell me what had occurred, they told me the transmission suddenly went from 5th gear down to 1st gear due to a "Transmission Molded Lead Frame issue" I had no idea what he was talking about, and he said the fix is a simple one that involved a computer software update. Well, I learned that in 2019 there was a "Customer Satisfaction program" for this issue but the problem is I knew nothing about it and when I purchased the vehicle in 2022, I wasn't told about this. Now, the Ford dealership I took the truck to said the "Customer Satisfaction program" that was issued had expired and I would have to pay for the repair. I'm confused because when I first started researching this issue the Carfax at the time I purchased the vehicle was a "Customer Satisfaction program", and after talking to the Hanford Auto Sales, in California, I purchased the vehicle they said they didn't do anything because it was just a "Customer Satisfaction program". INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11679138August 7, 2025
POWER TRAIN
Mostly when pulling out of parking lot but entering traffic at slow speeds complete loss of power for 4 to 5 seconds or longer.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11678967August 7, 2025
UNKNOWN OR OTHER
Rear passenger window stopped working due to switch failure. Unsafe for passengers in rear as road debris and outdoor weather was able to get in. Issue was resolved by replacing master switch
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11678764August 6, 2025
POWER TRAIN
My transmission down shifts while driving and locks up my rear wheels. It almost caused me to wreck on the highway today.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11678791August 6, 2025
POWER TRAIN
The contact owns a 2013 Ford F-150. The contact stated while driving at an undisclosed speed, the transmission unexpectedly downshifted and the malfunction warning light illuminated. The transmission downshifted to first gear and the contact lost control of the vehicle. In addition, the accelerator pedal was depressed; however, the transmission failed to shift out of first gear. The vehicle was taken to the dealer where it was diagnosed with a PCM software failure and molded lead frame failure. The contact was informed that the PCM software needed to be updated, and the molded lead frame needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure and a case was filed. The contact was informed that in June 2019 the vehicle was repaired under NHTSA Campaign Number: 19V075000 (Power Train). In addition, the contact stated that the software update was performed again two weeks prior, and the contact had to pay out-of-pocket for the repair. The contact referenced a recall for the lead frame; however, the warranty for the recall had expired in 2019. The contact stated that the vehicle was inoperable. The contact was advised to contact the NHTSA Hotline to report the failure. The failure mileage was approximately 87, 866.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11678792August 6, 2025
ELECTRICAL SYSTEM:IGNITION:COIL:SPARK PLUGS
The engine continues to shoot out the spark plugs. This is continued to happen with different cylinders. I’ve had it at the mechanic most of the time I’ve owned it.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11678827August 6, 2025
SERVICE BRAKES, HYDRAULIC
The contact owns a 2017 Ford F-150. The contact stated that while coming to a stop, there was an abnormal screeching sound while depressing the brake pedal. There was no warning light illuminated. The contact received notification of NHTSA Campaign Number: 25V236000 (Service Brakes, Hydraulic); however, the part to do the recall repair was not yet available. The dealer was contacted and confirmed that parts were not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the failure. The approximate failure mileage was 40,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11678885August 6, 2025
POWER TRAIN, VEHICLE SPEED CONTROL
When driving on the interstate with the normal flow of traffic at 55mph, the vehicle abruptly downshifted from 6th gear to 1st gear causing the the vehicle to lock up an nearly caused an accident. This was followed by a a mechanic warning light and the speedometer to lock out and no longer work. Once pulled over, the vehicle was powered down. When the vehicle was turned back on operation returned in a limp state.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11678939August 6, 2025
POWER TRAIN
The first transmission I had in my truck i had. Harsh shifting, Slipping gears, Delayed engagement, Transmission overheating, Loss of power and transmission stuck in higher gear while stopped. They replaced the transmission (at my cost ) now i have over heating issues. There should be a mandatory recall on this transmission, give me my money back and fix the issues for free.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11678716August 6, 2025
POWER TRAIN
Transmission has been skipping gears, hard shifting, getting stuck in gears. While traveling in the truck going up an on ramp and then trying to merge into traffic, the transmission got stuck in 7th gear. Pressing the accelerator would not move the vehicle and I was left without the ability to move out of traffic. Vehicles were having to put on their brakes, swerve and go around me. Prior to this time I was having some slight shifting irregularities between gears 2-3 and 7-8. I notified the dealership of issues and they said I would have to drop the vehicle off and it would take 7-10 days before they could even look at it. The vehicle was purchased in December 2020 and currently has just under 75,000 miles. I was told that it was out of warranty. For the first 4 years of ownership the vehicle has always been serviced at a Ford dealership. I was never notified of any issues with the transmission. However they did notify me that a windshield wiper arm was recalled and that was changed. Early in the ownership of the truck, I experienced the vehicle moving backwards when on an incline and taking my foot off of the brake, before accelerating. Also, experienced clanking and jarring when accelerating and then having to take foot off of the accelerator. In 2023, when having the vehicle serviced for oil change, I asked the service technician about these issues and was told that there was nothing wrong and that it was just typical for that type of transmission.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11678723August 6, 2025
VISIBILITY/WIPER
THE WINDSHIELD HAS TINY SPEC BETWEEN THE GLASS NOT A SCRATCH ON WINDOW OR CHIPS WHEN ITS REALY SUNNY OUT YOU CANT SEE IT REALLY HARD.THIS SHOULD BE A RECALL AT NO CHARGE.ITS AN ACCIDENT READY TO HAPPEN.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11678748August 6, 2025
SERVICE BRAKES
My truck has been regularly serviced by FORD and yesterday out of the blue the brake pedal went soft and i got a check engine light saying low fluid. Upon inspection we noticed all brake fluid had leaked with no visible exit. We refilled the fluid and the next day, the fluid was completely drained again with no visible exit. Upon expert inspection it was noted the brake master cylinder is leaking into the booster.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Ford F-150