Ford F-150 Complaints

39,812 consumer complaints on file.

#11707805December 30, 2025
SERVICE BRAKES
complete loss of brakes. there was zero response from the brake pedal for several complete pumps to the floor. after about 4 complete "stomps", the brakes locked, resulting in a violent and sudden stop. at the time, the dash began flashing multiple warning messages about display failure and also ABS failure and making many alarm sounds, further distracting me from dealing with a very dangerous situation. Had this occurred at speed and not at a fast idle speed, serious injury or death would likely have occurred. this is a Xcelerate fleet vehicle, and fleet services took the vehicle to a non-dealership shop, which claims to have fixed the problem but could not complete the recall repairs. fleet has only just today agreed to tow the vehicle to a Ford dealership for recall repair. This incident occurred on 9/26/2025.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11707786December 30, 2025
POWER TRAIN, STRUCTURE
The contact owns a 2021 Ford F-150. The contact stated that while driving 40 MPH, the contact heard an abnormally loud booming sound. The contact pulled over to the right side of the road, exited the vehicle. Upon inspecting underneath the vehicle, the contact noticed that the driveshaft was fractured and damaged. The contact stated that the failure had occurred on several different occasions. The vehicle was towed to a dealer, where it was diagnosed that the heat shield had rubbed on the driveshaft, and the driveshaft needed to be replaced. The vehicle was not repaired. The contact related the failure to NHTSA Campaign Number: 21V986000(Power Train, Structure); however, the VIN was not included in the recall. The manufacturer was not notified of the failure. The failure mileage was 74,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11707574December 29, 2025
POWER TRAIN
I own a 2019 F-150 XLT truck with only 56,000 miles. I bought the truck brand new in 2019 and now it only has 56,000 miles! The transmission just failed and is not under warranty of 5 years or 60,000 miles and it's frustrating Ford doesn't have any recalls for this Truck. This Truck is unsafe and needed a new 10 speed 1080r transmission. Incident #1-I was on the freeway at 65 miles an hour and the truck downshifted into 2nd gear! It abruptly, slowed down and I had to pull over on the side of the freeway, luckily no one was close behind me. I then had to re-start and make it back home. Incident #2- I was turning right at a light and had to merge into traffic and speed up to merge and the truck transmission went into neutral and would not shift into gear. I immediately pulled to the side of the road with cars slamming on their breaks behind me, honking! Incident#3- I was at a red light waiting to turn left and when the light turned green the truck transmission would not go..it was stuck in neutral and after a few seconds shifted and slammed into gear! The car behind me was using their horn to get me moving. A big wrench warning light came on the dashboard and then I decided to fix the issue. I took the Truck to the local Ford dealer and was told to get in line because there were 70 vehicles in back all waiting for the same issue. The dealer gave me an estimate to fix the transmission was $12,000-14,000 dollars! and could take a couple months before they look at my truck. So frustrating because I need a vehicle to get to work. I took it to a local transmission shop and he inspected the transmission and stated I needed to order a new one from Ford. I paid $9,800 for a new 10 speed transmission for my 2019 Ford Truck. I was without my truck for 1 week and caused a big inconvenience to my family.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11707582December 29, 2025
POWER TRAIN
The truck had a horrible shift from 3-5 that makes it hard to even get up to speed correctly and when getting up to around 2.5k-3k rpm it seems to slip makes a loud bang and the catch again and continues to go. It makes the truck annoying to drive and also feels like it’s just going to completely give out one day
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11707610December 29, 2025
UNKNOWN OR OTHER
My truck driver door won’t latch,in cold weather. Like it won’t catch when I try close it less I lock it then it catch but won’t close all the way tell it warm up. Seem like whn it’s down in teens a single digits or below and windy. I’ve had it happen two times so far. Thank you
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11707614December 29, 2025
UNKNOWN OR OTHER, POWER TRAIN
Ford Consumer Affairs was sent a letter with this information, too. My 2018 F150 truck had issues with the 10 speed transmission. It’s been jumping, skipping gear, down shifting for no reason. Yesterday, 12/28/25, we were returning home from a holiday trip on I-95’s left lane of the highway when the truck down-shifted from 10th gear to around 3rd or 4th gear spiking the RPM to over 5,000 RPM’s for no reason on 3 different occasions. We had to move to the right lane after the 3rd time due to the wrench light coming on and the transmission temperature gauge maxed out at super hot and turn on the hazards due to only doing 50 MPH in a 70 MPH highway until we could exit. This was dangerous in so many ways due to the volume of traffic on the highway. Downshifting that much instantly was like slamming on brakes with no break lights. We were verry lucky not getting rear ended and causing a possibly tragic situation. Thankfully, we did not get into an accident. There were a lot of cars on the road, as many families were returning home. This is happening all over the USA with the 10 speed transmission and may eventually cause a tragic accident on the road. We took it to the Cocoa Ford Dealership on 12/29/25 and the diagnostic paper states they 'performed a KOEO Self Test and found PQ7F7 for Gear 10 incorrect ratio. Verified fluid vented out of top of transmission. Tech Rec Overhaul. All one time use parts and rear main seal. Trans cooler. Due to parts/labor cost recommend assembly replacement.'
