Chevrolet Tahoe Complaints

950 consumer complaints on file.

#11691414October 4, 2025
ELECTRICAL SYSTEM, ENGINE
The engine in my vehicle has experiences major failures in valve flap adjusters, multiple valve failures, valve cover issues, and over consumption of oil by over a quarter in a week and a half of average driving. My safety was put at risk because the engine failure resulted in traction control malfunctions while going 70 mph up hill on a major interstate. This led to extreme shaking which did not stop until slowing down to below 15 mph. Luckily I was a mile from an exit and was able to coast off the road quickly; it was decent enough weather, and I was less than 5 miles from my destination so I could creep between 15-30 mph to not exacerbate traction control alarms. That slow mph did back up traffic behind me. As far as I am aware the problem was likely reproduced by the dealership service tech, which led to their recommendation to replace the whole engine. They do not consider it to be covered by any warranty anymore. The engine may be in their possession still, but I am unsure. There were zero warning lights/prompts from the vehicle that anything was going wrong prior to the shaking and loss of traction control at high speed. The dealer service team suggested that my high miles led to the engine failure. I do highway driving with it and have followed all manufacturer recommendations for oil changes, and even more frequent changes with OEM oil since about 80k miles. I do not think this engine should have failed at this amount of mileage. I made note of oil consumption around 95k miles and measured oil loss regularly. It was a little less than a quart every 2K to 3k miles which manufacturer states is within spec so I would top off oil. A year ago it had a TCM wire replaced after burning in half. 3 weeks ago I also had to replace the entire turbo. The wire rendered my car unable to go in gear. The turbo failure put me into limp mode. I think the turbo failure was a sign of a deeper issue that went undiagnosed.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11691258October 3, 2025
SERVICE BRAKES
I am reporting a critical safety design defect in my 2025 Chevrolet Tahoe Z71 (VIN: [XXX] ), involving the Brake Pedal Assembly geometry. Bought vehicle in January this year and within a few days of driving I noticed my foot repeatedly catching or hanging up on the brake pedal when moving from the accelerator to brake, which severely delays braking application (regardless of my footwear). This momentary obstruction creates an imminent risk of collision during sudden stops. This happens at least once a week when commuting to work. The component malfunctioning is the fixed brake pedal placement itself. No warning lamps or symptoms precede the issue; it is a physical interference defect. The problem was reported to Courtesy Chevrolet in Phoenix, Arizona on 10/02/2025 (Service R.O. 694801). The service advisor verbally acknowledged the issue but stated it was a "factory design issue" they could not fix, explicitly referring me to GM for resolution. Other than myself and the dealership, no one else has inspected this issue. The pedals are available for inspection. The attached photos provide supporting evidence. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11690914October 2, 2025
ELECTRICAL SYSTEM
On several occasions while operating the vehicle during inclement weather the windshield wipers intermittently stopped working. Restarting the vehicle several times did not remedy the problem. Once the vehicle was parked for a while the wipers started working again. This vehicle has been to the dealership regarding this issue numerous times and sent back in service with a message from the technician, could not duplicate the complaint.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11690910October 2, 2025
ELECTRICAL SYSTEM
On several occasions while operating the vehicle during inclement weather the windshield wipers intermittently stopped working. Restarting the vehicle several times did not remedy the problem. Once the vehicle was parked for a while the wipers started working again. This vehicle has been to the dealership regarding this issue numerous times and sent back in service with a message from the technician, could not duplicate the complaint.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11690812October 1, 2025
FUEL/PROPULSION SYSTEM
I JUST HAD TO BUY A FUEL PUMP CONTROL MODULE 2021 CHEVY TAHOE HIGH COUNTRY THAT WOULD CRANK OVER, AND NOT START. PER INTERNET, THIS PART IS ON A MILLION CAR PART FAILING. I FOUND ON INTERNET THAT IT SHOULD BE REPLACED AT NO CHARGE. I WAS STUCK AT HOUSE AND HAD A FRIEND CHECK WITH A OB2 TESTER AND IT SHOWED FAILURE. I CALLED 2 DEALERS AND MENTIONED RECALL AND WAS TOLD THEY KNEW NOTHING ABOUT. YET ON SEPTEMBER 11TH OF THIS YEAR, GM WAS WELL AWARE! RECALL #252516900. I HAD TO GET A RIDE AND GO PURCHASE AT A GM DEALER. AND PAID $69.09 WITH TAX. PART NUMBER #13554821 GM 03900 MODULE 03.900. AND COULD HAVE BEEN A SERIOUS PROBLEM IF I WOULD HAVE BEEN DRIVING OR STUCK OR SOMEWHERE. COSTLY TO GET TOWED AND NO CAR TO DRIVE. IM HANDICAP AND CAN'T BE WITHOUT. BUT FOR A DEALER TO CHARGE. AND PLAY DUMB SINCE I WAS GOING TO HAVE TO BUY AND CHANGE AT MY HOME. WANT MY MONEY BACK FOR A NO CHARGE PART.!!!!!!!!!
