Volvo S60 Complaints

1,272 consumer complaints on file.

#10132542August 11, 2005
VEHICLE SPEED CONTROL
BETWEEN 12/2004-6/2005 MY 2003 VOLVO S60 LOST POWER/ POWER DECREASES AT VARYING SPEEDS. THE MOST SIGNIFICANT WAS ON THE HWY GOING 65 MPH. I HAD JUST ACCELERATED TO GET ONTO THE HWY IN FRONT OF A SEMI TRUCK. MY CAR REACHED 65-70 MPH AND BEGAN TO DROP SPEEDS - 65 TO 55 TO 50 TO 40 WITH IN SECONDS. THE SEMI ALMOST RAN OVER ME BECAUSE THE SPEEDS DROPPED SO FAST. I CAUSED 2 OTHER CARS ON THE HWY TO GO ONTO THE SIDE RAMP OTHERWISE IT WOULD HAVE BEEN A HORRIBLE CRASH WITH THE SEMI. I HAVE TAKEN THE VEHICLE TO THE DEALER 3 TIMES COMPLAINING OF THE SAME PROBLEM. THE FINAL TIME STATING NOT TO GIVE THE CAR BACK UNTIL IT WAS FIXED. THE DEALER SAID THEY DOWNLOADED NEW SOFTWARE TO THE CAR? IF IT HAPPENS AGAIN THEY CAN INSTALL A BLACK BOX TO RECORD WHAT IS GOING ON. WHAT IF THE NEXT TIME THE SEMI DOES CRASH INTO ME? THE FIRST TIME THEY HAD THE CAR THE LABELED AS PEDAL POSITION SENSOR INSTALL/REPLACE? THE SECOND TIME THE INVOICE READS PRESSURE SENSOR INTAKE AIR REPLACED? ULTIMATELY, I SAW THE REPORT IN THE NEWS AND RECOGNIZED THE ISSUE TO EXACTLY WHAT HAPPENS TO MY CAR. I NOTICED THAT YOU DID NOT INCLUDE 2003 S60'S IN YOUR REPORT. I KNOW THESE SHOULD BE LOOKED AT AS WELL. I LOVE MY VOLVO I JUST DON'T FEEL VERY SAFE IN IT. PLEASE CONTACT ME FOR ANY QUESTIONS. *NM
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10132212August 10, 2005
STRUCTURE
DASHBOARD GIVES OFF EXCESSIVE GLARE IN WINDSHIELD ESPECIALLY WHERE THE PART ABOVE THE STEERING COLUMN JOINS WITH THE REST OF THE DASHBOARD. *NM
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10132035August 9, 2005
FUEL SYSTEM, GASOLINE:FUEL INJECTION SYSTEM:INJECTORS, FUEL SYSTEM, GASOLINE:DELIVERY
I WAS HAVING TROUBLE WITH THE CAR STALLING AND UPON TAKING MY 2002 VOLVO S 60 TO THE DEALER (BOZZANNI VOLVO IN COVINA, CA. THEY HANDLED THAT PROBLEM BY CLEANING THE THROTTLE BODY ASSEMBLY FOR A COST OF ABOUT $500.00. ABOUT TWO MONTHS LATER THE SAME PROBLEM OCCURRED AND THIS TIME THEY REPLACED THE ENTIRE THROTTLE BODY ASSEMBLY FOR A COST OF ABOUT $800.00. WHEN I QUESTIONED THE DEALER ABOUT THE PROBLEM, HE TOLD ME THAT IT WAS NO LONGER UNDER WARRANTY AND THAT THE REPAIR CHARGE AND REPAIR ITSELF WAS NECESSARY AND THAT THERE WAS NOTHING ELSE THEY COULD DO. THE CAR HAD ABOUT 55,000 MILES ON THE ODOMETER AND I FELT THAT THEY DID NOT DO THE JOB PROPERLY IN THE FIRST PLACE AND THAT THE REPAIR WORK SHOULD HAVE BEEN COMPLETED UNDER WARRANTY. I HAVE BEEN KEEPING UP WITH THE CURRENT INVESTIGATIONS ON VOLVO AND THEIR THROTTLE BODY ASSEMBLY FAILURES. WHILE MY CAR IS AN EARLY 2002 MILD PRESSURE TURBO, I FEEL THAT CURRENT INVESTIGATION SHOULD ENCOMPASS OTHER YEARS BECAUSE THE PROBLEMS IS QUITE SIMILAR. THIS OCCURRED EARLY ON IN 2005 AND I HAVE THE OLD PARTS AND THE DEALER PAPERWORK ON THE REPAIR. *JB
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10132070August 9, 2005
ELECTRICAL SYSTEM
CAR STALLS ON DECELERATION. *JB
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10132056August 9, 2005
STRUCTURE:BODY:DOOR
