Chevrolet Tahoe Complaints

950 consumer complaints on file.

#11685717September 8, 2025
ELECTRICAL SYSTEM, VISIBILITY/WIPER
Wipers failed during heavy rain in heavy traffic on 7/3/25. Wipers randomly started working. The wipers failed again during a heavy rain on 8/13/25 again in moderate traffic. Wipers failed during heavy rain, was unable to see while driving on an Interstate. I was able to navigate to the shoulder of the highway but was very scary being on an interstate highway in heavy traffic. Dealership repair occurred on 8/14/25. No warnings of any kind prior to the failures.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11685631September 8, 2025
ENGINE, ENGINE AND ENGINE COOLING
The contact owns a 2022 Chevrolet Tahoe. The contact stated that while driving at various speeds, the engine warning light illuminated. While inspecting the oil level, the contact discovered that the oil level was extremely low. The contact added oil as needed. The vehicle was taken to a dealer and five different tests were performed and each test produced varying results. The contact stated that on several tests, the oil level remained at a normal level, but on other tests, the oil level was extremely low. The vehicle was taken to another dealer, Koepp Chevrolet, INC. (13221 U.S. Hwy 87 W, La Vernia, TX 78121); and similar results were received. The manufacturer was not notified of the failure. The vehicle was not repaired. The failure mileage was approximately 63,800.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11685621September 8, 2025
STEERING
At low speeds the steering wheel locks up and become very difficult to turn. This has been an issue for a few years and only happens randomly. Reviewing N212333901 it is the same symptoms but for some reason my VIN is not covered in the recall while is the same year as affected vehicles (2021 Tahoe Z71)
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11685588September 7, 2025
ENGINE
Driving car, suddenly when accelerating engine light started flashing, car was shaking and making knocking noise
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11685247September 5, 2025
POWER TRAIN
This is an amendment to campaign 11684444 as there is some inaccurate info as it pertains to the diagnostic- 2021 Chevrolet Tahoe, Driving 25 MPH, in the neighborhood, my Tahoe kicked into neutral and abruptly stopped in the middle of the street. I immediately tried to restart it, however it would not start. After about 15 minutes, we tried again and it started enough to make it back to my in laws house, where it remains parked today. We did a diagnostic test and received the code for Fuel Pump Control Module failure. Contacted the Chevrolet dealership I bought my vehicle from and they indicated this is a common issue and the part is on back order. This is a very dangerous risk to safety and should be covered under a recall. I've seen where GMC issued a recall for the exact same issue, but only for Tahoes with 6.2L V8 engine; Mine is 5.3L. I am confused why that matters as it poses the same safety risk across the board. Very dangerous. Please consider this as a recall.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11685197September 5, 2025
FUEL/PROPULSION SYSTEM
The fuel filler neck for the diesel has a plastic neck extension made of cheap plastic and it broke making it a hazard to even fill the vehicle up and diesel fuel is spilled, not secured, and fumes could cause a fire hazard because the piece is faulty. GM customer service ignores me and transfers me over and over until they hang up and never actually talk to me about this
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11685037September 4, 2025
ENGINE
2021 to 2024 has had countless problems with the 6.2l engine. General Motors has put a stop of sale on vehicles with this engine. When I purchased the car the wrong oil was in the car which always burned off with 2 months after an oil change. They figured out the right oil but the damage has already been done.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11684848September 3, 2025
POWER TRAIN
Transmission valve body failure after factory warranty expired.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11684809September 3, 2025
POWER TRAIN
Rapid deceleration at 55mph on highway, followed by console message "reduced acceleration" with check engine light. Fortunately rolled into dealer within a mile. After analysis, they stated the transmission valve body and electronic control component needs replacement over $3,000. after tax. No warning signs prior. NTSB recall N24254441 covers only diesel engines not gas with same problem in 10 speed transmission.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11684775September 3, 2025