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11690768October 1, 2025
UNKNOWN OR OTHER
Onstar module is not working. I contacted Onstar and they stated to get repair I would need to continue paying for the service. Safety features are now not working due to this issue
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11689983September 26, 2025
FUEL/PROPULSION SYSTEM
Was in stop and go traffic. Car suddenly said “conditions not correct for shift” and engine died. The car would not turn on and it could not be put into neutral therefore was stuck in the lane stopping all traffic on the NJ turnpike. It created a safety issue for that reason as there was no way to move the car to a safe place until a tow truck came and had to drag it onto the bed. I have since had it repaired at a local shop not Chevrolet dealer and was told it was fuel pump failure. There was no warning or any other symptoms in facet I had just had an oil change a week prior. Had there not been stop and go traffic and I was going the speed limit (60mph), there could have been a major accident and injuries.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11689799September 25, 2025
FUEL/PROPULSION SYSTEM
The fuel pump control module failed while I was driving. My vehicle shut down in the middle of the road. I was unable to put my vehicle in neutral to move it off the road. A tow truck had to come in order to get it out of traffic. The next day we had it towed to the dealership who replaced the fuel pump control module. This is a safety issue because the car will shut down with no warning while driving. It’s very dangerous. The second safety issue is that the vehicle becomes immovable without a tow truck. There is no accessible shift override to manually put the vehicle in neutral.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11689493September 24, 2025
ENGINE
The contact owns a 2022 Chevrolet Tahoe. The contact stated that while having a routine oil change at a local dealer, the contact was informed that the engine was blown. No warning light was illuminated. In addition, upon further notice, the contact's husband heard an abnormal clicking sound coming from under the hood. The vehicle was diagnosed, and determined that the engine needed to be replaced. The vehicle was not repaired due to the cost. The manufacturer was made aware of the failure. The failure mileage was approximately 84,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11689130September 23, 2025
FUEL/PROPULSION SYSTEM, ENGINE
Low Oil Life notification on phone. Since L87 recall, an oil consumption test was stopped and the new type of oil has been added to the vehicle 5k miles ago. Had to add a full quart to register on dip stick. Will now start another oil consumption test with a dealership. I am very concerned about my families safety.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11688837September 22, 2025
SERVICE BRAKES, FORWARD COLLISION AVOIDANCE: AUTOMATIC EMERGENCY BRAKING, FORWARD COLLISION AVOIDANCE: WARNINGS
BRAKES JUST GAVE OUT ALMOST HIT THE CAR INFRONT AND SWURVED TO AVOID IT THE CAR ALMOST HIS THE WALL AND ANOTHER CAR WHILE TRYING TO CORRECT MY TRUCK IN A PROPER LANE. Brake pedal went straight down to the bottom and let the truck coast to a stop. SCARED TO DEATH THANK NGOD I DIDN'T HIT OR CRASH !!!!
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11688021September 18, 2025
POWER TRAIN
While traveling on [XXX] approximately 20 miles west of Rawlins WY the vehicle entered “limp mode” causing us to drive at an unsafe slow speed. The transmission caused a check engine light to activate which was confirmed by a service technician in Rawlins with a PO747 code show on his OBD2 scanner. The problem was confirmed by the servicing dealer in Lincoln NE. The transmission was inspected by the servicing dealer. They replaced the valve body and fasteners approximately 1 1/2 months later. The problem first occurred at the time of the incident and I had no prior warning. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11687162September 14, 2025
ELECTRICAL SYSTEM
Info center with radio, vehicle info, on star keeps going black screen. When this happens I loose all control of info center and on star goes out where no location would be available if the vehicle was in an accident. This is safety concern because with no automatic notifications of accident no one would know if vehicle was in an accident. The vehicle has been to dealer 4 times for this problem since February of this year. Each time the dealer says it needs another update each time. GM is having this issue with many of the Vehicles like this Tahoe. On Star is also aware of the issue too. GM knows there's an issue but now they are saying I have to pay for an update because I am out of my extended warranty even though this has been an ongoing problem which started when I was in warranty. This has to be a programming issue that they need to fix. The vehicle has to be shut off for up to an hour for screen and controls to come back on which is safety issue because no way to change any settings for vehicle and safety backup because of no on star.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11686318September 10, 2025
ENGINE
on [XXX] we bought our 2023 Tahoe High Country from Jeff Gordon Cheverolet in Wilmington NC. In April 2025 a recall was announced on our car for engine failure. In June of 2025 we received a letter stating that a fix for the recall was to have an inspection done. If passed, then an oil change and new cap would be done. This was completed. on [XXX], I was on the highway accelerating to get up the speed, when I heard a loud pop noise. Then i heard loud knocking coming from my engine, the check engine light came on with the traction light as well. The car then had sluggish acceleration and would not accelerate but would have high than normal RPMS and rev when trying to accelerate. I knew then that I had engine failure. I was able to get the car to a safe place and called the dealership right away. They got it towed to Marine Chevy since it was closer. The next day they did an inspection on the vehicle and said the camshaft and lifters were broken and had to be