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11707463December 29, 2025
POWER TRAIN, VEHICLE SPEED CONTROL, STEERING
I was driving about 55 mph when suddenly my 2013 truck down shifted to either first or third gear and I barely was able to control it to get off the road. The truck just bowed up and the vehicle behind me almost hit me. The speedometer stopped working and a wrench icon appeared. I tried to take off and the truck was stuck in third gear. Ford dealership said they would fix it if it was the OSS sensor. I paid to have it towed and they charged me over 2,000. There was a safety recall 24S37 on the 2014 with the 6R80 transmission the same kind my truck has. My 2013 did exactly the same thing as the 2014 and I believe it should have a safety recall. There was a extended warranty or something either 10 years or 150,000. My truck has 130,000. I talked to Ford customer satisfaction but they have done nothing. I told them I was going to report it.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11707505December 29, 2025
POWER TRAIN
transmission is downshifting early and hard. it is clunking and causing erratic speeds and shifting patterns. the hard shifting and downshifting is not normal and dangerous.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11707544December 29, 2025
ELECTRICAL SYSTEM, ENGINE, FUEL/PROPULSION SYSTEM
The vehicle experienced repeated failures involving multiple systems, including the transmission system (transmission replacement), powertrain/engine system (cylinder-related repairs), electronic control systems (vehicle computer/control module replaced multiple times), electrical system (ongoing electrical faults), and rear safety systems (backup camera failure). The vehicle is available for inspection upon request. These failures created ongoing safety concerns due to loss of vehicle reliability and malfunction of safety-related electrical systems, raising concern about unexpected mechanical or electrical failure during operation. The issues were confirmed and documented by Ford-authorized dealerships and independent service centers. Despite repeated repairs, the same or related problems continued to occur. The vehicle was inspected and repaired by Ford dealerships; however, one servicing dealership (Ford of Ventura) later closed, leaving unresolved issues without continuity of service. Warning lights and system alerts occurred prior to failures along with ongoing electrical malfunctions. Exact dates of first warning indicators are UNKNOWN, but symptoms recurred over time despite repairs. The vehicle was purchased with approximately 38,500 miles. Due to COVID-19-related delays, dealership availability and parts shortages caused months-long wait times for service, and when the vehicle was finally inspected by a dealership, it had approximately 60,000 miles. Major system failures occurred well under 100,000 miles. Ford later declined assistance, citing out-of-state purchase and maintenance not performed exclusively at Ford dealerships, despite regular routine maintenance. The cause of the failures is UNKNOWN, but the pattern suggests systemic mechanical and electrical defects rather than owner misuse. All invoiced available as system will not upload them at this time.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11707615December 29, 2025
PARKING BRAKE
The contact owns a 2021 Ford F-150. The contact stated that the vehicle was serviced under NHTSA Campaign Number: 23V509000 (Parking Brake), but the failure persisted. The contact stated that the failed to respond upon shifting to reverse(R) or drive(D). Additionally, the parking brake had seized. The messages "Parking Brake Fault" and " Parking Brake Service Required" were displayed. The dealer was contacted but refused to repair the vehicle under NHTSA Campaign Number: 23V509000(Parking Brake). The contact stated that the dealer had previously inspected the vehicle but no repair had been performed under the recall. The dealer instructed the contact to check the wiring harness. The contact followed the instructions and found that a wire had rubbed through and was fractured. The contact spliced the wire together with a wiring butt connector as a temporary repair. The manufacturer was not made aware of the failure. The failure mileage was approximately 134,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11707607December 29, 2025
POWER TRAIN
The contact owns a 2022 Ford F-150. The contact stated that upon starting the vehicle, the vehicle made an abnormal clanking and rattling noise. There was no warning light illuminated. The contact stated that upon shifting to drive(D), the vehicle failed respond; however, upon engaging 4-wheel Drive(4WD), the vehicle moved forward at a slow speed. The contact's husband drove the vehicle to an independent mechanic, who advised that the failure could be related to the rear axle hub bolt. The contact's husband drove the vehicle to a dealer to be repaired under NHTSA Campaign Number: 23V896000 (Power Train). The dealer confirmed that the rear axle hub bolt had fractured; however, the part to complete the recall repair was not available. The vehicle was not repaired. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was informed of the failure. The failure mileage was approximately 25,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11707605December 29, 2025
POWER TRAIN
Front differential diagnosed as failed, needing a full rebuild or replacement by local Ford Dealer. The vehicle now has 70,700 miles, the noise first thought to be a wheel bearing at 60K+ miles. Safety concerns are a possibility of a failure at highway speeds,. I have reviewed similar complaints with fewer miles on similar 2022 Ford f-150 trucks having these component failures.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11707547December 29, 2025
FORWARD COLLISION AVOIDANCE: ADAPTIVE CRUISE CONTROL
The contact owns a 2025 Ford F-150. The contact stated that while idle at a red light, while using the brake hold feature, the vehicle's brakes suddenly released, causing them to rear-end the vehicle in front. No air bags deployed. There were no injuries or medical attention needed. A police report was filed. The vehicle was taken to the dealer; however, the vehicle was not diagnosed. The vehicle's cruise control was set to 15 mph when entering and passing through a school zone, and once out of the school zone, the speed limit increased to 30 MPH at which time the vehicle accelerated to the higher speed with the cruise control still set to 15 MPH and activated. The manufacturer was informed of the failure. The failure mileage was approximately 3,000.