ENGINE AND ENGINE COOLING
The contact owns a 2021 Chevrolet Tahoe. The contact received notification of NHTSA Campaign Number: 25V274000 (ENGINE AND ENGINE COOLING). The contact stated that the dealer was contacted; however, the contact was informed that parts were not yet available. The vehicle was not repaired. The manufacturer was contacted about parts availability. The contact had not experienced a failure.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11684630September 2, 2025
FUEL/PROPULSION SYSTEM
On August 23, 2025 while driving on a highway with my daughter in the backseat, my car gradually stalled while it was going through an intersection. It ended up stalling prior to a turn ramp onto another highway. This resulted in an unsafe condition and unsafe location as it happened without warning or any alerts prior to or during the drive. The Tahoe was towed to the dealership service repair shop (Hendrick Chevrolet in Cary, NC) and was found to have a fuel pump control module failure requiring replacement (replacement: FP-number 13554821, module 3.900). The dealership service department acknowledged this is a part failure on the manufacturer end; however, mentioned this is a safety bulletin, but not a recall for the part. Due to the Tahoe being outside of warranty timeframe, this ended being an out of pocket expense. The service staff told us there were four other Tahoe vehicles waiting for this part at the dealership, and we waited over a week to obtain the part as it had to come from the manufacturing line. Due to the timeframe for repair (>1 week), we had associated rental car payments that was not provided by or covered by the dealership/manufacturer.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11684474September 2, 2025
SERVICE BRAKES, FORWARD COLLISION AVOIDANCE: ADAPTIVE CRUISE CONTROL, FORWARD COLLISION AVOIDANCE: AUTOMATIC EMERGENCY BRAKING
Driving along the highway in cruise control at about 70mph without any trailer being pulled. Suddenly I got brake errors. ABS, ESC, Trailer brake error failures all popped on the dash warnings. Brakes were unresponsive only applying hard pressure to the brake pedal was effective. There was zero feedback from the brake pedal to myself on it engaging and braking effectively. If this happened in a situation requiring more immediate braking, I would not have been able to figure out the braking capability of my vehicle in time. There were no issues with my vehicle at the time. I see that similar issues have been reported on Facebook "Chevy Tahoe Owners Group". Unknown whether it's a sensors glitch or a SW issue. After a few hours of being parked the car brake system started to work properly again. Made an appointment to check out they system at the dealership.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11684444September 2, 2025
ENGINE AND ENGINE COOLING
The contact owns a 2021 Chevrolet Tahoe. While driving 25 MPH, the vehicle stalled in the street. The vehicle was eventually restarted and was driven to the family’s residence. After arriving at the residence, the vehicle failed to restart. The contact stated that the failure was like the failure in NHTSA Campaign Number 25V274000 (Engine and Engine Cooling). There were no warning lights illuminated. The contact called the local dealer, but the vehicle was not diagnosed or repaired. The manufacturer was contacted and referred the contact to the NHTSA Hotline for assistance. The approximate failure mileage was 73,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11684441September 2, 2025
AIR BAGS:SRS MALFUNCTION WARNING LAMP/LIGHT
The contact owns a 2021 Chevrolet Tahoe. The contact stated that the message "Safety Restraint System" was displayed, and the air bag warning light was illuminated. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline for assistance in adding the VIN to a recall. The failure mileage was approximately 98,520. The VIN was not available.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11684398September 2, 2025
POWER TRAIN, ENGINE