replaced. I said I would need a new engine replaced due to the damage and recall. I was told it would not be under recall because it was the top and not bottom. They said the GM refused the new engine but would not tell me if it was the General Manager or General Motors that refused. I called and texted multiple times asking for pictures. They refused to send me any until 9/9 after multiple attempts. They only sent me one of the rods and rocker arms showing a rod bent and stated it was the lifters. still no pictures of the camshaft broke or lifters. These problems already have multiple class action lawsuits out for this particular engine failure. I was told the recall would still be on the engine even after the repair, I can still have engine failure. I refuse to pay the money for this car to continue to be in the shop due to a bad engine that was put in these models. I also have a case open with General Motors for replacing the engine as well and they are refusing to help. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11686099September 9, 2025
FUEL/PROPULSION SYSTEM
My 2021 Chevrolet Tahoe suddenly shaked and the engine shut off and on and nearly stalled on the road. I towed the car to the servicing dealer who has not been able to fix the issue. There is a national recall for the issue for the month of September 2021 Safety recall N212332040 for this issue but NHTSA has not added my car. NHTSA must include my car with the same issue and built in during the same month of the recall. The safety issue is the car will stop running and may block traffic or can be hit when it breaks down.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11685989September 9, 2025
ENGINE
The contact owns a 2021 Chevrolet Tahoe. The contact stated that while his wife was driving at undisclosed speeds, there was an abnormal ticking sound coming from the vehicle. The check engine warning light was illuminated. The vehicle was taken to the local dealer, where it was diagnosed, and determined that the cylinder #1 left side lifters and push rod had collapsed. The lifters and push rod assembly were replaced. The contact stated that on a separate occasion, while driving at undisclosed speeds, there was an abnormal ticking sound coming from the vehicle, and the check engine warning light illuminated. The vehicle was taken to the local dealer, where it was diagnosed, and determined that cylinder #4 lifters had detached, and the push rod was bent. The vehicle was repaired. The contact stated that the engine was consuming an excessive amount of engine oil. The contact related the failure to TSB: 15-06-01-002A. The dealer and manufacturer were not made aware of the failure. The failure mileage was approximately 12,400.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11685944September 9, 2025
ENGINE, UNKNOWN OR OTHER
We just recently had the cam shaft and lifters replaced, as the vehicle began experiencing a knocking sound. The repair was supposedly completed, and they gave the truck back. We took the truck back in within a week, bc we continued to hear the sound. They sent it back saying they didn’t hear anything after test driving it. Over the weekend the car shut off after beginning to shake uncontrollably. Now supposedly the camshaft bearing is gone, and the truck experience engine failure. I spoke with someone previously, as the issue being repaired hundred thousands of cars were recalled for the same issue. I was told that it wasn’t on the same line, even though my truck was experiencing the EXACT issue and fell under the years. We were placed back on the road with our family, with a vehicle
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11685909September 9, 2025
UNKNOWN OR OTHER
Driving down the highway (open road) and the sunroof spontaneously shattered.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11685886September 9, 2025
POWER TRAIN
I have a 2021 Tahoe that while circling a parking lot at my son's football practice. The Tahoe's emergency came on and the Tahoe abruptly stopped. A checked engine light came on. The Tahoe wouldn't release the emergency brakes. I was finally able to get it released. I took the vehicle to a transmission shop because I plugged OBD scan tool on it. It had two transmission codes. One generic and one for the vavle body. The transmission shop said they have had lots of Tahoes with the vavle body's going out. They told me about N242454441. I called Chevrolet and they advised me that wasn't for my Tahoe. I asked why and they said they don't know. If this is effecting the desiel only models then why is mine doing the same thing. Parts cant be ordered either. Please look into this matter.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11685851September 9, 2025
ENGINE
When i asked Kunez Lake Geneva, Wi. When the engine recall would be taken care of. I was told that GMC has to order the recall first. Then when asking about the process of inspecting. They informed me they would listen to the motor and decide if it was effected or not. I paid $82k for this vehicle. I find that listening to the motor isnt a thorough way of inspection. After they deem the motor ok. There going to put higher viscosity oil & an oil cap. What if something happens in the future. Is my familys life safety not important? Summary General Motors has decided that a defect which relates to motor vehicle safety may exist in certain 2021 – 2024 model year Cadillac Escalade and Escalade ESV, Chevrolet Silverado 1500, Suburban, and Tahoe, and GMC Sierra 1500, Yukon, and Yukon XL vehicles equipped with the 6.2L V8 gas engine (RPO L87). The connecting rod and/or crankshaft engine components in these vehicles may have manufacturing defects that can lead to engine damage and engine failure. Safety Risk If the engine fails during vehicle operation, the vehicle will lose propulsion, increasing the risk of a crash. Remedy Dealers will inspect and, as necessary, replace the engine. Vehicles that pass inspection will be provided a higher viscosity oil, which will also require a new oil fill cap, an oil filter replacement, and an owner’s manual insert.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Chevrolet Tahoe