Volvo S60 Complaints

1,272 consumer complaints on file.

#10143045November 17, 2005
POWER TRAIN:DRIVELINE:DRIVESHAFT, ENGINE AND ENGINE COOLING:EXHAUST SYSTEM
DT: THE CONTACT STATED WHILE VEHICLE WAS HAVING ROUTINE MAINTENANCE PERFORMED THE DEALER FOUND A BEND IN THE EXHAUST SYSTEM. THIS BEND COULD CAUSE THE DRIVESHAFT TO CRACK. THE DEALER SAID THE CONTACT MUST HAVE HIT SOMETHING TO CAUSE THE DAMAGE. BUT THERE WAS NO EVIDENCE THAT THE HE HIT ANYTHING. THE VEHICLE IS AT THE DEALER WAITING FOR AN INVESTIGATION. AT THIS POINT THE VEHICLE HAS NOT BEEN REPAIRED. *AK
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10142741November 15, 2005
FUEL SYSTEM, GASOLINE:CARBURETOR SYSTEM
2001 VOLVO S60 T5 W/MANUAL TRANSMISSION STALLED ABRUPTLY WITH A "REDUCED POWER" MESSAGE ON THE DASHBOARD COMPUTER DISPLAY WHILE ACCELERATING ON A HIGHWAY ONRAMP. THIS WAS A VERY DANGEROUS SITUATION, AS ANOTHER VEHICLE WAS BEHIND ME AND CAME CLOSE TO COLLIDING WITH MY VEHICLE DUE TO IMMEDIATE DECELERATION W/NO WARNING/BRAKE LIGHTS UNTIL I WAS ABLE TO REACT TO THE UNEXPECTED SITUATION. AFTER PULLING OVER, STOPPING THE CAR FOR A FEW MINUTES AND RESTARTING, I WAS ABLE TO CONTINUE DRIVING IT, BUT IT SEEMED TO RUN ROUGH AND "STUTTER" A BIT FOR THE REST OF THE TRIP. DROVE TO LOCAL VOLVO DEALERSHIP FIRST THING NEXT MORNING AND RESULTING DIAGNOSIS & REPAIR WAS "THROTTLE UNIT INTERNAL FAULT" AND REPLACEMENT OF THE ELECTRONIC THROTTLE MODULE (ETM). ENGINE FAULT CODES WERE: ECM 915D, 916D, 904C, 928A & 903F. REPAIRS TOTALED $1,012.03. *JB
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10142208November 8, 2005
VEHICLE SPEED CONTROL:ACCELERATOR PEDAL, STRUCTURE:BODY, SERVICE BRAKES, HYDRAULIC:PEDALS AND LINKAGES
DT: THE CONTACT STATED THERE WAS NOT ENOUGH ROOM BETWEEN THE FLOOR AND BOTTOM OF THE DASHBOARD. THERE WAS NO WAY THAT THE CONTACT'S HUSBAND COULD GET FOOT TO THE BRAKE. THIS ALMOST CAUSED SEVERAL ACCIDENTS. THERE IS ONLY 11 INCHES BETWEEN THE FLOOR AND THE DASHBOARD . *AK UPDATED 1/19/2006 - THERE IS LITTLE CLEARANCE BETWEEN THE PEDALS AND THE UNDERSIDE OF THE DASH WHICH RESULTED IN THE CONSUMER SHOE HITTING THE UNDERSIDE OF THE DASH LIMITING HIS ABILITY TO MOVE HIS FOOT BETWEEN THE BRAKE PEDAL AND ACCELERATOR PEDAL. *NM
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10141834November 5, 2005
ENGINE AND ENGINE COOLING
I COMMUTE APPROXIMATELY 30 MILES TO WORK. DURING MY COMMUTE ON NOV. 2, 2005 THERE WAS NOTHING OUT OF THE ORDINARY. ALL GAUGES READING WITHIN NORMAL LIMITS. I PARKED MY CAR. WENT INSIDE MY PLACE OF WORK. WITHIN 7 (SEVEN) MINUTES I WAS NOTIFIED BY A COWORKER THAT MY CAR WAS ON FIRE. THE RESULTING ENGINE FIRE TOTALED MY 2001 S60 T5 VOLVO. THERE WAS NOTHING LEFT OF THE ENGINE EXCEPT THE ENGINE BLOCK SITTING UPON THE TRANSMISSION. *JB
Crash:
No
Fire:
Yes
Injuries:
0
Deaths:
0
#10141597November 2, 2005
VEHICLE SPEED CONTROL