I am writing to formally document serious engine defects I have experienced with my 2021 Chevrolet Tahoe equipped with the 5.3L L84 V8 engine. 1.Crankshaft Failure oMy Tahoe suffered a catastrophic crankshaft failure that required major repair/replacement. oI am aware that GM has recalled certain vehicles equipped with the 6.2L L87 engine for crankshaft and rod-bearing defects. oBased on my experience, the same or a very similar defect has also occurred in my 5.3L engine, which is currently not included in that recall. 2.Valve Lifter Failure oIn addition, my vehicle has suffered from valve lifter collapse—a well-documented problem in 2021–2022 GM trucks and SUVs with both the 5.3L and 6.2L engines. oThis caused severe misfiring, drivability issues, and expensive repair needs. Why this is a concern: •Both failures occurred well before what would be expected of a modern engine. •The crankshaft failure raises a safety risk: sudden loss of propulsion while driving could lead to accidents. •The lifter issue is widely reported by other owners and has been the subject of GM service bulletins. •Taken together, these problems suggest systemic defects in the 2021 Tahoe’s 5.3L engine that have not been adequately addressed by GM. Requested Action: •I ask GM to extend recall and warranty coverage to include the 5.3L L84 engine in addition to the 6.2L L87. •I ask NHTSA to consider investigating whether the scope of the current 6.2L recall should be broadened to include 5.3L engines, given failures like mine. •At minimum, I request assistance in covering repair/replacement costs for both the crankshaft and lifter defects, which are clearly not due to normal wear and tear. Vehicle details: •Year/Make/Model: 2021 Chevrolet Tahoe •Engine: 5.3L V8 L84
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11684360September 2, 2025
ENGINE, VEHICLE SPEED CONTROL, FORWARD COLLISION AVOIDANCE: WARNINGS
I drive a 2021 Chevrolet Tahoe. This occurrence has happened on three separate occasions and each time it was raining outside. The first occurrence, my vehicle was running and parked in the rain after driving approximately 5 miles. While parked my check engine light came on with a series of warnings: service ECS, service traction control, forward collision system unavailable, reduced acceleration drive with care. Two days later it went away. The second occurrence, I was driving in the rain for approximately 22 miles and briefly parked with my vehicle running. I then turned out of a parking lot and began to accelerate to speed up and the check engine light came on along with all the same messages, this time my vehicle acceleration had seized and wouldn’t go faster than 30 MPH. I slowly drove back to the parking lot and turned the vehicle off to let it sit, disconnected the battery and reconnected, and the issues went away. The third occurrence, I was driving on the highway in the rain for approximately 10 miles, I went to merge into a right hand lane, I took my foot off the acceleration peddle to slow down for the merge and as I slightly turned the wheel to the right, my vehicle spun out three times, throwing the back end of the Tahoe into the inner highway wall, which spun me again to face the right direction, next to a highway exit. I then went to accelerate to exit the highway but noticed my vehicle would only coast and realized my engine had cut out at some point. I started the vehicle and exited the highway and parked in a parking lot only feet away from the exit. After I parked I noticed all the same warning lights came back on. Each occurrence happened on [XXX], [XXX], [XXX]. My vehicle was towed to Gunn GMC Collision Center in Selma, Tx and will be looked at on September 3, 2025 around 8:00am. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Crash:
Yes
Fire:
No
Injuries:
0
Deaths:
0
#11684312September 1, 2025
FUEL/PROPULSION SYSTEM
I own a 2021 Chevrolet Tahoe High Country (VIN: [XXX] ). My vehicle is subject to Recall #N252494000 (NHTSA #25V274) concerning the L87 engine and potential loss of propulsion. On [XXX], I received a “Low Oil” warning for the second time within a few months. This recurring issue matches the recall description. I contacted my local dealer, Kramer Autoplex (Livingston, TX), who confirmed the recall but stated no remedy is available. I am deeply concerned about safety, as the engine may suddenly lose power or sustain damage, leaving me and my family stranded or at risk of a crash. At this time, I have no assurance that my vehicle is safe to drive, no remedy is being offered, and I have already incurred expenses related to monitoring this issue. I am requesting NHTSA’s support in ensuring GM provides an expedited fix or interim assistance for affected owners. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11684061August 30, 2025
ELECTRICAL SYSTEM, ENGINE, POWER TRAIN