1. THE FRONT, RIGHT (PASSENGER) DOOR OF THE CAR IS COMING LOOSE, 2. REPORTED IT TO DEALERSHIP AND MANUFACTURER, AND 3. DEALER HAS SCHEDULED APPOINTMENT TO LOOK AT PROBLEM. *JB
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10131977August 8, 2005
VEHICLE SPEED CONTROL, TIRES
DT: VEHICLE STALLED/DIED/OST POWER WHILE DRIVING 30-35 MPH DUE TO THROTTLE BODY FAILURE. *AK
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10131782August 6, 2005
ELECTRICAL SYSTEM
WHILE DRIVING AT APPROX 40 MPH, I HEARD A POPPING NOISE AND A MESSAGE CAME ON IN THE DASH STATING "REDUCED EMISSION SERVICE". I WAS ABLE TO DRIVE AT A MAXIMUM OF 10 MPH FOR 5 MILES TO MY NEAREST VOLVO DEALERSHIP. MY MILEAGE WAS JUST ABOUT 69,000 MILES. THE TECHNICIAN DIAGNOSED IT AS AN ELECTRONIC THROTTLE MODULE FAILURE AND REPLACED THE ETM. THE CAR HANDLED PROPERLY AFTER THE REPAIR, WHICH WAS COVERED UNDER THE 7 YEAR/70,000 MILE EXTENDED EMISSIONS WARRANTY. THE OLD PART WAS RETURNED TO VOLVO CARS NORTH AMERICA. *JB
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10131717August 5, 2005
ELECTRICAL SYSTEM
RECENTLY PURCHASED 2002 VOLVO S60 FOR MY DAUGHTER, CERTIFIED USED. SHE WAS DRIVING AND THE CAR JUST STOPPED RUNNING, IT DIED IN THE MIDDLE OF THE ROAD. JUST READ YOUR ARTICLE ABOUT 1999-2001 AND THOUGHT YOU SHOULD CHECK INTO ALL YEARS. VOLVO SAID IT IS FIXED, WE PICK IT UP TOMORROW, HOWEVER I AM VERY CONCERNED THAT THIS WILL HAPPEN TO HER AGAIN. PURCHASED A VOLVO FOR SAFETY, NOW I AM VERY WORRIED. *NM
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10131239August 3, 2005
ELECTRICAL SYSTEM
MY 2001 S 60 VOLVO SEDAN LOSES POWER DURING ACCELERATION. THE RPMS RACE BUT THE VEHICLE FEELS LIKE IT'S GOING TO STALL. I HAVE BROUGHT THIS VEHICLE BACK TO THE DEALERSHIP 5 TIMES FOR THE SAME COMPLAINT. ON THE FIFTH TIME, THEY REPLACED THE ELECTRONIC THROTTLE MODULE. THAT WAS ON AUGUST 1, 2005. SINCE THE PROBLEM WAS INTERMITTENT, I CAN'T TELL YET IF THE PROBLEM HAS BEEN FIXED. *JB
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10131416August 3, 2005
SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP, ENGINE AND ENGINE COOLING:ENGINE
DT: CONSUMER STATED 2001 VOLVO S 60 WAS HAVING A PROBLEM WITH THE UNIT THAT REGULATED THE AIR FLOW INTO THE BRAKES AND ENGINE. THE CAR WAS MAKING A HISSING SOUND, LIKE AIR BEING LET INTO THE CABIN. THIS WAS HAPPENING A LOT, ESPECIALLY IN THE HEAT. THE BRAKES HAD TO BE DEPRESSED TO GET THE CAR TO STOP. CONSUMER HAD THE CAR FIXED LAST WEEK AT THE DEALERSHIP; THE MECHANIC INFORMED CONSUMER THAT THE AIR PUMP TO THE BRAKES HAD TO BE REPLACED. THIS VEHICLE WAS NOT STALLING,OR LOSING POWER, NOR WERE THERE NEAR MISSES. CONSUME R WAS JUST RESPONDING TO THIS BECAUSE OF WHAT SHE SAW ON THE NEWS. THE WARRANTY EXPIRED. REPAIRS WERE DONE AT CONSUMER'S EXPENSE. *AK
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10130946August 2, 2005
FUEL SYSTEM, GASOLINE