I WAS ON A LONG TRIP BACK HOME ON 11/29/05 WHEN I NOTICED MY 2001 VOLVO STARTED SURGING AFTER ABOUT 20 MINUTES OF THIS IT SHOWED ME A CHECK ENGINE LIGHT AND A MESSAGE APPEARED SAYING " PERFORMANCE REDUCED ". THE CAR WAS BASICALLY SHUTTING DOWN. I WAS DOING 75 MPH AT THE TIME AND HAD TO PULL OVER TO THE SHOULDER FROM THE LEFT LANE 4 LANES OVER TO THE RIGHT. THIS WAS A LITTLE SCARY DOING 75 MPH. I SAT ON THE SHOULDER FOR ABOUT 2 MINUTES AND TRIED RESTARTING THE CAR. I SEEMED FINE SO I CONTINUED ON. THE SAME THING HAPPENED 2 MORE TIMES ON THE TRIP HOME. THE FOLLOWING MONDAY 11/1/05 I BROUGHT THE CAR TO A RAMSEY VOLVO TO HAVE IT LOOKED AT. THEY TOLD ME THE ETM NEEDED TO BE REPLACED. I HAD THEM REPLACE IT. THE PROBLEM I HAVE IS THAT IT SEEMS AS IF THIS IS VERY COMMON AMONG VOLVO'S WITH THE ETM AND IT IS QUITE DANGEROUS WHEN THEY FAIL. IF AS MANY FAIL AS I SEE ON THE INTERNET I FEEL VOLVO SHOULD RECALL THE ETM AND FIX IT.*JB
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10140691October 25, 2005
POWER TRAIN:AUTOMATIC TRANSMISSION
STOPPED TO DROP OFF PASSENGER, WHEN ATTEMPTED TO PULL AWAY, TRANSMISSION FAILED TO ENGAGE. TURNED VEHICLE OFF TO CHECK IT. ON RESTART ENGAGED FINE. APPROX 1/2 MILE DOWN THE ROAD, TRANSMISSION FAILED AGAIN WHILE VEHICLE WAS IN MOTION. COASTED TO THE SIDE OF THE ROAD, TURNED VEHICLE OFF FOR A FEW MINUTES, ON RESTART TRANSMISSION ONCE AGAIN ENGAGED FOR ME TO GO A FEW HUNDRED FEET TO SAFETY. VEHICLE WAS TOWED TO DEALERSHIP WHICH DIAGNOSED THE TRANSMISSION WITH 'INTERNAL FAULTS' WHICH WOULD REQUIRE A COMPLETE REPLACEMENT OF THE TRANSMISSION. THE VEHICLE IN QUESTION HAS NEVER HAD ANY WARNINGS THAT THE TRANSMISSION WAS FAILING, NOR HAD IT EVER HESITATED TO ENGAGE PRIOR TO IT'S COMPLETE FAILURE. THE VEHICLE IS 4 1/2 YEARS OLD WITH ONLY 32K MILES. *NM
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10140698October 25, 2005
VEHICLE SPEED CONTROL, ENGINE AND ENGINE COOLING:ENGINE
CAR WOULD SUDDENLY LOSE POWER, CAUSING UNSAFE SITUATIONS IN TRAFFIC. WARNING LIGHT WOULD COME ON ALONG WITH CHECK ENGINE LIGHT AND MESSAGE SAYING "REDUCED PERFORMANCE". FAILURE WAS INTERMITTENT AT FIRST AND INSTRUMENT LIGHTS WOULD GO BACK TO NORMAL. *NM
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10140641October 24, 2005
VEHICLE SPEED CONTROL
2002 VOLVO 75,000 MI HAS A DEFECTIVE ELECTRONIC THROTTLE WHICH CAUSES CAR TO SUDDENLY SHUT OFF WHILE IN DRIVE. I UNDERSTAND THIS TO BE A COMMON PROBLEM AND THERE IS A CLASS ACTION LAWSUIT FILED IN CALIFORNIA FOR MODEL YEARS 1999-2001. COST TO REPLACE IS $1200.00. *NM
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10140526October 23, 2005
STEERING:HYDRAULIC POWER ASSIST SYSTEM