Crash:
Yes
Fire:
No
Injuries:
0
Deaths:
0
#11707462December 29, 2025
ELECTRICAL SYSTEM, FORWARD COLLISION AVOIDANCE: WARNINGS, LANE DEPARTURE: WARNING
I was driving and all of the dash lights came on simultaneously and I lost power braking ability while on the interstate. I was able to pull over and the truck shut off. I had to call a tow truck because it would not start back up. The AAA servicer reprogrammed the battery which turned all of the warning lights off except for the "push brake to start" warning and the truck will still not start because of this. The tech with AAA advised there is a recall related to this issue but my VIN search returns no results.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11707436December 29, 2025
UNKNOWN OR OTHER
I recieved the recall. It states parts are available. I called my dealer in Cortex, CO and was told they could not get the part to perform the repair.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11707213December 27, 2025
STEERING
Vehicle: 2012 Ford F-150 Incident Description: While driving straight under normal conditions, the “Service Power Steering Service Now” warning message suddenly appeared on the dashboard, accompanied by an audible warning alarm. Immediately after this warning, the steering wheel became extremely stiff and difficult to turn, with a sudden loss of power steering assistance. This failure occurred At the time, traffic was heavy, making it very difficult and dangerous to safely maneuver the vehicle and pull over. The sudden loss of steering assistance created a serious safety risk for myself and other drivers and could have resulted in a crash. I was eventually able to pull over to a safe location, This appears to be a sudden steering system failure and represents a significant safety concern
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11707254December 27, 2025
POWER TRAIN
Sudden downshifts of my transmission. Traveling on the highway at 65mph and all of a sudden the transmission shifted down to a lower gear, causing my wheels to lock and vehicle to shudder. Then after stopping on the side of the road, it took the vehicle several minutes to re-engage. I was able to limp the vehicle to the dealer where they replaced the Molded Lead Frame and Transmission Control Module. Very unexpected repair cost.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11707053December 26, 2025
POWER TRAIN
On December 24, 2025 at around 2:00 pm While driving my 2018 Ford F-150 from Hidalgo, Texas to Ciudad Victoria, Tamaulipas, Mexico, a distance of approximately 220 miles, my vehicle experienced a sudden and dangerous transmission failure that placed myself, my family, and other motorists at significant risk. For the first approximately 130 miles, the vehicle operated normally with no warning signs. While traveling on a two-lane highway, I attempted to pass an 18-wheeler. During the passing maneuver, the transmission began harsh and jerky shifting, slipping, and delayed gear engagement, followed by an immediate and significant loss of power and acceleration. As soon as I completed the pass, the vehicle failed to accelerate properly and lost power, leaving me exposed in a dangerous situation with limited ability to increase speed. Because the road only had one lane in each direction, this created a high-risk scenario involving oncoming traffic. Within seconds, the 18-wheeler I had just passed rapidly approached from behind, forcing the driver to brake suddenly to avoid a collision. This put the truck driver, surrounding motorists, and my family at serious risk of a major accident. The failure occurred without warning and during a critical maneuver where reliable acceleration was necessary. The sudden loss of power made it impossible to respond safely, demonstrating a serious safety concern. At the time of the incident, the vehicle had approximately 72,000 miles, is well maintained, garage-kept, and has never been used for towing, heavy-duty work, or commercial purposes. Given the mileage and normal use, this type of transmission failure is unexpected and unsafe.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11707110December 26, 2025
POWER TRAIN
The transmission was slipping in 2nd and 10th gear. This was confirmed by the dealer. A full transmission had to be replaced at 66,000 miles. The vehicle had an excellent maintenance record and well kept. Ford did pay half of the cost but I still ended up spending $6k out of pocket and my vehicle was in the shop for 27 days.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11707079December 26, 2025
ENGINE
There is a recall for the low pressure fuel pump that has been active since July of 2025 and there is still not resolution. This truck is not usable due to the issue.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Ford F-150