I OWNED A 1991 VOLVO S60 SEDAN AND I UNDERSTAND YOU ARE INVESTIGATING THIS CAR. FROM TIME TO TIME AS I DROVE IT, IT WOULD UNEXPECTEDLY LOOSE SPEED AND POWER FOR A FEW SECONDS AND THEN RESUME. IT NEVER FULLY STALLED OUT. I HAD MENTIONED THIS AT A SERVICE TIME FOR THE CAR BUT NOTHING WRONG WAS UNCOVERED. RECENTLY MY DAUGHTER WAS DRIVING THE CAR ON INTERSTATE 5 SOUTH OF LA WHEN THE CAR ENGINE CEASED FUNCTIONING WHILE SHE WAS DRIVING IN THE HOV LANE. FORTUNATELY THE DRIVER WAS ABLE TO COAST TO THE SHOULDER THROUGH TRAFFIC WITHOUT GETTING HIT. THE EASILY COULD HAVE BEEN HIT AND SHE COULD HAVE DIED AND WE NEVER WOULD HAVE KNOWN IT WAS A VEHICLE FAILURE. THE CAR WAS TOWED TO A DEALERSHIP WHERE I WAS TOLD THEY EVENTUALLY DIAGNOSED A "FAILED FUEL PUMP". I HAVE NO VALIDATION OF THIS. I DID NOT WANT TO DRIVE THIS CAR AGAIN AND IT WAS LEASE-END SO I TRADED THE CAR IN THAT VERY DAY FOR A NEW CAR. *NM
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10130959August 2, 2005
ENGINE AND ENGINE COOLING:ENGINE
I WAS TRAVELING ON I-65 FROM LOUISVILLE, KY TO CHICAGO, ILLINOIS AND ENCOUNTERED SUDDEN LOSS OF POWER AFTER DRIVING 205 MILES AT STEADY FREEWAY SPEEDS. THE CAR (VOLVO S60, 2003 MODEL) SUDDENLY LOST POWER AND SPEED FROM 70 MPH. I PULLED OVER TO THE SHOULDER AT A SPEED OF 40 MPH AND TURNED OFF THE ENGINE. I WAITED 10 MINUTES AND THEN STARTED THE ENGINE AND REENTERED THE HIGHWAY AND WAS ABLE TO ACCELERATE TO 70 MPH. AFTER ABOUT 3-5 MINUTES THE SAME LOSS OF POWER OCCURRED AND THE ENGINE TURNED OFF AND THE OIL LIGHT REMAINED ON. I ONCE AGAIN PULLED OFF TO THE SHOULDER, TURNED OFF THE VEHICLE AND CALLED FOR TOW ASSISTANCE. THE CAR WAS TOWED TO A VOLVO DEALER IN , INDIANA (NAPLETON AUTO) AND LEFT FOR 24 HRS. DEALER REPORTED NO DIAGNOSTIC EVIDENCE OF PROBLEM AND WAS UNABLE TO REPLICATE THE PROBLEM ON NON-HIGHWAY DRIVE TESTS. I SUBSEQUENTLY DROVE THE CAR ON A RETURN TRIP TO LOUISVILLE, KY ( 350 MI.) BUT WITH SEVERAL STOPS ALONG THE WAY TO REST THE ENGINE. THIS LOSS OF POWER CREATED A VERY SERIOUS SAFETY RISK. WHEN THE LOSS OF POWER OCCURRED I HAD A FAST MOVING TRUCK BEHIND ME AND AVOIDED AN ACCIDENT BY QUICKLY MOVING TO THE SHOULDER. I WAS VERY DISTRESSED BY THIS EXPERIENCE. *NM
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10130971August 2, 2005
ELECTRICAL SYSTEM:12V/24V/48V BATTERY, FUEL SYSTEM, OTHER
DT: CONTACT STATDS 2003 VOLVO CUT OFF WHILEGOING 60 MPH. CAR COMPLETELY LOST POWER IN THE MIDDLE LANE. IT WAS TOWED ,AND THEY KEPT IT FOR 3 DAYS. CONSUMER PICKED IT UP ON 7-16-05. THE DEALER REPLACED THE BATTERY. NINE DAYS LATER ON 7-24-05 THE CAR COMPLETELY QUIT AGAIN. THEY CALLED HECONSUME R AT HOME AND TOLD HER THEY THOUGHT IT WAS A FUEL PRESSURE ISSUE. HER CAR HAS BEEN IN THE SHOP 2 TIMES PREVIOUSLY FOR HESITATION AND DELAYS, AND THEY KEPT TELLING HER IT WAS CHIP RELATED .THE LAST TWO INCIDENTS OCCURRED AT RELATIVE HIGHER SPEEDS THAN THE FIRST TIME. CAR HAS BEEN IN THE SHOP FOR ONE WEEK, AND SHE DID HEAR FROM THE SERVICE DEALERSHIP LAST NIGHT. HE TOLD HER HE THOUGHT IT WAS A FUEL PRESSURE ISSUE AND HE WAS GOING TO CALL IN A SPECIALIST. *AK
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10130972August 2, 2005
ENGINE AND ENGINE COOLING
VOLVO S60 2.4T 2001; STALLS WITHOUT WARNING WHEN ACCELERATING AT SPEEDS IN EXCESS OF 50 MILES AN HOUR, WARNING LIGHTS COME ON, CAR WILL RESTART AFTER A FEW MINUTES. HAS HAPPENED 3 TIMES IN 3 DAYS. IN THE SHOP TODAY FOR REPAIR. *NM