I HAVE EXPERIENCED TWO INSTANCES OF POWER AND STEERING LOSS WHILE DRIVING MY VOLVO S80 DOWN THE ROAD. THE FIRST INSTANCE OCCURRED AS I WAS SLOWING DOWN TO TURN RIGHT, I LOST ALL POWER AND STEERING. FORTUNATELY DURING THIS INCIDENT I HAD TURNED THE CAR JUST ENOUGH PRIOR TO LOSING STEERING TO MISS A POLE. IF THERE HAD BEEN ANOTHER CAR COMING TOWARDS ME, IT COULD HAVE RESULTED IN A SERIOUS ACCIDENT. THE SECOND INCIDENT OCCURRED A COUPLE OF WEEKS AFTER THE FIRST INCIDENT AND IT HAPPENED AS I WAS GOING DOWN THE EXPRESSWAY AND BEGAN SLOWING TO STOP AT A STOP LIGHT. THE CAR LOST POWER/ STEERING AGAIN AND LUCKILY THIS TIME THERE WAS NO A CAR IN FRONT OF ME OR I WOULD HAVE HIT IT FROM BEHIND. BOTH TIMES THIS HAPPENED, I WAS ABLE TO ROLL THE CAR TO A STOP AND RESTART IT WITH NO PROBLEMS. I REPORTED THIS PROBLEM TO THE DEALER BUT THEY WERE NOT SURE WHAT WAS CAUSING THIS. *NM
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10140364October 20, 2005
VEHICLE SPEED CONTROL
I OWN A 2001 VOLVO S60 WITH A LITTLE OVER 18,000 MILES ON THE VEHICLE. ON 10-19-2005, I WAS STOPPED AT AN INTERSECTION WAITING FOR THE LEFT LANE TURN SIGNAL. WHEN THE SIGNAL TURNED GREEN, I PROCEEDED INTO THE INTERSECTION AND NOTICED THAT MY CAR STARTED TO LOSE POWER EVEN THOUGH MY FOOT WAS ON THE ACCELERATOR THROTTLE. I APPLIED MORE PRESSURE TO THE ACCELERATOR THROTTLE, BUT THE VEHICLE CONTINUED TO LOSE SPEED, THEN ALL OF A SUDDEN THE VEHICLE LURCHED FORWARD AS IF TO KICK IN AND THE ACCELERATION RESUMED. IT WAS ALARMING, BECAUSE IF I HAD BEEN ON A FREEWAY OR HAD BEEN IN A SITUATION WHEREBY I HAD TO PASS A SLOW DRIVER ON A TWO LANE HIGHWAY, I COULD HAVE BEEN IN SOME SERIOUS TROUBLE. AGAIN, MY CAR HAS VERY LOW MILEAGE FOR A 2001 VEHICLE. I WOULD APPRECIATE BEING INCLUDED IN ANY INVESTIGATION THAT MAY UNCOVER A POSSIBLE DEFECT IN THE VEHICLE REGARDING THIS MATTER. THANK YOU FOR YOUR TIME AND CONSIDERATION. SINCERELY, TERRY W. MORRIS. *NM
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10140237October 19, 2005
VEHICLE SPEED CONTROL
DT: 2002 VOLVO S60. THE CONTACT STATED THE ENGINE TURNED OFF WHILE DRIVING. THE VEHICLE WAS GOING APPROXIMATELY 25 MPH WHEN THIS OCCURRED. HE WAS THE ORIGINAL OWNER OF THIS VEHICLE. THE VEHICLE WAS TOWED TO THE DEALERSHIP, AND THEY COULD NOT FIND THE CAUSE OF THE PROBLEM. THIS HAPPENED IN JANUARY 2005. THERE HAS NOT BEEN A RECURRENCE. *AK
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10140271October 19, 2005
ELECTRICAL SYSTEM
MY 2002 VOLVO S60 STALLED ABOUT 3 TIMES IN THE PERIOD OF A FEW MONTHS DURING THE SPRING OF 2005. IT OCCURRED ONLY WHILE I WAS DRIVING IN STOP AND GO TRAFFIC. I WAS ABLE TO RESTART THE CAR. I TOOK IT INTO THE VOLVO DEALERSHIP. THEY RAN ALL KINDS OF TESTS, BUT COULD FIND NOTHING WRONG. THEY REPLACED THE MASS AIRFLOW SENSOR ANYWAY ON MAY 10, 2005 AND THE PROBLEM SEEMED TO GO AWAY - UNTIL OCT 6. IT STALLED AGAIN WHILE I WAS AT A STOP LIGHT. ON OCTOBER 19, SIX DRIVING DAYS LATER (I TRAVEL OUT OF TOWN A LOT FOR MY JOB), IT STALLED AGAIN IN STOP AND GO TRAFFIC ON THE FREEWAY. I KNOW THAT YOU HAVE HAD SIMILAR COMPLAINTS ABOUT THIS, BUT NOT FOR A 2002 MODEL. I THOUGHT THAT IT WAS IMPORTANT TO TELL YOU ABOUT MY PROBLEM AS WELL. *JB