The affected systems are the power train, engine, and electrical. My 2021 Chevrolet Tahoe experienced failures consistent with GM Technical Service Bulletin 21-NA-149 (engine wiring harness chafing) and the conditions outlined in Recall N232404190 (valve body failure, November 2024). Beginning in March 2025, the vehicle displayed warning lights and messages including Check Engine, Traction Control, Service Transmission, and limp mode (Reduced Acceleration – Drive with Care). The vehicle shifted erratically, lost power, and occasionally failed to accelerate, creating a serious safety hazard at highway speeds. These problems were documented at AutoNation Chevrolet South Clearwater, where multiple diagnostic trouble codes (P0700, P0717, P2714, P2716, P0706, and U-codes) were recorded but not properly investigated. No test drive was performed despite being claimed by the service technician, and the applicable TSB was not referenced. By July 2025, the condition worsened into a complete transmission failure, with additional codes (P0700, P077C, P17F6, P17FB, P1872). The dealer’s estimate required a full transmission replacement at nearly $10,000. GM reviewed the case through its internal Policy Evaluation Tool and increased goodwill assistance from 15% to 40%, while AutoNation contributed only $500. GM’s partial contribution confirms the defect is recognized, yet this VIN remains excluded from the official recall. This issue placed my family and other motorists at significant risk, as sudden loss of power and shifting failures occurred during normal driving conditions. Dealer records, GM documentation, and photographs of warning messages are available. I request that NHTSA expand Recall N232404190 to include affected VINs such as mine, since the symptoms, diagnostic codes, and confirmed failures match exactly what GM has already identified as a known safety issue.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11684054August 30, 2025
ELECTRICAL SYSTEM, ENGINE, POWER TRAIN
The affected components are the electrical system, engine, and power train. In March 2025, my 2021 Chevrolet Tahoe displayed multiple warning lamps across the dash, including traction control and check engine lights. The vehicle shifted erratically and sometimes entered limp mode. I brought the vehicle to AutoNation Chevrolet South Clearwater for inspection. The dealer replaced the battery, dismissed my concerns, and stated that a test drive was performed, but the mileage in and out on the invoice was identical, showing it never actually occurred. Diagnostic trouble codes (P0700, P0717, P2714, P2716, P0706, and multiple U-codes) were present but were not fully investigated. A GM Technical Service Bulletin (21-NA-149, December 2022) covers these exact symptoms (caused by engine wiring harness chafing), but it was never referenced or applied. Because the problem was not addressed, the condition worsened. By July 2025, the vehicle suffered a complete transmission failure. At that point, the dealer confirmed the issue, documenting transmission slipping, shuddering, noise, and additional codes (P0700, P077C, P17F6, P17FB, P1872). GM increased its goodwill contribution from 15% to 40% of the $9,925 repair cost, while AutoNation offered only $500 despite their role in the missed diagnosis. Safety Risk: My family and I were at risk each time the vehicle stalled, lost power, or shifted erratically while driving, including at highway speeds. These failures created a significant risk of collision. The drivability problem was not properly confirmed in March 2025 despite multiple codes being present. By July 2025, the dealer acknowledged and confirmed the transmission failure. The vehicle remains available for inspection, and I have retained all invoices, diagnostic reports, and communications with GM and the dealership.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11683976August 29, 2025
ENGINE, ELECTRICAL SYSTEM
When driving the car just stops losing power then the car immediately shuts down and stops driving. I had to call a tow truck when it’s taken to the dealership the fuel pump power control module is faulty. This is a 2021 Tahoe they had to replace the fuel pump, power control module, and this vehicle should not have to be replaced. Chevrolet/GMC knows that these modules will make the vehicle stop wherever it is driving. I happen to be on a freeway going 70 mph and could have been killed. They have not put a recall out to have these modules replaced in any SUV. This is a danger for any driver on the road. This is a lawsuit waiting to happen for people. You know that they are aware this is happening because they paid for the tow and replaced this part that is not warranty now for free. Yes, great that it was paid for but thankful I did not lose my life as I could’ve been rear ended when my car shut down going that fast in the middle of the freeway I am begging that they please put a recall so no one gets injured or killed.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Chevrolet Tahoe