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10130988August 2, 2005
ENGINE AND ENGINE COOLING:ENGINE
ENGINE IS IDLING VERY LOW. HAS DIED ON MAJOR THOROUGHFARES 3 TIMES IN PAST 2 WEEKS. DID RESTART. TAKING IT IN IN 2 DAYS (EARLIEST APPOINTMENT WAS A WEEK FROM WHEN I CALLED THE DEALERSHIP). *NM
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10131000August 2, 2005
ENGINE AND ENGINE COOLING:ENGINE:GASOLINE
(1) DRIVING ON INTERSTATE AT MAXIMUM LEGAL SPEED FOR SEVERAL HOURS. (2) ENGINE ABRUPTLY STOPS WITHOUT WARNING RESULTING IN LOSS OF POWER STEERING AND BRAKES. ATTEMPTS TO RESTART ENGINE WHILE MOVING NOT SUCCESSFUL. NEGOTIATE THROUGH TRAFFIC TO SHOULDER OF ROAD, NARROWLY AVOIDING ACCIDENT. (3) VEHICLE SAT ON SIDE OF ROAD FOR APPROXIMATELY FIVE MINUTES AND THEN RESTARTED WITHOUT ANY PROBLEMS. WERE ABLE TO CONTINUE TRIP AND RETURN HOME. (4) TOOK VEHICLE TO DEALERSHIP. ENGINE WAS CHECKED, BUT NO PROBLEMS FOUND. (5) THIS HAS OCCURRED TWO TIMES DURING THE FOUR YEARS WE HAVE OWNED VEHICLE .. *NM
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10131012August 2, 2005
VISIBILITY:WINDSHIELD
DT: 2005 VOLVO SAA. THE CONSUMER STATED THAT IS==WAS A GLARE IN THE WINDSHIELD. THE DASHBOARD ITSELF WAS A TWO TONE COLOR BLACK AND TAN. THE BLACK PIECE WAS RIGHT ABOVE THE STEERING COLUMN, AND THE REST OF THE DASH WAS TAN . THEREFORE CAN SEE A CREASE IN THE GLARE OF THE WINDSHIELD. DEALERSHIP SAID EITHER PAINT THE BLACK PART OF THE DASHBOARD TAN OR PUT DASHBOARD COVER ON AT MY EXPENSE. IF SUN GLASSES USED THE GLARE WAS OKAY, BUT IF NOT USED THE GLARE WOULD BE IN MY RIGHT EYE. CONSUMER MUST LEAN OVER TO THE LEFT TO BE ABLE SEE WITHOUT THIS GLARE. *AK
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10131047August 2, 2005
VEHICLE SPEED CONTROL
DT: 2003 VOLVO S60. WHILE DRIVING 35 MPH VEHICLE STALLED INTERMITTENTLY, AND THEN ACCELERATED. TOOK VEHICLE TO DEALER 4 TIMES. REPLACED THROTTLE BODY. *AK
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10131048August 2, 2005
ELECTRICAL SYSTEM
DT: IN APRIL THE VEHICLE STALLED WHEN MAKING A RIGHT HAND TURNS. DID THE SAME THING A FEW DAYS LATER. TOOK VEHICLE TO THE DEALER, THEY CHECKED THE VEHICLE AND THEY HADN'T HEARD OF THIS BEFORE. SOME KIND OF PLATE HAD TO BE CLEANED . THE VEHICLE JUST TURNED 30,000 MILES. THEN A MONTH LATER WHILE MERGING AT 55 MPH THE VEHICLE DIED. IT DID START AGAIN. BROUGHT THE VEHICLE BACK TO DEALER, THEY KEPT THE CAR A WEEK AND DID TESTING, AND CLAIMED ONE OTHER PERSON HAD THE SAME COMPLAINT. THEY DID THE SAME THING TO CONSUMER'S VEHICLE THAT THEY DID TO OTHER PERSON' VEHICLES. THEN, DEALER SAID THERE WAS A RECALL. *AK
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10131088August 2, 2005
VEHICLE SPEED CONTROL
(1) CAR RAN ROUGH IN ANY GEAR WHEN TRYING TO MAINTAIN SPEED (2) I TOOK IT TO THE DEALER IMMEDIATELY BECAUSE I COULD NOT STAND IT (3) $1409 REPAIR TO REPLACE THE ELECTRONIC THROTTLE MODULE. I WAS TOLD IF I DID NOT REPLACE IT THE CAR WOULD STALL AND BE UNDRIVEABLE. *NM
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Volvo S60