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10139777October 15, 2005
VEHICLE SPEED CONTROL
VOLVO S60 2001 THE VEHICLE EXHIBITS A SUDDEN LOSS OF SPEED AND ENGINE POWER. THIS HAPPENS WHILE DRIVING IN HIGHWAY TRAFFIC WITHOUT WARNING. I HAVE HAD THE VEHICLE TO THE VOLVO DEALER TWICE AN THEY CAN'T FIND ANYTHING WRONG. I SUSPECT THAT THE ELECTRONIC THROTTLE CONTROL IS THE PROBLEM. *NM
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10139501October 12, 2005
VEHICLE SPEED CONTROL
ELECTRONIC THROTTLE MODULE FAILURE, LOST STEERING AND POWER ON INTERSTATE AT 80 MILES PER HOUR. REPLACED CONTROL, REPLACED ALTERNATOR, FINALLY REPLACED EMT. PART OUT OF WARRANTY I PUT MYSELF AT RISK OF DEATH BECAUSE OF THIS PART FAILURE. PART NOT COVERED BY WARRANTY 80,000 MILES ON CAR. *NM
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10138985October 7, 2005
TIRES:SIDEWALL
I EXPERIENCED A PROBLEM WITH THREE OUT OF A SET OF FOUR GOODYEAR AMERICAN EAGLE TIRES PURCHASED AT WALMART IN NORTH CAROLINA ON 09/25/2003. THESE WERE 60,000 MILE RATED (TREAD WEAR RATING 420) RADIAL TIRES SIZE: P205/55R16. THESE WERE FOR MY VOLVO S-60...THE MANUFACTURER'S RECOMMENDED SIZE. I KEPT THE RECOMMENDED PSI @ 38 TIRE PRESSURE. I HAD THEM ROTATED AND REBALANCED SEVERAL TIMES, USUALLY AT ABOUT 5,000/6,000 MILE INTERVALS. DURING MY MOST RECENT SERVICE FOR ROTATION AND REBALANCING ON AUGUST 31, THE WALMART STORE IN ROANOKE, VA BROUGHT THIS DEFECT TO MY ATTENTION. THREE OF THE TIRES HAD DEVELOPED SEVERE AND POTENTIALLY DANGEROUS CRACKS ON THE INSIDE SIDEWALL BETWEEN THE TREAD AND THE RIM CIRCLING THE INSIDE OF THE SIDEWALL AND APPEARED TO BE A "BLOW-OUT" POTENTIAL HAZARD. THE MANUFACTURER'S PRODUCTION CODE WAS: DOT PJT24AHR2403. WALMART ADJUSTED AND REPLACED THIS SET WITH THE SAME TIRE THAT THEY HAD IN STOCK. I REPORTED THE PROBLEM TO GOODYEAR AND WAS GIVEN A CLAIM # 789726. I PHONED THEM TO ASK WHAT COULD HAVE BEEN DONE TO AVOID THIS PROBLEMS OR TO AVOID THIS SAME PROBLEM FOR OCCURRING ON THE CURRENT SET THAT WALMART HAD PUT ON. THEY TOLD ME THAT NOTHING COULD HAVE BEEN DONE OR COULD BE GUARANTEED ON THE NEWER SET. I THINK FURTHER INVESTIGATION SHOULD BE DONE BY NHTSA AS THIS COULD BE A VERY SERIOUS PROBLEM FOR OTHER DRIVERS CAUGHT UNAWARE TO THIS PROBLEM. PLEASE ADVISE. *NM
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10138942October 6, 2005
FUEL SYSTEM, GASOLINE
FIRST EVENT--NORMAL VEHICLE OPERATION- 33000 MILES 48 MONTHS OLD. STALLED TURNING LEFT THROUGH BUSY INTERSECTION AT RUSH HOUR--LOSS POWER STEERING CAPABILITY ALMOST RAN OFF ROAD TOWARD LIGHT POST--NO ACCIDENT OCCURRED. (MAY, 2005) NO REPAIRS. SECOND EVENT--NORMAL VEHICLE OPERATION (35,250)-STALLED GOING THROUGH INTERSECTION OCT. 4 2005. NO ACCIDENT.--ELECTRONIC THROTTLE MODULATOR CLEANED --{GIVEN OPTION OF CLEANING $220 (WITH NO GUARANTEE) OR REPLACING FOR $970 (STILL WITH NO GUARANTEE)} *NM
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10138068September 28, 2005
ELECTRICAL SYSTEM
THE ELECTRONIC THROTTLE MODULATOR (ETM) IN MY 01' VOLVO S60, LIKE MANY OTHERS, HAS BECOME FAULTY. WHILE SITTING IDLE OR IN DRIVE, THE RPM'S WILL FLUCTUATE ERRATICALLY CAUSING WHAT SEEMS TO BE BURSTS IN ACCELERATION AND NEAR STALLS. CONSEQUENCES OF THIS DEFECT INCLUDE IMPROMPTU BREAKING TO CORRECT RPM FLUCTUATIONS. THE CAR WAS DIAGNOSED A MONTH AGO BY A CERTIFIED VOLVO DEALER WITH A FAILING ETM. MY WIFE AND I ARE SAVING MONEY SO THAT THE REPAIR CAN BE DONE. HOPEFULLY VOLVO RECALLS THE PART SO THAT WE CAN HAVE OURS REPLACED ASAP BEFORE MORE SEVERE COMPLICATIONS OCCUR. *NM
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10137112September 20, 2005
FUEL SYSTEM, GASOLINE:FUEL INJECTION SYSTEM
CAR WAS SURGING WHILE DRIVING. ELECTRONIC THROTTLE MODULE (ETM) WAS CLEANED AT COST OF $88.00. PROBLEM CONTINUED UNTIL CAR LOST POWER AT 65 MPH ON THE FREEWAY. I WAS UNABLE TO ACCELERATE OR DECELERATE. HAD TO SHIFT FROM DRIVE TO NEUTRAL IN ORDER TO SLOW DOWN UNTIL I WAS ABLE TO SAFELY PULL OFF THE ROAD. PROBLEM DID NOT REOCCUR AFTER RESTART OF ENGINE FOR ABOUT ONE WEEK, WHEN IT HAPPENED REPEATEDLY THEREAFTER. FINALLY REPLACE ETM AT COST OF $1,100.00. *NM
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10131082September 19, 2005
VEHICLE SPEED CONTROL
DT: 2001 VOLVO S60. THE CALLER STATED THE AIR FLOW METER WAS REPLACED AT THE COST $290.00. THIS STARTED ABOUT A YEAR AGO, ANDS HAPPENED 5-6 TIMES . THE CAR WILL LOSE POWER AND STALL. THE CHECK ENGINE LIGHT CAME ON. TOOK VEHICLE TO THE DEALER, AND THEY RAN A DIAGNOSTIC TEST, REPLACED AIR MASS METER. THE WORK WAS PERFORMED ON APRIL 5 2005, BY WC MOTOR COMP INC. THE CALLER HEARD ABOUT THE INVESTIGATION, AND I KNEW THAT THIS WAS WHAT WAS WRONG WITH VEHICLE. DID NOT CONTACT THE MANUFACTURER, BUT JUST CALLED NHTSA. *AK *NM
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10136312September 13, 2005
VEHICLE SPEED CONTROL
HAD PROBLEMS WITH CAR STALLING AT SLOW SPEEDS, BUT ALL OF A SUDDEN WHILE DRIVING ON A MAJOR HIGHWAY AT 65 MPH AND CAR LOST POWER. WE WERE ABLE TO GLIDE TO SHOULDER WHERE CAR STALLED. IT RESTARTED IMMEDIATELY, BUT ABOUT EVERY 5 MI. THE CAR WOULD STALL AGAIN. THE SERVICE DEPT. AT STAMFORD VOLVO TOLD ME I HAD BAD GAS AND THEY REPLACE A SENOR IN THE FUEL SYSTEM. AS SOON AS I LEFT THE DEALERSHIP AND GOT ON THE HIGHWAY THE CAR STALLED AGAIN. I BROUGHT IT BACK TO THE DEALER. THEY SERVICED THE CAR AGAIN AND TOLD ME THE WATER IN THE GAS RUSTED SOME SCREEN IN THE FUEL SYSTEM. THEY REPLACED IT AND THUS FAR THE CAR HASN'T' STALLED BUT THERE IS STILL SOME HESITATION WHILE DRIVING AT HIGH SPEEDS. *NM
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Volvo S60